Parts Catalog

Bulletin No. SPTP004-0306
March 2006
9 SPEED
TRANSMISSION
PARTS LIST
MODELS:
PS95-9A
PS125-9A
PSO140-9A
PSO150-9A
9 Speed
Transmission
Parts Catalog
9 SPEED TRANSMISSION PARTS LIST
Contents
MODELS:
PS95-9A & PS125-9A,
PSO140-9A & PSO150-9A
9 SPEED TRANSMISSION
Ratio Table
3
Gears and Related Parts - Main Section
Drive Gear Group
Mainshaft Group
Countershaft Group
4-11
4-5
4-5
6-7
Gears and Related Parts - Range Section
Counter shaft and Synchronizer Group
Mainshaft Group
8-11
8-9
10-11
End Yoke Table
11
Clutch Housing Group
Drive Gear Bearing Cap Group
Main Case Group
12-14
12-14
12-14
Optilube Pump
15-16
Williams Air Control and Interlock Group
17-18
Shift Bar and Fork Assembly.
19-20
Range Case Group
Range Piston Housing and Shift Fork Group
Countershaft Bearing Cap Group
Rear Bearing Cap Group
21-22
21-22
21-22
21-22
Shift Tower Assembly and Related Parts
Upper Shift Lever and Knob Assembly
Shift Knob Assembly
Shift Lever Isolator
Air Harness
Floor Board Boot
Upper Shift Lever
Lower Shift Lever and Tower
Tower Control Housing
23-24
23-24
23-24
23-24
23-24
23-24
23-24
23-24
23-24
Remote Control Assembly...
25-26
Overhaul Kits - Major and Minor
27-28
Air Control Plumbing Diagram
29
Bill of Materials
30-32
2
tech line 800-401-9866
www.ttcautomotive.com
9 SPEED TRANSMISSION
MODELS:
PS95-9A & PS125-9A,
PSO140-9A & PSO150-9A
RATIO TABLE
Model
PS125-9A, PS95-9A
Speeds
1st
2nd
3rd
4th
5th
6th
7th
8th
9th
Rev
13.95
9.05
6.51
4.77
3.55
2.55
1.83
1.34
1.00
14.30
PSO140-9A
PSO125-9A
PSO150-9A
10.40
6.74
4.85
3.55
2.65
1.90
1.37
1.00
.75
10.65
IDENTIFICATION
SHIFT PATTERN
The Name Plate NP-202 affixed to the rear left hand side of the
Transmission is stamped with Information.
In requesting more information on the Transmissions, please furnish
this information.
Serial
B/M
Model
SD-PS-9N
Shift Pattern Decal
Navistar No.
Abbreviations used in this
parts list include:
N.S. - Not Shown
N.S.S. - Not Sold Seperately
N.R. - Not Required
A.R. - As Required
3
tech line 800-401-9866
www.ttcautomotive.com
GEARS & RELATED PARTS
Main Section
9 SPEED TRANSMISSION
MODELS:
PS95-9A & PS125-9A,
PSO140-9A & PSO150-9A
4
tech line 800-401-9866
www.ttcautomotive.com
GEARS & RELATED PARTS
Main Section
Ref. No. Part No.
9 SPEED TRANSMISSION
MODELS:
PS95-9A & PS125-9A,
PSO140-9A & PSO150-9A
201-35-2
201-35-6
201-35-7
313645X
201-381-1
Description
Drive Gear Group-Input Main Section
Shaft-Input 2.00"-10 spline #306 (1.180" dia.) Pilot
Shaft-input 1.75"-10 spline #205 (.983" dia.) Pilot
Shaft-input 1.75"-10 spline #306 (1.180" dia.) pilot
S/Assy. - Bearing & Belleville Snap Ring
Snap Ring - Input Shaft
1
1
1
1
1
or
201-8-16 NLA
201-8-43
201-8-2
Mainshaft Group Main Section
Use 201-8-43-1X Kit
Gear Drive (5th & 9th) (40T) (for PS Direct Transmission)
Gear - Drive (4th & 8th) (38T) (for PSO-Overdrive Transmission)
1
1
1
B-2
or
201-465-2
201-465-5
Collar - M/S Clutch (4th, 5th & 8th, 9th) (for PS Direct Transmission)
Collar - M/S Clutch (4th, 5th & 8th, 9th) (for PSO-Overdrive Transmission)
1
1
B-3
or
201-8-2
201-8-16 NLA
201-8-43
Gear - Mainshaft (4th & 8th) (38T) (for PS Direct Transmission)
Use 201-8-43-1X Kit
Gear-Mainshaft (5th & 9th) (40T) (for PSO-Overdrive Transmission)
1
1
B-4
B-5
201-8-4
201-465-2
Gear - Mainshaft (3rd & 7th) (44T)
Collar - M/S Clutch (2nd, 3rd & 6th, 7th)
1
1
B-6
B-7
B-8
201-8-37
201-8-35
201-465-2
Gear - Mainshaft (2nd & 6th) (58T)
Gear - Mainshaft (1st) (58T)
Collar - M/S Clutch (1st & Rev.)
1
1
1
B-9
B-10
B-11
B-12
201-8-10-1X
201-362-1-1X
201-381-3
N.S.S.
Gear - M/Shaft Reverse (Includes Thrust Ring & Reivets)
Kit - Mainshaft & Snap Ring
Snap Ring - Mainshaft Drive Gear - Range
Mainshaft
1
1
1
1
A-1
A-1
A-1
A-2
A-3
B-1
Quantity
For kits refer to pg's.22 - 24
N.S.S
NLA
Not Sold Seperately
No Longer Available
5
tech line 800-401-9866
www.ttcautomotive.com
GEARS & RELATED PARTS
Main Section
9 SPEED TRANSMISSION
MODELS:
PS95-9A & PS125-9A,
PSO140-9A & PSO150-9A
6
tech line 800-401-9866
www.ttcautomotive.com
GEARS & RELATED PARTS
Main Section
Ref No. Part No.
