service manual - Philips Parts and Accessories

Transcription

ICF-DVD57TV
SERVICE MANUAL
US Model
Ver. 1.0 2005.04
Manufactured under license from Dolby
Laboratories. “Dolby”, “Pro Logic”, and the
double-D symbol are trademarks of Dolby
Laboratories.
Model Name Using Similar Mechanism
NEW
Optical Pick-up Block Name
KHM-310BAA
“DTS,” “DTS Digital Surround” and “DTS
Digital Out” are trademarks of Digital Theater
Systems, Inc.
SPECIFICATIONS
AUDIO POWER
SPECIFICATIONS
POWER OUTPUT AND TOTAL HARMONIC
DISTORTION
With 6–ohm loads, both channels driven from
100 – 10 000 Hz; rated 1.4 W per channelminimum RMS power, with no more than 10
% total harmonic distortion in AC operation.
DVD/CD player section
Emission duration
Laser output
Frequency response:
TV section
Television system
Channel coverage
Antenna
Screen type
Size
System
Number of dots
Input
American TV standard/
NTSC
VHF: 2–13/UHF: 14–69/
CATV: 1–125
75-ohm external antenna
terminal for VHF/UHF
Wide LCD color monitor
9 inches
TFT active matrix
336,960 dots
1 video, 1 audio
Wow and flutter:
Output
Continuous
Less than 1,000 µW
(This output is the value
measured at a distance of
about 200 mm from the
objective lens surface on
the optical pick-up block
with 7 mm aperture.)
CD: 20 – 20,000 Hz +1/-1
dB
DVD Video: 20 – 22,000 Hz
+1/-1 dB
Below measurable limit
OPTICAL OUTPUT
Radio section
Frequency range
FM : 87.5 – 108 MHz
AM: 530 – 1,710 kHz
General
Time display
Speaker
Power outputs
Power requirements
Dimensions
Mass
Supplied accessories
12-hour system
77 mm (3 1⁄8 inches) dia,
6Ω
1.8 W + 1.8 W (at 10%
harmonic distortion)
120 V AC, 60 Hz
Approx. 400 × 123 × 322.5
mm (w/h/d)
(Approx. 15 3⁄4 × 4 7⁄8 × 12 3⁄4
inches) incl. projecting
parts and controls
Approx. 4.8 kg (10 lb 9 oz)
Mounting screws (4),
Template (1),
Spacers (4),
Remote control (1)
Design and specifications are subject to change
without notice.
LCD-TV DVD KITCHEN CLOCK RADIO
9-879-703-01
2005D05-1
© 2005.04
Sony Corporation
Personal Audio Group
Published by Sony Engineering Corporation
ICF-DVD57TV
Notes on chip component replacement
• Never reuse a disconnected chip component.
• Notice that the minus side of a tantalum capacitor may be
damaged by heat.
Flexible Circuit Board Repairing
• Keep the temperature of the soldering iron around 270 ˚C
during repairing.
• Do not touch the soldering iron on the same conductor of the
circuit board (within 3 times).
• Be careful not to apply force on the conductor when soldering
or unsoldering.
SAFETY CHECK-OUT
After correcting the original service problem, perform the following
safety check before releasing the set to the customer:
Check the antenna terminals, metal trim, “metallized” knobs, screws,
and all other exposed metal parts for AC leakage.
Check leakage as described below.
LEAKAGE TEST
The AC leakage from any exposed metal part to earth ground and
from all exposed metal parts to any exposed metal part having a
return to chassis, must not exceed 0.5 mA (500 microamperes).
Leakage current can be measured by any one of three methods.
1. A commercial leakage tester, such as the Simpson 229 or RCA
WT-540A. Follow the manufacturers’ instructions to use these
instruments.
2. A battery-operated AC milliammeter. The Data Precision 245
digital multimeter is suitable for this job.
3. Measuring the voltage drop across a resistor by means of a
VOM or battery-operated AC voltmeter. The “limit” indication
is 0.75 V, so analog meters must have an accurate low-voltage
scale. The Simpson 250 and Sanwa SH-63Trd are examples
of a passive VOM that is suitable. Nearly all battery operated
digital multimeters that have a 2 V AC range are suitable. (See
Fig. A)
CAUTION
Use of controls or adjustments or performance of procedures
other than those specified herein may result in hazardous radiation
exposure.
About the discs this unit
can play
This unit can play the following discs:
•DVD VIDEO
•DVD-R/DVD+R
•DVD-RW/DVD+RW
•Video CD
•Audio CD
•CD-R/CD-RW
Disc type
Label on the disc
DVD Videos
Video CD
Audio CDs
To Exposed Metal
Parts on Set
0.15 µF
1.5 k Ω
AC
voltmeter
(0.75 V)
“DVD VIDEO,” “DVD-R” and “DVD-RW” are
trademarks.
Discs that this system cannot play
•CD-ROMs
•CD-Rs/CD-RWs other than those recorded in
the following formats:
Earth Ground
Fig. A. Using an AC voltmeter to check AC leakage.
SAFETY-RELATED COMPONENT WARNING!!
COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE
WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN
THE PARTS LIST ARE CRITICAL TO SAFE OPERATION.
REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE
PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR
IN SUPPLEMENTS PUBLISHED BY SONY.
2
— music CD format
— video CD format
•Data part of CD-Extras
•Super Audio CDs
•DVD-ROMs
•DVD-RAMs
•DVD Audio discs
•8 cm(3 inches) DVD discs
•Photo Movies created after recording in VR
mode by DVD Handycam.
•Progressive JPEG format file
•Discs with non-standard shapes (e.g., heart,
square, star) cannot be played on this unit.
Attempting to do so may damage the unit.
Do not use such discs.
•A disc with paper or stickers on it
•A disc that has the adhesive, cellophane tape,
or a sticker still left on it.
* A logical format of files and folders on a CDROMs, defined by ISO (International
Organization for standardization).
ICF-DVD57TV
Notes about CD-R/CD-RW/DVD-R/
DVD-RW/DVD+R/DVD+RW
• In some cases, CD-Rs, CD-RWs, DVD-Rs,
DVD-RWs, DVD+Rs or DVD+RWs cannot be
played on this system depending upon the
recording quality or physical condition of the
disc, or the characteristics of the recording
device. Furthermore, the disc will not play if
it has not been correctly finalized. For more
information, see the operating instructions
for the recording device.
• A disc recorded in packet write format
cannot be played.
DVD region code this unit can play.
This unit has a region code printed on the top
of the unit and will only play DVDs that are
labeled with identical region codes. DVDs
labeled
will also be played on this unit.
If you try to play any other DVD, the message
“WRONG REGION” will appear on the screen.
Depending on the DVD, the region code
indication may not appear even if the DVD is
prohibited by area restrictions.
ALL
Region code
Note on DTS*-encoded DVDs/CDs
To enjoy DTS Digital Surround™ playback, an
external 5.1-channel DTS Digital Surround™
decoder system must be connected to the
digital output of this unit.
* “DTS,” “DTS Digital Surround” and “DTS Digital
Out” are trademarks of Digital Theater Systems,
Inc.
TABLE OF CONTENTS
1.
SERVICING NOTES ............................................... 4
2.
GENERAL ................................................................... 5
3.
DISASSEMBLY
3-1.
3-2.
3-3.
3-4.
3-5.
3-6.
3-7.
3-8.
3-9.
3-10.
Disassembly Flow ...........................................................
Cabinet (Upper), Tray Lid Assy ......................................
Mechanical Deck Assy ....................................................
Cabinet (Front) Assy .......................................................
DVD Board ......................................................................
MAIN Board ....................................................................
Monitor Assy ...................................................................
Cabinet (Disp Rear) .........................................................
Shield (Disp) ....................................................................
MONITOR Board,
Liquid Crystal Display Panel (LCD1) .............................
3-11. Belt, Tray .........................................................................
3-12. Optical Pick-up KHM-310BAA ......................................
6
7
7
8
8
9
9
10
10
11
12
12
4.
TEST MODE .............................................................. 13
5.
ELECTRICAL ADJUSTMENTS ......................... 16
6.
DIAGRAMS
6-1.
6-2.
6-3.
6-4.
6-5.
6-6.
6-7.
6-8.
6-9.
6-10.
6-11.
6-12.
6-22.
6-23.
6-24.
Block Diagram – DVD Section – ....................................
Block Diagram – TUNER Section – ...............................
Block Diagram – AUDIO/PANEL Section – ..................
Block Diagram – MONITOR Section – ..........................
Block Diagram – POWER SUPPLY Section – ...............
Printed Wiring Board – DVD Board (Side A) – ..............
Printed Wiring Board – DVD Board (Side B) – ..............
Schematic Diagram – DVD Board (1/2) – ......................
Schematic Diagram – DVD Board (2/2) – ......................
Printed Wiring Board – TU Board – ................................
Schematic Diagram – TU Board – ..................................
Printed Wiring Board
– MAIN Board (Component Side) – ...............................
– MAIN Board (Conductor Side) – .................................
Schematic Diagram – MAIN Section (1/4) – ..................
Printed Wiring Board – LCD Board – .............................
Printed Wiring Boards – SWITCH/TRANS Section ......
– MONITOR Board (Component Side) – .......................
– MONITOR Board (Conductor Side) – .........................
Schematic Diagram – MONITOR Board (1/3) – ............
7.
EXPLODED VIEWS
7-1.
7-2.
7-3.
7-4.
7-5.
7-6.
Cabinet (Upper) Section ..................................................
Cabinet (Front) Section ...................................................
Cabinet (Lower) Section-1 ..............................................
Cabinet (Lower) Section-2 ..............................................
Monitor Section ...............................................................
Mechanical Deck Section ................................................
8.
ELECTRICAL PARTS LIST ................................ 76
6-13.
6-14.
6-15.
6-16.
6-17.
6-18.
6-19.
6-20.
6-21.
22
23
24
25
26
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
70
71
72
73
74
75
3
ICF-DVD57TV
SECTION 1
SERVICING NOTES
NOTES ON HANDLING THE OPTICAL PICK-UP
BLOCK OR BASE UNIT
The laser diode in the optical pick-up block may suffer electrostatic break-down because of the potential difference generated
by the charged electrostatic load, etc. on clothing and the human
body.
During repair, pay attention to electrostatic break-down and also
use the procedure in the printed matter which is included in the
repair parts.
The flexible board is easily damaged and should be handled with
care.
NOTES ON LASER DIODE EMISSION CHECK
The laser beam on this model is concentrated so as to be focused
on the disc reflective surface by the objective lens in the optical
pick-up block. Therefore, when checking the laser diode emission, observe from more than 30 cm away from the objective lens.
UNLEADED SOLDER
Boards requiring use of unleaded solder are printed with the leadfree mark (LF) indicating the solder contains no lead.
(Caution: Some printed circuit boards may not come printed with
the lead free mark due to their particular size)
: LEAD FREE MARK
Unleaded solder has the following characteristics.
• Unleaded solder melts at a temperature about 40 °C higher than
ordinary solder.
Ordinary soldering irons can be used but the iron tip has to be
applied to the solder joint for a slightly longer time.
Soldering irons using a temperature regulator should be set to
about 350 °C.
Caution: The printed pattern (copper foil) may peel away if the
heated tip is applied for too long, so be careful!
• Strong viscosity
Unleaded solder is more viscou-s (sticky, less prone to flow)
than ordinary solder so use caution not to let solder bridges occur such as on IC pins, etc.
• Usable with ordinary solder
It is best to use only unleaded solder but unleaded solder may
also be added to ordinary solder.
4
ICF-DVD57TV
SECTION 2
GENERAL
This section is extracted from
instruction manual.
Connection
Location of controls
qd
qf
qg
qh
qj
qk
1
2
3
4
Use this hookup if you subscribe to a CATV
System that does not require a cable box.
ql
w;
wa
ws
5
6
7
8
9
0
qa
wd
qs
Refer to the pages listed for details.
* There is a tactile dot on the VOLUME + and
u buttons.
1 DISPLAY RELEASE
2 Disc Tray
3 TIMER dial and TIMER indicator, PUSH
START/STOP button
To operate the Cooking Timer.
4 Clock Display Window
5 Receptor for the remote control
6 CLOCK button
To set the clock.
7 MODE/SCREEN SIZE button
To set the screen mode, and to set the FM
mode.
8 TV MENU button
To change the screen settings.
9 ENTER button
0 SOUND button
To set the audio emphasis.
qa VOLUME +/– buttons
qs Speakers (left/right)
qd Z OPEN/CLOSE button
qf AUX button
To watch the AUDIO/VIDEO INPUT.
qg TV button
To turn on the TV.
qh DVD button
To turn on the player.
qj RADIO ON/BAND button
To turn on the radio.
To change the band (FM/AM).
qk OFF button
To turn off the AUX/TV/DVD/Radio
unit.
ql x (Stop) button
w; u (Play/Pause) button
wa TV CH/PRESET –, .(Previous)/
+ ,>(Next) button
To select a TV channel, to tune in a preset
station, to select the item during TV
MENU operation, or to adjust the screen
settings.
ws RADIO TUNE/TIME SET –, m(Fast
reverse)/+, M(Fast forward) button
To tune in a desired radio station or to set
the clock.
This can also be used in slow playback mode.
wd Monitor
Basic Connections
(Connecting CATV or an
Antenna)
Connecting directly to cable or an antenna
Setting the Clock
Remote control
1
2
3
4
5
6
7
qf
qg
qh
qj
8
9
0
qa
qs
qd
wa
ws
wd
The corresponding buttons of the
remote control function the same as
those on the unit.
Instructions in this manual describe how to use
the unit by mainly using the remote control.
1
Plug in the unit.
“AM 12:00” will flash in the Clock Display
Window.
2
Press CLOCK for a few seconds.
You will hear a beep and the hour digits
will start to flash in the Clock Display
Window.
3
Press RADIO TUNE/TIME SET –, m(fast
reverse) or +, M(fast forward) until
the correct hour appears in the Clock
Display Window.
4
Press CLOCK (or ENTER) once.
The minute digits will flash.
5
Press RADIO TUNE/TIME SET –, m(fast
reverse) or +, M(fast forward) until
the correct minute appears in the Clock
Display Window.
6
Press CLOCK (or ENTER) once.
You will hear two short beeps and the
seconds start counting from zero.
qk
ql
w;
wf
wg
* There is a tactile dot on the “5”, “u” and
“TUNE/CH+” buttons of the remote control.
Refer to the pages listed for details.
1 SETUP button
Used to perform menu operations.
2 DISP (Display) button
To display the channel number or the time
information of the disc.
3 AUX button
To watch the AUDIO/VIDEO INPUT.
4 Number buttons
5 REPEAT button
To select the repeat mode (DVD/Video
CD/Audio CD).
6 .(Previous)/>(Next) buttons
7 tSLOW/m(Fast reverse)/TSLOW/M
(Fast forward) buttons
This can also be used in slow playback
mode.
8 TOP MENU button
To display the top menu of a recorded DVD,
or to set the PBC (playback control)
function on or off for the Video CD.
9 O (Return) button
q; v/V/b/B buttons
qa MENU button
To display the recorded DVD menu.
qs VOL (Volume) +/– buttons
qd MUTING button
To attenuate the volume.
qf TV button
To turn on the TV.
qg OFF button
To turn off the AUX/TV/DVD/Radio unit.
qh RADIO/BAND button
To turn on the radio.
qj DVD button
To turn on the unit.
qk TV MENU button
To change the screen settings.
ql u (Play/Pause) button
w; x (Stop) button
wa AUDIO button
To change the audio output/audio language.
ws ANGLE button
To select the multiple angles of view while
playing a DVD.
wd ENTER button
To enter a setting.
wf TUNE/CH +/– buttons
To select the desired TV channel, to tune in
to the desired station, to select the item
during TV MENU operation or to adjust
the screen settings.
wg SOUND button
To set the audio emphasis.
Tips
• To set the current time rapidly, hold down
RADIO TUNE/TIME SET –, m(fast reverse) or +,
M(fast forward).
• To set the current time exactly to the seconds,
adjust the minute function in step 6 and then
press CLOCK (or ENTER) to synchronize it with a
time signal (such as the telephone time signal).
• In the 12-hour system: “AM 12:00” = midnight.
5
ICF-DVD57TV
SECTION 3
DISASSEMBLY
• This set can be disassembled in the order shown below.
3-1. DISASSEMBLY FLOW
SET
3-2. CABINET (UPPER), TRAY LID ASSY
(Page 7)
3-3. MECHANICAL DECK ASSY
(Page 7)
3-4. CABINET (FRONT) ASSY
(Page 8)
3-11. BELT, TRAY
(Page 12)
3-5. DVD BOARD
(Page 8)
3-7. MONITOR ASSY
(Page 9)
3-6. MAIN BOARD
(Page 9)
3-8. CABINET (DISP REAR)
(Page 10)
3-12. OPTICAL PICK-UP
KHM-310BAA
(Page 12)
3-9. SHIELD (DISP)
(Page 10)
3-10. MONITOR BOARD,
LIQUID CRYSTAL DISPLAY PANEL (LCD1)
(Page 11)
6
ICF-DVD57TV
Note: Follow the disassembly procedure in the numerical order given.
3-2. CABINET (UPPER), TRAY LID ASSY
4 two screws
(B3)
4 eight screws
(B3)
5 screw (B3)
4 eight screws
(B3)
7 cabinet (upper)
6
3 Turn on the power supply, and press the
open/close button to close the tray.
2 tray lid assy
1 Turn on the power supply, and press the
open/close button to open the tray.
3-3. MECHANICAL DECK ASSY
3 three screws
(B3)
6 mechanical deck assy
1 flexible flat (24 core) cable
(CN702)
2 connector
(CN703)
4
(CN351)
7
ICF-DVD57TV
3-4. CABINET (FRONT) ASSY
(CN601)
(CN602)
(CN403)
4 two screws
(B2.6)
5 claw
6 cabinet (front) assy
4 two screws
(B2.6)
5 three claws
5 claw
3-5. DVD BOARD
(CN704)
(CN701)
4 four screws
(B2.6)
3 connector
(CN705)
5 DVD board
6 shield (DVD lower)
8
ICF-DVD57TV
3-6. MAIN BOARD
2 connector
(CN901)
2 four connectors
(CN403, CN404, CN405, CN406)
2 two connectors
(CN302, CN401)
3 terminal
(CN902)
4 three screws
(B2.6)
4 three screws
(B2.6)
5 MAIN board
(CN10)
3-7. MONITOR ASSY
1 four connectors
(CN403, CN404, CN405, CN406)
5 Push the button (release).
6
7 monitor assy
4 four screws
2 four claws
3 cover (shaft)
9
ICF-DVD57TV
3-8. CABINET (DISP REAR)
3 two sliders (DISP)
4 cabinet (DISP rear)
2 six claws
2 three claws
2 three claws
2 three claws
1 two screws
2 two claws
3-9. SHIELD (DISP)
1 two screws
1 three screws
2 shield (DISP)
1 two screws
10
ICF-DVD57TV
3-10. MONITOR BOARD, LIQUID CRYSTAL DISPLAY PANEL (LCD1)
1 four connectors
(CN1403, CN1404, CN1405, CN1406)
4 screw
6 MONITOR board
2 connector
(CN1801)
8 bracket (DISP)
4 screw
5 two screws
7 screw
8 bracket (DISP)
7 screw
3 LCD flexible board
(CN1802)
qa two adhesive tapes
qs liquid crystal display panel
(LCD1)
9
qa two adhesive tapes
q; panel (DISP)
11
ICF-DVD57TV
3-11. BELT, TRAY
5 chuck cam
6 belt
3 claw
4 tray
3 claw
1 Slide the chuck cam in the direction
of arrow to releae the chucking.
2
3-12. OPTICAL PICK-UP KHM-310BAA
2 two claws
7 insulator
5 insulator screw
8 optical pick-up KHM-310BAA
6
7 insulator
7 insulator
5 insulator screw
5 insulator screw
7 insulator
5 insulator screw
4 holder (FFC)
12
3 two claws
ICF-DVD57TV
SECTION 4
TEST MODE
LCD TEST MODE
TV TEST MODE
Procedure:
1. Turn the power on while pressing simultaneously three keys
of M , x and [TV MENU].
2. The microprocessor version will be displayed on the LCD.
3. Press the Z key. The LCD display will become as follows.
Procedure:
1. Turn the power on while pressing simultaneously two keys
of M and x .
2. When the TV test mode is activated, the monitor will become
as follows.
LCD display
SR7596 TEST MODE MENU
TIMER
RADIO
DVD FM
TV AM
AUX PM
MEGABASS
MEGAXpand
MHz
kHz
1.
2.
3.
4.
5.
VOL
4. The display corresponding to a key is turned off, if a key on
the set is pressed.
SR7596 Ver. 1.00a
Key Corresponding Table
Key
TIMER
INITIAL MENU
FOR FACTORY
LCD SETTING
LOAD DEFAULT
TUNER TEST
Segment
TIMER , TIMER LED
CLOCK
AM, PM, : (colon)
MODE
5a, 5d, MEGA EXPAND, P, kHz, MHz
TV MENU
6b, 6c, 6d, 6e, 6g, 5c, 5e
3. Five items can be changed over by pressing the [TV MENU]
key.
4. The selected item is displayed in red and the items not selected
are displayed in cyan. (“SR7596 Ver. 1.00a” is displayed in red.)
5. You can enter the selected item by pressing the [ENTER] key.
6. Also, an item can be selected directly with the [1] to [5] keys
on the remote commander (RMT-CDVD57A).
SOUND
MEGA BASS
VOLUME –
– VOL –
1.
VOLUME +
. (dot)
m
5f
M
6a
.
4a, 4d, 4e
>
1d, 1h, 1a, 1e, 1f, 1g
• TV menu item is initialized.
Procedure:
1. Press the [TV MENU] key to select the “INITIAL MENU” on
the main screen.
2. Each item of TV menu can be initialized, if pressing the
[ENTER] key.
u
2c, 2f, 2h, 2i
x
3e, 3f
OFF
1b, 1c, 2a, 2b, 2d, 2e, 2g, 3a, 3b, 3c, 3d, 3g,
4b, 4c, 4f, 4g
BAND
RADIO, FM
DVD
DVD
TV
TV
AUX
AUX
5. After all keys on the set were pressed, press the Z key, and
the test mode will be released.
INITIAL MENU (TV MENU PRESET)
2.
FOR FACTORY (FOR ADJUSTMENT)
3.
LCD SETTING
• It is used at the time of adjustment.
Procedure:
1. Press the [TV MENU] key to select the “FOR FACTORY” on
the main screen.
2. A changing between setting item and “EXIT” is possible by
pressing the [TV MENU] key. (The selected item is displayed
in red)
3. If the [ENTER] key is pressed when the setting item has been
selected, settable items can be changed over, and the value of
the selected item can be adjusted by pressing the . /
> keys. (For details, refer to VIDEO BUS ADJUSTMENT
(See page 19))
4. The main screen comes back if the [ENTER] key is pressed
when “EXIT” has been selected.
Note: The same operation is also carried out by pressing the keys
on the remote commander.
This mode is not used in servicing.
4.
LOAD DEFAULT
5.
TUNER TEST
• It carries out, only when EEPROM (IC1451) is exchanged.
Procedure:
1. Press the [TV MENU] key to select the “LOAD DEFAULT” on
the main screen.
2. All settings can be initialized, if pressing the [ENTER] key.
(In addition to the “INITIAL MENU”, set value of RGB
decoder (IC1501) and tuner N value)
This mode is not used in servicing.
13
ICF-DVD57TV
DVD TEST MODE
Procedure:
1. Turn the power on and press the [DVD] key to select the “DVD”.
2. Press the Z key to open the disc tray.
3. Press the key on the remote commander (RMT-CDVD57A)
as following order.
[TOPMENU] → [ANGLE] → [MENU] → [AUDIO]
4. When the test mode is activated, the monitor will become as
follows.
SR-7596
TEST MODE
JITTER VALUE
RF LEVEL
TRACKING ERROR AMP
FOCUS ERROR AMP
TRK SERVO GAIN AUTO ADJ
FCS SERVO GAIN AUTO ADJ
1.
–
–
–
–
–
–
—
—
—
—
—
—
1.45 ± 0.1 Vp-p
17. Connect the oscilloscope to TP710 and TP711 on the DVD
board.
18. Check that the oscilloscope waveform of R-Y signal is as
shown in the figure below.
1.45 ± 0.1 Vp-p
DVD OPERATION CHECK
Procedure:
1. Insert the DVD test disc (TDV-540C) (Part No. J-2501-235A) to start the automatic adjustment for DVD.
2. Connect the multi meter to TP753 and TP751 on the DVD
board.
3. Check that the reading of multi meter is 40 to 75 mA.
4. Check that the JITTER VALUE of monitor is 2D5 to 000
HEX.
board.
6. Check that the RF LEVEL of monitor is B8 to 87 HEX.
7. Check that the oscilloscope waveform of RF signal is as shown
in the figure below. (eye pattern)
A good eye pattern means that the diamond shape (◊) in the
center of the waveform can be clearly distinguished.
550 ± 100 mVp-p
8. Check that the TRACKING ERROR AMP of monitor is EB
to 8C HEX.
9. Check that the FOCUS ERROR AMP of monitor is FF to BE
HEX.
10. Check that the TRK SERVO GAIN ADJ of monitor is 56 to
38 HEX.
11. Check that the FOCU SERVO GAIN ADJ of monitor is 42 to
18 HEX.
12. Insert the DVD test disc (HLX-N1) (Part No. 8-797-000-10)
and play the title5-chapter2 (full color bar 100%).
board.
14. Check that the oscilloscope waveform of Y signal is as shown
in the figure below.
1.0 ± 0.1 Vp-p
14
board.
16. Check that the oscilloscope waveform of B-Y signal is as
shown in the figure below.
2.
CD OPERATION CHECK
Procedure:
1. Insert the CD test disc (PATD-012) (Part No. 4-225-203-01)
to start the automatic adjustment for CD.
2. Connect the multi meter to TP753 and TP752 on the DVD
board.
3. Check that the reading of multi meter is 55 to 85 mA.
4. Check that the JITTER VALUE of monitor is 2BC to 000
HEX.
board.