9 SPEED TRANSMISSION
MODELS:
PS95-9A & PS125-9A,
PSO140-9A & PSO150-9A
201-30-2
201-30-14
201-210-4-2
201-210-4-3
201-210-4-1
Description
Countershaft Group Main Section
Countershaft - Main (Before S/N J930506005)
Countershaft - Main (After S/N J930506005)
Key - Countershaft Gear - Middle
Key - Countershaft Gear - Front
Key - Countershaft Gear - Rear
or
C-11
C-12
201-196-31
201-196-33
201-312-2
201-312-3
201-196-6 NLA
201-196-44
201-196-2
201-196-14 NLA
201-196-35
201-47-2
201-47-5
Gear - Countershaft (1st) (24T)
Gear - Countershaft (2nd & 6th) (37T)
S/S by 313762X Kit
Gear - Countershaft PTO Drive
S/S by 313762X Kit
Gear - Countershaft (3rd & 7th) (39T)
Gear - Countershaft (4th & 8th) (46T) (for PS)
S/S by 201-8-43-1X Kit
Gear - Countershaft (4th & 8th) (52T) (for PSO)
Ring - Countershaft Thrust (Flat)
Ring - Countershaft H.R. Gear Thrust
C-13
or
C-14
Or
C-15
Or
C-16
C-17
C-18
201-196-14 NLA S/S to 201-8-43-1X Kit
201-196-35
Gear - Countershaft H.E. (5th & 9th) (65T) (for PS)
201-196-2
Gear - Countershaft H.E. (5th & 9th) (46T) (for PSO)
551011
Bearing - Cone Front Countershaft (Before S/N J930506005)
551013
Bearing - Cone Front Countershaft (After S/N J930506005)
551010
Bearing - Cup Front Countershaft (Before S/N J930506005)
550375
Bearing - Cup Front Countershaft (After S/N J930506005)
201-47-3
Ring - Countershaft (1st) Thrust
550182
Bearing - Cone Rear Countershaft
550375
Bearing - Cup Rear Countershaft
1
2
2
2
2
2
2
2
2
2
C-19
or
or
or
or
201-228-1-1
201-228-1-2
201-228-1-3
201-228-1-4
201-228-1-5
Shim - Countershaft Rear Bearing (.005 thick)
Shim - Countershaft Rear Bearing (.010 thick)
Shim - Countershaft Rear Bearing (.015 thick)
Shim - Countershaft Rear Bearing (.020 thick)
Shim - Countershaft Rear Bearing (.030 thick)
A/R
A/R
A/R
A/R
A/R
D-1
D-2
D-3
D-4
D-5
201-360-1
545002-1
201-196-12
330952
545001-5
Plate - Retainer Countershaft (with opti-lube use 1 )
Screw - Plate Retaining Countershaft
Gear - Countershaft Reverse - Range (21T)
Washer - Countershaft Reverse Drive Gear Retaining
Screw - Reverse Drive Gear Retaining Washer
2
6
2
2
2
C-1
C-2
C-3
C-4
C-5
C-6
C-7
C-8
C-10
Quantity
2
2
2
2
2
2
2
1
2
1
2
2
1
2
2
2
7
tech line 800-401-9866
www.ttcautomotive.com
GEARS & RELATED PARTS
Range Section
9 SPEED TRANSMISSION
MODELS:
PS95-9A & PS125-9A,
PSO140-9A & PSO150-9A
8
tech line 800-401-9866
www.ttcautomotive.com
GEARS & RELATED PARTS
Range Section
9 SPEED TRANSMISSION
MODELS:
PS95-9A & PS125-9A,
PSO140-9A & PSO150-9A
10
tech line 800-401-9866
www.ttcautomotive.com
GEARS & RELATED PARTS
Range Section
Ref. No. Part No.
9 SPEED TRANSMISSION
Description
MODELS:
PS95-9A & PS125-9A,
PSO140-9A & PSO150-9A
Quantity
F-1
F-2
F-3
201-362-3
313668X
201-8-41
Mainshaft Group - Output Range Section
Output Shaft
Kit - Needle Bearing - Output Shaft
Gear - Output - Low Range (52T)
1
1
1
F-4
F-5
F-5A
F-5B
F-5C
F-5D
201-47-4
313628X
N.S.S.
N.S.S.
N.S.S.
N.S.S.
Washer - Thrust Output Shaft
S/Assy. - Bearing and Spacer Output Shaft
Bearing - Cone Output Shaft
Bearing - Cupy Output Shaft
Spacer - Bearing Cup Output Shaft
Spacer - Bearing Cone Output Shaft
1
1
2
2
1
1
F-6
or
201-37-6
201-452-1
Spacer - Speedometer
Electronic Speedometer Signal Gear (16 grooves)
1
1
or
201-452-2
97-453-1
Speedometer Drive Gear (4T)
Speedometer Driven Gear (12T)
1
1
or
201-452-3
97-453-7
Speedometer Drive Gear (8T)
Speedometer Driven Gear (16T)
1
1
F-7
F-8
F-9
See Tab Bills
330734
545065
Flange or End Yoke
Washer - Output Shaft Nut 1
Nut-Output Shaft (1.75" - 16 UNEF - 3B)
1
N.S.S
Series
Not Sold Seperately
Yoke Style
End Yoke
Part No.
1710
1710
1760
1760
1810
1810
Full Round
Half Round
Full Round
Half Round
Full Round
Half Round
6-4-611
6-4-6611-1
6.3-4-651
6.3-4-651-1
6.5-4-3451
6.5-4-3451-1
SPL170
Half Round
170-4-471-1
S
End of Hub to
C/L Length
5.620"
5.620"
6.030"
6.030"
5.880"
5.880"
Maximum
Momentary
Joint Angle
Spline Type
30 degrees
30 degrees
30 degrees
30 degrees
30 degrees
30 degrees
Straight Sided
Straight Sided
Straight Sided
Straight Sided
Straight Sided
Straight Sided
N.S.S. - Not Sold Separately
11
tech line 800-401-9866
www.ttcautomotive.com
CLUTCH HOUSING, FRONT BEARING CAP, & MAIN CASE
9 SPEED TRANSMISSION
MODELS:
PS95-9A & PS125-9A,
PSO140-9A & PSO150-9A
12
tech line 800-401-9866
www.ttcautomotive.com
CLUTCH HOUSING, FRONT BEARING CAP & MAIN CASE
9 SPEED TRANSMISSION
Ref. No. Part No.
MODELS:
PS95-9A & PS125-9A,
PSO140-9A & PSO150-9A
G-1
201-518-21-2X
or
201-518-14-5x
or
201-518-25-2x
or
201-518-20-2x
N.S.
201-463-26
Description
Clutch Housing Group
Clutch Housing,Hand Hole Cover,Oil Troughts and Bushings (SAE #1 Iron)
(Includes G-1A thru G-6)
Clutch Housing,Hand Hole Cover,Oil Troughts and Bushings (SAE #2 Iron)
(Includes G-1A thru G-6)
Clutch Housing,Hand Hole Cover,Oil Troughts and Bushings (SAE #1 Iron)
(Neutral Start Switch Provision) (Includes G-1A thru G-6)
Clutch Housing,Hand Hole Cover,Oil Troughts and Bushings (SAE #1)
(Aluminum With Neutral Switch Provision) (Includes G-1A thru G-6)
"O”Ring-Countershaft Front (Aluminum Clutch Housings Only)
G-1A
G-2
G-3
G-4
G-5
G-6
N.S.S.
97-24-8
97-96-18-1X
201-468-1
545002-13
201-468-2
Clutch Housing
Bushing - Clutch Release Shaft
S/Assy. - Hand Hole Cover
Oil Trough - Countershaft
Screw - Oil Troughs (2 each)
Oil Trough - Drive Gear (N.L.A)(Less opti-lube Only)(301504-,505,544)
1
4
1
2
6
1
G-7
G-7A
G-7B
G-7C
G-8
40-477-1
201-477-3
201-200-6
201-438-15-3
545002-7
Support - Shift Rails (Front & Rear)
Support - Shift Rails (Front)(Neutral Start Switch Provision)
Plate-Lift(Neutral Start Switch Provision)
Pin-Roll(2.125")(Neutral Start Switch Provision)
Screw - Support Bar (3.75" - 16X1.50") (2 each)
2
1
1
1
4
G-9
G-10
330969
545001-1
Lift Hook
Screw - Clutch Housing (.500" - 16 X 1.375")
2
16
G-11
201-19-2-1X
G-12
G-13
G-14
G-15
N.S
Quantity
1
1
1
1
2
N.S.S.