6. Check that the RF LEVEL of monitor is A5 to 70 HEX.
7. Check that the oscilloscope waveform of RF signal is as shown
in the figure below. (eye pattern)
A good eye pattern means that the diamond shape (◊) in the
center of the waveform can be clearly distinguished.
700 ± 200 mVp-p
8. Check that the TRACKING ERROR AMP of monitor is BA
to 6E HEX.
9. Check that the FOCUS ERROR AMP of monitor is FF to B9
HEX.
10. Check that the TRK SERVO GAIN ADJ of monitor is 4F to
32 HEX.
11. Check that the FOCU SERVO GAIN ADJ of monitor is 52 to
37 HEX.
ICF-DVD57TV
Connecting Location:
– DVD BOARD (Side B) –
TP752
TP761
TP751
TP753
TP709 TP707
TP711
TP706
TP708
TP710
TP702
15
ICF-DVD57TV
SECTION 5
ELECTRICAL ADJUSTMENTS
0 dB=1 µV
TUNER SECTION
T1
[AM]
Setting:
Function: RADIO
Band: AM
AM RF signal
generator
Put the lead-wire
antenna close to
the set.
AM VCO VOLTAGE ADJUSTMENT
Adjustment Part
Frequency Display Reading on Digital Voltmeter
Confirmation
530 kHz
1.0 ± 0.1 V
L4
1,710 kHz
5.3 ± 0.7 V
MAIN board
CN302 pin 1
level meter
AM TRACKING ADJUSTMENT
Adjust for a maximum reading on level meter
L3
620 kHz
CT3
1,400 kHz
6Ω
+
–
set
30% amplitude
modulation by
400 Hz signal
Output level:
as low as possible
MAIN board
CN302 pin 2
T2
[FM]
Setting:
Function: RADIO
Band : FM
MAIN board
CN302 pin 1
TU board
FM RF signal
TP (ANT)
generator
0.01 µF
level meter
6Ω
+
–
set
22.5 kHz frequency
deviation by 400 Hz
signal
Output level:
as low as possible
TU board
TP (GND)
MAIN board
CN302 pin 2
digital voltmeter
TU board
TP (VT)
TP (GND)
100 k Ω
• Repeat the procedures in each adjustment several times, and
the tracking adjustments should be finally done by the trimmer
capacitors.
16
AM IF ADJUSTMENT
450 kHz
FM IF ADJUSTMENT
Adjust for a minimum reading on level meter
10.7 MHz
FM VCO VOLTAGE ADJUSTMENT
Adjustment Part
Frequency Display Reading on Digital Voltmeter
Confirmation
87.5 MHz
1.3 ± 0.2 V
L2
108 MHz
3.0 ± 0.2 V
FM TRACKING ADJUSTMENT
L1
87.5 MHz
CT1
108 MHz
Adjustment and Connecting Location:
TU board (See page 17)
ICF-DVD57TV
– TU BOARD (Component Side) –
T2 FM IF Adjustment
L4
AM VCO Voltage Adjustment
T1 AM IF Adjustment
L2
FM VCO Voltage Adjustment
L1
CT1
L3
CT3
FM Tracking Adjustment
AM Tracking Adjustment
– TU BOARD (Conductor Side) –
TP
(VT)
TP
(ANT)
TP
(GND)
17
ICF-DVD57TV
5-2-3. VSS (–13.0V) Check
Connection:
MONITOR SECTION
5-1. VOLTAGE AND FREQUENCY ADJUSTMENT
digital
voltmeter
TP1951
5-1-1. 5.0V Adjustment
Connection:
set
+
–
digital
voltmeter
TP1907
set
TP1901 (GND)
+
–
TP1901 (GND)
Adjustment Procedure:
1. Connect a digital voltmeter to the TP1907 and TP1901 (GND)
on the MONITOR board.
2. Adjust the RV1901 so that the reading of digital voltmeter is
5.0 ± 0.1 V.
5-1-1. DC/DC Converter Frequency Adjustment
Connection:
TP1906
set
Checking Procedure:
2. Check that the reading of digital voltmeter is –12.0 ± 1.0 V.
5-2-4. 7.5V Check
Connection:
digital
voltmeter
TP1909
set
+
–
frequency
counter
+
–
TP1901 (GND)
Adjustment Procedure:
1. Connect a frequency counter to the TP1906 and TP1901
(GND) on the MONITOR board.
2. Adjust the RV1902 so that the reading of frequency counter is
243 ± 1 kHz.
TP1901 (GND)
Checking Procedure:
2. Check that the reading of digital voltmeter is 7.4 ± 0.2 V.
5-2-5. 3.9V Check
Connection:
digital
voltmeter
TP1421
set
+
–
5-2. VOLTAGE CHECK
5-2-1. VDD (3.3V) Check
Connection:
TP1901 (GND)
digital
voltmeter
TP1954
set
+
–
Checking Procedure:
5-2-6. Inverter Voltage Check
Connection:
TP1901 (GND)
Checking Procedure:
digital
voltmeter
TP1952
+
–
TP1901 (GND)
Checking Procedure:
18
TP1412
set
+
–
TP1901 (GND)
5-2-2. VGH (17.0V) Check
Connection:
set
digital
voltmeter
Checking Procedure:
ICF-DVD57TV
5-3. PLL ADJUSTMENT
5-5. OSD DOT CLOCK CHECK
Connection:
Connection:
frequency counter
(high impedance probe)
TP1515
digital
voltmeter
TP1651
set
set
+
–
+
–
TP1901 (GND)
TP1901 (GND)
Adjusting Procedure:
2. Adjust the RV1651 so that the reading of digital voltmeter is
2.2 ± 0.15 V.
1. Connect an frequency counter to the TP1515 and TP1901
2. Check that the reading of frequency counter is 6.5 ± 0.2 MHz.
5-6. NTSC SUB CARRIER CHECK
5-4. V COM ADJUSTMENT
Connection:
Connection:
frequency counter
(high impedance probe)
TP1510
TP1960
osclloscope
set
set
+
–
+
–
TP1901 (GND)
TP1901 (GND)
Connect an oscilloscope to the TP1960 and TP1901 (GND) on the
MONITOR board.
Checking Procedure:
1. Connect an frequency counter to the TP1510 and TP1901
2. Check that the reading of frequency counter is 3.579545 MHz
± 100 Hz.
5-4-1. Voltage Set Up Adjustment
Adjust the set so that the A level of the waveform on the oscilloscope
is 6.6 ± 0.1 Vp-p. (Refer to the 5-7. video bus adjustment)
5-7. VIDEO BUS ADJUSTMENT
Connection: (5-7-1 to 5-7-9)
TP1963 or
TP1964 or
TP1965
INPUT VIDEO jack
(JK501)
NTSC pattern
generator
A
osclloscope
set
5-4-2.
Position Set Up Adjustment
Check the B level of the waveform on the oscilloscope is 4.7 ± 0.1
Vp-p and adjust the RV1501 so that the C level of the waveform
on the oscilloscope is –1.9 ± 0.1 Vp-p.
TP1901 (GND)
Condition: (5-7-1 to 5-7-9)
Input the NTSC video signal (10 step (no burst)) (1 Vp-p 75 Ω) to
the INPUT VIDEO jack (JK501) on the MAIN board from NTSC
pattern generator.
B
0V
C
+
–
1. Set the TV test mode (Refer to TV TEST MODE (See page
13).
2. Press the [TV MENU] key to select “LOAD DEFAULT”, and
press the [ENTER] key to write initial values to the EEPROM.
Note: It carries out, only when EEPROM (IC1451) is exchanged.
3. Press the [TV MENU] key to select “FOR FACTORY”, and press
the [ENTER] key to enter the adjustment mode.
4. If entering the adjustment mode, press the [TV MENU] key to
select item, and press the [ENTER] key to execute all adjustment
items mentioned below.
19
ICF-DVD57TV
5-7-1. Gamma 1 Adjustment
5-7-5. White Limit (White Limiter Level) Adjustment
1. Connect an oscilloscope to the TP1964 and TP1901 (GND)
2. Adjust the . / > keys so that the C level of the
waveform on the oscilloscope is 2.1 ± 0.1 Vp-p.
2. Adjust the . / > keys so that the F level of the
F
C
0V
5-7-2.
Gamma 2 Adjustment
0V
5-7-6.
2. Adjust the . / > keys so that the D level of the
R-Sub BRT (R-ch Sub Bright) Adjustment
1. Connect an oscilloscope of 1 step voltage to the TP1963 and
TP1901 (GND) on the MONITOR board.
2. Adjust the . / > keys so that the B level of the
D
B
0V
0V
5-7-3.
Y Gain (Luminance Signal Contrast Level)
Adjustment
2. Adjust the . / > keys so that the E level of the
5-7-7.
B-Sub BRT (B-ch Sub Bright) Adjustment
2. Adjust the . / > keys so that the B level of the
E
B
0V
0V
5-7-8.
5-7-4.
R-Sub CONT (R-ch Sub Contrast) Adjustment
Black Limit (Black Limiter Level) Adjustment
2. Adjust the . / > keys so that the A level of the
E
0V
A
20
0V
ICF-DVD57TV
5-7-9.
B-Sub CONT (B-ch Sub Contrast) Adjustment
– MONITOR BOARD (Component Side) –
RV1901
5.0V Adjustment
RV1902
DC/DC Converter
Frequency Adjustment
E
0V
RV1651
PLL Adjustment
Connection: (5-7-10 to 5-7-12)
INPUT VIDEO jack
(JK501)
NTSC pattern
generator
set
RV1501
V COM Adjustment
5-7-10. VCO Free Run Adjustment
Condition:
Input the NTSC video signal (10 step (no burst)) (1 Vp-p 75 W) to
the INPUT VIDEO jack (JK501) on the MAIN board from NTSC
pattern generator.
– MONITOR BOARD (Conductor Side) –
Adjust the . / > keys so that a screen on the monitor may
become normal.
TP1412
TP1421
5-7-11. PLL/V POS Adjustment
TP1515
Condition:
Input the NTSC video signal (monoscope) (1 Vp-p 75 W) to the
INPUT VIDEO jack (JK501) on the MAIN board from NTSC
pattern generator.
TP1906
TP1901
(GND)
Press the . / > keys to adjust so that the position of screen
on the monitor becomes vertically symmetric.
TP1909
TP1907
5-7-12. H POS Adjustment
TP1651
TP1510
Condition:
Input the NTSC video signal (monoscope) (1 Vp-p 75 W) to the
INPUT VIDEO jack (JK501) on the MAIN board from NTSC
pattern generator.
TP1960
TP1951
Press the . / > keys to adjust so that the position of screen
on the monitor becomes horizontally symmetric.
TP1952
ICF-DVD57TV
21
21
TP1965
TP1954
TP1963
TP1964
ICF-DVD57TV
SECTION 6
DIAGRAMS
6-1. BLOCK DIAGRAM – DVD Section –
6 DVDRF IP
C
8 MA
B
9 MB
A
10 MC
D
11 MD
2
3
4
5
E
F
18 TNI
19 TPI
VC
29 V20
PD
20 MDI1
21 MDI2
22 LDO2
L.P.F.
YUV6/B 203
L.P.F.
B
(Page 24)
B-Y
R-Y
ASDATA0 217
ACLK 215
ABCK 214
ALRCK 213
3 SDTI
AOUTL+ 12
1 MCLK
2 BICK
4 LRCK
AOUTL– 11
AOUTR+ 10
5 PDN
AOUTR– 9
MIX AMP
IC303
DVD LCH
R-CH
ARST 222
• R-ch is omitted due to same as L-ch.
• SIGNAL PATH
OPTICAL
TRANSCEIVER
JK502
SPDIF 225
: DVD/CD PLAY (VIDEO)
OPTICAL
OUTPUT
: DVD/CD PLAY (ANALOG AUDIO OUT)
23 LDO1
: DVD/CD PLAY (DIGITAL AUDIO OUT)
MAIN SYSTEM CONTROLLER
IC401 (1/3)
FOCUS/TRACKING COIL DRIVE,
SPINDLE/SLED MOTOR DRIVE
IC705
FCS+
FCS–
14 VOFS+
13 VOFS–
7 VNFFC
VINFC 1
42 FOO
TRK+
TRK–
16 VOTK–
15 VOTK+
20 VNFTK
VINTK 26
41 TRO
SLED MOTOR+
SLED MOTOR–
17 VOLD–
18 VOLD+
VINLD 23
38 FMO
SPINDLE MOTOR+
SPINDLE MOTOR–
11 VOLD–
12 VOLD+
VOSL 6
37 DMO
STBY 28
50 STBY
XIFCS 169
XIFBUSY 168
56 DVD XIFCS
50 DVD XIFBUSY
AMUTE 220
57 DVD AMUT IN
XPRST 110
58 DVD RST
TMS 49
DVD OPEN 39
S001-1
DISC TRAY
OPEN DETECT
DVD CLOSE 42
S001-2
DISC TRAY
CLOSE DETECT
DISC TRAY OPEN/CLOSE
MOTOR DRIVE
IC351
LOADING A 51
3 A IN
A OUT 8
LOADING B 60
2 B IN
B OUT 7
M
61 TRAY DET
M301
DISC TRAY
OPEN/CLOSE
FLASH ROM
IC707
34 OP_OUT
36 OP_INP
35 OP_INN
SD-RAM
IC708
D0 – D7
A-1, A0 – A19
DQ0 – DQ15
A0 – A11
29, 31, 33, 35,
38, 40, 42, 44
45, 25 – 18, 8 – 1,
48, 17, 16, 9
26 28 11
2, 4, 5, 7, 8, 10, 11, 13, 42,
44, 45, 47, 48, 50, 51, 53
23 – 26,
29 – 34, 22, 35
81 – 84,
86 – 88, 91
93, 78, 53 – 59, 75, 74,
72 – 67, 92, 60, 61, 76
77 79 66
125 – 123, 121, 120, 118, 117,
115, 135, 133 – 128, 126
147, 149 – 151, 166 – 164,
162, 160, 159, 146, 158
AD0 – AD7
IOA0 – IOA20
RD0 – RD15
RA0 – RA11
228 XTALO
RF AMP, SERVO DSP,
MPEG DECODER
IC706
X701
27MHz
229 XTALI
ICF-DVD57TV
22
22
DQML
DQMH
RAS
CAS
CS
WE
136 LIMIT
54 DVD SO0
53 DVD SI0
55 DVD SCK
20 21
38 37
15 39 18 17 19 16
143 145 156 157 113 137 140 139 142 138
DQM0
DQM1
XRAS
XCAS
XRCS
XRWE
MSW
SO 178
SI 170
SCK 179
CE
OE
WE
114 DVD/CD
LIMIT SWITCH
(Page 25)
XIOCS
XIOOE
XIOWR
CDVR
DVD/CD
SWITCH
Q702
A
D/A CONVERTER
IC704
Q703
DVDVR
Y, B-Y, R-Y
CLK
CKE
CDLD
AUTOMATIC
POWER CONTROL
Q701
YUV5/G 202
Y
RCLK
CKE
DVDLD
L.P.F.
BA0/A13
BA1/A12
OPTICAL PICK-UP
BLOCK
(KHM-310BAA)
DVDA
DVDB
DVDC
DVDD
YUV4/R 200
BA0
BA1
RF
EEP_DA 103
EEP_CK 102
EEPROM
IC709
5 SDA
6 SCL
ICF-DVD57TV
6-2. BLOCK DIAGRAM – TUNER Section –
T2
FM IFT
T2
FM IF
10
ANT
2
FM
RF IN
FM
RF AMP
MIX OUT
FM
MIX
CF2
4
7
FM
IF IN
FM IF
AMP
DET
OUT
AF
16
BUFFER
FM
DET
CT1, L1
FM TRACKING
L1
FM RF
24
FM
RF OUT
FM
OSC
CF4
D1
L3
AM FERRITE-ROD
ANTENNA
AM IF
AMP
AM
DET
OSC
OUT
AM
OSC
CT3, L3
20
AM TRACKING
19
BUFFER
17
FM OSC
AM OSC
D3
(1/2)
ST
IND
IF
BUFFER
ST IND
AM
MIX
MUTE
R-OUT
TU LCH
12
11
D
(Page 24)
R-CH
LEVEL
DET
IF OUT
AM
RF AMP
MPX
STEREO/
MONO,
FM/AM
AM IF
BUFFER
CT3
6
AM
IF IN
T1
22
L-OUT
AF
AMP
T1
AM IFT
CT1
AM
RF IN
15
MPX
IN
18
LPF2/MO-ST
C
LPF1/BAND
(Page 26)
QUAD
FM/AM RF AMP, MIX, OSC,
FM/AM IF AMP, DET, MPX
IC1
13 14
• R-ch is omitted due to same as L-ch.
• SIGNAL PATH
21
L4
L2
AM VCO VOLTAGE
FM VCO VOLTAGE
: FM
: AM
L2
FM OSC
L4
AM OSC
D3
(2/2)
D2
VT B+
MUTE
LOW-PASS
FILTER
20
X1
75kHz
19
XOUT
XIN
LOW-PASS
FILTER
REFERENCE
DIVIDER
BAND
7
13
MO/ST
9
BAND
8
ST-IND
10
IF IN
11
AMIN
12
FMIN
16
PD
17
LP-IN
18
LP-OUT
6
FM/AM
FM/AM PLL
IC2
UNIVERSAL
COUNTER
PHASE
DETECTOR/
CHARGE PUMP
DI
CL
CCB
INTERFACE
1/2
CE
DO
UNLOCK
DETECT
12 BIT
PROGRAMMABLE
DIVIDER
SWALLOW
COUNTER
SHIFT REGISTER & LATCH
ICF-DVD57TV
23
23
2
3
1
4
PLL DATA
PLL CLK
PLL CE
PLL DATA, PLL CLK,
PLL CE, MUTE
E
(Page 24)
ICF-DVD57TV
6-3. BLOCK DIAGRAM – AUDIO/PANEL Section –
TV LCH
INPUT
SELECT
SWITCH
SEL L
4
1
V LIN
VOLUME
CONTROL
SURROUND
CONTROL
INPUT SELECT SWITCH,
ELECTRICAL VOLUME,
SURROUND/TONE CONTROL
IC302
TONE
CONTROL
LOGIC
14 13
19
L OUT
17
12
13
MUTING
Q103
18
L IN
NF L
MUTING
CONTROL
Q302
SIGNAL PATH
D103
AGC
Q104
: FM
+
+
STANDBY
SWITCH
Q301
D102
: TV (AUDIO)
R-CH
R-CH
(Page 25) G
µ-COM R DATA,
µ-COM S DATA,
µ-COM CLK,
µ-COM LATCH,
RESET
68 67
PLL DATA
PLL CLK
PLL CE
MUTE
µ-COM R DATA
µ-COM S DATA
µ-COM CLK
µ-COM LATCH
RESET
65
66
64
63
29
33
34
37
36
VOL DAT
VOL CLK
(Page 23) E
PLL DATA, PLL CLK,
PLL CE, MUTE
RADIO DATA
RADIO CLK
RADIO CE
RADIO MUTE
A MUTE 78
R-CH
BUZZER 52
µ-COM R DATA
µ-COM S DATA
µ-COM CLOCK
µ-COM LATCH
XRESET
SEG0 – SEG15
10 – 25
IC401 (2/3)
STBY 79
COM0 – COM3
6–9
LIQUID CRYSTAL DISPLAY
LCD601
REMOTE CONTROL
RECEIVER
IC601
SIRCS
BUFFER
Q401
TIMER LED 80
LED DRIVE
Q601
D604
TIMER
46 KEY0
OPEN/CLOSE LED 30
LED DRIVE
Q651
OPEN/
CLOSE
Z
45 KEY1
AUX LED 31
LED DRIVE
Q652
D652
AUX
44 KEY2
TV LED 32
LED DRIVE
Q653
D653
TV
43 KEY3
DVD LED 59
LED DRIVE
Q654
D654
DVD
TUNER LED 35
LED DRIVE
Q655
D655
RADIO
BAND
48 RC
S659 – 664
D651
S665 – 670
S653 – 658
S652
S651
X1
XT2
XT1
40 ENCODE+
41 ENCODE–
X2
ROTARY
ENCODER
75
74
71
70
X401
4.19MHz
ICF-DVD57TV
24
24
X402
32.768kHz
SP101
(L-CH)
3
R-CH
8
R-CH
R-CH : R-ch is omitted due to same as L-ch.
L OUT
POWER
AMP
STBY
F
TU LCH
BOUTL
(Page 25)
CD LIN
5
R LIN
7
TV LIN
9
BNFL
(Page 23) D
POWER AMP
IC301
DVD LCH
SI
SC
(Page 22) B
MONITOR ON
SP201
(R-CH)
ICF-DVD57TV
6-4. BLOCK DIAGRAM – MONITOR Section –
TV/AUX AUDIO
SELECT SWITCH
IC502
L
JK501
INPUT
1
TV LCH
2
AUDIO
R-CH
R
13
VIDEO
4
3
TV ANT
X1501
3.579545MHz
5
TU501
TV TUNER UNIT
VHF/UHF
MUTING
Q101
Q504
LIQUID CRYSTAL
DISPLAY MODULE
LCD1 (1/2)
VIDEO INPUT SELECT SWITCH
IC501
L OUT 25
R OUT 24
V COM AMP
IC1503
VCOMOUT 28
R-CH
D101, 105
63
VXO-NTSC
R-CH
V COM BIAS
Q1506 – 1510
TRAP
RV1501
V COM
3
VIDEO AMP
Q505
7
1
Y
5
CTRAPOUT 53
54 CTRAPIN
57 CIN
4
2
A
52 YIN
B-Y
R-Y
Y, B-Y, R-Y
R-OUT 26
G-OUT 21
RGB DECODER
IC1501
4 R-YIN
HDOUT 32
VDOUT 31
HSYNCLOCK
RF AGC 13
AGC
Q501
MODE 20
AUDIO MODE
SELECT SWITCH
Q503
30 T-AGC
39
AUDIO MODE
SELECT SWITCH
Q502
20 HSYNCN
19 VSYNCN
DATA
SCLK
CSN
SDATA
SCLK
48 47
31 T-MUTE
MUTE 22
78 T-MODE
SYNC DET
Q1503, 1505
79 T-FMONO
G
2
5
8
14
HSYNCIN
VDBIN
BLACK
POL
CPH1
CPH2
CPH3
CPV
29
27
25
16
CLK1
CLK2
CLK3
CPV
OEV1
OEV2
OEV3
OEH
19
18
17
21
OEV1
OEV2
OEV3
OEH
54 55 53
61 62 63 64 35
X1
OSD-DATA
OSD-CLK
OSD-CS
ZOOM
JUST
SIDE1
SIDE2
XRESET
12 31 4 3 39
74
µCOM-S DATA
µCOM-R DATA
µCOM-CLK
µCOM-LATCH
XRESET
EEPROM-SDA
EEPROM-SCL
57
56
58
51
76
49 50
VSYNC
µ-COM R DATA
µ-COM S DATA
µ-COM CLK
µ-COM LATCH
RESET
52
HSYNCLOCK
µ-COM R DATA, µ-COM S DATA,
µ-COM CLK, µ-COM LATCH, RESET
36 VCO1
37 VCO0
75
65
(Page 24)
ICF-DVD57TV
25
25
SUB SYSTEM CONTROLLER
IC1401 (1/2)
VSS (–13.0V)
STV1
STV2
STH1
STH2
5 6
66 67
VGON (17V)
VDD (3.3V)
VEE (5.0V)
20
26
23
24
X1401
4.19MHz
SDA
SCL
DISPLAY
RELEASE
BLUE
STV1
STV2
STH1
STH2
37 TFT OPEN
: AUX IN (AUDIO)
: AUX IN (VIDEO)
33 PD
X2
SDA
SCL
: TV (VIDEO)
PHASE
COMPARATOR
IC1651
HD
VD
BLAK
POL
SIGNAL PATH
GREEN
LCD CONTROLLER
IC1601
RV1651
PLL
EEPROM
IC1451
S401
VSS–13V
OSC
3 1 2
R-CH : R-ch is omitted due to same as L-ch.