97-463-36-1X
545002-1
Front Bearing Cap Group
S/Assy. - Drive Gear Bearing Cap and Oil Seal
(Includes G-12 thru G-13)
Bearing Cap
Oil Seal - Drive Cap Bearing Cap (w/installation sleeve)
Screw - Drive Gear Bearing Cap (.375" - 16 X 1.875")
1
1
4
201-15-13-1X
201-15-9-1X
201-15-10-1X
201-463-26
Main Case Group
S/Assy. -Main Case (Includes G-15A thru G-18)
Ford Only(Includes G-15A thru G-18)
Aluminum
"O”Ring-Countershaft Rear (Aluminum Clutch Housings Only)
1
1
1
4
1
13
tech line 800-401-9866
www.ttcautomotive.com
CLUTCH HOUSING, FRONT BEARING CAP & MAIN CASE
9 SPEED TRANSMISSION
MODELS:
PS95-9A & PS125-9A,
PSO140-9A & PSO150-9A
Ref. No. Part No.
Description
G-15A
G-16
G-17
G-18
N.S.
G-19
G-20
G-21
G-22
G-23
G-24
G-25
N.S.S.
545123
N.S.S.
201-39-1
330934
500597-14
201-118-4
201-96-5
545002-2
201-438-3
545012
73-267-1
Case
Plug - Filler & Drain with O-Ring
Washer - Filler & Drain Plug
Plug - Case Oil Return Hole
Magnet- Ceramic(Located @Large PTO Opening)
Pin -Alighnment(Optilube Mounting Plate)
Gasket_Oil Outlet Cover(Location Is Case Bottom)
Cover-Oil Outlet(Location Is Case Bottom)
Screw-Oil Outlet Cover(Location Is Case Bottom)
Pin-Dowel Case
Screw - PTO Aperture Cover (8Hole)
Cover - PTO (8 Hole)
1
1
1
1
2
4
1
1
2
4
8
1
G-26
G-27
50-267-2
330800
Cover - PTO (6 Hole)
Screw - PTO Aperture Cover
1
6
N.S.S
N.S.
Quantity
Not Sold Seperately
Not Shown
14
tech line 800-401-9866
www.ttcautomotive.com
OPTILUBE PUMP & RELATED PARTS
9 SPEED TRANSMISSION
MODELS:
PS95-9A & PS125-9A,
PSO140-9A & PSO150-9A
15
tech line 800-401-9866
www.ttcautomotive.com
MODELS:
PS95-9A & PS125-9A,
PSO140-9A & PSO150-9A
OPTILUBE PUMP & RELATED PARTS
9 SPEED TRANSMISSION
Ref. No. Part No.
OL-1
OL-2
OL-3
OL-4
OL-5
OL-6
OL-7
OL-8
OL-9
OL-10
OL-11
OL-12
OL-13
Description
201-501-11-2X
201-420-13X
545002-1
201-501-13X
201-360-2
545002-2
201-501-11-1X
N.S.S
N.S.S
N.S.S
N.S.S
N.S.S
N.S.S
N.S.S
N.S.S
Kit - Optilube Pump (Includes OL-1 thru OL-13)
S/Assy - Discharge Tube
Screw - Mounting Plate
S/Assy.-Oil Bypass Valve
Plate - Internal Pump Mounting
Screw - Pump Housing
Kit - Optilube Pump Housing and Gears (Includes OL-7 thru OL-13)
Gerotor Element - Internal Oil Pump
Shaft - Internal Oil Pump
Housing - Pump
"O" Ring - Tube
S/Assy.- Inlet Tube
Gear - Lube Pump Drive
Ring - Gear Pump Snap
Quantity
1
1
4
1
1
2
1
1
1
1
1
1
1
1
Not Sold Seperately
16
tech line 800-401-9866
www.ttcautomotive.com
WILLIAMS CONTROL & INTERLOCK GROUP
9 SPEED TRANSMISSION
MODELS:
PS95-9A & PS125-9A,
PSO140-9A & PSO150-9A
17
tech line 800-401-9866
www.ttcautomotive.com
WILLIAMS CONTROL & INTERLOCK GROUP
9 SPEED TRANSMISSION
MODELS:
PS95-9A & PS125-9A,
PSO140-9A & PSO150-9A
Ref. No. Part No.
Description
H-1
313630X
Williams Control
S/Assy. - Williams Control
1
H-2
H-3
H-4
H-5
545025-2
545028-6
545109
201-449-1
Elbow - Williams Control 90 Degrees
Screw - Williams Control (.438" - 14x2.2250")
Tee - Adapter Williams Control
Elbow - Williams Control
2
2
1
1
H-6
H-7
201-118-1
201-438-5
Gasket - Williams Control
Pin - Williams Air Control Valve
1
3
H-8
H-9
H-10
545128
201-72-6
40-438-1
Interlock Parts Group
Plug - 1st and Reverse Spring Plunger
Spring - 1St and Reverse
Pin - Plunger 1St and Reverse
2
2
2
H-11
or
or
or
H-12
313538
313552
M-556-3X
M-556-1X
201-438-2
Switch - Back up Light (Nav)
Switch - Back up Light (Paccar)
Switch - Back up Light (Mack)
Switch - Back up Light (Ford)
Pin - Actuating Back up Light Switch
1
1
1
1
1
H-13
H-14
H-15
201-200-1
201-200-2
330801-1
Interlock - Shifter Rail
Plate - Interlock Retainer
Screw - Interlock Plate (.438" - 14X.875")
1
1
2
H-16
H-17
201-80-1
201-72-2
201-72-8-1x
3
3
1
201-118-2
Ball - Poppet
Spring - Poppet Shift Rail
On Left Front Position for 9th Gear in COE
White Paint on Spring
Gasket
H-18
201-487-1
Insert - Poppet Spring & Ball
3
N.S.
N.S,
N.S,
201-420-9
330971
201-118-2
Convoluted Conduit
Clamp
Gasket-Shift Lever
A/R
A/R
1
N.S.
Quantity
Not Shown
18
tech line 800-401-9866
www.ttcautomotive.com
SHIFT BAR & FORK ASSEMBLY
9 SPEED TRANSMISSION
MODELS:
PS95-9A & PS125-9A,
PSO140-9A & PSO150-9A
19
tech line 800-401-9866
www.ttcautomotive.com
SHIFT BAR & FORK ASSEMBLY
9 SPEED TRANSMISSION
Ref. No. Part No.
MODELS:
PS95-9A & PS125-9A,
PSO140-9A & PSO150-9A
SB-1
or
SB2
or
SB-4
or
313696X
313795X
313694X
313769X
313695X
313819X
SB-4
or
313642-1X
313818-1X
and
201-66-18-3X
SB-5
545002
Description
Shift Bar and Fork Assemblies
Fork and Bar Assy. - 1st and Reverse
Fork and Bar Assy. - 1st and Reverse (Neutral Start Switch Provision)
Fork and Bar Assy. - 2nd and 3rd
Fork and Bar Assy. - 2nd and 3rd (Neutral Start Switch Provision)
Fork and Bar Assy. - 4th and 5th (PS Only)(Direct Transmissions)
Fork and Bar Assy. - 4th and 5th (PS Only) (Direct Transmissions)
(Neutral Start Switch Provision)
Bar Assy - 4th and 5th (PSO Only)(Overdrive Transmissions)
Bar Assy - 4th and 5th (PSO Only)(Overdrive Transmissions)
(Neutral Start Switch Provision)
Fork and Bar Assy.- 4th and 5th (PSO Only)(Overdrive Transmissions)
(Contains SB - 8 thru SB13)
Screw - Fork Mountin Bracket Overdrive (.375" X 1.00")
SB-6
SB-7
SB-8
SB-9
201-411-3-1X
N.S.S.
N.S.S.
N.S.S.
Kit - Shift Fork Mounting Bracket, Pin and Snap Rings
Mounting Bracket - Overdrive Shift Fork
Pin - Mounting
Snap Ring - Mounting Bracket Pin
1
1
1
2
SB-8
SB-9
SB-11
SB-12
SB-13
313642-1X
N.S.S.
N.S.S.
N.S.S.
N.S.S.
N.S.S.
REPAIR KITS FOR REF . NO. SB-4
Kit - Overdrive Shift Bar, Pins and Snap Rings
Pin - Mounting
Snap Ring - Mounting Bracket Pin
Snap Ring - Clevis Pin
Clevis Pin - Shift Fork
Shift Bar - 4th and 5th Overdrive
1
1
2
1
1
1
313818X
SB-8
SB-9
SB-11
SB-12
SB-13
N.S.S.
N.S.S.
N.S.S.
N.S.S.
N.S.S.
Kit - Overdrive Shift Fork, Pins and Snap Rings with Neutral Start
Switch Provision
Pin - Mounting
Snap Ring - Mounting Bracket Pin
Snap Ring - Clevis Pin
Clevis Pin - Shift Fork
Shift Bar - 4th and 5th Overdrive with Neutral Start Provision
Quantity
1
1
1
1
1
1
1
1
1
2
1
1
2
1
1
1
201-66-18-3X
N.S.S.
N.S.S.
N.S.S.
N.S.S.
N.S.S.
201-486-1
201438-10
Kit - Overdrive Shift Fork, Pins and Snap Rings
Pin - Mounting
Snap Ring - Mounting Bracket Pin
Shift Fork and Shoe Sub - assy. - 4th and 5th Overdrive
Snap Ring - Clevis Pin
Clevis Pin - Shift Fork
Shoe - Overdrive Shift Fork
Pins
1
1
2
1
1
1
2
SB-11
SB-12
201-438-6-1X
N.S.S.
N.S.S.
Kit - Mounting Pin and Snap Rings
Snap Ring - Clevis Pin
Clevis Pin - Shift Fork
1
1
1
SB-8
SB-9
201-438-7-1X
N.S.S.
N.S.S.
Kit - Mounting Bracket, Pins and Snap Rings
Pin - Mounting
Snap Ring - Mounting Bracket Pin
1
1
2
SB-8
SB-9
SB-10
SB-11
SB-12
SB-14
20
tech line 800-401-9866
www.ttcautomotive.com
RANGE CASE GROUP
9 SPEED TRANSMISSION
MODELS:
PS95-9A & PS125-9A,
PSO140-9A & PSO150-9A
21
tech line 800-401-9866
www.ttcautomotive.com
RANGE CASE GROUP
9 SPEED TRANSMISSION
Ref. No. Part No.
J-1
J-1A
J-2
J-3
N.S
J-4
J-5
J-6
J-7
or
J-8
J-9
201-15-3-1X
N.S.S.
NP-96
252-SP
NP-196
545123
N.S.S.
201-39-1
330360-7
330360-15
545001-1
545025-1
K-1
N.S.
K-2
K-3
K-4
K-5
K-6
K-9
K-8
K-7
K-10
K-11
201-66-23-2X
201-486-3
545045
201-501-2-1X
N.S.S.
545025-1
545002-1
201-463-1
201-463-2
201-463-3
183-463-6
201-136-7
K-12
K-13
and
N.S.
K-14
K-15
K-16
K-17
K-18
K-19
201-22-3
545002-1
545002-7
330564-3
500381-4
201-411-1
313644X
313042
330831
545025-1
Description
Range Case Group
S/Assy. - Case (Range) (Includes J-1A thru J-6)
Case -Range
Name Plate
Pin- Name Plate
Patent Plate
Plug - Filler & Drain Magnetic
Washer - Filler & Drain Plug
Plug - Temperature Indicator Hole
Stud - Rear Mounting (2.375")
Stud - Rear Mounting (3.562")
Screw - Range Case (.500"-13X1.375")
Elbow - 90 degree
Range Piston Housing and Shift Fork Group
S/Assy. - Fork and Rod and Clips - Range
Clips-Fork
Nut - Piston Rod - Range
S/Assy - Piston Housing - Range (Includes K-4 thru K-6)
Housing - Piston - Range
Elbow - Piston Housing 90 degree
Screw - Piston Housing (.375" - 16X.875")
"O" Ring - Piston Shift - Range
"O" Ring - Piston Housing - Range
"O" Ring - Piston Rod - Range
"O" Ring - Piston to Rod - Range
Piston - Shift - Range
Countershaft Bearing Cap Group
Cap - Countershaft Bearing
Screw - Bearing Cap (.375" - 16X.875")
Screw - Bearing Cap (.375" - 16X1.500")
Lift Hook
Spacer - Filter Regulator
Bracket - Filter Regulator
Kit - Power Control and Mounting Parts (Incl. K-17 thru K-19)
S/Assy. - Filter Regulator
Clamp - Filter Regulator Mounting
Elbow - Filter Regulator 90 degree
L-1
L-2
L-3
L-4
L-5
L-7
or
or
or
or
L-8
201-19-8-2X
201-19-8-1X
N.S.S.
201-463-8
545021
55-334-1
201-228-2-1
201-228-2-2
201-228-2-3
201-228-2-4
201-228-2-5
545002-6
Rear Bearing Cap Group
S/Assy. - Elect/Mech Bearing Cap Rear (Incl. L-2 thru L-5)
Bearing Cap
Seal - Bearing Cap Rear
Plug - Electronic Speedometer
Plug - Speedometer Outlet
Shim - Output Shaft (.005 thick)
Shim - Output Shaft (.010 thick)
Shim - Output Shaft (.015 thick)
Shim - Output Shaft (.020 thick)
Shim - Output Shaft (.030 thick)
Screw - Bearing Cap Rear (.375" - 16 X .250")
MODELS:
PS95-9A & PS125-9A,
PSO140-9A & PSO150-9A
Quantity
1
1
1
4
1
2
2
1
2
16
1
1
2
1
1
1
1
4
1
1
1
1
1
1
6
2
2
4
1
1
1
1
1
1
1
1
2
1
A/R
A/R
A/R
A/R
A/R
4
22
tech line 800-401-9866
www.ttcautomotive.com
SHIFT TOWER & RELATED PARTS
9 SPEED TRANSMISSION
MODELS:
PS95-9A & PS125-9A,
PSO140-9A & PSO150-9A
23
tech line 800-401-9866
www.ttcautomotive.com
SHIFT TOWER & RELATED PARTS
9 SPEED TRANSMISSION
MODELS:
PS95-9A & PS125-9A,
PSO140-9A & PSO150-9A
Ref. No. Part No.
Description
Quantity
N.S.
N.S.
P-1
or
P-2
P-3
or
or
N.S.