: TV (AUDIO)
OSC OUT 7
OSC IN 8
18 36
RED
VB (2.5V)
15 BLK
YS 17
35 VDIN
VGH17V
VDD3V
VEE5V
16 VR
17 VG
18 VB
BLAK
POL
46 CSYNCIN CSYNCOUT 34
46 T-AFT
AFT OUT 15
BUFFER
Q1504
B
OSD DRIVER
IC1502
BLAK
POL
SYNC
SEPARATOR
Q1501, 1502
VDOUT
HDOUT
34
32 T-SDATA
33 T-SCL
SDA 4
SCL 3
F MONO 21
80
DVD ON
TV +5V
77
TV/AUX_MUTE
TV +9V
TV/AUX
23
2
14
26
G
R-IN2 14
G-IN2 15
B-IN2 16
(Page 22)
9V (MPX)
5V (TU)
5V (F)
5V (D/D)
R
G-OUT
B-OUT
B-OUT 19
5 B-YIN
R-OUT
ZOOM
JUST
SIDE1
SIDE2
RESET
DET OUT 16
VCOM
VCOM
F
(Page 24)
ICF-DVD57TV
6-5. BLOCK DIAGRAM – POWER SUPPLY Section –
DC/DC
CONVERTER
T1901
VSS–13V
VGH+17V
VCC+7.5V
VEE+5V
VDD+3.3V
RV1901
5V VOLTAGE
D1905
D1904
D1903
D1902
D1901
RV1902
FREQUENCY
B+ SWITCH
Q1902, 1904
F1901
OUT1 7
PLL/RF +3.3V
+3.3V
REGULATOR
IC702
VIDEO DAC +3.3V
+3.3V
REGULATOR
IC703
DVD +1.8V
8V_SW 59
INVERTER
TRANSFORMER
T1801
REGULATOR
CONTROL
Q907, 909
+
LCD BACK LIGHT
CONTROL
IC1801
+1.8V
REGULATOR
IC701
8 OUTL
13 OUTR
F904
SWITCHING
REGULATOR
Q916
+3.3V
REGULATOR
IC903
D924, 925
REGULATOR
CONTROL
Q913, 918
TV +5V
TH902
F1801
TFT-ON 60
D911
D913
15 SCP
LIQUID CRYSTAL
DISPLAY MODULE
LCD1 (2/2)
(BACK LIGHT)
D914, 915
2 RT
DVD +3.3V
SPC-DET 41
F903
SWITCHING
REGULATOR
Q908
POWER CONTROL
IC1901
3 NON1
IC1401 (2/2)
DC/DC
CONVERTER
Q1901, 1903
BATT 7
BATT 14
TEMPERATURE
DETECT
IC952
POWER CONTROL
IC905
10 OUT2
11 DT2
DEAD TIME
Q910
VCC 9
2 IL
TH901
TEMPERATURE
DETECT
IC951
7 OUT1
6 DT1
DEAD TIME
Q917
5 EN
DVD +5V
IC401 (3/3)
SCP
15
SWITCHING
Q903
+5V
REGULATOR
IC901
B+ SWITCH
Q901, 904
TV +9V
B+ SWITCH
Q905, 906
SWITCHING
Q902
MONITOR ON 62
F901
+9V
REGULATOR
IC902
+9V
T901
POWER
TRANSFORMER
RECT
D901
RECT
D905, 906
AC IN 49
(AC IN)
F902
+5V REGULATOR
Q911, 914, 919, 923, 924
+5V
D1402
SUB µ-COM +3.3V
RESET SIGNAL
GENERATOR
IC402
XRESET 76
RECT
D902
+3.9V
REGULATOR
IC904
ANT
D402
SIGNAL PATH
MAIN µ-COM +3.3V
: FM
D401
LED +3.3V
+12V
POWER AMP
B+
D651 – 653
(LCD BACK LIGHT)
+6V
RADIO/VT
B+
RADIO ON
SWITCH
Q402
RADIO ON 77
+5.4V
MOTOR DRIVER
B+
ICF-DVD57TV
26
26
D351
+6V REGULATOR
Q912, 915, 920 – 922
C (Page 23)
ICF-DVD57TV
• Note For Printed Wiring Boards and Schematic Diagrams
Note on Printed Wiring Board:
• X : parts extracted from the component side.
• Y : parts extracted from the conductor side.
• W : indicates side identified with part number.
•
z
: Through hole.
•
f : internal component.
: Pattern from the side which enables seeing.
•
(The other layers' patterns are not indicated.)
Caution:
Pattern face side:
(Conductor Side)
Parts face side:
(Component Side)
Parts on the pattern face side seen from
the pattern face are indicated.
Parts on the parts face side seen from
the parts face are indicated.
Caution:
Pattern face side:
(Side B)
Parts face side:
(Side A)
Parts on the pattern face side seen from
the pattern face are indicated.
Parts on the parts face side seen from
the parts face are indicated.
• Circuit Boards Location
Note on Schematic Diagram:
• All capacitors are in µF unless otherwise noted. (p: pF)
50 WV or less are not indicated except for electrolytics
and tantalums.
• All resistors are in Ω and 1/4 W or less unless otherwise
specified.
•
f : internal component.
• 2 : nonflammable resistor.
• C : panel designation.
TRANS board
DVD board
DETECTION board
Note: The components identified by mark 0 or dotted line
with mark 0 are critical for safety.
Replace only with part number specified.
•
•
•
•
• DVD board is multi-layer printed board.
However, the patterns of intermediate-layer have not been included in this diagrams.
•
•
•
•
A : B+ Line.
B : B– Line.
H : adjustment for repair.
Voltages and waveforms are dc with respect to ground
under no-signal (detuned) conditions.
– DVD/MONITOR Boards –
no mark : DVD PLAY
(
) : CD PLAY
[
] : TV
〈〈
〉〉 : AUX
∗
: Impossible to measure
– TU Board –
no mark : FM
(
) : AM
– Other Boards –
no mark : RADIO (FM/AM)
(
) : DVD PLAY
[
] : TV
〈〈
〉〉 : AUX
Voltages are taken with a VOM (Input impedance 10 MΩ).
Voltage variations may be noted due to normal production tolerances.
Waveforms are taken with a oscilloscope.
Voltage variations may be noted due to normal production tolerances.
Circled numbers refer to waveforms.
Signal path.
L : DVD/CD PLAY (VIDEO)
F : DVD/CD PLAY (ANALOG AUDIO OUT)
J : DVD/CD PLAY (DIGITAL AUDIO OUT)
N : FM
O : AM
E : TV (AUDIO)
a : TV (VIDEO)
d : AUX (AUDIO)
G : AUX (VIDEO)
LCD board
MS-203 board
TU board
MAIN board
MONITOR board
ICF-DVD57TV
27
27
KEY board
ICF-DVD57TV
• See page 27 for Circuit Boards Location.
6-6. PRINTED WIRING BOARD – DVD Board (Side A) –
1
3
4
5
6
7
8
9
10
DVD BOARD (SIDE A)
R739
R713
R714
C709 +
R779
R777
R778
193
1
R768
R767 R769
192 C795
+
C790
C707
C714
+
FB703
C701 +
C784
C783
R764
R765
R805
1
C837 +
FB706
C870
IC709
4
R766
R793 5
R792
8
C787
C781
C838
C782
R803
R804
C778 +
128
C780
65
C779
C785
F
FL703
129
C768 +
FB705
C765 64
FL702
C764
C702 +
FB704
R728
C861
R806
R747
C789
C751
R827
R746
R826
R828
R745
R824
R744
C788
C767 +
C736
IC706
R825
C750
R738
C766 +
C737
L704
C735 +
R735
R731
FL706
E
Q702
1S1G2D
ECB
R736
Q703
R742
C756
C757
C776
C708 +
C703 +
R761
1D2G2S
C720
C722
C798 C797 C796
256
R753
C747 +
C721
C727
C726
R751
R752
C719
C723 +
R782
R784
R813
C847
C728
R780
C794
R750
R781
C791 C792 C793
C746 +
D
C770
C771
C772
C773
C774
C808
C812
R727
C813
C826
R787
R835
C825
R724
C748 +
FL711
FL709
R725
C822
C821
C818
C
C804 C803
BP601
C807 +
C775 +
R726
C869
BP702
BP703
C802
C738 +
C724
X701
C801
BP701
BP704
C799
R734
FL707
C743
C741
C800
B
R821
A
2
: Uses unleaded solder.
11
1-866-128-
G
• Semiconductor
Location
Ref. No. Location
IC706
IC709
E-5
F-6
Q702
Q703
E-3
E-2
ICF-DVD57TV
28
28
(11)
ICF-DVD57TV
6-7. PRINTED WIRING BOARD – DVD Board (Side B) –
1
2
A
3
4
5
6
B
DVD BOARD (SIDE B)
7
8
9
10
MAIN BOARD
CN355
(Page 34)
1
R709
FL712
TP752
Q701
C814
C815
C819
R786
TP751
R788
24
TP761
1
R823
R754
R743
1
24
C760
C761
R759
C762
CN702
R748
R829
R755
R758
R830
R831
C777
C759
R729
FL713
1
C827
48
C871
25
C829
1
TP753
FL710
C831
54
CN701
R760
C763
L707
C832
C839
FL701
24
R762
R763
R832
C830
TP708
IC707
C833
IC701
TP710
1
C834
C852
C840
6
IC708
R794
1E 2B 2C
C745
C755
C704
1
FB702
TP706
TP711 TP709
3
C705
IC703
C706
4
R740
L706
R790
27
C744
1C 1B 2E
L705
C817
C816 C820
R785
R833
R834
C805
R791
R836
C855
R807
C856
R808
C835
C859 R810
C858
R701
C717
TP707
1
C716
15
C810 C811 C823 C824
R706
FB710
FB711
FB712
5
3
14
FL708
C758
C715 4
21
R741
R817
R816
R722
C809
L703
28
E
8
C749
R770
R812
R815
R814
R721
R819
R818
R723
FB707
L702
FL705
F
IC705
C860
R771
R772
R773
R774
C732
C734
C733
C729
C731
FB708
R809
C857
D
FB709
R811
R718
C730
R720
L701
22
C710
C739
R710
R711
R717
R796
7
6
C711
4
R797
R840
C
28
R732
IC702
R703
1
(Page 34)
R712
MAIN
BOARD
CN454
1
C712
R839
R838
16
R798
1
1
C740
IC704
R799
CN704
3
8
C742
R737
R733
9
C843
C849
C
R822
3
R800
8
R837
B
CN705
R820
R841
C841
R801
6
CN703
11
TP702
1-866-128-
G
• Semiconductor
Location
Ref. No. Location
ICF-DVD57TV
IC701
IC702
IC703
IC704
IC705
IC707
IC708
E-4
B-7
E-3
B-4
C-9
E-6
E-5
Q701
D-8
A
MAIN BOARD
CN354
OPTICAL PICK-UP
BLOCK
(KHM-310BAA)
(Page 34)
29
29
(11)
ICF-DVD57TV
• See page 50 for IC Block Diagrams.
6-8. SCHEMATIC DIAGRAM – DVD Board (1/2) –
(1/2)
A1
A2
701
+1.8V REGULATOR
IC701
TK11218CMCL-G
C704
0.01
VOUT
NOISE
A3
GND
A4
GND
FB702
0
FL701
A5
CONT
VIN
R701
0
C705
0.22
CN701
24P
A6
FL705 0
C707
47
6.3V
C701
47
6.3V
C706
0.22
A7
C708
47
6.3V
TP702
3.3V
A8
FL702 0
3.3V
A9
FB704
0
FB703
GND
R703
0
GND
C702
220
6.3V
5.0V
5.0V
702
708
IC702
TK11233CMCL-G
GND
FL703 0
GND
FB706
0
IC708
MT48LC4M16A2P
VOUT
NOISE
C831 0.1
GND
TP706
FB710 0
Y
FB711 0
C709
47
6.3V
B-Y
C710
0.22
FB712 0
R711
1k
A-R+
A-R+
A-R-
C721
1000p
A-GND
C719
1000p
GND
VIN
R837
0
SPDIF GND
DQ9
DQ9
C840 0.1
VCCQ
DQ8
DQ7
DQ8
VCC
VSS
C834 0.1
2.5
C852 10p
NC
DQML
2.5
XWE
WE
ABCK
DQMH
DQM1
DCLK
XCAS
CAS
CLK
RAS
CKE
DCKE
XRAS
MCLK
ACLK
XCS
CS
NC
BA0
SPDIF
R839
100
A-L-
A-R-
5.0V
SPDIF
A-L+
R838 0
(Page 38)
DQ10
ASDATA0
SDTI
BICK
DZFL
A-R+
MAIN BOARD
(3/4)
CN355
C716
0.22
C715
0.22
DQ10
DQ11
DQM0
DZFR
R710
1k
VSSQ
DQ5
VSSQ
ALRCK
VDD
CONT
VCCQ
DQ7
LRCK
C724
0.22
C723
10
16V
DQ11
DQ6
VSS
NOISE
DQ12
DQ4
DQ12
RESET
PDN
VOUT
A-R-
DQ3
DQ6
R713
100
AOUTL+
C717
0.01
VCCQ
DQ5
AOUTL-
C720
1000p
DQ13
VSSQ
C833 0.1
CSN
C722
1000p
IC703
TK11133CSCL-G
C714
47
6.3V
DQ13
DQ2
DQ4
AOUTR+
CCLK
+3.3V REGULATOR
CN705
3P
DQ14
CDTI
703
A-L-
A-LA-GND
DQ14
DQ3
AOUTR-
R706
0
A-L+
A-L+
DQ1
C839 0.1
IC704
AK4385VT-E2
R712
1k
R-Y
TP711
V-GND
VSSQ
DQ2
D/A CONVERTER
V-GND
TP710
DQ15
VCCQ
DQ1
704
C711
0.22
TP709
R-Y
DQ15
DQ0
C832 0.1
Y
TP707
TP708
VSS
DQ0
GND
CONT
VIN
V-GND
B-Y
VCC
GND
C703
47
6.3V
5.0V
SD-RAM
C830 0.01
C712
0.01
FB705
GND
(Page 38)
R794
0
+3.3V REGULATOR
5.0V
MAIN BOARD
(3/4)
CN354
C837
10
16V
R709
1k
MA11
BA0/A13
A11
BA1/A12
A9
A10/AP
A8
A0
A7
A1
A6
A2
A5
A3
A4
BA1
R714
10k
MA9
MA10
MA8
MA0
FL706 0
MA7
MA1
C744
1000p
MA6
MA2
MA5
LD2
MA3
L705
10µH
C735
22
6.3V
(0)
VCC
-1
C746
47
6.3V
TP753
FL708
0
DQS0
A10
AUTOMATIC
POWER
R741
TP752 4.7
CONTROL
LDGND
DVDLD(LD7800)
C747
47
6.3V
(2. 3)
C748
100
6.3V
(Page
31)
707
C749
0.1
FLASH ROM
FL713
0
IC707
MBM29LV160BE
NC
C827
0.1
-2
NC
MDI1
PD
IN6
L706
10µH
(2. 2)
A16
LD1
FL707 0
C745
1000p
DVDVR(VR650)
A17
BP703
FMO
E(VOE/E+G)
Q702
UM6K1N-TN
C736 0.1
VCC
V20
VC
705
(0)
GND
-2
(0)
TP1
S
MC
R739
10k
BP701
S
RF
VINFC
C742 150p
R742
47k
A/A(VOA/A)
RF
VINTK
R822 10k R737 10k
DMO BP702
C/C(VOC/C)
(0)
TRKR731
47k
FCS+
R735
100k
FCS-
C741 150p
VIBSL+
Q703
UN2212
INVERTER
CTKERR2
2.5
(3. 3)
VINLD
GND
C740
0.1
PVCC2
PGND
VOLD-
A2
VOSL+
R724 1
VOTKVOFS+
VOTK+
2.5
INP
CN703
6P
SLED_MOTOR+
SLED_MOTORLIMIT_SWITCH
LIMIT_SWTICH
SPINDLE_MOTOR+
SPINDLE_MOTOR-
ICF-DVD57TV
30
30
R729
1
D3
∗
C829
0.01
AD3
C871 1
D10
A18
D2
A17
D9
A7
D1
A6
D8
A5
D0
A4
OE
A3
GND1
A2
CE
A1
A0
∗
AD2
∗
AD1
∗
∗
∗
∗
AD0
XPRD
XPCE
∗
A1
R727
1
R725
1
INN
D11
A6
A3
VOSL-
VOLD+
D4
VCC
A7
A4
PGND
VOFS-
RESET
A5
VNFTK
2.5
2.5
AD4
WE
R836
0
A8
PVCC1
R726 1
D12
A18
VCC
C738
220
6.3V
D5
A20
R791
10k
VNFFC
GND
A19
A19
PREGND
C739
0.1
D13
AD5
R788
0
C743
0.1
R734 10k
VOSL
R733 10k
D6
A8
XPWR
R821 10k
VIBSL-
R732
10k
R820
10k
A9
WP/ACC
CTKERR1
MD
MA
D14
AD6
R790
10k
BIAS
MSW
TRK+
STBY
CFCERR1
CFCERR2
D/D(VOD/D)
A10
A-1
AD7
A20
IC705
BA5954FP
(3. 3)
FOO
B/B(VOB/B)
D7
A9
F(VOF/F+H)
MB
A-1
A11
A10
FOCUS/TRACKING COIL DRIVE,
SPINDLE/SLED MOTER DRIVE
-1
GND2
A12
A11
BP704
SWITCH
C737 0.1
A13
A12
R738
100
(0. 2)
DVD/CD
BYTE
A13
TRO
R736
100
TN1
A16
A14
A14
CDVR(VR780)
NC
A15
A15
COLD(LD780)
BAA
VSS
(3. 3)
TP751 R740
4.7
Q701
QST8TR
CN702
24P
MA4
C835 0.1
DQS1
L704
47µH
A11
ICF-DVD57TV
6-9. SCHEMATIC DIAGRAM – DVD Board (2/2) –
• See page 47 for Waveforms. • See page 50 for IC Block Diagrams.
• See page 59 for IC Pin Function Description.
(2/2)
A1
A2
C726
100p
ABCK
ACLK
ASDATA0
ARST
SPDIF
C869
1000p
ALRCK
A3
FB709
0
C727
47p
4
R815
1k
R814
470
R721
100
L701
1.8µH
C732
100p
R717
0
R-Y
R720
0
B-Y
C729
330p
A4
A8
C772 1
1.6
1.5
1.3
C773 1
1.1
C770 1
C771 1
RF
C774 1
MA
R750 0
MB
R751 0
MC
R752 0
MD
R753 0
C731
330p
C734
100p
1.3
1.3
0
L703
FB707
1.8µH
0
R817 1k
C796
0.1
R722 100
C797
0.1
C733
100p
R718
0
C730
330p
R770
10k
1.3
R771 10k
C798 0.1
R774 10k
R773 10k
C799 0.1
R778
R777 100
R780
R779
R812 1k
C800 0.1
R813 470
R723
100
R816 470
C801 47p
1.6
R772 10k
C803 15p
0.1
R781
C802
X701 27MHz
R782 100
R833 1M
R834 1M
C808 0.47
R785 4.7M
0.8
0.5
8
R818
470
DVSS18
A7
5
R819
1k
2
FL711
0
ARST
A6
6
7
C847
100p
L702
1.8µH
FB708
0
C728
22p
3
RFRPDC
1.6
1.6
C810
0.047
1.8
0.1
C812
C816 0.1
C811
0.047
C860
1000p
R784 1M
0.1
1
C814
C813
20p
0.1
C815
R786 100k
C819
0.047
FL712 0
C817
C823
0.1
0. 9
1.4
C824
0.1
C820 1000p
A5
C804
12p
C805
390p
C807
47
6.3V
C809
0.1
C818 0.1
C822 0.033
C825
C826
0.1
C821 0.1
R787 22k
BP601
0.1
R835
47k
R768
22k
R767
470
R769
100
C795 0.1
C794 0.1
1.7
1.7
C793
0.1
C859 1000p
C768 47 6.3V
R811 470
C757 0.1
3.1
C767 47 6.3V
C756 0.1
R810 470
C766 47 6.3V
C858 1000p
TN1
TP1
C792
0.1
MDI1
DVSS18
R761 0
C857 1000p
LD2
(3. 3)
LD1
(2. 3)
C856 1000p
0
0
0
FL709 0
C775
47
6.3V
TP761
C776
0.1
R840 0
DVD RESET
R808 470
R796 0
XIFCS
R797 0
R807 470
XIFBUSY
R798 470
SI0
C791 0.1
C755 0.1
V20
706
A9
R825
470k
R823
220k
R824
4.7M
R800 470
MA6
R801 0
SCK
DVD AMUTE
MA7
MA8
R744 220k
INN
MA5
SO0
8
IC706
CXD9849R
C758
0.1
R799 470
R841 0
MPEG DECODER
C750
2200p
MA4
DVSS18
RF AMP,SERVO DSP,
(Page
30)
CN704
8P
C855 1000p
R809 470
MA9
R743
470k
C841
1000p
C843
100p
C849
100p
MA11
INP R745 470k
DCKE
2.1
R754 10k
DMO
DCLK
C790 0.1
R755 22k
FMO
C751 2200p
R826
220k
C759
R830
100k
C760 0.1
R827
4.7M
R828
470k
0.015
R746
220k
C761
330p
C762
330p
R829 47k
C789
0.1
R831 10k
R758 22k
MA3
R759 10k
TRO
MA2
USB_VSS18
MA1
L707
0
FOO
C763 0.1
R747
0
MA0
USB_VSS18
MA10
R748 10k
C777 0.01
BA1
0.3
DVSS18
R762 470
IN6
C764
0.1
BA0
XCS
R760
10k
C788 0.1
∗
∗
∗
A2
A3
A4
XRAS
XCAS
XWE
2.5
A5
DQM1
R806 1k
A6
DQS1
LIMIT
A7
DQ8
A8
A18
DQ9
A19
DQ10
DQ11
1.5
C765 1500p
DQ12
DVSS18
A11
ICF-DVD57TV
31
31
WP
SCL
SDA
NC
GND
0.1
C785
EEPROM
IC709
BR24L16FV
R766
100
DQ14
DQ15
DQ0
DQ1
VCC
0.1
C784
DQ2
DQ3
DQ4
DQ5
DQ7
DQ6
NC
(3. 3)
C787
1000p
C838
0.1
DQS0
R793
1k
709
R805 100
R765 10k
R764 1k
R804 1k
R803 1k
A-1
A17
AD7
AD6
AD4
AD5
AD3
AD0
AD1
AD2
XPRD
A1
XPCE
A20
A10
A9
A11
A12
A13
A14
A15
A16
XPWR
A10
R792
1k
NC
2.5
XINTO
EEP_DA
EEP_CK
∗
C783 0.1
0.1
C781
R728
10k
C870
1000p
C779
0.1
QDM0
C778
22
6.3V
0.1
R763
100
C780
C782
0.1
R832
47
FL710
0
∗
∗
∗
∗
∗
DVSS18
DQ13
C861 1000p
TRAY DET
C
MAIN
BOARD
(3/4)
CN454
(Page 38)
ICF-DVD57TV
6-10. PRINTED WIRING BOARD – TU Board –
1
2
3
4
5
6
7
8
9
10
TU BOARD
A
L3
AM FERRITE-ROD
ANTENNA
TP
(VT)
B
TP
(ANT)
D
L1
1
TRANS
BOARD
TP
(GND)
2
(Page 41)
C
(SHIELD CASE)
R5
E
MAIN
BOARD
CN10
(Page 35)
24
1
C13
T1
10
11
L2
D
IC2
L4
IC1
T2
13
E
12
11
1-863-438-
F
• Semiconductor
Location
Ref. No. Location
D1
D2
D3
D10
D11
B-7
C-6
C-6
B-9
B-9
IC1
IC2
D-7
D-3
ICF-DVD57TV
32
32
(11)
ICF-DVD57TV
• See page 47 for Waveforms.