P-4
or
P-6
P-7
P-8
See Chart
See Chart
201-420-5-1X
201-420-5-2X
97-463-7
201-483-3
201-483-4
201-483-5
313885X
205-20-13
205-20-15
500370-4
500357-13
204-W
Shift Lever and Tower Assembly (Includes P-1 thru P-24)
Upper Lever and Knob Assy. (Includes P-1 thru P-15)
Harness - Air tUbing (48" long)
Harness - Air tubing (92" long for Remote Control use)
"O" Ring - Retaining Air Harness
Boot - Floorboard (Oval)
Boot - Floorboard (Oval)
Boot - Floorboard (Rectangular)
Shift Knob Assy. (Includes P-4 thru P-10)
Insert - Shift Pattern (9 speed Spicer w/shift pattern)
Insert - Shift Pattern ( Spicer )
Nut - Shift Knob Retaining
Washer - Shift Knob Retaining
Washer - Shift Knob Stop
1
1
1
1
3
1
1
1
1
1
1
1
1
1
P-9
P-10
P-11
N.S.
39Q-38-3 N.S.S.
201-205-1
201-438-8
201-420-7
Knob - Shift Air Valve (Serviced as 313885X)
Index Washer
Roll Pin - Shift Knob
Tube Support ( 3/16 )
1
1
1
1
P-12A
P-12B
P-13
See Special Note
See Special Note
See Special Note
545063
Upper Shift Lever Sub-Assy
S/Assy. - Upper Shift Lever ( Single Crimp Style )
S/Assy. - Upper Shift Lever ( Double Crimp Style )( Includes Lower End )
Set Screw ( Single Crimp Style Only )
1
1
1
N.S.
P-16
N.S.
N.S.
P-19
P-20
P-21
P-20
P-23
See Special Note
101-483-2
33Q-15-1
33Q-15-2
97-381-11
34Q-8
34Q-7
See Special Note
201-72-3
Lower Lever and Tower Assy. (Includes P-13 thru P-24)
Boot - Shift Tower & Lever
Tie - Cable (Upper)
Tie - Cable (Lower)
Snap Ring
Ring - Outer
Ring - Inner
Shift Lever - Lower End ( Single Crimp Style Only )
Spring - Disc
1
1
1
1
1
2
2
1
2
N.S.
N.S.
P-24
or
P-25
201-17-2X
201-17-3X
N.S.S.
N.S.S.
312268
1
1
1
1
1
P-26
P-27
201-118-2
545028-2
Sub-Assy. - Tower Housing (Includes P-24 thru P-25)
Sub-Assy. - Tower Housing (Includes P-24 thru P-25)
Tower - (6.312" Fulcrum) (Serviced as 201-17-2X)
Tower - (5.312" Fulcrum) (Serviced as 201-17-3X)
Breather
Following Parts are not Included in above Assemblies.
Gasket - Tower Housing
Screw - Tower Housing
1
6
Special Note
For Upper &/or Lower Levers Use 25Q - ( XXXX )
Found on Upper & Lower levers or Call Spicer Support Line @ 800-401-9866 With Stamping Numbers.
N.S.
Not Shown
N.S.S
Not Sold Seperately
A/R
As Required
24
tech line 800-401-9866
www.ttcautomotive.com
REMOTE CONTROL & RELATED PARTS
9 SPEED TRANSMISSION
MODELS:
PS95-9A & PS125-9A,
PSO140-9A & PSO150-9A
25
tech line 800-401-9866
www.ttcautomotive.com
REMOTE CONTROL & RELATED PARTS
9 SPEED TRANSMISSION
Ref. No. Part Number
201-18-6-3X
RC-1
201-18-6X
RC-2
RC-3
RC-4
RC-6
N.S.S.
312268
40-24-1
28P-19
Description
Remote Control Assembly
S.Assy. - Remote Control Housing, Bushings and Ball Joint
(Includes RC-2 thru RC-6 and RC-28 (313715))
Remote Control Housing
Breather Assembly
Bushing - Remote Control Housing
Seal - Remote Control Housing
Quantity
1
1
1
1
2
1
RC-7
201-65-5
RC-8
97-483-3
RC-9
33Q-15-1
RC-10 545136
RC-11 201-6-3
RC-12 500371-3
RC-12A
500024-5
RC-13 500362-11
Rod - Inner Shift Control
boot - Shift Rod Rubber
Tie - Cable
Bolt - Outer Shift lever
lever - Remote Outer Shift Control
Nut - Ball Stud
1
1
2
1
1
1
Cotter Pin
Lock Washer
1
1
RC-14
RC-15
RC-16
RC-17
RC-18
N.S.
RC-19
RC-20
RC-21
RC-22
201-6-11-1X
545117
201-999-3
201-483-2
N.S.S.
313727X
N.S.S.
N.S.S.
201-381-4
201-72-10
S/Assy. - Selector Lever and Arm (Includes RC-15 thru RC-22)
Ball Stud Selection Lever
Bearing - Race Selector Lever
Boot - Selector Lever
Lever - Selection
Kit - Grease Parts (Includes RC-19 and RC-20)
Nipple - Selection Lever
Retainer - Selection Lever
Snap Ring - Selection Lever
Spring - Disc Selection Lever
1
1
2
1
1
1
1
1
1
3
RC-23
RC-24
RC-25
RC-26
RC-27
RC-28
RC-29
RC-30
313673
545114
201-65-6
73Q-2
545113
313715
201-6-2
545137
Ball Joint - Female
Jam Nut - Turnbuckle
Tie Rod
Turn Buckle
Jam Nut - Turnbuckle (Left Hand)
Ball Joint - Male (.500-13 UNC thread on end into Housing)
Finger - Inner Shift
Screw - Shift Finger
1
2
1
1
1
1
1
1
N.S.
N.S.
545028-2
201-118-2
Parts Listed Below are not Included in Assembly
Screw - Control Housing (.438 - 14 X 1.500")
Gasket - Tower Housing
6
1
N.S. Not Shown
MODELS:
PS95-9A & PS125-9A,
PSO140-9A & PSO150-9A
N.S.S. Not Sold Seperately
26
tech line 800-401-9866
www.ttcautomotive.com
SERVICE PARTS OVERHAUL KITS
9 SPEED TRANSMISSION
Part Number
201-400-1X
313432-33X
313669X
313429-23X
201-210-4-1
201-201-4-2
201-210-4-3
201-438-6-1X
201-438-7-1X
201-47-4
201-47-6
330955
500007-24
545065
545087
Description
Major Overhaul Kit
Kit - Minor Overhaul
Kit - Range Piston Housing Repair
Kit - Shift Tower Repair Parts
Key - Countershaft Gear Rear
Key - Countershaft Gear Middle
Key - Countershaft Gear Front
Kit - Overdrive Shift Fork Mounting Pin and Snap Ring
Kit - Overdrive Shift Fork Bracket Pin and Snap Ring
Washer - Output Shaft Thrust (Range)
Ring - Range Mainshaft Drive Gear Thrust
Washer - Countershaft Reverse Idler Thrust (Range)
Key - Woodruff PTO Gear
Nut - Mainshaft
Pin - Thrust Washer Lock (Range Coutnershaft)
313432-33X
201-200-8
2783
2362
312475-45X
313667X
201-381-1
201-381-3
201-436-8
545080-1
545124
97-463-36-1X
201-463-26
Minor Overhaul Kit (Includes in Major Overhaul Kit)
Lock Strap
Bulletin - Mainshaft nut (Loctite Application)
Maintenance Manual
Kit - Gasket
Kit - Shim
Ring - Snap Input Shaft
Ring - Snap Mainshaft Range Drive Gear
Seal - Output Shaft Rear Bearing Cap
Anaerobic Sealant - Mainshaft Nut (0.5 cc vial)
Washer - Filler and Drian Plug
Oil - Seal Drive Gear Bearing Cap (w/installatin Tool)
"O" Ring - Counter Shaft ( Front )
1
1
1
1
1
1
1
1
1
1
3
1
6
313628X
313668X
550996
550998
551009
Bearings - Range Section
S/Assy. - Bearing and Spacer Output Shaft
Kit - Output Shaft Gear Needle Bearing
Bearing - Countershaft Front
Bearing - Countershaft Rear
Bearing - Countershaft Rear
1
1
2
2
2
313645X
550182
550375
550375
551010
551011
551013
550997
Bearings - Main Section
S/Assy. - Bearing and Belleville Snap Ring (Input Shaft)
Bearing - Countershaft Rear Cone
Bearing - Countershaft Rear Cup
Bearing - Coutnershaft Front Cup(After S/N J930506005)
Bearing - Coutnershaft Front Cup(Before S/N J930506005)
Bearing - Coutnershaft Front Cone(Before S/N J930506005)
Bearing - Coutnershaft Front Cone(After S/N J930506005)
Bearing - Reverse Idler Needle
MODELS:
PS95-9A & PS125-9A,
PSO140-9A & PSO150-9A
Quantity
1
1
1
2
2
2
1
1
1
1
2
2
1
2
1
2
2
2
2
27
tech line 800-401-9866
www.ttcautomotive.com
SERVICE PARTS OVERHAUL KITS
9 SPEED TRANSMISSION
Part Number
Description
313669X
Kit - Range Piston Housing Repair
(Include in Major Overhaul Kit)
"O" - Ring - Splitter or Range Piston
"O" - Ring - Range Shift Piston
"O" - Ring - Range Piston Housing
"O" - Ring - Range Piston Rod
Bulletin - "O" Ring Lubrication Instruction
Lubricant - "O" Ring
183-463-6
201-463-1
201-463-2
201-463-3
2726
330895
313429-23X
Quantity
1
1
1
1
1
1
1
Kit - Shift Tower Small Parts Repair
(Included in Major Overhaul Kit)
Pin - Actuating Back - up Light
Pin - Air Control Valve
Insert - Poppett Spring and Ball
Spring - Shift Rail Poppet
Ball - Poppet
Pin -1st and Reverse Select Plunger
Spring - 1st and Reverse Shift Plunger
1
3
3
3
3
3
3
312477-46X
201-72-3
2860
34Q-7
34Q-8
34Q-9
Kit- Shift Housing Bushing Kit
Spring-Disc
Bulletin
Ring-Inner (Lower)
Ring-Outer
Ring-Inner (Upper)
1
2
1
1
2
2
312475-45X
201-118-1
201-118-2
2724
545056-9
Gasket Kit (Included in Major and Minor Overhaul Kit)
Gasket - Williams Air Control Valve
Gasket - Tower Housing
Bulletin - Anaerobic Sealant Application
Anaerobic Sealant - 24cc Tube
1
1
1
1
1
313667-X
2825
201-228-1-1
201-228-1-2
201-228-1-3
201-228-1-4
201-228-1-5
201-228-1-8
201-228-1-9
201-228-2-1
201-228-2-2
201-228-2-3
201-228-2-4
201-228-2-5
Shim Kit (Included in Major and Minor Overhaul Kit)
Bulletin - Counterhsaft Shim Instructions
Shim - Coutnershaft Rear Bearing (.005" thick)
Shim - Countershaft Rear Bearing (.010" thick)
Shim - Coutnershaft Rear Bearing (.015" thick)
Shim - Countershaft Rear Bearing (.020" thick)
Shim - Countershaft Rear Bearing (.030" thick)
Shim - Countershaft Rear Bearing (.0465/.0435)
Shim - Countershaft Rear Bearing (.0515/.0485)
Shim - Output Shaft (.005" thick)
Shim - Output Shaft (.010" thick)
Shim - Output Shaft (.015" thick)
Shim - Output Shaft (.020" thick)
Shim - Output Shaft (.030" thick)
1
1
4
4
4
4
4
1
1
1
1
1
201-8-43-1X
201-196-35
201-8-43
2864
Kit - M/S & C/S Gear Replacement
Gear - C/S H.E.
Gear - M/S H.E.
Bulletin - Head End Gear Replacement
1
1
1
1
201-438-2
201-438-5
201-487-1
201-72-2
201-80-1
40-438-1
62-72-8
MODELS:
PS95-9A & PS125-9A,
PSO140-9A & PSO150-9A
1
28
tech line 800-401-9866
www.ttcautomotive.com
DIRECT AIR CONTROLS DIAGRAM
9 SPEED TRANSMISSION
MODELS:
PS95-9A & PS125-9A,
PSO140-9A & PSO150-9A
29
tech line 800-401-9866
www.ttcautomotive.com
301500-4
301500-3
301500-2
301500-1
301499-4
301499-3
301499-2
301499-1
301496-6
301496-5
301496-4
301496-3
301496-2
301496-1
301495-5
301495-4
301495-3
301495-2
301495-1
301432-6
301432-2
301432-1
301431-7
301431-6
301431-2
301431-1
BM
PS95-9A
PS95-9A
PS95-9A
PS95-9A
PS95-9A
PS95-9A
PSO125-9A
PSO125-9A
PSO125-9A
PSO125-9A
PSO150-9A
PSO150-9A
PSO150-9A
PSO150-9A
PSO150-9A
PSO150-9A
PS140-9A
PS140-9A