6-11. SCHEMATIC DIAGRAM – TU Board –
L3
D3
KV1520NT
AM FERRITE-ROD
L4
C41
220p
ANTENNA
AM OSC
C42
100p
C43
22p
L11
1µH
JC12
0
JC11
0
R41
10k
CT3
C49
0.01
C32
1000p
R40
220k
D1
KV1471E
C39
0.1
TP
(VT)
C37
0.01
R32
100k
R30
22k
C35
0.01
CT1
C13
0.01
C33
0.01
R50
1k
C80
0.01
R52
0
L2
FM
R33 C30
10k 0.01
R31
3.3k
FM
C31
22p
C65
4.7
50V
R65
10k
C52
10p
R63
10k
C54
220
10V
R51
10k
R24
220
C56
1000p
R54
470
OSC
RF
C53
0.22
R91
220
D2
KV1471E
C51
22p
L1
C34
0.01
C47
10p
R14
1k
JC3 0
C24
220p
X1
75KHz
C22
0.1
R11
3.3k
C59
100p
R55 R53
10K 4.7k
C95
1000p
C57
1000p
C20
0.1
C55
100p
C23
1
50V
C21
1
50V
11
D
TRANS
BOARD
FM IN
BAND
AM IN
MO/ST
IF IN
VDD
BAND
ST-IND
VSS
MW/LW
MUTE
PD
LP-IN
DO
LP-OUT
DI
CL
XIN
XOUT
CE
LPF1
/BAND
L-OUT
LPF2
/MO-ST
R-OUT
MPX-IN
QUAD
AGC
GND2
DET-OUT
IF-OUT
ST-IND
IF-IN
OSC-
AM OSC
OUT
FM
IF-IN
AM
VCC2
FM OSC
OUT
AM
VCC1
RF-IN
MIX-
FM/AM PLL
C12
4.7
50V
R2
470
D11
1SS355
TP
(ANT)
CUT
IC1
TA2149BN
FM
GND1
FM/AM IF AMP,DET,MPX
RF-IN
FM/AM RF AMP,MIX,OSC,
AM LOW
RF-OUT
FM
C13
0.01
C1
47p
C60
1000p
R4
10k
JC13
0
D10
1SS355
(Page 39)
C7
5p
C9
10p
T1
AM IFT
IC2
LC72137M-TLM
C61
100p
JC4
0
C62
100p
C63
100p
R13
2.2k
R94
1k
R92
220
C66
100p
R60
2.2k
R59
2.2k
R56
220
R57
100
L21
10µH
C68
100p
CF4
R61
2.2k
JC5
0
CNP1
11P
MUTE
R58
2.2k
COUNT
PLL CLK
T2
FM
IFT
R1
470
PLL DATA
JC6
R5 0
1K
PLL CE
JC33
0
CF2
LCH
R10 47
JC2 0
R +B
JC1 0
JC34 0
R3
10k
C10
1
50V
RCH
GND
C15
0.22
C8
1000p
C4
1000p
C11
0.1
C18
220
10V
VT
C29
100
10V
C14
0.22
ICF-DVD57TV
33
33
C27
100p
C26
100p
TP
(GND)
S-GND
E
MAIN
BOARD
(3/4)
CN10
(Page 38)
ICF-DVD57TV
6-12. PRINTED WIRING BOARD – MAIN Board (Component Side) –
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
A
(COMPONENT SIDE)
R538
C481
Q401
B
BC E
MAIN BOARD
C419
R411
C421
1
61
80
R480
C425
C424
A
Q921
C980
K
R974
A
R483
DVD
BOARD
CN701
R482
R481
R477
R476
R475
C466
R474
1
D904
R484
C465
R473
E CB
R413
R311
Q301
C417
Q924
R415
C982
C415
R414
R977
CN354
60
R458
R459
R431
R472
C413
R417
R410
R455
R456
R471
E
C411
R419
R416
R412
R453
R454
R457
R421
R418
C423
R449
R452
R450
R451
R420
BCE E C B
IC401
R448
C409
Q923
R447
R423
R402
R445
D
R422
BCE
R424
20
Q922
A
21
BCE
R976
R443
40
41
R406 R403
R446
R462
R463
R444
R465
D903 K
C401
C403
C404
C405
C406
C407
R437
C439
R430
R429
R428
R427
R426
R425
R439
R440
C440
R435
R442
R464
R434
R441
R436
C
R438
C431
R537
FB351
FB352
F
F904
24
F903
3
L903
L906
CN355
G
(Page 29)
1
B
DVD
BOARD
CN705
H
4
C947
1 2
R972
(Page 29)
IC952
1
C522
2
2
8
7
(Page 29)
• Semiconductor Location
D101
D103
D105
D201
D203
D205
D903
L-14
I-13
L-14
L-15
I-13
L-15
C-8
Ref. No. Location
Ref. No. Location
Ref. No. Location
D904
D-8
IC951
IC952
H-4
H-8
IC302
IC303
IC401
IC501
IC502
J-14
K-12
D-3
I-17
J-16
Q101
Q104
Q201
Q204
K-14
I-13
K-15
J-13
Q301
Q401
Q504
Q921
Q922
Q923
Q924
D-15
B-2
J-16
D-9
C-9
E-8
D-8
ICF-DVD57TV
34
34
Q504
E CB
R528
C216
C116
R213
BCE
E CB
Q101
Q201
C215
1
C525
R227
R225
D201
D205
A
K
R226
A
K
K
R159
R126
D105
C
14
7
IC502
R259
K
C115
A
DVD BOARD
CN704
R518
R127
D101
L
R529 R517
C305
C217
R113
R208
C210
R304
R204
R262
C110
A
R257 R201
8
C208
C207
R209
C204
C205
C203
C201
R263
R211
5
R261
R203
R258
R202
R205
R207
C202
R111
R523
8
12
C214
1
R163
IC303
K
C310
IC302
R216
4
R218
C307
R128
13
R109
C108
C107
1
C117
C105
C104
R105
R107
C103
R118
L302
R228
C114
L908
R231
Q204
C101
R102
R158
R157
R101
L905
R130
R131
R230
BCE
24
R161
R162
R103
R104
R108
C102
R252
BCE
R305
K
R303
A
Q104
R306
K
R152
C220
C221
C241
D203
J
4
1
C120
C121
C141
8
D103 A
Ref. No. Location
IC501
R520
TH902
L907
TH901
L904
I
5
CN454
1
3
3
R116
4
IC951
R125
11
1-866-125-
(11)
ICF-DVD57TV
8
9
10
(Page 41)
TRANS
BOARD
Q
A
F
12
(Page 43)
MONITOR BOARD
CN1403
(CONDUCTOR SIDE)
13
15
(Page 43)
MONITOR BOARD
CN1405
H
14
LCD BOARD
CN604
16
17
(Page 40)
N
2
C918
C917
R535
R540
ECB
C435
R962
C967
C428
C447
C459
C460
C461
IC351
1
BCE
D925
K
K
A
D907
C354
BCE
C925
R914
BCE
ECB
R939
K
C355
D351
9
R911
K
A
D911
R936
K
A
D913
D924
K
A
R968
Q917
R971
C971
R957
R907
R926
+
ECB
C941
R935
BCE
Q910
C919
D915 A
C353
C945
R938
R910
+
R913
R909
C957
C950
D914 A
R937
Q902
Q903
1
D918 K
A
C935
IC903
1
5
2
4
1
9
2
8
CN351
1
+
CN407
C302
11
1-866-125-
C952
+
C450
C432
C462
R953
R948
R945
R960
C970
C968
R963
R959
R958
C948
R950
R941
R956
Q402
ECB
R940
C966
R302
R961
R949
3
Q916
Q908
D912 A
C961
C482
+
(11)
C960
+
C937
C209
C959
1
+
C112
R478
C426
BCE
R916
R917
ECB
ECB
R920
R921
R922
C939
R931
R912
6
3
C527
C211
R220
R932
BCE
Q904
BCE
CN406
L301
+
C303
C529
1
C953
C309
C308
R132
R232
R219
C239
L505
R124
R123
C304
+
C238
4
Q918 Q913
R542
C236
+
R253
6
C949
C932
+
R120
C138
R153
1
R925
C930
3
10
+
+
R545
4
11
C933
+
C951
R
16
C946
+
+
C218
C212
R222
IC905
R969
R251
R301
+
K
C524
R223
C927
+
K
R151
C109
+
+
R122
C111
Q907 Q909
CN404
R133
R539
+
R149
C301
+
+
AUDIO
C940
C924
R906
R544
ECB
R525
Q505
R527
R536
R534
R530
R522
R543
R150
C306
C137
R929
8
9
C136
C118
R224
R934
C931
C237
L
C929
R927
R915
1
C528
JK501
R933
C928
C983
R250
R119
K
R533
R249
C139
R908
R930
+
INPUT
Q901
C356
R513
C523
R978
C938
+
R541
J
Q905 Q906
C364
C363
C362
R514
R515
C519
A
+
C943
R924
R928
D908
11
+
+
R521
1
+
R918
R532
C455
X402
+
VIDEO
I
+
R524
R526
C463
1
C521
R519
C429
L402
X401
C913
+
+
+
C441
R470
3
+
C515
R233
R531
R409
C470
+
C922
L504
ECB
ECB
1
R923
C518
C449
C446
C942
+
C520
C445
R469
C453
C914
IC901
C921
H
C452
7
3
+
C444
R468
C474
+
IC902
C357
R467
C451
R408
C467
R466
C464
C978
C506
C442
C479
IC402
1
C501
1
C433
C478
D920
K
A
2
C923
R354
C448
C422
3
CN902
C920
OPTICAL
OUTPUT
C443
C420
1
+
3
C430
BCE
Q919
R951
C974
C962
C963
R486
CN405
L501
C955
+
G
R488
R487
K
D919
A
R966
ECB
Q914
Q920
R975
Q915
ECB
C975
IC904
6
Q503
R507
F
JK502
R460
R510
R506
R508
JK502
R461
C412
C416
C480
C402
C410
C414
C476
3
C981
CN403
L502
R946
Q502
ECB
C517
C436
D922
C972
C964
1
R509
R504
TU501
TV TUNER UNIT
VHF/UHF
R516
C511
R511
C508
C437
D402
C408
1
C516
R512
C510
R505
C507
R503
C504
C965
C956
C514
26
Q501
E
C505
R502
L503
C503
C513
13
C475
C477
+
C502
C512
C973
+
C418
+
R501
6
+
+
C509
1
D923
R489
D401
R485
C954
C235
C135
C438
+
R942
+
R947
K/A
K
C979
R943
D304
BCE
C125
A
K
K
D303
A
R309
K
R312
D104
A
R137
C126
ECB
+
Q302
R237
R236
C314
K/A
K
D916
+
C225
D917
+
R239
R144
R143
K
A
R139
A
R964
A
Q911
R965
+
R246
C127
Q912
C976
R954
C977
R955
R138
Q103
C315
C317
D204
R238
A
C130
R136
R142
C984
C985
D921
K
R967
C140
L401
6
CN901
BCE
C240
1
R315
C316
R243
R244
C226
Q203
C128
C129
R242
+
C227
R141
C228
+
+
R247
R146
R241
R314
ECB
A
D202
K
A
D102
K
+
C321
R147
D
C234
1
C915
+
(Page 41)
C134
+
+
DETECTION
BOARD
R140
R316
R317
C233
CN401
2
C318
C229
R240
+
K
+
1
C230
C231
+
2
15
C916
C133
R145
CN302
R245
C131
C232
+
C
15
+
+
1
+
1
R952
+
SP201
(R-CH)
16
1
IC301
C322
C132
4
D403
CN602
CN601
11
SP101
(L-CH)
(Page 40)
LCD BOARD
CN603
M
19
(CHASSIS)
(CHASSIS)
12
B
18
R479
MAIN BOARD
11
C485
7
C456
6
C457
5
C351
4
C427
3
K
2
A
1
C458
6-13. PRINTED WIRING BOARD – MAIN Board (Conductor Side) –
2
C311
MS-203 BOARD
CN001
+
10
(Page 41)
CN10
+
P
KEY BOARD
CN408
L
(Page 41)
L
TU BOARD
CNP1
E
(Page 32)
G
MONITOR BOARD
CN1404
J
MONITOR BOARD
CN1406
(Page 43)
(Page 43)
Ref. No. Location
D102
D104
D202
D204
D303
D304
D-3
C-9
D-3
D-6
D-9
D-10
Ref. No. Location
Ref. No. Location
Ref. No. Location
Ref. No. Location
Ref. No. Location
D351
D401
D402
D403
D907
D908
D911
D912
D913
D914
D915
D916
D917
D918
D919
D920
D921
D922
D923
D924
D925
D-12
J-16
J-15
IC301
IC351
B-6
I-18
IC402
IC901
IC902
IC903
IC904
IC905
J-17
C-15
C-15
B-18
I-17
H-12
J-16
I-14
J-16
J-15
J-15
C-13
C-11
I-15
C-13
E-13
C-11
D-13
D-15
F-13
G-13
K-12
E-13
H-15
ICF-DVD57TV
35
35
Ref. No. Location
JK502
G-2
Q103
Q203
Q302
C-9
D-6
D-10
Ref. No. Location
Ref. No. Location
Ref. No. Location
Ref. No. Location
Ref. No. Location
Q402
Q501
Q502
Q503
Q505
Q901
Q902
Q903
Q904
Q905
Q906
Q907
Q908
Q909
Q910
Q911
Q912
Q913
Q914
Q915
Q916
Q917
Q918
Q919
Q920
K-10
E-6
F-7
F-7
I-5
H-13
J-16
J-16
H-13
G-15
G-15
H-13
I-14
H-13
J-15
C-12
C-11
I-16
C-13
D-11
I-15
J-16
I-16
C-13
C-12
ICF-DVD57TV
6-14. SCHEMATIC DIAGRAM – MAIN Section (1/4) –
1
2
4
3
5
6
7
9
8
10
11
12
14
13
16
15
A
MAIN BOARD
DETECTION
BOARD
(1/4)
TU501
TV TUNER UNIT
(BTF-PA402Z)
(4.7)
R519
0
L501
22µH
10k
10k
R525
R527
C517 0.01
C516 1
C514 0.01
C513 1
C515 470 10V
R516 1k
C512 100p
C511 100p
R512 1k
R507
220k
C510 100p
R504
100k
(3.6)[0.8]
<<0.8>>
C519
47 16V
R522
1k
R511 1k
R506 47k
C508 1
C507 0.01
10k
R503
C506 22 25V
1k
R502
22p
1k
C505
R501
0.01
22p
C503
C504
1
C502
L503
10µH
C509 4700p
D
(4.7)
R521
0
TIN
2
TOUT
TV/AUX
3
VIN
6
DVDIN
DVDON
5
4
Q505
2SC4081-T106R
VIDEO AMP
8
1
VCC
21
R531
2.2k
(3.5)[0]<<3.5>>
R520
1k
L504
22µH
R505
220k
L502
10µH
VEE
JK501
R220
22k
VIDEO INPUT
SELECT SWITCH
C518
470
10V
R532
100k
R530
2.2k
IC501
AUDIO
(9)
L
(7.7)
(4)
7
R544
10
C523
10
50V
(9)
(4.5)
(7.5)
R533
0
C521
470
10V
IC501
NJM2234V
IC B/D
VIDEO
R542
1k
R515
100
R513
1k
R514
470
R541
2.2k
CN403
6P
V-GND
2
R-Y
3
V-GND
4
B-Y
5
V-GND
6
Y/CVBS
1
u-COM GND
2
3.9V
3
TUNER MUTE
4
TUNER MODE
5
TUNER F MONO
6
TUNER AFT(A/D)
7
TUNER AGC
8
TUNER SDA
1
AUX CONT
VDD
LOUT
AUX CONT
[4.4]
4
[4.4]
Q502, 503
AUDIO MODE
SELECT SWITCH
R517
10k
R523
47k
C137
0.47
50V
[8.9]<<0>>
RVIN
TUNER CONT
ROUT
TUNER CONT
ROUT
VSS
RTIN
IC502
TG40668FT
C01
R540 2.2k
C527 C529
10 0.01
50V
[9]
[0]<<3.7>>
TU_AFT
TU_AGC
TU_SDATA
C211
0.47
50V
[0]<<3.7>>
[4.4]
R222
0
TU_SCL
9
[4.4]
[4.4]
[8.9]<<0>>
R528
1k
LTIN
5
R119
4.7k
6
R510
4.7k
Q503
DTA124EUA-T106
LOUT
[4.4]
C111
0.47
50V
7
[0.3]
LVIN
2
R122
0
3
[4.4]
[5.1]
10 11 12 13 14
[5.1]
[4.4]
C237
0.47
50V
R518
0
IC B/D
11
MAIN
BOARD
(3/4)
IC502
C139
1000p
TV/AUX AUDIO
SELECT SWITCH
(Page 39)
DVD ON
2
RESET
3
U-COM RDATA
4
u-COM CLK
5
u-COM SDATA
6
C03
u-COM LATCH
7
TFT OPEN
1
8V
2
8V
3
INV-GND
4
INV-GND
5
P-GND
u-COM_S_DATA
C524
100
16V
C525
0.01
C239
1000p
u-COM_LATCH
(Page 45)
H
MONITOR
BOARD
(2/3)
CN1405
(Page 45)
CN406
10P
C05
MAIN
BOARD
(4/4)
1
u-COM_CLK
C04
12
TV/AUX AMUTE
u-COM_R_DATA
(Page 38)
I
11
RESET
[8.9]<<0>>
Q504
DTC144EUA
INVERTER
TV/AUX
CN405
7P
R219
4.7k
C02
[0]
<<3.7>>
TUNER SCK
10
G
MONITOR
BOARD
(2/3)
CN1404
9
R509
4.7k
Q502
DTA124EUA-T106
8
[0]
R124
100k
100k
R123
100k
(Page 44)
TU_MUTE
R224
R223 100k
[5.1]
F
MONITOR
BOARD
(1/3)
CN1403
CN404
11P
R535
2.2k
R529
1k
[5.1]
F
G
BY
TU_MUTE
Q501
2SD601A
AGC
L505
100µH
TU_AFT
TU_SDATA
TU_SCL
[3.7]
TU_AGC
R508
220k
[0]
C501
470
10V
R543
10k
H
1
RY
E
INPUT
R120
22k
C528
220
16V
C522
0.01
C520
100
16V
R
100k
R526
10k
100k
[9]
[3]
[3]
[5.1]
R524
10k
C
100p
5V(D/D)
26
C138
L OUT
25
R153
R OUT
24
100p
9V(MPX)
23
100k
MUTE
22
C238
F MONO
21
R253
MODE
20
R539 100
SAP IND
19
R536 470
ST IND
18
2
R534 1K
GND
17
S401
DISPLAY
RELEASE
1
[5.1]
DET OUT
16
[4.1]
AFT OUT
15
[4.1]
5V(IF)
14
[2.9]
RF AGC
13
[0]
VIF
6
[0.3]
AS
5
[2.4]
SDA
4
[5.1]
SCL
3
[3.7]
5V(TU)
2
[2.8]
NC
CN401
2P
1
VHF/UHF
R545
B
6
P-GND
D02
7
P-GND
D03
8
8V
D04
9
8V
D05
10
8V
D06
B02
J
13
MAIN
BOARD
(2/4)
(Page 37)
K
ICF-DVD57TV
36
36
J
MONITOR
BOARD
(1/3)
CN1406
(Page 44)
ICF-DVD57TV
• See page 47 for Waveforms. • See page 59 for IC Pin Function Description.
3
5
4
A
6
7
9
8
COM0
COM1
COM2
SEG7
9
COM3
SEG8
8
SEG0
SEG9
7
SEG1
SEG10
6
SEG2
SEG11
5
SEG3
SEG12
4
SEG4
SEG13
3
SEG5
SEG14
2
SEG6
SEG15
1
10 11 12 13 14 15 16 17 18 19 20
R601
220
R602
470
D601
TLFGE53T
R603
220
R604
470
D602
TLFGE53T
R605
220
R606
470
D603
TLFGE53T
R609
100
Q601
DTA124EUA-T106
LED DRIVE
G
R610 220
LED ON:3.2
LED OFF:0
C
Q651
DTC144EUA
LED ON:3
LED OFF:0
R607
220
C602
0.01
I
15
16
R663
470k
R664
S658
220k
R661
R662
47k
R659
470k
R660
S656
TV
MENU
S657
R653
22k
R651
100k
R652
22k
IC601
PRM7240
3.1
R608
10k
R654
S652
VOLUME +
C604
1000p
TIMER
100k
47k
R657
R658
47k
22k
R655
100k
R656
S654
SOUND
S655
ENTER
22k
47k
S653
VOLUME –
3.1
3
O
220k
CLOCK
1
D604
D651
SLR-342DYT32
R666
REMOTE CONTROL
RECEIVER
2
S651(2/2)
ROTARY
ENCORDER
C601
0.01
R611 100
14
13
R665
IC601
3.1
LED ON:0
LED OFF:3
OPEN/
CLOSE
Z
LED ON:0.8
LED OFF:1.8
12
(LCD BACK LIGHT)
LCD601
KEY BOARD
11
D601-603
LCD BOARD
B
10
C603 0.1
2
D604
SLR-342DUT32
1
C606 0.01
47k
S651(1/2)
S657
MODE/
SCREEN SIZE
S651(1/2)
TIMER
PUSH
START/STOP
C605
0.1
MONITOR ON
AUX
R612 220
CN603
R613 100
1.7
<<0.7>>
MONITOR ON
TV
CN602
100p
100p
100p
100p
100p
100p
100p
100p
100p
100p
100p
100p
100p
100p
100p
100p
100p
100p
C405
C406
C407
C408
C409
C410
C411
C412
C413
C414
C415
C416
C417
C418
C419
C420
C421
C422
SEG12
SEG11
SEG10
SEG9
SEG8
SEG7
SEG6
SEG5
SEG4
SEG3
SEG2
SEG1
SEG0
COM3
COM2
COM1
COM0
SEG15
1.7
(0.7)
12P
(2/4)
R616 220
R617 100
100p
MONITOR ON
DVD
100p
Q653
DTC144EUA
C404
0[3.2]
CN601
C403
1.7
[0.7]
D653
TLFGE53T
SEG13
R615 100
16P
MAIN
BOARD
R614 220
SEG14
Q652
DTC144EUA
D
E
CN604
12P
16P
D652
TLFGE53T
0<<3.2>>
D654
TLFGE53T
0(3.1)
C424
2.2
Q654
DTC144EUA
RADIO ON
BAND
R619 100
D655
TLFGE53T
R403
100k
CN407
9P
CN408
9P
3.2(0)
R406
100k
R440 1k
0(3)
u-COM_LATCH
R441 1k
3.2
S663
OFF
C437 100p
3.1
R442
100k
RADIO ON
BAND
C438
100
16V
VLC2
NC
NC
RADIO DATA
RADIO CE
u-COM LATCH
AVDD
RADIO MUTE
DVD OPEN DISC TRAY OPEN:3.1
DISC TRAY CLOSE:0
ENCODE+
MONITOR ON
TRAY DET
15
C464
22p
C463
22p
R478
4.7k
X402 32.768kHz
0
0
C462
100p
C15
0
R477
1k
3.1(0)
R476
1k
0
R475
1k
0
R474
1k
0.9(0)
R473
1k
0(3.1)
R472
1k
0
R471
1k
22
C16
MUTE
C461
100p
D401 1SS119-25TD
C460
100p
C459
100p
C458
100p
C457
0.01
C456
0.01
D402 1SS119-25TD
R486
470k
3.2
1
PLL_CE
PLL_DATA
RST
G VIN
3.3
3
2
C480
0.01
PLL_CLK
3.2
0(3.1)
0(3.1)
MAIN
BOARD
(3/4)
(Page 38)
C479
0.1
C476
470
10V
C475
10
50V
IC402
R431 1k
C452 100p
R459 10k
C453 0.01
R458 1k
R457 1k
R456 10k
R451 1k
R452 47
D10
RESET SIGNAL
GENERATOR
IC402
XC61CN2002MR
R429
100p
R488
100k
D11
C485
0.01
D12
(Page 39)
C10
(Page 38)
C11
R448 1k
C18
ICF-DVD57TV
37
37
16
MAIN
BOARD
(4/4)
D13
TRAY_DET
C448 0.01
C449 100p
C455 100p
XIFCS
DVD_RESET
C442 100p
SCK
DVD_AMUTE
C441 100p
XIFBUSY
14
C451 100p
C447
100p
C19
MAIN
BOARD
(3/4)
R450 10k
R449 1k
R470 100k
R469 100k
R447 1k
SOO
C09
L402 100uH
R479 220k
1
R489
47k
R464
100k
C450 100p
C08
C428
0.01
0
C467
100
16V
C466
2.2
0.01
C17
SIO
C07
L
R461
220k
R468 100k
R465
100k
(Page 36)
C402 0.01
MAIN
BOARD
(1/4)
C446 0.01
B02
R467 100k
>
R466 220k
R445 100
0
R455 100
R453 100
R446 100
–
0
0(3.1)
0
0(3)
0
3.2
2.8
3.1
3.1
DISC TRAY OPEN:3.1
DISC TRAY CLOSE:0 R441
1k
0
R454 100
R463 100
3.1
–
3.1
C465
1.7
41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60
R443 1k
13
M
0.8
VLC1
RESET
C445 0.01
.