PS140-9A
PS140-9A
PS140-9A
PSO140-9A
PSO140-9A
PSO140-9A
PS125-9A
PS125-9A
PS125-9A
PS125-9A
Model
Navistar
Navistar
Navistar
Navistar
Navistar
Navistar
Navistar
Navistar
Navistar
Navistar
Navistar
Navistar
Service
Navistar
Navistar
Navistar
Navistar
Navistar
Navistar
Navistar
Navistar
Navistar
Navistar
Navistar
Navistar
Navistar
Navistar
Navistar
Navistar
Navistar
Cust
W/Ext Oil Pump, Rplcd by 301568-2
Replaced by 301568-2
Replaced by 301567-2
Replaced by 301567-2
Replaced by 301553-9
Replaced by 301553-9
Replaced by 301554-2
Replaced by 301553-9
Replaced by 301553-5
Replaced by 301553-1
Replaced by 301556-4
Replaced by 301556-3
Replaced by 301556-2
Replaced by 301556-2
Replaced by 301558-6
Replaced by 301558-5
Replaced by 301558-6
Replaced by 301556-2
Replaced by 301556-2
Replaced by 301556-2
Replaced by 301555-5
Replaced by 301555-5
Replaced by 301555-5
Replaced by 301555-5
Replaced by 301555-5
Replaced by 301557-7
Replaced by 301557-2
Replaced by 301557-2
Replaced by 301554-7
Replaced by 301554-6
Replaced by 301554-2
Replaced by 301554-2
Pull
Pull
Pull
Pull
Pull
Pull
Pull
Pull
Pull
Pull
Pull
Pull
Pull
Pull
Pull
Pull
Pull
Pull
Pull
Pull
Pull
Pull
Pull
Pull
Pull
Pull
Pull
Pull
Pull
Pull
Pull
Pull
Pull
Pull
Clutch
Type
1
1
1
1
1
1
2
2
1
2
2
2
2
2
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
2
1
1
SAE
201-518-20-2X
201-518-20-2X
201-518-20-2X
201-518-20-2X
201-518-20-2X
201-518-20-2X
201-518-14-5X
201-518-14-5X
201-518-10-5X
201-518-14-5X
201-518-14-5X
201-518-14-5X
201-518-14-5X
201-518-14-5X
201-518-10-5X
201-518-10-5X
201-518-10-5X
201-518-21-2X
201-518-10-5X
201-518-10-5X
201-518-10-5X
201-518-10-5X
201-518-10-5X
201-518-10-5X
201-518-10-5X
201-518-10-5X
201-518-10-5X
201-518-21-2X
201-518-10-5X
201-518-10-5X
201-518-10-5X
201-518-14-5X
201-518-10-5X
201-518-10-5X
Assembly #
Alum
Alum
Alum
Alum
Alum
Alum
201-35-2
201-35-2
201-35-2
201-35-2
201-35-2
201-35-2
201-35-7
201-35-7
201-35-2
201-35-7
201-35-6
201-35-2
201-35-7
201-35-2
201-35-2
201-35-2
201-35-2
201-35-2
201-35-2
201-35-2
201-35-2
201-35-2
201-35-2
201-35-2
201-35-2
201-35-2
201-35-2
201-35-2
201-35-2
201-35-2
201-35-2
201-35-2
201-35-2
201-35-2
Input
Shaft
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
Drive Gear
Brg Cap
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
Front Case
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
Rear Case
201-19-5-2X
201-19-5-2X
201-19-5-2X
201-19-5-2X
201-19-5-2X
201-19-5-2X
201-19-5-2X
201-19-5-2X
201-19-5-2X
201-19-5-2X
201-19-5-2X
201-19-5-2X
201-19-5-2X
201-19-5-2X
201-19-5-2X
201-19-5-2X
201-19-5-2X
201-19-8-1X
201-19-5-2X
201-19-8-1X
201-19-5-2X
201-19-5-2X
201-19-5-2X
201-19-5-2X
201-19-5-2X
201-19-5-2X
201-19-5-2X
201-19-5-2X
201-19-5-2X
201-19-5-2X
201-19-5-2X
201-19-8-1X
201-19-5-2X
201-19-5-2X
201-19-5-2X
MS Rear
Brg Cap
201-452-1 6-4-6611-1
201-452-1 6-4-6611-1
201-37-7
201-37-7
201-37-6
201-37-6
Speedo
Drive
MODELS:
PS95-9A & PS125-9A,
PSO140-9A & PSO150-9A
301500-7
LPS125-9A
Navistar
Replaced by 301568-2
201-35-2
9 SPEED TRANSMISSION
301500-9
LPS125-9A
Navistar
Replaced by 301569-5
Alum
BILL OF MATERIALS
PS9
301547-1
LPSO125-9A
Navistar
201-518-20-2X
Clutch Housing
301547-2
LPSO125-9A
Navistar
1
End
Yoke
301548-1
LPSO125-9A
Pull
Matl
301548-1
LPS140-9A
W/CS OIL PUMP, Rplcd by 301569-5
Note
301548-2
Navistar
6.5-4-3451
301549-1
LPS140-9A
201-37-7
301549-2
30
Cust
Replaced by 301569-4
Replaced by 301569-3
Pull
Pull
Pull
Pull
Clutch
Type
1
1
1
1
1
SAE
201-518-20-2X
201-518-20-2X
201-518-20-2X
201-518-20-2X
201-518-20-2X
201-518-20-2X
Assembly #
Alum
Alum
Alum
Alum
Alum
Alum
Alum
Matl
201-35-2
201-35-2
201-35-2
201-35-2
201-35-2
201-35-2
201-35-2
Input
Shaft
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
Drive Gear
Brg Cap
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
Front Case
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
Rear Case
201-19-5-2X
201-19-5-2X
201-19-5-2X
201-19-5-2X
201-19-5-2X
201-19-5-2X
201-19-5-2X
201-19-5-2X
201-19-5-2X
MS Rear
Brg Cap
MODELS:
PS95-9A & PS125-9A,
PSO140-9A & PSO150-9A
Navistar
Replaced by 301569-5
Pull
201-518-20-2X
201-15-3-1X
201-19-5-2X
9 SPEED TRANSMISSION
Model
Navistar
Replaced by 301570-2
1
201-15-3-1X
BILL OF MATERIALS
PS9
LPS9-VPD
Service
Replaced by 301570-2
1
201-15-13-1X
201-15-3-1X
Clutch Housing
BM
LPS9-VPD
Navistar
Pull
201-15-13-1X
End
Yoke
301549-3
LPS140-9A
Navistar
Pull
201-19-2-1X
201-15-13-1X
Speedo
Drive
301549-4
LPSO140-9A
Replaced by 301571-4
201-19-2-1X
201-19-5-2X
Note
301549-5
LPSO140-9A
Replaced by 301571-2
201-35-2
201-19-2-1X
201-19-5-2X
301550-1
Navistar
201-35-2
201-15-3-1X
301550-2
Navistar
Alum
201-35-2
201-15-3-1X
LPSO150-9A
201-518-20-2X
Alum
201-15-13-1X
LPSO9-VPD
1
201-518-20-2X
201-15-13-1X
301551-1
Pull
201-518-14-5X
201-19-2-1X
301551-2
Replaced by 301571-3
1
201-19-2-1X
Navistar
2
201-35-6
LPSO9-VPD
Pull
201-35-7
201-452-1 6-4-6611-1
301551-3
Pull
201-518-14-5X
201-19-5-2X
201-452-1 6-4-6611-1
Replaced by 301571-4
201-518-14-5X
201-19-5-2X
Service
2
201-15-3-1X
201-19-5-2X
Navistar
2
201-15-3-1X
LPSO150-9A
Pull
201-15-13-1X
201-15-3-1X
Service Replacement 301554-2
Replaced by 301553-9
PS95-9A
Pull
201-15-13-1X
201-452-1 6-4-6611-1
301551-4
Replaced by 301553-5
201-19-2-1X
201-15-13-1X
201-37-6
301553-1
Replaced by 301553-9
201-19-2-1X
201-19-5-2X
Navistar
201-35-2
201-19-2-1X
201-19-5-2X
Navistar
201-35-6
201-15-3-1X
PS95-9A
201-518-10-5X
201-35-7
201-15-3-1X
PS95-9A
201-518-14-5X
201-15-13-1X
301553-2
1
201-518-14-5X
201-15-13-1X
301553-3
Pull
2
201-19-2-1X
Navistar
2
201-19-2-1X
201-19-5-2X
201-37-7
PS95-9A
Pull
201-35-7
201-19-8-1X
301553-4
Pull
201-35-2
201-15-3-1X
201-19-8-1X
TSP
201-518-14-5X
201-15-3-1X
Navistar
201-518-10-5X
201-15-13-1X
201-15-3-1X
PS95-9A
2
201-15-13-1X
PS95-9A
1
201-19-2-1X
201-15-13-1X
301553-5
Pull
201-19-2-1X
201-37-7
301553-7
Pull
201-35-2
201-19-2-1X
201-37-7
Navistar
201-35-2
201-19-8-1X
Navistar
201-518-10-5X
201-35-2
201-19-5-2X
PS95-9A
201-518-10-5X
201-15-3-1X
PS125-9A
1
201-518-10-5X
201-15-3-1X
301553-9
1
201-15-13-1X
201-37-7
301554-1
Pull
1
201-15-13-1X
201-19-8-1X
Service Replacement 301556-2
Service Replacement 301557-2
6.5-4-3451
6.5-4-3451
Pull
201-19-2-1X
201-19-5-2X
Navistar
Pull
201-19-2-1X
201-15-3-1X
201-19-5-2X
PS125-9A
Service Replacement 301554-7
201-35-2
201-15-3-1X
301554-2
Service Replacement 301554-7
201-35-2
201-15-13-1X
201-15-3-1X
Navistar
201-518-10-5X
201-15-13-1X
Navistar
201-518-14-5X
201-19-2-1X
201-15-13-1X
PS125-9A
1
201-19-2-1X
201-19-5-2X
PS125-9A
2
201-35-2
201-19-2-1X
201-19-5-2X
301554-3
Pull
201-35-2
201-15-3-1X
301554-4
Pull
201-518-10-5X
201-35-2
201-15-3-1X
Service Replacement 301554-7
201-518-10-5X
201-15-13-1X
Navistar
1
201-518-10-5X
201-15-13-1X
Navistar
1
201-19-2-1X
PS125-9A
Pull
1
201-19-2-1X
PS125-9A
Pull
201-35-2
301554-5
Pull
201-35-2
301554-6
Service Replacement 301555-5
201-518-10-5X
201-19-5-2X
Navistar
Service Replacement 301555-5
201-518-10-5X
201-19-5-2X
PS125-9A
Navistar
1
201-15-3-1X
201-19-5-2X
301554-7
Navistar
1
201-15-3-1X
PS140-9A
Pull
201-15-13-1X
201-15-3-1X
PS140-9A
Pull
201-15-13-1X
201-19-5-2X
301555-1
Service Replacement 301555-5
201-19-2-1X
201-15-13-1X
201-19-5-2X
301555-2
Service Replacement 301555-5
201-19-2-1X
201-15-3-1X
Navistar
201-35-2
201-19-2-1X
201-15-3-1X
Navistar
201-35-2
201-15-13-1X
PS140-9A
201-518-10-5X
201-35-2
201-15-13-1X
PS140-9A
201-518-10-5X
201-19-2-1X
301555-3
1
201-518-10-5X
201-19-2-1X
301555-4
Pull
1
201-35-2
Navistar
1
201-35-7
PS140-9A
Pull
201-518-14-5X
301555-5
Pull
201-518-14-5X
Navistar
2
Navistar
2
PSO125-9A
Pull
201-19-5-2X
PSO125-9A
Pull
201-15-3-1X
201-19-5-2X
301556-1
Navistar
201-15-13-1X
201-19-5-2X
301556-2
Navistar
201-19-2-1X
201-15-3-1X
PSO125-9A
201-35-2
201-15-3-1X
PSO125-9A
201-518-10-5X
201-15-13-1X
301556-3
1
201-15-13-1X
301556-4
Pull
201-19-2-1X
Navistar
201-19-2-1X
PSO140-9A
201-35-2
301557-1
201-35-2
Service Replacement 301557-7
201-37-7
201-518-10-5X
Navistar
201-518-21-2X
Navistar
1
PSO140-9A
1
PSO140-9A
Pull
301557-2
Pull
301557-6
31
301569-2
301569-1
301568-2
301567-2
301558-7
301558-6
301558-5
301558-4
301558-3
301558-2
301558-1
301557-7
BM
LPS9-VPD
LPS9-VPD
LPS140-9A
LPS140-9A
LPSO125-9A
LPS125-9A
PSO150-9A
PSO150-9A
PSO150-9A
PSO150-9A
PSO150-9A
PSO150-9A
PSO150-9A
PSO140-9A
Model
Navistar
Service
Navistar
Navistar
Navistar
Navistar
Navistar
Navistar
Navistar
Navistar
Navistar
Navistar
Navistar
TSP
Cust
Service Replacement 301569-5
Service Replacement 301569-5
Service Replacement 301569-5
MOL Group Service Replacement 301558-6
Navistar
Service Replacement 301569-5
W/Neutral Start Provision
Service Replacement 301558-6
Service Replacement 301558-2
Service Replacement 301558-2
W/Neutral Start Provision
Pull
Pull
Pull
Pull
Pull
Pull
Pull
Pull
Pull
Pull
Pull
Pull
Pull
Pull
Pull
Pull
Pull
Pull
Clutch
Type
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
SAE
201-518-20-2X
201-518-20-2X
201-518-20-2X
201-518-20-2X
201-518-20-2X
201-518-20-2X
201-518-20-2X
201-518-20-2X
201-518-20-2X
201-518-20-2X
201-518-20-2X
201-518-20-2X
201-518-10-5X
201-518-10-5X
201-518-21-2X
201-518-10-5X
201-518-10-5X
201-518-10-5X
201-518-10-5X
201-518-21-2X
Assembly #
Alum
Alum
Alum
Alum
Alum
Alum
Alum
Alum
Alum
Alum
Alum
Alum
201-35-2
201-35-2
201-35-2
201-35-2
201-35-2
201-35-2
201-35-2
201-35-2
201-35-2
201-35-2
201-35-2
201-35-2
201-35-2
201-35-2
201-35-2
201-35-2
201-35-2
201-35-2
201-35-2
201-35-2
Input
Shaft
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
201-19-2-1X
Drive Gear
Brg Cap
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
201-15-13-1X
Front Case
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
201-15-3-1X
Rear Case
201-19-5-2X
201-19-5-2X
201-19-5-2X
201-19-5-2X
201-19-5-2X
201-19-5-2X
201-19-5-2X
201-19-5-2X
201-19-5-2X
201-19-5-2X
201-19-5-2X
201-19-5-2X
201-19-8-1X
201-19-8-1X
201-19-5-2X
201-19-8-1X
201-19-5-2X
201-19-5-2X
201-19-5-2X
201-19-5-2X
MS Rear
Brg Cap
201-452-1
Speedo
Drive
6.5-1-2271
End
Yoke
MODELS:
PS95-9A & PS125-9A,
PSO140-9A & PSO150-9A
301569-3
LPS140-9A
Navistar
Pull
9 SPEED TRANSMISSION
301569-4
LPSO140-9A
Navistar
Pull
BILL OF MATERIALS
PS9
301569-5
LPSO150-9A
Navistar
Clutch Housing
301570-2
LPSO9-VPD
Service
Matl
301571-1
LPSO9-VPD
Note
301571-2
LPSO150-9A
201-37-6
301571-3
Service Replacement 300571-4
301571-4
32
14700 Helm Court
Plymouth, MI 48170
(800) 401-9866 or (734) 456-3770
Fax: (734) 456-3739
www.ttcautomotive.com