1.6
VLC0
RADIO CLK
S660
TV CH/PRESET
2.4
COM0
VDL CLK
TUNER LED
C444 0.01
+
1.4 R410 10k COM0
COM1
VDL DAT
u-COM CLOCK
ENCODE-
S664
C440 0.01
3.1
IC0
u-COM S DATA
3.1
C477 0.1
RESET C436 100p
TV LED
XT1
0(1.2)
D403
1SS119-25TD
3.2(0)
XT2
IC401
uPD789478GC-SR7596A
AUX LED
X401
4.19MHz
0(1.8)
0
R439 1k
IC401
OPEN/CLOSE LED
0(6.2)
3.2
R485
C435 100p
VDD0
C14
R480
10k
C478 0.1
0
0(3.2)
u-COM_CLK
u-COM R DATA
C13
C470
0.01
R481
1k
1k
R437 1k
R438 100
u-COM_S_DATA
VSSO
61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80
0[3.2]
23
5.1
LOADING B
0<<3.2>>
R436 1k
X1
NC
DVD LED
R435 1k
C432 100p
NC
DVD RST
R434 1k
C431 100p
X2
DVD AMUT IN
x
C430 100p
NC
DVD XIFCS
S662
0(3)
XRESET
DVD SCK
LED ON:3.2
LED OFF:0
R430 1k
RADIO ON
SEG15
DVD SOO
u-COM_R_DATA
C443 0.01
S666
R483
1k
POWER ON:0 R482
STANDBY:5.1 1k
SEG14
DVD SIO
1.4
BUZZER
1.4
R429 10k
R462 100
K
1.4 R411 10k COM1
COM2
1.4 R414 10k SEG0
1.4 R412 10k COM2
COM3
1.4 R415 10k SEG1
1.4 R416 10k SEG2
1.4 R417 10k SEG3
1.4 R418 10k SEG4
1.4 R419 10k SEG5
1.4 R413 10k COM3
1
SEG0
SEG1
SEG2
SEG3
SEG4
SEG5
SEG6
SEG7
2
LOADING A
R428 10k
SEG15
C439 2.2
470k
R678
3
STBY
DVD XIFBUSY
SEG14
C401
100p
u
m
M
4
A MUTE
AC IN
S661
S659
RADIO TUNE/
TIME SET
5
SEG13
3.1
+
220k
470k
R690
S665
6
SEG12
RC
1.4
AVSS
1.4
R427 10k
L401 100µH
R677
220k
R689
J
7
LED ON:0
LED OFF:3.1
KEY0
R426 10k
SEG13
R460 1k
S670
MONITOR ON
DVD
8
TIMER LED
KEY1
SEG12
C474
0.01
R484
1k
C12
9
SEG11
KEY2
1.4
KEY3
R425 10k
DVD CLOSE
S660
SEG11
40 39 38 37 36 35 34 33 32 31 30 29 28 27 26 25 24 23 22 21
47k
R672
220k
MONITOR ON
TV
R676
100k
S669
R674
470k
47k
R671
R673
47k
S668
MONITOR ON
AUX
R408
22k
SIRCS
BUFFER
C433 100p
S667
OPEN/
CLOSE
Z
R409
10k
R487
S659
SEG8
SEG10
47k
R668
20 19 18 17 16 15 14 13 12 11 10
Q401
2SC4081-T106R
100k
R670
22k
R667
22k
R669
S666
R675
22k
R682
R681
47k
R684
47k
R683
47k
470k
R686
R685
R687
R688
100k
I
220k
H
S665
100k
R679
R680
22k
47k
C481
1000p
1.4 R420 10k SEG6
1.4
0.6
1.4 R421 10k SEG7
0
1.4 R422 10k SEG8
R538
10k
SEG9
R537
10k
1.4 R423 10k SEG9
Q651 – 655
LED DRIVE
R424 10k SEG10
Q655
DTC144EUA
F
G
C426
0.01
C425
2.2
R618 220
0.7
(1.7)
R402 C427
100k 0.01
C423
2.2
ICF-DVD57TV
5
6
7
9
8
2
3
A-GND
4
A-L-
5
A-L+
6
V-GND
7
R-Y
8
C364
0.01
C101
10
R157
47k
R101
47k
C102
10
R158
47k
R102
47k
RY
R105
22k
17
5.0V
18
5.0V
19
5.0V
20
GND
21
GND
22
3.3V
23
C108
100p
R118
2.2k
FB351
0
3
6
SI0
4
SO0
5
R205
22k
DVD_AMUTE
4.4
C217 2.2
C117 2.2
4.4
4.4
4.4
R208
4.7k
R302
1k
L301
0
R301
1k
CN10
11P
MUTE
R218
2.2k
11
10
C301 C204 C205
47
16V 100p 100p
C302
0.01
C311
2.2
50V
C114 2.2
4.4
C214 2.2
4.4
C115 2.2
4.4
C215 2.2
4.4
C116 2.2
4.4
C216 2.2
4.4
C303
10
50V
CAP
V LIN
TNF L
V RIN
TNF R
SEL R
BNF R
SEL L
BOUT R
CO LIN
BNF L
CO RIN
BOUT L
R LIN
LOUT
R RIN
ROUT
TV LIN
VCC
TV RIN
SI
VREF
SC
GND
0.7
C241
0.1
4.4
4.4
C220
0.1
R228
470k
4.4
4.4
R128
470k
4.4
9
PLL DATA
8
PLL CE
7
0
6.1(0)
R130
R132
0
0
R232
0
0
R306 1k
R305
1k
Q402
DTA123JUA
RADIO ON
SWITCH
C304
47
16V
IC B/D
L302
100µH
C305
0.01
C307
100p
C310
100p
C12
C13
C14
15
MAIN
BOARD
(2/4)
(Page 37)
(Page 39)
ICF-DVD57TV
38
38
VCC
L OUT
BS L
(NC)
R OUT
R317 1k
R149
10k
R150
47k
R152
1k
C136
10
50V
POWER ON:0
STANDBY:5.1
Q301
DTA144EUA
STANDBY
SWITCH
C482
47
16V
MAIN
BOARD
(4/4)
0.6
R151
100k
C306
47
16V
17
M
R116
4.7k
1.8
(6.2)
D19
L
R216
4.7k
INPUT SELECT SWITCH,
ELECTRICAL VOLUME,
SURROUND/TONE CONTROL
IC302
BD3870FS
C15
1
D103
1SS355
IC302
C16
S-GND
R213
10k
R249
10k
2.2k
Q104, 204
AGC
C17
2
R113
10k
D26
VT
C210
2.2
6.2
D27
3
D24
4
D23
RCH
GND
D22
5
D15
6
D21
K
LCH
R +B
C110
2.2
R250
47k
0
C141 0.1
9
PLL_DATA
PLL_CE
C236
10
50V
R131 220k
C121 0.22
4.4
R251
100k
R252
1k
0.6
C120 0.1
4.4
PLL_CLK
PLL CLK
R230
2.2k
R231 220k
C221 0.22
4.4
C132
100
16V
C234
10
50V
C134
10
50V
SP101
(L-CH)
R145
2.2
C133
0.01
R245
2.2
C233
0.01
R246
10k
R146
10k
POWER ON:5
STANDBY:0
5
R311
0
R147
22k
R247
22k
C318
47
16V
R233
0
C218
2200p
6
C203
470p
R202
47k
D105
1SS355
4.4
8
8
J
TU
BOARD
CNP1
R144 C140 R140 C128 R141
220 1000p 2.2k 2200p 4.7k
C225
4.7
50V
C308
0.22
C309
0.1
C118
2200p
R263
22k
9
6
7
R258
47k
R126
1k
R133
0
R303
220k
0.1
C209
4.7
50V
7
C202
10
SCK
SCK
R159
22k
R127
47k
R304
1k
0
D201
Q201
2SC4081-T106R 1SS355
8
SO0
TRAY DET
R227
47k
0
SI0
DVD AMUTE
R259
22k
5
3
R201
47k
1
D202
1SS355
D205
1SS355
R226
1k
R211
10k
R204 4.7k
XIFBUSY
R257
47k
2
6.4 12.2
D102
1SS355
Q101, 201
MUTING
0.1
D101
Q101
2SC4081-T106R 1SS355
C207 C208
100p 100p
R261 R203
47k 4.7k
C201
10
XIFBUSY
7
(2.5)
5
C212
0.47
50V
R225
22k
1
+
–
MIX AMP
IC303
RC4580IPWR
(2.5)
2
C112
0.47
50V
–
+
R262
4.7k
1
XIFCS
2
GND
IC303
FB352
0
R163
22k
R111
10k
24
DVD RESET
C109
4.7
50V
D203
1SS355
16
GND
C105
100p
Q204
2SC4081-T106R
GND
TRAY_DET
(Page 33) E
C129
0.01
R143
470
R316
10k
Q104
2SC4081-T106R
15
13 14 15 16 17 18 19 20 21 22 23 24
14
COUNT
R142
22k
C315
0.022
R109
22k
1
13
GND
C107
100p
2
12
5.0V
C104
100p
3
Y
GND
MUTE
C230
47
16V
C229
0.01
R108
4.7k
R107
4.7k
Y
4
11
XIFCS
DVD
BOARD
(2/2)
CN704
C227
0.47
50V
R162
47k
R104
4.7k
R103
4.7k
12 11 10
V-GND
3
SP201
(R-CH)
7
C103
470p
R161
47k
BY
CN454
8P
DVD_RESET
(Page 31) C
Q203
2SD2652
C316
2200p
R207
4.7k
I
R315
2.2k
R314
10k
R125 22k
10
4
6.4 12.9
C322
1000p
9
B-Y
3.3V
R238
1k
R242
22k
C317
2200p
4
H
R239
100k
C130
47u 16V
(2.5)
G
C363
1000p
21
C131
100
16V
R243 470
1
A-RA-R+
D204
1SS355
R237
22k
VCC
DVD
BOARD
(1/2)
CN701
C362
100p
12.2
C232
1000
16V
R244 220
A-GND
C226
1000p
R236
10k
CN354
24P
5
R241 4.7k
3
6
R139
100k
C228 2200p
2
7
C127
0.47
50V
R240 2.2k
1
5V
8
7.2
0
R354
0
C357
10
50V
9
0.6
C240 1000p
SPDIF
SPDIF GND
C356
1000p
20
CN302
4P
R312 C314
22
10k
25V
C354
0.1
CN355
3P
V GND
(Page 30) A
C355
0.1
0
R138
1k
C126
1000p
D104
1SS355
(5)
(2.5)
F
GND
3
10
0
Q103, 203
MUTING
Q103
2SD2652
0
D351
IN4002B
11
0
R309
2.2k
D303
1SS355
R136
10k
R137 22k
(5)
E
2
12
0.6
D304
1SS355
(2.5)
DVD
BOARD
(1/2)
CN705
1
5V
13
C231 100 16V
C353
47
16V
(0)
(Page 30) B
SPDIF
14
POWER ON:5
STANDBY:0
2.2
0
0
C125
4.7
50V
JK502
15
BS R
1
POWER GND
NC
2
STBY
B IN
3
FILTER
A IN
4
NF R
NC
5
C351
0.1
JK502
OPTICAL
OUTPUT
19
IC B/D
Q302
DTA144EUA
MUTING
CONTROL
5
M
D
18
R IN
GND
6
NF L
VCC
7
L IN
B OUT
8
2.2
A OUT
9
5.5
NC
IC B/D
OPTICAL
TRANSCEIVER
JK502
HVE0024
(1.6)
POWER AMP
IC301
BA5417
5
PREGND1
C01
C04
C18
C19
C11
C10
C09
(3/4)
CN351
5p
17
16
IC301
DISC TRAY
OPEN/CLOSE
MOTOR DRIVE
IC351
BA6208
R209 22k
M301
DISC TRAY
OPEN/CLOSE
CN001
5p
S001
15
14
IC351
(2.5)
C
MAIN
BOARD
0
S001-1
DISC TRAY
OPEN DETECT
S001-2
DISC TRAY
CLOSE DETECT
C08
C07
MS-203
BOARD
13
MAIN
BOARD
(1/4)
MAIN
BOARD
(2/4)
B
12
11 (Page 36)
14 (Page 37)
A
11
10
PREGND2
4
C05
3
C03
2
C02
1
C321
10
50V
C235
0.1
C135
0.1
ICF-DVD57TV
1
2
3
4
5
6
7
9
8
10
11
12
13
14
15
16
17
18
19
20
21
22
16 (Page 37)
(4/4)
D11
D10
D13
MAIN BOARD
D12
MAIN
BOARD
(2/4)
A
TRANS BOARD
IC901
B
+5V REGULATOR
IC901
XC6202P502PR
(5)
O
1
(9)
I
3
G
2
C978
100
16V
C918
0.1
C903
0.1
C920
22
25V
C917
0.1
D901
RBV-406H
2
1
C
9
C905
0.1
4
0(9)
3
CR
NON1
INV1
FB1
DT1
OUT1
GND
3
4
5
6
7
8
I
G
D904
1SS355
O
5
3
C936 0.1
D916
DA204U
12.3
R946
220
C982
1
5.7
5.6
2.7
0
Q923
DTC144EUA
Q914
2SA1576A
C974
0.01
(SHIELD)
(9.2)
6.2
D907 RB501V-40
12.9
-1.2
D924
1SS355
R976
1k
Q922
2SA1576A
6.7
R977
1K
6.7
R943
47
D917
DA204U
12.3
11.6
C980
1
6.7
Q915
2SA1576A
R947
220
6.7
2.7
0
C973
470
10V
C975
0.01
C979
Q921
22
DTC144EUA
25V
D914
1SS355
C977
0.01
MAIN BOARD
(3/4)
(Page 38)
ICF-DVD57TV
39
D24
D15
D26
D27
D23
D22
D21
D19
17
0.7
CN902
1P
R965
4.7k
R967 2.2k
39
R952
10k
0
Q920
2SC4081-T106R
R968 10k
D915
1SS355
J
R955 10k
R956
47k
C966
2.2
D925
1SS355
Q912
2SD2396K
Q913,915,920-922
+6V REGULATOR
C901
100p
C910
0.1
R901
1M 1/2W
D
(Page
33)
C984
1000p
R964
4.7k
C985
100p
0(2.5)
L902
TU
BOARD
0.7
R966 2.2k
Q917
2SA1576A
DEAD TIME
0
(2.5)
4
3
0
C976
0.01
D902
2 RBV-406H
1
C908
0.1
R951
10k
Q919
2SC4081-T106R
C909
0.1
C912
0.47
0(1.5)
R960 22k
(1.5)
(1.8)
(1.2)
C948 2200p
(1.2)
(1)
NC
5.6
D923
MTZJ-T-77-6.8B
C947
0.1
(1.7)
GND
R969
100k
R975
1K
R942
47
11.6
D903
1SS355
3.9
12.9
C972
470
10V
C965 0.01
C971
100p
2
3.7
5.6
R974
1k
C981
22
25V
TH901
I
D919 1SS355
2
C954 470 10V
1
C942
10
50V
Q924
2SA1576A
C911 0.1
5
D921 1SS355
Q918
2SA1576A
1
IC951
XC61CN3502NR
R945
47k
R948
220k
R953
22k
R958
100k
C970
0.47
(AC IN)
L901
-1.2
C962 0.01
3.9
C955 220 16V
VCC
CT
2
F902
2.5A
125V
C907
0.1
Q911
2SD2396K
IC904
C943
0.01
1
D906
1SS355
C916
0.01
+3.9V REGULATOR
IC904
XC6201P392PR
T901
POWER
TRANSFORMER
R902
47k
Q911,914,919,923,924
+5V REGULATOR
C956 470p 10V
16.7 R957
(9.2) 220
TEMPERTURE
DETECT
R912
47k
C915
4700
16V
4.7k
C945
100p
IC951
28
1
R971
10k
F901
2.5A
125V
D905
1SS355
R903 100k
Q906
DTC144EUA
(13.7)
(1.5)
(1.7)
(6.4)
OUT2
9
R959
27
R938
220
F904
3.15A
72V
C967 470p
R949
47
16.2
(9.4)
3
R961 47k
R950
22k
16.7
(9.2)
Q913
2SC4081-T106
4
R962 220k
C959
0.01
3
L906
22µH
R937
2.2k
R963 22k
C960
0.01
16.7
(13.7)
C906
0.1
0(0.7)
Q904
2SC4081-T106R
C923
0.1
IC B/D
16.7
(13.7)
4
C968 220p
C961 0.01
2
15.9
(9.2)
D918
RB050L-40TE25
1
C950 470 25V
G
R940
220k
S
VIN
L907
22µH
R941
100k
C957 0.01
3
I
C951 2200 25V
O
1
2
5
6
VOUT
L908
22µH
(5.1)
(3.1)
C953
100
16V
D913
1SS355
O(5.1)
+3.3V
REGULATOR
IC903
BA33BCOFP
C946 470 25V
IC903
TCP6102
SWITCHING
REGULATOR
C921
470
10V
C941
2.2
POWER CONTROL
IC905
BA9743AFV
RB501V-40
Q913, 918
REGULATOR CONTROL
C949 0.01
26
R936
1k
9(0.1)
R935
47k
IC905
D908
Q916
(1.2)
(1.2)
(0)
(2.5)
C983
0.1
R972
100k
C938
100p
Q901,904
MONITOR ON
SWITCH
R908
22k
C904
0.1
C902
0.1
6
R954 10k
C939 2200p
R931 47k
R932 220k
C940 0.47
R923 22k
16 15 14 13 12 11 10
3.9
3.7
FB2
2
G
R978
47k
16.7
6P
C914
0.01
3
C964 0.01
NC
1
I
2
0(3.1)
Q910
2SA1576A
DEAD TIME
O
9
(8.2)
0(2.5)
DT2
R930
220
1
0
(2.5)
TEMPERTURE
DETECT
IC952
XC61CN3502NR
INV2
16.7
(6.6)
Q909
2SA1576A
0(1.5)
IC952
NON2
R929
47
C928
100p
R934
100k
SCP
16
(6.6)
Q908
TCP6102
SWITCHING
REGULATOR
R918
220
3
VREF
25
16.2
(6.4)
GND
16.7
(16.6)
4
R928
22k
D02
(Page
36)
H
3
R915
2.2k
F903
3.5A
72V
D06
R939 22k
G
R927
4.7k
D05
R926 10k
MAIN
BOARD
(1/4)
D04
C952 220 16V
12
4
L903
22µH
VIN
C932 470 25V
D03
16.7
(13.7)
Q907
2SC4081-T106
D912
RB050L-40TE25
R916
47k
R917
10k
C935 0.01
F
1
2
5
6
L904
22µH
C937 0.01
C933 2200 25V
L905
22µH
16.7
(13.7)
VOUT
E
S
C927 470 25V
O(8.2)
TH902
C931 0.01
24
R922
47k
0.4(13.7)
9
D920 1SS355
Q907, 909
REGULATOR CONTROL
R921
220k
R924
220k
R925
10k
C930
0.01
D911
1SS355
16.7(0)
Q905
DTA144EUA
R923 C929
47k 470p
R911
1k
16.7(13.7)
R913
47k
R906
100k
CN901
C913
4700
25V
D922
MTZJ-T-77-5.6B
Q902
2SC4081
0
(2.5)
0
(2.5)
C925
0.01
IC902
+9V REGULATOR
IC902
XC6202P902FR
C924 0.1
0(2.5)
Q905,906
MONITOR ON
SWITCH
C919
1
R909
22k
C922 100p
0
0(2.5)
R914
47k
D
Q901
2SB1694
R907
220
R920 100k
R910
1k
Q903
2SA1576A
0
SWITCHING
(HINGE)
ICF-DVD57TV
6-18. PRINTED WIRING BOARD – LCD Board –
1
2
3
4
5
6
7
8
9
10
LCD BOARD (COMPONENT SIDE)
A
B
C
D
11
E
1-866-127-
(11)
LCD BOARD (CONDUCTOR SIDE)
F
S658
S657
CLOCK
MODE/
SCREEN SIZE
S656
S654
TV
MENU
SOUND
S655
S652
+
VOLUME
R606
12
11
D601 – 603
(LCD BACK LIGHT)
N
CN604
R651
R605
R604
R654
R653
R656
R655
R658
R657
R660
R662
R661
R664
R663
R659
S653
–
D603
R603
IC601
R602
1
R601
3
D602
R608
C605
D601
R652
C604
R609
G
R666
R665
ENTER
H
MAIN
BOARD
CN601
2
(Page 35)
R607
C606
C603
1
Q601
S651
TIMER
PUSH
START/STOP
ECB
15
D604
I
• Semiconductor
Location
16
Ref. No. Location
1
M
CN603
LCD601
C602
C601
TIMER
MAIN
BOARD
CN602
20
(Page 35)
D601
D602
D603
D604
G-2
G-4
G-6
I-8
IC601
G-1
Q601
I-7
2
J
1
11
1-866-127-
ICF-DVD57TV
40
40
(11)
ICF-DVD57TV
6-19. PRINTED WIRING BOARDS – SWITCH/TRANS Section –
1
2
3
4
5
6
DETECTION BOARD
7
8
9
10
11
12
13
15
16
KEY BOARD
A
K
2
14
S661
u
MAIN
BOARD
CN401
1
(Page 35)
1
m
2
5
4
R674
R673
R672
R671
R670
>
D653
D654
MONITOR ON
AUX
D652, S668
TV
D653, S669
DVD
D654, S670
R676
R675
R678
BCE
R619
Q654
R618
BCE
R617
Q653
S664
R616
BCE
R615
R614
Q652
R677
R690
R689
R688
R687
D652
R613
BCE
S670
OFF
Q655
BCE
D655
RADIO ON
BAND
D665, S664
CN001
1
S660
+
TV CH/PRESET
S669
R612
R611
Q651
OPEN/
CLOSE
Z
D651, S667
MS-203 BOARD
P
R669
.
S668
R610
D
R682
R681
M
S667
D651
MAIN
BOARD
CN351
E
S666
–
R686
R685
(Page 35)
C
S665
+
S663
8
9
R684
MAIN
BOARD
CN407
RADIO TUNE/
TIME SET
R683
(11)
CN408
L
11
1-866-131-
S659
–
2
S401
DISPLAY
RELEASE
R680
R679
B
R668
R667
S662
x
(Page 35)
S001-1
DISC TRAY
OPEN DETECT
–1
S001-2
DISC TRAY
CLOSE DETECT
–2
S001
11
1-866-129-
1-861-327-
M
(11)
12, 21
M301
DISC TRAY
OPEN/CLOSE
TRANS BOARD
F
L901
F902
D
W1
TU
BOARD
F901
(Page 32)
JW902
4
C904
JW901
4
C910
H
• Semiconductor
Location
D902
R901
G
L902
C901
J
Q651
Q652
Q653
Q654
Q655
D-7
D-9
D-11
D-12
D-14
C905
C902
C908
C911
A
D905
K
A
C903
D906
K
C909
T901
POWER
TRANSFORMER
R902
D-7
D-8
D-10
D-12
D-13
I-8
I-7
I-7
I-7
C907
I
D651
D652
D653
D654
D655
D901
D902
D905
D906
C906
Ref. No. Location
1
C912
(AC IN)
1
R903
JW903
D901
6
1
11
1-866-130-
K
Q
MAIN BOARD
CN901
(Page 35)
ICF-DVD57TV
41
41
(11)
ICF-DVD57TV
6-20. PRINTED WIRING BOARD – MONITOR Board (Component Side) –
1
A
2
3
4
5
6
7
8
9
10
11
12
13
14
15
MONITOR BOARD (COMPONENT SIDE)
F1801
C1402
R1407
C1401
C1424
R1439
R1441
R1442
C1412
R1443
C1427
C1426
20
C1805
R1821
C1818
C1811
R1814
C1812
IC1801
R1808
C1803
R1802
R1803
R1819
R1806
R1807
L1902
R1805
R1815
C1820
C1817
R1822
C1824
R1818
R1817
K
A
D1905
A
D1901
A
D1902
K
D1903
K
D1904
T1801
INVERTER
TRANSFORMER
L1904
R1665
C1660
R1660
R1659 R1656
C1661
R1661
C1659
R1663
IC1651
L1906
4
R1658
A
K
L1905
C1662
R1657
1
R1655
R1651
C1658
A
R1653
8
5
R1662
D1652
24
K/A A
D1654
K
D1653
L1651
C1819
R1572
FB1612
R1666
R1667
C1651
C1652
L1601
C1656 R1652
K
C1607
C1608
C1813
L1903
L1602
L1603
13
C1807
C1823
C1809
Q1901
A
C1609
R1642
R1633 R1640
R1639
R1631
R1638
R1634
Q1504
C1568
1
R1578
RV1501
R1953
B C E R1518
R1519
C1524
R1571
R1513
R1514
R1515
R1511 C1518
K
25
12
R1612
32
R1510
R1628
FB1604
FB1605
FB1606
FB1607
FB1608
FB1609
FB1610
FB1611
17
R1643
R1644
33
C1603
R1630
R1614
R1615
R1616
R1617
R1618
R1619
R1620
R1621
R1622
FB1603
R1626
R1625
FB1602
R1624
R1623
FB1601
R1611
C1526
16
H
R1524
R1523
R1522
R1521
IC1501
R1509
C1511
C1512
C1513
R1609
D1651
C1653
36
IC1601
RV1651
A
R1604
C1530
48
37
1
R1603
C1528
1
G
48
R1607
C1503
C1506
C1508
C1509
C1510
R1527
R1525
C1531
49
R1526
C1537
C1533
R1529
R1530
R1531
R1602
R1528
64
R1601
B
11
C1804
R1811
1
A
R1577
R1536
R1533
C1550
R1532
C1539
L1506
C1551
R1540 R1539
R1542 R1541
C1540
C1541
R1535
R1534
C1544
C1543
C1542
Q1502
ECB
10
C1814
C
10
BP1401
(TV TEST MODE)
R1813
R1934
5
R1403
1
R1933
T1901
DC/DC
CONVERTER
K
C1548
C1907
6
R1404
21
K
F
C1910
L1901
R1405
80
C1810
E
BCE
R1812
20
C1816
R1408
E
Q1501 E C B
R1906
R1924
R1907
C1902
Q1902
1E 1B2C
R1916
R1918
1
C1815
R1936
R1932
C1808
L1907
R1549
R1550
R1553
R1938
R1406
20
R1554
C1405
F1901
R1409
IC1401
R1546
11
R1414
R1410
R1548
D
R1413
C1806
Q1903
R1912
IC1502
R1411
8
1C2B2E
R1935
R1917
C1911
C1570
C1904
R1427
R1412
40
R1923
R1415
C1417 C1406
41
BCE
R1543
R1432
60
61
R1937
R1545
R1431
1
C1903
1
R1430
R1436
C1553
R1552
C1557
10
R1429
R1544
R1908
C1411
Q1904
C1561
C1571
L1508
IC1901
R1927
C1413
R1424
R1555
C1560
C1559
C1558
C
C1408
R1422 R1418 R1417 R1416
R1425
R1419
R1426
RV1902
C1407
R1804
R1919
9
C1912 R1920 C1913
16
R1902
R1423
R1428
C1409
C1410
C1569
R1573
L1801
C1909
C1908
R1911
R1930
R1914 R1929
R1905
R1926
R1904
RV1901
R1903
R1910
R1928
R1931 R1913
R1922
C1906
R1940
R1925
B
R1909
R1939
1
R1557
R1558
30
CN1801
2
CN1802
I
11
1-866-126-
J
LCD1 (1/2)
LIQUID CRYSTAL
DISPLAY MODULE
LCD1 (2/2)
LIQUID CRYSTAL
DISPLAY MODULE
(BACK LIGHT)
Ref. No. Location
D1651
D1652
D1653
D1654
D1901
D1902
F-8
F-8
G-9
G-9
E-9
E-10
Ref. No. Location
Ref. No. Location
Ref. No. Location
Ref. No. Location
D1903
D1904
D1905
E-10
E-11
E-11
D-7
G-4
Q1501
Q1502
Q1504
Q1901
Q1902
Q1903
Q1904
IC1401
IC1501
IC1502
IC1601
IC1651
IC1801
IC1901
D-4
G-7
F-9
C-13
C-10
F-4
F-5
H-5
D-11
C-9
C-11
(11)
C-9
ICF-DVD57TV
42
42
ICF-DVD57TV
6-21. PRINTED WIRING BOARD – MONITOR Board (Conductor Side) –
1
2
3
4
5
6
7
8
(Page 35)
A
J
9
MAIN BOARD
CN404
G
11
(Page 35)
(Page 35)
MAIN BOARD
CN406
10
13
14
15
(Page 35)
MAIN BOARD
CN405
H
12
MAIN BOARD
CN403
F
MONITOR BOARD (CONDUCTOR SIDE)
TP1412
CN1406
CN1404
C1901
10
CN1403
CN1405
C1925
11
1
7
1
1
1
6
C1430
C1429
+
R1820
R1816
R1810
TP1421
C1432
B
R1444
C1418
4
R1437
C1419
C1556
+
R1453
+
1
C1431
R1434
C1555
R1435
C1552
IC1451
R1454
R1547
R1433
R1551
C1905
TP1515
5
C1421
TP1906
8
C1420
D1402 D1403
R1420
R1402
C1801
C1451 R1421
+
C
R1451
+
C1554
R1452
L1507
X1401
R1438
C1425
R1440
D
TP1909
TP1901
(GND)
+
+
+
+
+
L1505
C1604
L1501
+
C1522
C1657
+
C1916
L1502
C1610
+
C1917
C1606
C1918
L1652
+
C1919
C1501
C1502
TP1907
C1915
+
C1514
C1515
E
C1523
+
C1920
+
C1538
+
+
C1601
R1575
R1560
L1950
ECB
R1561 R1567
ECB
+
R1507
R1508
C1519
C1521
R1504
R1579
+
C1525
R1517
R1503
C1505
C1507
C1562
R1952
Q1509 Q1506
L1954
D1951
11
1-866-126-
Ref. No. Location
D1402
D1403
D1501
D1951
D1952
C-7
C-7
G-11
I-8
I-8
Ref. No. Location
Ref. No. Location
IC1451
IC1503
C-9
H-6
Q1503
Q1505
Q1506
G-10
G-10
H-7
Q1507
Q1508
Q1509
Q1510
+
K
K
C1959
L1952
TP1954
R1950
L1953
+
R1954
C1958
J
C1516
+
C1953
L1951
TP1952
C1517
TP1964
C1960
+
I
C1520
A
A
+
C1951
C1957
TP1963
+
D1952
TP1965
+
+
C1955
C1504
TP1960
R1951
8
C1527
R1502
R1505
R1955
5
2E2B 1C
R1570
K
Q1508
IC1503
BCE
A
R1569
2C1B 1E
Q1505
R1516
+
BCE
C1529
R1570
Q1503
R1520
R1563
R1605
+
+
R1566
C1565
R1564 R1565 C1567
C1563
+
L1510
L1509
4
BCE
R1645
C1654
R1501
R1506
TP1510
C1535
+
C1566
Q1507
BCE
R1512
C1532
+
C1564
R1562
1
Q1510
C1534
C1602
+
G
R1574
C1655
+
R1629
D1501
+
R1568
TP1951
C1549
C1547
R1646
H
C1546
C1611
C1922
C1923
X1501
C1545
+
C1536
C1921
+
C1605
TP1651
C1924
+
F
G-7
G-7
H-7
G-7
ICF-DVD57TV
43
43
(11)
ICF-DVD57TV
6-22. SCHEMATIC DIAGRAM – MONITOR Board (1/3) –
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
(Page 46)
24
A
MONITOR BOARD
B
C07
C05
MONITOR
BOARD
(3/3)
(1/3)
C1801
47
25V
TP1420
L1801 100µH
R1803
22k
3.1
K
OUTR
12
PGND
13
R1814 1k
38
11
IC1801
BTR
2
7.6
C1815 0.47
C1809 0.47
C1823 470P
7.9
REF
14
BATT
C1807 1000P
2.1
0
5
15
COMP
4.9
ISFB
AGND
16
C1816
0.47
0.3
25
24
GND1
23
2.5
G-OUTDET
22
2.5
60
KILLDET
G-OUT
21
61
APCDET
B-OUTDET
20
62
SCOUT
B-OUT
19
R1510 47
2.5
2.5
0
63
VXO-NTSC
BLANK
7
8
9
C1517
2.2
50V
G-OUT
C1516
2.2
50V
B-OUT
0
0
0
R1506
10k
R1503
2.2k
17
33
C1515
47
25V
32
0
0
C1514
0.1
BLK
L1502
100µH
C1503
0.1
R1505
4.7k
0
OSD_BOUT
2
OSD_GOUT
5
OSD_ROUT
C1502
0.1
2
C1506
0.1
C1501
47k
R1508
10k
R1502
10k
R1504
4.7k
C1505 R1507
2.2
4.7k
50V
C04
C03
C02
C06
R1573
4.7
22
23
MONITOR
BOARD
(2/3)
MONITOR
BOARD
(3/3)
(Page 46)
(Page 45)
ICF-DVD57TV
44
44
BATT
OUTL
PGND
BTL
2
8
C1819
15p
3150V
C1818
470p
4
C1812
1
R1813
4.7k
R1821
100k
R1815 4.7k
T1801
INVERTOR
TRANSFORMER
C1817 0.047
C1808 0.01
C1810
0.1
6
5
C1824 0.022
C1814
0.01
C1803 C1806
1
0.022
CN1801
2P
7
7.4
1.8
DRV
10
7.9
EN
9
6
DBRT
8
3.2
BDSC
7
1
IL
6
2.1
ABRT
5
R1807
1k
10 11 12 13 14 15 16
3.4
2
4
R1812
100k
R1509 47
18
B-IN2
6
R-IN2
5
B-DET
4
B-IN1
3
R-DET
2
C1513 1
2.4
IC B/D
1
G-IN2
YS
G-DET
VXO-PAL
3.4
64
3
R-OUT
0
C1549
9p
2
R1808
2.2k
C1519
0.1
C1518
0.01
2.5
GND3
1
0
CSYNCOUT
VDIN
PDL
VSS
NRGB
HSYNCLOCK
SCP
VCC2
VREFDRIV
2
R1535
10k
R1511 47
7.3
RGB DECODER
IC1501
AN2546FH-AV
3
5
2.4
1.6
4.5
+BCLKFLT
VCC1
IC1501
R1579
4.7k
C1569
1000p
FT
HSYNCLOCK
C1526 0.022
R1521 1M
R1522 10k
R1524 10k
C1528 0.022
3
58
C1520
2.2
50V
2.5
B14
6
2.6
CIN
34
C1521 1
B11
Y/CVBS
GND2
ACCDET
57
VDOUT
B10
5
AFCDET
56
HDOUT
3.1
B15
4
17
R1806
470k
2.9
2.5
B04
(Page
36)
3
B-Y
V-GND
B01
J
V-GND
VCDADJ
26
28
2.5
TP1510
C1501
47
25V
B05
MAIN
BOARD
(1/4)
CN403
SCK
SDATA
C1531 470P
27
R-OUT
5
L1501
47µH
2
1.8
R-OUTDET
YDET
3.1
R1534 10k
CN1403
6P
1
VCC1
CSYNCIN
CTRAPIN
55
29
2.4
C1504
2.2
50V
R-Y
C1530 1
C1532 22 16V
R1526 1k
54
VCC3
VCOMOUT
36
4
59
C1544
0.022
18
R1805
1k
2.5
H
V-GND
30
3.1
3.6
C1541
0.1
37
F
5
0
3.3
CTRAPOUT
X1501
3.579545MHz
I
31
2.7
C1542
0.1
C1543
0.1
C1548
1
NAVSYNCIN
GND
1.2
DV/DC CONVERTER
FREQUENCY
YIN
53
3.4
0.7
R1931
10k
R1920
10k
52
C1512 1
Q1902
2SC4081-T106R
RV1902
R1913
22k
32
VDOUT
2.3
C1511 1
R1922
22k
R1936
2.2k
R1927
10k
HDOUT
RWMOUT
3.1
G-IN1
0
R1903
22k
SECAM BLACK ADJ
C1510 0.1
Q1902,1904
B+ SWITCH
R1938
2.2k
R1935
22k
COMDC
R-IN1
10
C1907
0.47
R1532
2.2k
PONRST
51
VREF
9
8V
R1917
10k
Q1903
IMZ1A
DV/DC
CONVERTER
19
C1813
0.01
LCD BACK
LIGHT CONTROL
IC1801
MP1015
35
50
C1507 2.2 50V
8V
-1.5
20
C1522
1
49
C1509 0.1
8
-2
R1928
22k
C1811
1
C1523
47
25V
R1513
470k
3
C1508 0.1
8V
R1937
47k
R1910 100k
C1538
4.7
50V
VCC1
7
L1902
10µH
Q1904
2SB1694
7.3
R1514
100k
B-YIN
P-GND
8.1
8.2
F1901
0.5A
50V
L1506
47µH
R1811
100k
C1525
1
Q1503,1505
SINC DET
R1519 R1518
47k
100k
B-YOUT
6
0.4
-1
C1545
22p
C1546
10p
C1547
7p
C1539
0.1
C1540
0.1
C1524
2200p
L1505
100µH
R-YIN
5
P-GND
R1533
1k
4.6
RV1902
10k
C1537
2.2
R-YOUT
4
P-GND
R1536
0
R1516
10k
R1515
100K
2.4
C1805
0.01
C1804
1
48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33
PALN
INV-GND
5V
C1550
0.22
R1932
22k
4
C1536
4.7
50V
Q1502
2SC4081
-T106R
2.7
3.4
R1523
10k
R1804
0
0
0.7
R1517
22k
Q1504
2SC4081-T106R
BUFFER
0
R1810
220k
IC B/D
5
Q1501
2SC4081-T106R
R1577
4.7k
C1912 470p
3
R1531
1k
SDATA
OUT1
8
R1539 100k
C1551 1
DT1
7
4
FB1
6
5
SCLK
R1934 2.2k
R1918 2.2k
R1933 2.2k
VCC
OUT2
DT2
FB2
INV1
5
R1906 47k
2
R1907 47k
(Page
36)
8V
INV-GND
RV1901
R1924 220k R1923 220k
J
C1901
0.01
1
C1902 220p
8V
MAIN
BOARD
(1/4)
CN406
INV2
NON1
4
1.6
3
1.3
RT
2
C1910 470p 1.7
CT
1
1.7
31
RV1901
10k
C1904 470p
L1901
150µH
CN1406
10P
0.9
R1902
47k
R1908 4.7k
B07
R1530
470
3.4
POWER CONTROL
IC1901
BA9743AFV
B08
R1540
47k
R1542
22k
IC1901
B06
F
NON2
SCP
IC B/D
MONITOR
BOARD
(2/3)
E
VREF
(Page 45) 21
9
R1916 2.2k
1.6
8.1
16 15 14 13 12 11 10
Q1501, 1502
SYNC SEPARATOR
C1533
1000p
3
R1919
2.2k
2.4
1.2
0
2.5
R1528 1k
C1534
100p
C1535
100p
C1913
1
B02
D
G
R1529
220k
3
C1909 470p
R1926 220k
R1940 100k
R1939
47k
C1908
0.47
R1930
22k
R1911
100k
C1906
0.47
Q1505
R1512
2SC4081-T106R
10k
Q1503
2SC4081-T106R
3.1
C1529 C1527
0.47
22
16V
50V
R1541 47k
R1904
47k
R1909
22k
R1905 47k
C
R1914
22k
R1929
10k
R1925
220k
3.6
R1520
D1501
1SS356-TW11 10k
R1820
100k
0
R1525
4.7k
R1527
4.7k
R1802
10k
R1819
10k
VLFB
F1801 1A 32V
R1818
470
R1816
220k
C1820 R1817
4700p
220
R1822
1k
LCD1 (2/2)
LIQUID CRYSTAL
DISPLAY MODULE
(BACK LIGHT)
ICF-DVD57TV
• See page 47 for Waveforms. • See page 50 for IC Block Diagrams. • See page 59 for IC Pin Function Description.
5
6
7
8
9
T1901
DC/DC
CONVERTER
(2/3)
13
14
15
22 (Page 44)
MONITOR
BOARD
(1/3)
B11
B01
B04
B14
C17
C13
C09
C10
C12
C11
B08
B07
B02
B06
MONITOR
BOARD
12
MONITOR
BOARD
(3/3)
MONITOR
BOARD
(1/3)
B
11
25 (Page 46)
21 (Page 44)
A
10
B15
4
B05
3
C16
2
C15
1
B10
45
D1901
SB01-05CP-TB-E
10
D1902
SB01-05CP-TB-E
C1915
4.7
50V
C1920
47
25V
L1903
47µH
TP1909
9
7
C
44
C1921
22
16V
C1916
10
16V
L1904
47µH
C1917
22
16V
L1905
47µH
C1918
10
16V
L1906
47µH
C1923
22
16V
C1919
4.7
50V
L1907
47µH
C1924
22
16V
D1903
SB05-05CP-TB-E
6
43
5
40
TP1906
D
C1911
470p
100V
HSYNCLOCK
3
4
Q1901
2SD1760Q
DV/DC
CONVERTER
C1922
100
16V
D1904
SB05-05CP-TB-E
8
0.4
TP1907
8
42
2
(Page 36)
u-COM SDATA
5
u-COM LATCH
6
TFT OPEN
7
3.3
R1420 100
0
R1419
10k
1.6
C1413
100p
3.3
3.3
3.3
0
SCL
SDA
5
GND
6
NC
7
WP
8
1
2
3
4
3.7
0
3.3
0
3.6
R1410 100
R1411 1k
R1453 1k
R1454 10k
R1412 1k
3.3
3.7
R1409 100
C1401
0.01
C1406
0.01
C1405
0.01
C1431
0.01
C1411
1
IC1451
EEPROM
IC1451
BR24C04F-WE2
C1432
100p
C1407
100p
C1408
100p
M
ICF-DVD57TV
45
OSD_GOUT
OSD_ROUT
BLK
R1550 100
R1553 100
R1554 100
0
0
VC1
BLK1
BLK2
VC2
VG
VR
VB
DSC IN
TEST
GND
DSC OUT
8
9
10
1.4
CMDCT
1.4
VDD
2.5
PCL
3.1
DATA
7
3.1
CSN
6
R1555 10k
R1552 10k
R1551 1k
C1571
100p
R1451
4.7k
IC B/D
C1402
0.01
5
C1557
5p
C1558
22p
C1559
10p
L1508
22µH
45
C1410
100p
C1556
47
25V
C1552
0.01
C1570
100p
R1452
4.7k
C1409
100p
L
4
R1421 100
C1451
0.1
R1414
4.7k
3
3.3
3.3
3.3
R1403
100k
R1413
4.7k
2
C1553
100p
3.2
AN16
AN17
AVDD
TFT OPEN
NC
XRESET
T-S DATA
T-SCL
R1545 470
3.1
R1444
1k
TV/AUX_MUTE
T-MUTE
R1544 470
R1424 100
R1427 1k
4
R1543 470
R1425 100
3.3
R1418 220
3
u-COM CLK
R1426 100
3.3
R1417 1k
u-COM RDATA
3.3
21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40
R1402
220k
1
0
R1416 1k
MAIN
BOARD
(1/4)
CN405
NC
2
SCP-DET
T-AGC
RESET
SEG10
3.3
R1415 100
H
NC
BP1401
(TV TEST MODE)
CN1405
7P
K
NC
0
1
NC
SEG8
SEG9
0
DVD ON
NC
SEG7
3.3
11
SEG6
R1408 10k
TV/AUX AMUTE
T-AFT
R1407 1k
10
SEG5
R1406 10k
TV/AUX
D1403
1SS119-25TD
RIN
AVSS
NC
9
EEPROM-SDA
SEG4
0
8
TUNER SCK
EEPROM-SCL
SEG3
R1405 10k
7
TUNER SDA
SEG2
NC
TUNER AGC
uCOM-LATCH
IC1401
uPD789477GC-SR7596B
TEST_MODE
6
SEG1
0
TUNER AFT(A/D)
VSYNC
IC1401
0
5
SEG0
SEG15
TUNER F MONO
COM3
OSD-CS
SEG14
4
9
3
COM2
R1404 10k
(Page 36)
TUNER MUTE
TUNER MODE
uCOM-R DATA
R1422 1k
VCC
OSD-DATA
uCOM-S DATA
L1507
47µH
3.3
3.3
IC1502
µPD6467GR-546-1
NC
COM1
uCOM-CLK
3.3
R1428
100
NC
OSD-CLK
8V-SW
IC B/D
R1423 100
6
COM0
TFT-ON
41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60
5
VLC0
SEG13
J
2
ZOOM
4
VLC1
SEG12
MAIN
BOARD
(1/4)
CN404
1
3.9V
JUST
3
VLC2
SEG11
G
u-COM GND
TP1421
SIDE1
2
NC
20 19 18 17 16 15 14 13 12 11 10
CN1404
11P
C1925 0.01
I
SIDE2
HSYNCLOCK
SDA
IC
NC
SCL
XT1
XT2
VDD
VSS
X1
X2
XRESET
TV/AUX
DVD-ON
T-MODE
T-FMONO
1
NC
8
H
OSD DRIVER
7
[0]<<3.7>>
VBLK
IC1502
VSYNCN
20 19 18 17 16 15 14 13 12 11
80 79 78 77 76 75 74 73 72 71 70 69 68 67 66 65 64 63 62 61
G
0
2.9
VDOUT
HSYNCN
R1429 100
R1432 100
0
R1430 100
R1433 1k
0
0
R1434 1k
0
R1435 1k
3
3.3 R1431 100
R1436 10k
3
1.3
1.8
3.2
3.6[0.8]<<0.8>>
5.1
5.1
39
3.3
R1438 0
R1443 1k
R1439
100
0
R1440 0
0
R1546 100
C1420
100p
3.1
C1419
100p
R1548 100
HDOUT
C1418
100p
R1441 1k
R1442 1k
F
OSD_BOUT
VDOUT
C1417
0.1
C1421 R1437
0.1
4.7k
X1401
4.19MHz
SCLK
C1429
220
10V
C1430
1
R1549 100
JUST
SIDE1
41
D1402
C1412 C1427 C1426 C1425 C1424 1SS119-25TD
0.01 0.01 0.01 0.01
0.01
3.3
TP1901
ZOOM
SCK
R1912
0
SIDE2
E
1
C1905
47
25V
SDATA
D1905
SB01-05CP-TB-E
C1903
0.1
R1547 C1554
100k
10
16V
C1555
0.1
TP1515
C1560
10p
C1561
22p
ICF-DVD57TV
4
6
7
8
(3/3)
7
0
R1630 100
JUST
R1646 1k
R1659
4.7k
FB1601
R1623 0
FB1602
R1624 0
0
1
1
3
0
3.1
1.6
1
D1652
UDZSTE-175.1B
R/L
1.6
FB1611 STH2
0.1
37
VCO0
STH2
24
38
VSS(A)
STH1
23
39
RESET
ZOOMC
22
R1640 0
C1609
1000p
R1621 100
40
HDOT1
41
UONS
IC1601
0
42
3.1
R1643 100
3.1
R1644 100
3.1
HPOS4
43
44
HPOS2
45
HPOS1
46
N/P
OEV2
OEV3
0
R1620 100
FB1608 STV1
0.1
R1619 100
FB1607 OEV1
0.1
R1618 100
FB1606 OEV2
0.1
R1617 100
FB1605 OEV3
0.5
R1616 100
FB1604 CPV
0
R1615 100
1.6
R1614
19
18
17
CPV
16
INTEXT
15
47
VDD(D)
POL
14
48
VSS(D)
U/D
13
0
R1645
1k
ZOOM
VPOS1
VPOS3
9
VPOS2
BLACK
8
3.1
3.1
10 11 12
0
R1611 1k
R1604
1k
VDOUT
R1603 1k
SIDE1
7
3.1
3.3
0
R1602 1k
HDOUT
MONITOR
BOARD
(1/3)
SIDE2
R1601
1k
23
6
R1609 1k
5
R1607 1k
VDBIN
4
1.2
SIDE1
3
HOUT
SIDE2
2
VOUT
HSYNCIN
1
3
SYNCIN
C1611
1000p
2.4
R1612
1k
R1605 1k
C02
C06
ZOOM
I
20
0
C04
(Page
44)
21
OEV1
LCD CONTROLLER
IC1601
MN5814
HPOS3
C1601
100p
C1602
1000p
H
OEH
STV1
3.1
C1610
100
16V
FB1609 OEH
0.4
0
R1638
0
G
3.1
R1642 100
FB1610 STH1
R1622 100
0
3.2
F
C1652
0.01
CPH3
STV2
CPH2
CPH1
JUST
HDDT2
PDSSET
PD
VCD1
VDD(A)
QVDZMSEL
46
R1639
1k
R1633
100
R1634
100
R1667
4.7k
36 35 34 33 32 31 30 29 28 27 26 25
C1608
9p
E
2
3.1
1.5
D1654
DAN217-T146
STV2
CPH3
R1626 0
FB1603
L1601
1.5µH
D1653
1SS356-TW11
C1651
0.1
CPH2
FB1612
R1625 100
C1607
47p
0
R1657
220k
C1659
0.1
C1657
22
16V
C1656
0.1
R1658
47k
CPH1
R1629 1k
C1603
0.01
R1631
470k
R1666
47k
R1662
22k
4
C1655
0.01
R1628 0
D
R1652
1k
R1661
220k
R1655
100k
C1654
47
25V
C1606
0.1
C1658
0.1
(Page 44)
15
L1652
47µH
C1604
100
16V
C1605
0.1
14
R1663
100k
R1660
1M
R1656
4.7k
L1602
47µH
C07
L1603
47µH
3
1.0
D1651
1SV231
C05
5
OFF
SET
IN1
2
1
R1651 RV1651
1k
47k
PLL
6
C1660 470p
8
–+
PHASE SEPARATOR
IC1651
NJU7071V
24
13
R1665
47k
C1662
0.1
C1661
220p
OFF
SET
IN2
IC1651
C1653
1000p
B
2.1
5
L1651
10µH
MONITOR
BOARD
(1/3)
12
TP1651
R1653
10k
C
11
10
9
VSS
MONITOR BOARD
5
1.0
A
3
NC
2
VDD
1
• See page 59 for IC Pin Function Description.
CN1802
30P
TP1960
30
VCOM
29
STH1
28
VB(2.5V)
27
RED
26
GREEN
25
BLUE
STH1
R1557
100k
C1562
10
16V
R-OUT
C03
G-OUT
R1558
47k
C15
J
R1560
47k
R1561
220k
Q1506 – 1510
V COM BIAS
TP1965
OEH
R1570 R1571
22k
22k
7.4
-0.3
-0.3
C16
R1564
22k
0
C17
22k
7
6
–
+
–
+
1
2
3
Q1508
IMZ1A-T108
-0.3
-0.3
M
C1563
47
25V
C1565
0.1
C1564
47
25V
C1566
0.1
R1566 100k
R1563 100k
R1574 47k
R1562 100k
(Page
45)
-1
C10
C09
10µH
TP1952
L1951
10µH
L1952
10µH
L1953
10µH
C11
C12
O
ICF-DVD57TV
46
46
VEE(5.0V)
15
GND
14
VCOM
13
STV2
12
OEV3
11
OEV2
10
OEV1
9
CPV
8
U/D
7
STV1
6
NC
5
VSS(-13.0V)
STV1
RV1501
47k
R1569
22k
R1572
47k
L1954
10µH
C1955
10
16V
4
GND
3
VDD(3.3V)
2
NC
1
VGON(17V)
V-COM
D1951
1SS356-TW11
D1952
1SS356-TW11
C1953
22
16V
STH2
16
-0.9
TP1954
C1951
10
16V
R1953 0
0.3
L1509
10µH
L1950
R/L
17
CPV
-0.3
R1568
47
TP1951
CLK3
18
OEV1
-2
Q1507
2SA1576A-T106-QR
C1567
0.1
CLK2
19
OEV2
-11.9
-0.9
-11.7
CLK1
20
OEV3
7.4
-0.6
Q1510
2SA1576A-T106-QR
21
STV2
C1568
4.7
-0.3
25
MONITOR
BOARD
(2/3)
R1952 0
-0.3
-11.9
-0.3
MODE
STH2
0
R1575
4.7k
R1576
4.7k
4
VDD(3.3V)
22
CPH3
Q1506
2SC4081-T106R
V-
R1565
10k
OEH
23
CPH2
0.3
Q1509
2SC4081-T106R
24
CPH1
R1955
0
5
7.2
V COM AMP
IC1503
NJM4558E(TE2)
R1951 0
R1578
22k
R1567
47
V+
22k
R1559
IC1503
K
R1556
8
N
TP1964
B-OUT
L1510
10µH
C13
L
TP1963
C1957
4.7
50V
C1958
47
25V
R1950
4.7k
C1959
0.1
R1954
4.7k
C1960
0.1
LCD(1/2)
LIQUID
CRYSTAL
DISPLAY
MODULE
16
ICF-DVD57TV
• Waveforms
– DVD Board –
1
– TU Board –
IC706 6 (DVDRF IP)
(DVD play mode)
7
54 ns
200 mV/DIV, 200 ns/DIV
IC706 <x// (YUV4/G)
(DVD play mode)
0.9 Vp-p
500 mV/DIV, 5 µs/DIV
IC706 <xx, (XTALO)
1 Vp-p
1.3 Vp-p
37 ns
3
IC2 w; (XOUT)
13.3 µs
2 V/DIV, 20 ns/DIV
8
H
qa
4.4 Vp-p
0.6 Vp-p
2
IC706 <xzb (ACLK)
IC706 <x/x (YUV5/B)
(DVD play mode)
1.5 Vp-p
H
4
IC706 <x/c (YUV6/R)
(DVD play mode)
1.5 Vp-p
H
5
IC706 <xzc (ALRCK)
3.7 Vp-p
20.8 µs
2 V/DIV, 10 µs/DIV
6
IC706 <xzv (ABCK)
4.4 Vp-p
326 ns
2 V/DIV, 100 ns/DIV
47
ICF-DVD57TV
– MAIN Board –
wa
– MONITOR Board –
IC501 7 (TOUT)
(DVD play mode)
wj
Q916 (Gate)
(Except radio mode)
0.5 Vp-p
5.1 µs
H
IC401 ua (XT2)
4.1 µs
5 V/DIV, 2 µs/DIV
wk
IC905 1 (CT)
(Except radio mode)
3.3Vp-p
30.6 µs
es
IC1501 ql (B-OUT)
(DVD play mode)
0.5 Vp-p
3.6Vp-p
5.3 µs
1 V/DIV, 10 µs/DIV
wd
IC1901 1 (CT)
(Except radio mode)
13.2 Vp-p
1 Vp-p
ws
ea
IC401 ug (X2)
(Except radio mode)
H
1 V/DIV, 10 µs/DIV
ed
IC1501 wa (G-OUT)
(DVD play mode)
3.5 Vp-p
3.2 Vp-p
H
238 ns
1 V/DIV, 50 µs/DIV
1 V/DIV, 100 ns/DIV
wf
Q908 (Drain)
(Except radio mode)
ef
IC1501 wh (R-OUT)
(DVD play mode)
14.8 Vp-p
3.6 Vp-p
5.1 µs
H
1 V/DIV, 50 µs/DIV
5 V/DIV, 2 µs/DIV
wg
Q908 (Gate)
(Except radio mode)
eg
IC1501 ea (VDOUT)
(DVD play mode)
3.2 Vp-p
12.4 Vp-p
5.1 µs
H
5 V/DIV, 20 µs/DIV
wh
Q916 (Drain)
(Except radio mode)
1 V/DIV, 20 µs/DIV
eh
IC1501 es (HDOUT)
(DVD play mode)
15.6 Vp-p
5.1 µs
5 V/DIV, 20 µs/DIV
48
3.2Vp-p
H
1 V/DIV, 5 ms/DIV
ICF-DVD57TV
ej
IC1501 yd (VXO-NTSC)
(Except radio mode)
rd
11.2 Vp-p
0.4 Vp-p
4 µs
279 ns
5 V/DIV, 2 µs/DIV
ek
IC1801 q; (BTL), qa (BTR)
(Except radio mode)
rf
4 µs
21.8 µs
5 V/DIV, 2 µs/DIV
5 V/DIV, 10 µs/DIV
IC1401 ug (X2)
(Except radio mode)
T1901 9
(Except radio mode)
16 Vp-p
10.9 Vp-p
el
T1901 8
(Except radio mode)
rg
T1901 q;
(Except radio mode)
34.4 Vp-p
3.2 Vp-p
4 µs
238 ns
10 V/DIV, 2 µs/DIV
2 V/DIV, 100 ns/DIV
r;
Q1901 (Collector)
(Except radio mode)
4 µs
23.2 Vp-p
10 V/DIV, 2 µs/DIV
ra
rh
IC1601 ej (VCO0)
3.4 Vp-p
34.6 ns
2 V/DIV, 10 ns/DIV
T1901 1
(Except radio mode)
26 Vp-p
4 µs
10 V/DIV, 2 µs/DIV
rs
T1901 3
(Except radio mode)
7.4 Vp-p
4 µs
2 V/DIV, 2 µs/DIV
49
ICF-DVD57TV
• IC Block Diagrams
– DVD Board –
4
5
VOUT
5
VIN
GND
6
IC703 TK11133CSCL-G
VOUT
VIN
IC701 TK11218CMCL-G
IC702 TK11233CMCL-G
4
REG
VOLTAGE
CONTROL
REG
VOLTAGE
CONTROL
GND
NOISE
BYPASS
IC704 AK4385VT-E2
16 DZFL
15 DZFR
14 VDD
MCLK 1
13 VSS
BICK 2
AUDIO
DATA
INTERFACE
SDTI 3
LRCK 4
8X
INTERPOLATOR
∆Σ
MODULATOR
SCF
12 L+
11 L-
8X
INTERPOLATOR
∆Σ
MODULATOR
SCF
10 R+
9 R-
PDN 5
µP
INTERFACE
CSN 6
CCLK 7
CDTI 8
DE-EMPHASIS
CONTROL
CLOCK
DIVIDER
STBY
BIAS
VINTK
CTK ERR1
CTK ERR2
VINLD
PRE GND
PVCC2
VNFTK
PGND
VOLD–
VOLD+
VOTK–
VOTK+
IC705 BA5945FP-E2
28
27
26 25
24
23
22
21
20
19
18 17
16 15
STANDBY
+
–
THERMAL
SHUT
DOWN
ACTUATOR
DRIVER
+
–
DET
AMP
+
–
LOADING
DRIVER
–
+
DET
AMP
–
+
–
+
1
2
3
4 5
6
7
8 9
10
11 12
13 14
CFC ERR1
CFC ERR2
VINSL+
VINSL–
VOSL
VNFFC
VCC
PVCC1
PGND
VOSL–
VOSL+
VOFC–
VOFC+
ACTUATOR
DRIVER
VINFC
–
+
50
SLED
DRIVER
1
2
3
NOISE
BYPASS
3
GND
2
COMP
CONTROL
1
CONTROL
COMP
ICF-DVD57TV
IC707 MBM29LV160BE70TN-KE1-SR7596
A15
A14
A13
A12
A11
A10
A9
A8
A19
48 A16
1
2
3
4
5
6
7
8
9
TIMER FOR
PROGRAM/ERASE
LOW VCC
DETECTOR
47 BYTE
ERASE
VOLTAGE
GENERATOR
PROGRAM
VOLTAGE
GENERATOR
46 VSS
45 DQ15/A-1
INPUT/OUTPUT
BUFFERS
44
43
42
41
40
39
38
NC 10
WE 11
RESET 12
RY/BY
BUFFER
NC 13
NC 14
STATE CONTROL
&
COMMAND
REGISTER
DATA LATCH
A18
A17
A7
A6
A5
A4
A3
A2
A1
ADDRESS LATCH
RY/BY 15
16
17
18
19
20
21
22
23
24
Y-DECODER
Y-GATING
X-DECODER
CELL MATRIX
DQ7
DQ14
DQ6
DQ13
DQ5
DQ12
DQ4
37 VCC
36
35
34
33
32
31
30
29
CHIP ENABLE/
OUTPUT ENABLE
LOGIC
DQ11
DQ3
DQ10
DQ2
DQ9
DQ1
DQ8
DQ0
28 OE
27 VSS
26 CE
25 A0
VDDQ
3
VDD
DQ2
DQ1
5
4
DQ0
VSSQ
6
1
DQ4
DQ3
8
7
2
VDDQ
9
11 DQ6
10 DQ5
12 VSSQ
13 DQ7
14 VDD
XCS
XRAS
XCAS
XWE
19
18
17
16
15 DQML
A3
A2
A1
A0
A10
BA1
BA0
26
25
24
23
22
21
20
27 VDD
IC708 MT48LC4M16A2P-7E-Y14W
DATA BUS
ADDRESS BUS
BANK
ROWADDRESS
LATCH
&
DECODER
12
12
12
BANK
MEMORY
ARRAY
SENSE
AMP
COMMAND
DECODE
MODE
REGISTER
12
COLUMNADDRESS
COUNTER/
LATCH
8
I/O GATING,
DQM MASK LOGIC,
READ DATA LATCH,
WRITE DRIVERS
16
16
DATA
OUTPUT
REGISTER
16
COLUMN
DECODER
VSS 54
DQ15 53
VSSQ 52
DQ13 50
DQ14 51
VDDQ 49
DQ11 47
DQ12 48
VSSQ 46
DQ9 44
DQ10 45
VDDQ 43
NC 40
VSS 41
DQMH 39
CKE 37
CLK 38
DATA BUS
NC 36
29
30
31
32
33
34
35
A4
A5
A6
A7
A8
A9
A11
DATA
INPUT
REGISTER
8
ADDRESS BUS
VSS 28
16
DATA BUS
BANK
CONTROL
LOGIC
DQ8 42
2
CONTROL LOGIC
12
ADDRESS REGISTER
ADDRESS BUS
2
REFRESH
COUNTER
ROWADDRESS
MUX
51
ICF-DVD57TV
IC709 BR24L16FV-WE2
8bit
11bit
16kbit EEPROM ARRAY
SLAVE/ WORD
ADDRESS REGISTER
A0 1
A1 2
A2 3
DATA
REGISTER
STOP
11bit
START
ADDRESS
DECODER
8
Vcc
7
WP
6
SCL
5
SDA
CONTROL CIRCUIT
ACK
GND 4
HIGH–VOLTAGE
GENERATOR
POWER SUPPLY
VOLTAGE DETECTOR
– TU Board –
IC1 TA2149BN
RF GND 1
24 FM RFOUT
FM RF
23 RF VCC
FM RFIN 2
AM LOW CUT 3
MIX OUT 4
22 AM RFIN
AM
MIX
FM
OSC
FM
MIX
21 FM OSC
AM
OSC
VCC 5
AM IF IN 6
AM IF
1/1 OR
1/16
LEVEL
DET
ST
1/8
FM IF IN 7
AGC 9
AM
DET
AGC
AF BUFF
IF REQ
17 IF REQ
16 DET OUT
AF
15 MPX IN
ST/MO
FM/AM
R-OUT 11
MUTE
52
18 ST LED
SW
FM
DET
QUAD 10
L-OUT 12
19 OSC OUT
IF BUFF
FM IF
GND 8
20 AM OSC
BUFF
BUFF
VCO
DIVIDE
14 LPF1
DECODE
13 LPF2
ICF-DVD57TV
IC2
CE
DI
CL
DO
LC72137M-TLM-E
1
2
3
4
CCB
I/F
20 XOUT
19 XIN
REFERENCE
DIVIDER
B01
5
6
B03
7
I01
8
I02
9
DATA SHIFT REGISTER
LATCH
B02
18 AOUT
17 AIN
16 PD
PHASE
DETECTOR
CHARGE
PUMP
12BITS
PROGRAMMABLE
DIVIDER
15 VSS
UNLOCK
DETECTOR
POWER ON
RESET
14 VDD
13 B04
SWALLOW
COUNTER
1/16,1/17
4BITS
UNIVERSAL
COUNTER
12 FMIN
1/2
11 AMIN
IFIN 10
– MAIN Board –
IC301 BA5417
T.S.D.
+
–
+
–
STANDBY
BS
FILTER
2
3 4 5
6
7
8
9
10
11 12
13
14 15
NC
OUT2
VCC
OUT1
BS1
POWER GND
STBY
FILTER
NF1
IN1
NF2
PRE GND1
PRE GND2
IN2
1
BS2
BS
53
ICF-DVD57TV
IC302 BD3870FS-E2
IC351 BA6208
SWITCH
MOTOR
DRIVE
SWITCH
MOTOR
DRIVE
5
INPUT 1
INPUT 2
NC
GND
6
7
8
9
NC
4
OUTPUT1
3
OUTPUT 2
2
Vcc
1
NC
REG
IC501 NJM2234V (TE2)
8 GND
VIN1 1
BUFFER
SW1 2
7 VOUT
VIN2 3
6 V+
BIAS
SW2 4
54
5
VIN3
(MUTE)
ICF-DVD57TV
VDD
C1
C4
I/O 4
O/I 4
O/I 3
I/O 3
14
13
12
11
10
9
8
1
2
3
4
5
6
7
I/O 1
O/I 1
O/I 2
I/O 2
C2
C3
VSS
IC502 TC4066BFT (EL, N)
IC905 BA9743AFV-E2
S R
TIMER LATCH
R
U.V.L.O.
CT 1
TRIANGLE
OSCILLATOR
RT 2
VREF
16 VREF
VREF
ERROR AMP 1
NON1 3
INV1 4
+
–
15 SCP
VREF
REFERENCE
VOLTAGE
FB1 5
S.C.P. COMP
+
+
–
PWM COMP1
–
+
+
DT1 6
ERROR AMP 2
+
–
PWM COMP2
–
+
+
14 NON2
13 INV2
12 FB2
OUT1 7
11 DT2
GND 8
10 OUT2
9 VCC
– MONITOR Board –
IC1451
BR24C04F-WE2
8bit
9bit
4096bit EEPROM ARRAY
SLAVE/ WORD
ADDRESS REGISTER
A0 (NC) 1
A1 2
A2 3
DATA
REGISTER
STOP
9bit
START
ADDRESS
DECODER
8
VCC
7
TEST
6
SCL
5
SDA
CONTROL CIRCUIT
ACK
GND 4
HIGH–VOLTAGE
GENERATOR
POWER SUPPLY
VOLTAGE DETECTOR
55
ICF-DVD57TV
HFO
AFC DET
GND
VDD
LDET
PRGB
VSS
44
43
42
41
40
39
38
37
IIC BUS
SYNC
SEPARATOR
VCO
REGULATOR
LOGIC
LOGIC
SCP OUT
VCC1
45
HSS
NAVI SYNC-IN
46
EXT POL
HSS-IN
48 47
VDB IN
DAT
SCLK
IC1501 AN2546FH-AV
36
35
34
33
LOGIC
32 HD
L/N
31 VD
RST 49
LOGIC
V SYNC
DROP
HHKILL
COM DC 50
DAC-OUT 51
PHASE
COMP
PWM
F DET
DAC
30 PWM
29 VCC3
VERTICAL
COUNT
DAC
VCOM
28 COMMON OUT
27 R-CH AVE DET
+
–
Y-IN 52
CLAMP
SWITCH
SYNC
CUT
DELAY
SHARPNESS
–
+
GCA
26 R-OUT
25 VCC2
24 AVE
23 GND1
TRAP-OUT 53
22 G-CH AVE DET
Y DET 55
+
–
ACC DET 56
C-IN 57
ACC DET
BPF
–
+
LIMIT
21 G-OUT
ACC
AMP
INVERT
20 B-CH AVE DET
VCC1 58
R-Y, B-Y DEMODULATOR
GND3 59
KILLER
KILL DET 60
APC DET 61
APC
TINT
GCA
G-Y
GENERATOR
VXO
GENERATOR
MATRIX
18 BLAK
OSD SWITCH
17 YS
INTERNAL/
EXTERNAL
SWITCH
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
R-Y OUT
B-Y OUT
R-Y IN
B-Y IN
VCC1
VREF
R-IN 1
G-IN 1
B-IN 1
R-CH DET
G-CH DET
B-CH DET
R-IN 2
G-IN 2
B-IN 2
CLAMP
VXO3
REGULATOR
56
19 B-OUT
BRIGHT
YUV
SWITCH
VXO
–
+
CONTRAST
SCP-OUT 62
VXO1 63
VXO2 64
+
–
GAMMA
ICF-DVD57TV
IC1502
µPD6467GR-546-E1
CLK 1
DISPLAY CONTROL
DATA REGISTER
CS 2
20 VSYNC
DATA 3
18 VB
OUTPUT INSTRUCTION
DATA
DATA INPUT
SHIFT
REGISTER
17 VG
1bit x 336 word
OUTPUT CONTROLLER
PCL 4
VDD 5
CMDCT 6
19 HSYNC
BACK GROUND CONTROL
DATA REGISTER
INSTRUCTION
DECODER
VIDEO RAM
REVERSE DATA
1bit x 336 word
BLINK DATA
1bit x 336 word
COLOR DATA
CHARACTER DATA
9bit x 336 word
13 BLK2
VERTICAL
ADDRESS
COUNTER
HORIZONTAL
ADDRESS
COUNTER
VERTICAL
ADDRESS
REGISTER
HORIZONTAL
ADDRESS
REGISTER
14 VC2
11 BLK1
CHARACTER GENERATOR ROM
12 x 18bit x 512 word
DATA
SELECTOR
WRITE
ADDRESS
COUNTER
15 VBLK
12 VC1
3bit x 336word
CONTROL SIGNAL
16 VR
VERTICAL
POSITION
COUNTER
HORIZONTAL
POSITION
COUNTER
VERTICAL
SIZE
COUNTER
CHARACTER
SIZE
REGISTER
OSCOUT 7
OSCIN 8
OSCILLATOR
HORIZONTAL
SIZE
COUNTER
SYNC
GUARD
TEST 9
GND 10
57
ICF-DVD57TV
IC1801 MP1015EF-LF-Z
20 AGND
FEED BACK
CONTROL
BLOCK
19 ISFB
18 VLFB
BRIGHTNESS
CONTROL
BLOCK
ABRT 1
IL 2
17 FT
16 COMP
MODE
CONTROL
BLOCK
BOSC 3
DBRT 4
CONTROL LOGIC
&
THERMAL
SHUT DOWN
EN 5
15 REF
VREF
DRV 6
14 BATT
BATT 7
DRIVER
BLOCK
DRIVER
BLOCK
OUTL 8
13 OUTR
PGND 9
12 PGND
BTL 10
11 BTR
IC1901 BA9743AFV-E2
R
U.V.L.O.
CT 1
RT 2
TRIANGLE
OSCILLATOR
VREF
16 VREF
VREF
ERROR AMP 1
NON1 3
INV1 4
+
–
S R
TIMER LATCH
15 SCP
VREF
REFERENCE
VOLTAGE
FB1 5
S.C.P. COMP
+
+
–
DT1 6
PWM COMP1
–
+
+
PWM COMP2
–
+
+
ERROR AMP 2
+
–
14 NON2
13 INV2
12 FB2
OUT1 7
GND 8
11 DT2
10 OUT2
9 VCC
58
ICF-DVD57TV
• IC Pin Function Description
DVD BOARD IC706 CXD9849R (RF AMP, SERVO DSP, MPEG DECODER)
Pin No.
Pin Name
I/O
1
AGND
-
2
DVDA
I
AC coupled input path A
3
DVDB
I
AC coupled input path B
4
DVDC
I
AC coupled input path C
5
DVDD
I
AC coupled input path D
6
DVDRF IP
I
AC coupled DVD RF signal input from the optical pick-up block
7
DVDRF IN
I
AC coupled DVD RF signal input terminal Not used
8
MA
I
DC coupled main-beam RF signal input A
9
Description
Ground terminal
MB
I
DC coupled main-beam RF signal input B
10
MC
I
DC coupled main-beam RF signal input C
11
MD
I
DC coupled main-beam RF signal input D
12
SA
I
DC coupled sub-beam RF signal input A Not used
13
SB
I
DC coupled sub-beam RF signal input B Not used
14
SC
I
DC coupled sub-beam RF signal input C Not used
15
SD
I
DC coupled sub-beam RF signal input D Not used
16
CDFON
I
CD focusing error negative input terminal Not used
17
CDFOP
I
CD focusing error positive input terminal Not used
18
TNI
I
3 beam satellite PD signal negative input from the optical pick-up block
19
TPI
I
3 beam satellite PD signal positive input from the optical pick-up block
20, 21
MDI1, MDI2
I
Laser power monitor input from the optical pick-up block
22
LDO2
O
Laser diode drive signal output to the optical pick-up block (for DVD)
23
LDO1
O
Laser diode drive signal output to the optical pick-up block (for CD)
24
SVDD3
-
Power supply terminal (+3.3V)
25
CSO/RFOP
O
Central servo signal output or positive main beam summing output terminal Not used
26
RFLVL/RFON
O
RFRP low pass or positive main beam summing output terminal Not used
27
SGND
-
Ground terminal
28
V2REFO
O
Reference voltage (+2.8V) output terminal Not used
29
V20
O
Reference voltage (+2V) output to the optical pick-up block
30
VREFO
O
Reference voltage (+1.4V) output terminal
31
FEO
O
Focus error monitor output terminal Not used
32
TEO
O
Tracking error monitor output terminal Not used
33
TEZISLV
O
Slice level of tracking error signal output terminal Not used
34
OP_OUT
O
Output from the internal operational amplifier
35
OP_INN
I
Input to the internal operational amplifier
36
OP_INP
I
Input to the internal operational amplifier
37
DMO
O
Spindle motor control signal output to the motor driver
38
FMO
O
Sled motor control signal output to the motor driver
39
TROPENPWM
O
Disc tray motor control signal output terminal Not used
40
PWMOUT1
O
PWM output terminal Not used
41
TRO
O
Tracking coil control signal output to the coil driver
42
FOO
O
Focus coil control signal output to the coil driver
43
USB_VSS18
-
Ground terminal
44
USBP
I/O
USB communication data input/output terminal Not used
45
USBN
I/O
USB communication data input/output terminal Not used
46
USB_VDD3
-
47
FG
I
Motor hall sensor input terminal
59
ICF-DVD57TV
Pin No.
Pin Name
I/O
48
TDI
O
Serial data output terminal Not used
49
TMS
I
Disc tray open/close detection signal input from the main system controller
"L": disc tray is closed
50
Description
STBY
O
Standby signal output to the coil/motor driver
51
TDO
O
Chip select signal output terminal Not used
52
DVDD18
-
53 to 59
IOA2 to IOA8
O
Address signal output to the flash ROM
60, 61
IOA18, IOA19
O
62
DVSS
-
Ground terminal
63
APLLCAP
-
Connection terminal for an external capacitor
64
APLLVSS
-
Ground terminal
65
APLVDD3
-
66
XIOWR
O
Write enable signal output to the flash ROM
67 to 72
IOA16 to IOA11
O
73
DVDD3
-
74, 75
IOA10, IOA9
O
76
IOA20
O
77
XIOCS
O
Chip select signal output to the flash ROM
78
IOA1
O
79
XIOOE
O
Output enable signal output to the flash ROM
80
DVDD3
-
81 to 84
AD0 to AD3
I/O
85
DVSS18
-
86 to 88
AD4 to AD6
I/O
89
IOA21
O
Address signal output terminal Not used
90
ALE
O
Address latch enable signal output terminal Not used
91
AD7
I/O
92
IOA17
O
93
IOA0
O
Data/address signal input/output terminal with the flash ROM
Ground terminal
94
DVSS
-
Ground terminal
95
XUWR
O
Write enable signal output terminal Not used
96
XURD
O
Data read enable signal output terminal Not used
97
DVDD18
98 to 101 UP1_2 to UP1_5
I/O
102
EEP_CK
O
Not used
Serial data transfer clock signal output to the EEPROM
103
EEP_DA
I/O
Two-way data bus with the EEPROM
104, 105
UP3_0, UP3_1
I/O
Not used
106
RXD
I
Receive data input terminal for UART communication when data writing to flash memory
107
TXD
O
Transmit data output terminal for UART communication when data writing to flash memory
108
DVDD3
-
109
IEC
I
IEC mode enable signal input terminal Not used
110
XPRST
I
Reset signal input from the main system controller
111
IR
I
IR control signal input terminal Not used
112
XINT0
O
Interrupt request signal output terminal Not used
113
DQM0
O
Data mask signal output to the SD-RAM
114
DVD/CD
O
DVD/CD selection signal output terminal
115
RD7
I/O
116
DVSS18
-
60
Two-way data bus with the SD-RAM
Ground terminal
ICF-DVD57TV
Pin No.
Pin Name
I/O
117, 118
RD6, RD5
I/O
119
DVSS
-
120, 121
RD4, RD3
I/O
122
DVDD18
-
123 to 125
RD2 to RD0
I/O
126
RD15
I/O
Description
Ground terminal
127
DVDD3
-
128 to 133
RD14 to RD9
I/O
134
DVSS
-
135
RD8
I/O
136
LIMIT
I
Detection signal input from the limit switch
137
DQM1
O
Data mask signal output to the SD-RAM
138
XRWE
O
Write enable signal output to the SD-RAM
139
XCAS
O
Column address strobe signal output to the SD-RAM
140
XRAS
O
Row address strobe signal output to the SD-RAM
141
DVDD3
-
142
XRCS
O
Chip select signal output to the SD-RAM
143
BA0
O
Bank address signal output to the SD-RAM
144
DVSS18
-
Ground terminal
Bank address signal output to the SD-RAM
Ground terminal
145
BA1
O
146, 147
RA10, RA0
O
Address signal output to the SD-RAM
148
DVSS
-
Ground terminal
149 to 151
RA1 to RA3
O
152
DVDD18
-
153
TVREF
-
Not used
154
RCLKB
-
Not used
155
DVDD3
-
156
RCLK
O
Serial data transfer clock signal output to the SD-RAM
157
CKE
O
Clock enable signal output to the SD-RAM
158
RA11
O
159, 160
RA9, RA8
O
161
DVSS
-
Ground terminal
162
RA7
O
163
DVSS18
-
Ground terminal
164 to 166
RA6 to RA4
O
167
DVDD3
-
168
XIFBUSY
I
Busy signal input from the main system controller
169
XIFCS
O
Chip select signal output to the main system controller
Serial data output to the main system controller
170
SI
O
171, 172
RD28, RD27
I/O
173
DVDD18
-
174
RD26
I/O
175
DVSS
-
176, 177
RD25, RD24
I/O
178
SO
I
Serial data input from the main system controller
Serial data transfer clock signal output to the main system controller
179
SCK
O
180, 181
RD23, RD22
I/O
Two-way data bus terminal Not used
Ground terminal
61
ICF-DVD57TV
Pin No.
Pin Name
I/O
182
DVDD3
-
183 to 188
RD21 to RD16
I/O
189
DACVDDC
-
190
VREF
-
For bandgap reference voltage terminal
191
FS
-
Full scale adjustment terminal
192
YUV0/CIN
O
Video data (bit 0) output or compensation capacitor connecting terminal Not used
193
DACVSSC
-
Ground terminal
194
YUV1/Y
O
Video data (bit 1) output or luminance signal output terminal Not used
195
DACVDDB
-
196
YUV2/C
O
Video data (bit 2) output or chroma signal output terminal Not used
197
DACVSSB
-
Ground terminal
198
YUV3/CVBS
O
Video data (bit 3) output or video signal output terminal Not used
199
Description
DACVDDA
-
200
YUV4/G
O
Video signal output terminal
201
DACVSSA
-
Ground terminal
202
YUV5/B
O
CB (component video) signal output to the RGB decoder
203
YUV6/R
O
CR (component video) signal output to the RGB decoder
204
DVDD3
-
205
VSYNC
I
Vertical synchronize signal input terminal Not used
206
YUV7
O
Video data (bit 7) output terminal Not used
207
HSYNC
I
Horizontal synchronize signal input terminal Not used
208
SPMCLK
I
SPDIF digital audio data transfer clock signal input terminal Not used
209
SPDATA
I
SPDIF digital audio data input terminal Not used
210
SPLRCK
I
SPDIF digital audio L/R sampling clock signal input terminal Not used
211
SPBCK
I
SPDIF digital audio bit clock signal input terminal Not used
212
DVDD3
-
213
ALRCK
O
L/R sampling clock signal output to the D/A converter
214
ABCK
O
Bit clock signal output to the D/A converter
215
ACLK
O
Serial data transfer clock signal output to the D/A converter
216
DVSS18
-
Ground terminal
217
ASDATA0
O
Serial data output to the D/A converter
218, 219
ASDATA1,
ASDATA2
O
Serial data output terminal Not used
220
AMUTE
O
Audio muting on/off control signal output to the main system controller
221
DVDD18
-
222
62
ARST
O
Reset signal output to the D/A converter
223
DVSS
-
Ground terminal
224
MC_DATA
I
Serial data input terminal Not used
225
SPDIF
O
SPDIF digital audio signal output terminal
226
RFGND18
-
Ground terminal
227
RFVDD18
-
228
XTALO
O
System clock output terminal (27 MHz)
229
XTALI
I
System clock input terminal (27 MHz)
230
JITFO
O
Output terminal of the RF jitter meter
231
JITFN
I
Input terminal of the RF jitter meter
232
PLLVSS
-
Ground terminal
233
IDACEXLP
O
For data PLL D/A converter low-pass filter terminal
234
PLLVDD3
-
ICF-DVD57TV
Pin No.
Pin Name
I/O
235
LPFON
O
Data PLL loop filter output terminal
236
LPFIP
I
Data PLL loop filter input terminal
Description
237
LPFIN
I
Data PLL loop filter input terminal
238
LPFOP
O
Data PLL loop filter output terminal
239
ADCVDD3
-
240
S_VCM
-
Not used
241
ADCVSS
-
Ground terminal
242
S_VREFP
-
For reference voltage terminal
243
S_VREFN
-
For reference voltage terminal
244
RFVDD3
-
245
RFRPDC]
O
RF ripple detect output terminal
246
RFRPAC
I
RF ripple detect input terminal
247
HRFZC
I
High frequency RF ripple zero crossing terminal
248
CRTPLP
O
Defect level filter capacitor connecting terminal
249
RFGND
-
Ground terminal
250
CEQP
-
Not used
251
CEQN
-
Not used
252
OSP
O
RF offset cancellation capacitor connecting terminal
253
OSN
O
RF offset cancellation capacitor connecting terminal
254
RFGC
O
RF AGC loop capacitor connecting for DVD-ROM
255
IREF
I
Reference current input terminal Not used
256
AVDD3
-
63
ICF-DVD57TV
MAIN BOARD IC401 µPD789478GC-SR7596A (MAIN SYSTEM CONTROLLER)
Pin No.
Pin Name
I/O
Description
1, 2
NC
-
Not used
3 to 5
VLC2 to VLC0
-
Terminal for doubler circuit capacitor connection to develop liquid crystal display drive voltage
6 to 9
COM0 to COM3
O
Common drive signal output to the liquid crystal display
10 to 25
SEG0 to SEG15
O
Segment drive signal output to the liquid crystal display
26 to 28
NC
-
Not used
29
µ-COM R DATA
I
Serial data input from the sub system controller
30
OPEN/CLOSE LED
O
LED drive signal output of the OPEN/CLOSE indicator "H": LED on
31
AUX LED
O
LED drive signal output of the AUX indicator "H": LED on
32
TV LED
O
LED drive signal output of the TV indicator "H": LED on
33
µ-COM S DATA
O
Serial data output to the sub system controller
34
µ-COM CLOCK
O
Serial data transfer clock signal output to the sub system controller
35
TUNER LED
O
LED drive signal output of the RADIO ON/BAND indicator "H": LED on
36
XRESET
O
System reset signal output to the sub system controller
37
µ-COM LATCH
O
Latch signal output to the sub system controller
38
AVDD
-
Power supply terminal (+3.3V) (for A/D converter)
39
DVD OPEN
I
Disc tray open detect switch input terminal "H": disc tray is opend
40, 41
ENCODE+,
ENCODE-
I
Jog dial pulse input from the rotary encoder
42
DVD CLOSE
I
Disc tray close detect switch input terminal "L": disc tray is closed
43 to 46
KEY3 to KEY0
I
Front panel key input terminal (A/D input)
47
AVSS
-
Ground terminal (for A/D converter)
48
RC
I
SIRCS signal input from the remote control receiver
49
AC IN
I
Power failure detection signal input terminal
50
DVDXIFBUSY
O
Busy signal output to the servo DSP
51
LOADING A
O
Disc tray open/close motor drive signal (close direction) output terminal
52
BUZZER
I
Beep sound drive signal output terminal
53
DVD SI0
I
Serial data input from the servo DSP
54
DVD SO0
O
Serial data output to the servo DSP
55
DVD SCK
I
Serial data transfer clock signal input from the servo DSP
56
DVD XIFCS
I
Chip select signal input from the servo DSP
57
DVD AMUT IN
I
Audio muting on/off control signal input from the servo DSP
58
DVD RST
O
Reset signal output to the servo DSP
64
59
DVD LED
O
LED drive signal output of the DVD indicator "H": LED on
60
LOADING B
O
Disc tray open/close motor drive signal (open direction) output terminal
61
TRAY DET
O
Disc tray open/close detection signal output to the servo DSP "L": disc tray is closed
62
MONITOR ON
O
Power on/off control signal output for the monitor section "H": power on
63
RADIO MUTE
O
Radio muting on/off control signal output to the FM/AM PLL "L": muting on
64
RADIO CE
O
PLL chip enable signal output to the FM/AM PLL
65
RADIO DATA
O
PLL serial data output to the FM/AM PLL
66
RADIO CLK
O
PLL serial data transfer clock signal output to the FM/AM PLL
67
VOL CLK
O
Serial data transfer clock signal output to the electrical volume
68
VOL DAT
O
Serial data output to the electrical volume
69
IC0
-
Not used
70
XT1
I
Sub system clock input terminal (32.768 kHz)
71
XT2
O
Sub system clock output terminal (32.768 kHz)
ICF-DVD57TV
Pin No.
Pin Name
I/O
72
VDD0
-
73
VSS0
-
Ground terminal
74
X1
I
Main system clock input terminal (4.19 MHz)
75
X2
O
Main system clock output terminal (4.19 MHz)
76
XRESET
I
System reset signal input from the reset signal generator "L": reset
For several hundreds msec. after the power supply rises, "L" is input, then it changes to "H"
77
RADIO ON
O
Power on/off control signal output for the radio section "L": power on
78
A MUTE
O
Audio muting on/off control signal output terminal "L": muting on
79
STBY
O
Power amplifier on/off control signal output terminal
"L": power amplifier on, "H": standby mode
80
TIMER LED
O
LED drive signal output of the TIMER indicator "L": LED on
Description
65
ICF-DVD57TV
MONITOR BOARD IC1401 µPD789477GC-SR7596B (SUB SYSTEM CONTROLLER)
Pin No.
Pin Name
I/O
Description
1, 2
NC
-
Not used
3 to 5
VLC2 to VLC0
-
Not used
6 to 9
COM0 to COM3
O
Not used
10 to 25
SEG0 to SEG15
O
Not used
26
Monitor test mode setting terminal "H": test mode on
TEST_MODE
I
27 to 29
NC
-
Not used
30
T-AGC
O
TV AGC on/off control signal output to the TV tuner unit
31
T-MUTE
O
TV muting on/off control signal output to the TV tuner unit "H": muting on
32
T-SDATA
O
Serial data output to the TV tuner unit
33
T-SCL
O
Serial data transfer clock signal output to the TV tuner unit
34
TV/AUX_MUTE
O
TV/AUX audio muting on/off control signal output terminal "H": muting on
35
XRESET
O
Reset signal output to the LCD controller
36
NC
I
Not used
37
TFT OPEN
I
Monitor open/close detection signal input terminal
"L": monitor is opened, "H": monitor is closed
38
AVDD
-
Power supply terminal (+3.3V) (for A/D converter)
39, 40
AN17, AN16
I
Not used
41
SCP-DET
I
Over current detection signal input from the power control
42 to 45
NC
I
Not used
46
T-AFT
I
TV AFT detection signal input from the TV tuner unit (A/D input)
47
AVSS
-
Ground terminal (for A/D converter)
48
NC
-
Not used
49
EEPROM-SDA
I/O
Two-way data bus with the EEPROM
50
EEPROM-SCL
O
Serial data transfer clock signal output to the EEPROM
51
µCOM-LATCH
I
Latch signal input from the main system controller
52
VSYNC
I
Vertical sync signal input from the RGB decoder
53
OSD-CS
O
Chip select signal output to the OSD driver
54
OSD-DATA
O
Serial data output to the OSD driver
55
OSD-CLK
O
Serial data transfer clock signal output to the OSD driver
56
µCOM-R DATA
I
Serial data input from the main system controller
57
µCOM-S DATA
O
Serial data output to the main system controller
58
µCOM-CLK
I
Serial data transfer clock signal input from the main system controller
59
8V_SW
-
8V power on/off control signal output terminal "H": power on
60
TFT-ON
O
Power on/off control signal output for back light unit "H": power on
61
ZOOM
O
Screen size selection signal output to the LCD controller "H": zoom screen
62
JUST
O
Screen size selection signal output to the LCD controller "H": wide screen
63, 64
SIDE1, SIDE2
O
Screen size selection signal output to the LCD controller
65
HSYNCLOCK
I
Horizontal sync detection signal input from the RGB decoder
66
SDA
O
Serial data output to the RGB decoder
67
SCK
O
Serial data transfer clock signal output to the RGB decoder
68
NC
I
Not used
69
66
IC
I
Connected to the ground
70
XT1
I
System clock input terminal Not used
71
XT2
O
System clock output terminal Not used
72
VDD
-
73
VSS
-
Ground terminal
ICF-DVD57TV
Pin No.
Pin Name
I/O
74
X1
I
System clock input terminal (4.19 MHz)
Description
75
X2
O
System clock output terminal (4.19 MHz)
76
XRESET
I
System reset signal input from the main system controller
77
TV/AUX
O
TV/AUX selection signal output terminal "L": TV, "H": AUX
78
T-MODE
O
Audio mode selection signal output to the TV tuner unit
79
T-FMONO
O
Audio mode selection signal output to the TV tuner unit
80
DVD ON
O
Video input selection signal output terminal "L": TV or AUX, "H": DVD
67
ICF-DVD57TV
MONITOR BOARD IC1502 µPD6467GR-546-E1 (OSD DRIVER)
Pin No.
Pin Name
I/O
Description
1
SCLK
I
Serial data transfer clock signal input from the sub system controller
2
CSN
I
Chip select signal input from the sub system controller
3
DATA
I
Serial data input from the sub system controller
4
PCL
I
Clear signal input after the power supply rises
5
VDD
-
6
CMDCT
I
Command LSB/MSB first input selection signal input terminal
"L": LSB first, "H": MSB first Fixed at "H" in this set
7
OSC OUT
O
Output terminal to the clock generator circuit
8
OSC IN
I
Input terminal from the clock generator circuit
9
TEST
I
Test mode setting terminal "H": test mode, normally fixed at "L"
10
GND
-
Ground terminal
11
BLK1
O
Blanking signal output terminal Not used
12
VC1
O
Character signal output terminal Not used
13
BLK2
O
Blanking signal output terminal Not used
14
VC2
O
Character signal output terminal Not used
15
BLK
O
Blanking signal output to the RGB decoder
16 to 18
VR, VG, VB
O
Character signal output to the RGB decoder
19
VSYNCN
I
20
HSYNCN
I
Horizontal sync signal input from the RGB decoder
68
ICF-DVD57TV
MONITOR BOARD IC1601 MN5814 (LCD CONTROLLER)
Pin No.
Pin Name
I/O
Description
1
SYNCIN
I
Composite sync signal input terminal Not used
2
HSYNCIN
I
Horizontal sync signal input from the RGB decoder
3, 4
SIDE2, SIDE1
I
Screen size selection signal input from the sub system controller
5
VDBIN
I
6
HOUT
O
Horizontal sync signal output terminal Not used
7
VOUT
O
Vertical sync signal output terminal Not used
8
BLACK
O
Black signal output to the RGB decoder
9 to 11
VPOS3 to VPOS1
I
Vertical display position selection signal input terminal
12
ZOOM
I
Screen size selection signal input from the sub system controller "H": zoom screen
13
U/D
I
Above and below scan direction selection signal input terminal Not used
14
POL
O
Polarity inversion signal of reflection and opposite output to the RGB decoder
15
INTEXT
I
Composite/separate sync selection signal input terminal
16
CPV
O
Gate driver clock signal output to the liquid crystal display module
17 to 19
OEV3 to OEV1
O
Gate driver output enable pulse signal output to the liquid crystal display module
20
STV1
O
Gate driver start pulse signal output to the liquid crystal display module
21
OEH
O
Source driver output enable pulse signal output to the liquid crystal display module
22
ZOOMC
O
Screen size selection signal output terminal Not used
23, 24
STH1, STH2
O
Source driver start pulse signal output to the liquid crystal display module
25
CPH3
O
Source driver clock signal output to the liquid crystal display module
26
STV2
O
Gate driver start pulse signal output to the liquid crystal display module
27
CPH2
O
28
R/L
I
Left and right scan direction selection signal input terminal Not used
29
CPH1
O
30
HDOT2
I
Mode selection signal input for number of display pixel
31
JUST
I
Screen size selection signal input from the sub system controller "H": wide screen
32
POSSET
I
Horizontal display position and vertical display position offset selection signal input terminal
33
PD
O
Phase comparation output terminal
34
QVDZMSEL
I
Screen size selection signal input terminal
35
VDD (A)
-
36
VCO1
I
VCO signal and system clock signal input terminal
37
VCO0
O
System clock signal output terminal
38
VSS (A)
-
Ground terminal
39
RESET
I
System reset signal input from the sub system controller
40
HDOT1
I
Mode selection signal input for number of display pixel
41
UONS
I
Screen size selection signal input terminal
I
Horizontal display position selection signal input terminal
42 to 45 HPOS4 to HPOS1
46
N/P
I
NTSC/PAL selection signal input terminal "L": NTSC, "H": PAL Fixed at "L" in this set
47
VDD (D)
-
48
VSS (D)
-
Ground terminal
69
ICF-DVD57TV
SECTION 7
EXPLODED VIEWS
NOTE:
• -XX and -X mean standardized parts, so they
may have some difference from the original
one.
• Color Indication of Appearance Parts
Example:
KNOB, BALANCE (WHITE) . . . (RED)
↑
↑
Parts Color Cabinet's Color
7-1.
• Items marked “*” are not stocked since they
are seldom required for routine service. Some
delay should be anticipated when ordering
these items.
• The mechanical parts with no reference
number in the exploded views are not supplied.
• Accessories are given in the last of the
electrical parts list.
The components identified by mark
0 or dotted line with mark 0 are
critical for safety.
Replace only with part number
specified.
CABINET (UPPER) SECTION
4
5
2
6
5
3
4
2
5
2
2
cabinet (lower) section-1
1
cabinet (front) section
Ref. No.
1
2
3
4
70
Part No.
Description
A-1110-050-A
3-252-827-01
2-586-577-01
2-586-584-01
LID ASSY, TRAY
SCREW (B2.6), (+) BV TAPPING
CABINET (UPPER)
DUCT
Remark
Ref. No.
Part No.
Description
5
3-254-145-01 SCREW (B3), (+) BV TAPPING
6
3-254-143-01 SCREW (B3), (+) BV TAPPING
Remark
ICF-DVD57TV
7-2.
CABINET (FRONT) SECTION
59
59
LCD board
57
55
60
58
53
61
D604
56
LCD601
59
62
54
64
65
52
59
63
51
Ref. No.
51
52
53
54
Part No.
Description
X-2055-910-1
2-586-593-01
2-586-599-01
2-586-597-01
Remark
Ref. No.
Part No.
Description
60
1-830-500-11 CABLE, FLEXIBLE FLAT (16 CORE)
55
CABINET (FRONT) SUB ASSY
KNOB (TIMER)
WINDOW (IR)
BUTTON (L) (CLOCK, MODE/SCREEN SIZE,
TV MENU, ENTER, SOUND, – VOLUME +)
A-1110-042-A LCD BOARD, COMPLETE
61
62
63
64
1-830-499-11
1-830-498-11
A-1110-046-A
2-586-600-01
56
57
58
59
2-586-620-01
2-586-596-01
2-586-601-01
3-254-081-01
65
CASE (LCD), SHIELD
HOLDER (LCD)
SLIDER (TIMER)
SCREW
Remark
CABLE, FLEXIBLE FLAT (12 CORE)
KEY BOARD, COMPLETE
BUTTON (FUNCTION)
(Z, AUX, TV, DVD, RADIO ON, OFF)
2-586-598-01 BUTTON (R) (m, M, ., >, u, x)
D604
8-719-053-59 LED SLR-342DU (TIMER)
LCD601 1-805-844-11 DISPLAY PANEL, LIQUID CRYSTAL
71
ICF-DVD57TV
7-3.
CABINET (LOWER) SECTION-1
106
106
109
110
108
DVD board
not supplied
106
106
not supplied
104
104
114
106
MAIN board
107
105
F902
106
F901
104
TRANS board
111
103
104
113
SP101
112
104
cabinet (lower)
section-2
103
mechanism deck section
SP201
102
monitor section
101
Ref. No.
Part No.
Description
Ref. No.
Part No.
Description
101
102
* 103
104
105
2-586-603-01
3-245-709-51
3-264-193-01
3-254-143-01
A-1110-007-A
COVER (SHAFT)
SCREW
BRACKET (SP) F
SCREW (B3), (+) BV TAPPING
TRANS BOARD, COMPLETE
0 111
112
113
114
0 F901
1-828-104-11
A-1070-124-A
1-830-502-11
3-253-143-01
1-533-450-12
POWER SUPPLY CORD
TU BOARD, COMPLETE
SCREW (B2.6), (+) P TAPPING
FUSE, GLASS TUBE (DIA. 5) (2.5A/125V)
106
107
108
109
110
3-252-827-01
A-1110-033-A
1-830-501-11
1-830-497-11
A-1110-038-A
SCREW (B2.6), (+) BV TAPPING
MAIN BOARD, COMPLETE
DVD BOARD, COMPLETE
0 F902
SP101
SP201
1-533-450-12 FUSE, GLASS TUBE (DIA. 5) (2.5A/125V)
1-826-139-11 SPEAKER (7.7cm)
1-826-139-11 SPEAKER (7.7cm)
72
Remark
Remark
ICF-DVD57TV
7-4.
CABINET (LOWER) SECTION-2
165
168
169
167
170
166
165
#2
171
172
164
163
173
161
162
160
155
161
153
158
156
157
156
156
159
not supplied
154
#1
#1
152
151
Ref. No.
Part No.
Description
151
152
153
154
155
2-586-586-01
X-2055-909-1
2-586-588-01
A-1110-012-A
2-586-628-01
SLIDER (CABINET LOWER)
CABINET (LOWER) SUB ASSY
PLATE (BOTTOM)
DETECTION BOARD, COMPLETE
PLATE (CABINET LOWER B)
156
157
158
159
160
3-254-143-01
2-586-625-01
2-586-624-01
2-586-627-01
3-245-709-51
SCREW (B3), (+) BV TAPPING
SHAFT (B)
SHAFT (A)
PLATE (CABINET LOWER A)
SCREW
161
162
163
2-591-273-01 CUSHION
2-586-579-01 BUTTON (RELEASE)
2-586-611-01 SPRING (RELEASE)
Remark
Ref. No.
Part No.
Description
164
165
2-586-581-01 HOLDER (RELEASE)
3-252-827-01 SCREW (B2.6), (+) BV TAPPING
166
167
168
169
170
2-586-609-01
2-586-580-01
2-586-610-01
2-586-582-01
2-586-612-01
SHAFT (RELEASE)
HOLDER (LOCK)
SHAFT (LOCK)
HOOK (RELEASE LEFT)
SPRING (LOCK)
171
172
173
#1
#2
2-586-583-01
2-586-613-01
2-586-585-01
7-684-025-04
7-624-102-04
HOOK (RELEASE RIGHT)
SPRING (PUSH)
CAP (DETECT)
N 5, TYPE2
STOP RING 1.5, TYPE-E
Remark
73
ICF-DVD57TV
7-5.
MONITOR SECTION
214
208
210
#3
209
206
202
211
202
202
205
213
212
216
202
202
202
207
215
not supplied
not supplied
202
202
202
215
not supplied
202
not supplied
203
203
LCD1
203
not supplied
204
201
202
Ref. No.
Part No.
Description
201
202
203
204
205
2-586-589-01
3-254-081-01
2-591-273-01
2-591-436-01
2-586-587-01
CABINET (DISP FRONT)
SCREW
CUSHION
PANEL (DISP)
SLIDER (DISP)
206
207
208
209
210
2-586-590-01
A-1110-017-A
2-597-435-01
2-586-617-01
2-591-271-01
CABINET (DISP REAR)
MONITOR BOARD, COMPLETE
WASHER
SPRING, CONICAL
DISC (CONCAVE)
74
Remark
Ref. No.
211
212
213
214
215
216
LCD1
* #3
Part No.
Description
2-591-272-01
2-586-630-01
2-586-602-01
X-2055-063-1
3-245-709-51
DISC (CONVEX)
PLATE (SHAFT)
HOLDER (SHAFT)
SHAFT ASSY
SCREW
2-587-092-01 PLATE (MONITOR)
1-805-652-12 DISPLAY PANEL, LIQUID CRYSTAL
7-684-000-27 NUT, HEXAGON (M8) TYPE2
Remark
ICF-DVD57TV
7-6.
MECHANICAL DECK SECTION
401
(including disc tray open/clowse motor (M301),
MS-203 board)
not supplied
402
not supplied
not supplied
not supplied
(disc tray open/close
motor (M301))
not supplied
(MS-203 board)
403
404
406
405
(including sled motor,
spindle motor)
404
404
405
405
not supplied
(sled motor)
404
not supplied
(spindle motor)
405
407
408
Ref. No.
401
402
403
404
405
Part No.
Description
Remark
A-6071-669-A LOADING ASSY (M) (Including disc tray open/
close motor (M301), MS-203 board)
3-088-371-01 BELT
3-088-372-01 INSULATOR
3-087-599-01 INSULATOR SCREW
Ref. No.
Part No.
0 406
8-820-264-03 OPTICAL PICK-UP KHM-310BAA/C2RP
(Including sled motor, spindle motor)
2-586-604-01 HOLDER (FFC)
407
408
Description
Remark
75
ICF-DVD57TV
DETECTION
SECTION 8
ELECTRICAL PARTS LIST
DVD
NOTE:
• Due to standardization, replacements in the
parts list may be different from the parts
specified in the diagrams or the components
used on the set.
• -XX and -X mean standardized parts, so they
may have some difference from the original
one.
• RESISTORS
All resistors are in ohms.
METAL: Metal-film resistor.
METAL OXIDE: Metal oxide-film resistor.
F: nonflammable
Ref. No.
Part No.
• Items marked “*” are not stocked since they
are seldom required for routine service.
Some delay should be anticipated when
ordering these items.
• SEMICONDUCTORS
In each case, u: µ, for example:
uA... : µA...
uPA... : µPA...
uPB... : µPB...
uPC... : µPC...
uPD... : µPD...
• CAPACITORS
uF: µF
• COILS
uH: µH
Description
Remark
A-1110-012-A DETECTION BOARD, COMPLETE
**************************
< SWITCH >
S401
1-571-936-11 SWITCH, LEAF (DISPLAY RELEASE)
************************************************************
A-1110-038-A DVD BOARD, COMPLETE
********************
< CAPACITOR >
C701
C702
C703
C704
C705
1-126-205-11
1-128-390-11
1-126-205-11
1-162-970-11
1-115-467-11
ELECT CHIP
ELECT CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
47uF
220uF
47uF
0.01uF
0.22uF
20%
20%
20%
10%
10%
6.3V
6.3V
6.3V
25V
10V
C706
C707
C708
C709
C710
1-115-467-11
1-126-205-11
1-126-205-11
1-126-205-11
1-115-467-11
CERAMIC CHIP
ELECT CHIP
ELECT CHIP
ELECT CHIP
CERAMIC CHIP
0.22uF
47uF
47uF
47uF
0.22uF
10%
20%
20%
20%
10%
10V
6.3V
6.3V
6.3V
10V
C711
C712
C714
C715
C716
1-115-467-11
1-162-970-11
1-126-205-11
1-115-467-11
1-115-467-11
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
0.22uF
0.01uF
47uF
0.22uF
0.22uF
10%
10%
20%
10%
10%
10V
25V
6.3V
10V
10V
C717
C719
C720
C721
C722
1-162-970-11
1-162-964-11
1-162-964-11
1-162-964-11
1-162-964-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.001uF
0.001uF
0.001uF
0.001uF
10%
10%
10%
10%
10%
25V
50V
50V
50V
50V
C723
C724
C726
C727
C728
1-124-779-00
1-115-467-11
1-162-927-11
1-162-923-11
1-162-919-11
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10uF
0.22uF
100PF
47PF
22PF
20%
10%
5%
5%
5%
16V
10V
50V
50V
50V
C729
C730
C731
C732
C733
1-162-959-11
1-162-959-11
1-162-959-11
1-162-927-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
330PF
330PF
330PF
100PF
100PF
5%
5%
5%
5%
5%
50V
50V
50V
50V
50V
C734
C735
C736
1-162-927-11 CERAMIC CHIP
1-128-390-11 ELECT CHIP
100PF
220uF
0.1uF
5%
20%
10%
50V
6.3V
16V
76
Ref. No.
Part No.
The components identified by mark
0 or dotted line with mark 0 are
critical for safety.
Replace only with part number
specified.
When indicating parts by reference
number, please include the board.
Description
Remark
C737
C738
1-128-390-11 ELECT CHIP
0.1uF
220uF
10%
20%
16V
6.3V
C739
C740
C741
C742
C743
1-107-826-11
1-107-826-11
1-164-217-11
1-164-217-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
150PF
150PF
0.1uF
10%
10%
5%
5%
10%
16V
16V
50V
50V
16V
C744
C745
C746
C747
C748
1-162-964-11
1-162-964-11
1-126-205-11
1-126-205-11
1-126-206-11
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
ELECT CHIP
ELECT CHIP
0.001uF
0.001uF
47uF
47uF
100uF
10%
10%
20%
20%
20%
50V
50V
6.3V
6.3V
6.3V
C749
C750
C751
C755
C756
1-107-826-11
1-162-966-11
1-162-966-11
1-107-826-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.0022uF
0.0022uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
16V
50V
50V
16V
16V
C757
C758
C759
C760
C761
1-107-826-11
1-107-826-11
1-164-245-11
1-107-826-11
1-162-959-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.015uF
0.1uF
330PF
10%
10%
10%
10%
5%
16V
16V
25V
16V
50V
C762
C763
C764
C765
C766
1-162-959-11
1-107-826-11
1-107-826-11
1-162-965-11
1-126-205-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
330PF
0.1uF
0.1uF
0.0015uF
47uF
5%
10%
10%
10%
20%
50V
16V
16V
50V
6.3V
C767
C768
C770
C771
C772
1-126-205-11
1-126-205-11
1-125-837-11
1-125-837-11
1-125-837-11
ELECT CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
47uF
47uF
1uF
1uF
1uF
20%
20%
10%
10%
10%
6.3V
6.3V
6.3V
6.3V
6.3V
C773
C774
C775
C776
C777
1-125-837-11
1-125-837-11
1-126-205-11
1-107-826-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
1uF
47uF
0.1uF
0.01uF
10%
10%
20%
10%
10%
6.3V
6.3V
6.3V
16V
25V
C778
C779
C780
C781
C782
1-124-778-00
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
22uF
0.1uF
0.1uF
0.1uF
0.1uF
20%
10%
10%
10%
10%
6.3V
16V
16V
16V
16V
C783
0.1uF
10%
16V
ICF-DVD57TV
DVD
Ref. No.
Part No.
Description
C784
C785
C787
C788
1-107-826-11
1-107-826-11
1-162-964-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.001uF
0.1uF
10%
10%
10%
10%
16V
16V
50V
16V
Remark
Ref. No.
Part No.
Description
Remark
C789
C790
C791
C792
C793
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
16V
16V
16V
16V
16V
C794
C795
C796
C797
C798
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
16V
16V
16V
16V
16V
C799
C800
C801
C802
C803
1-107-826-11
1-107-826-11
1-162-923-11
1-107-826-11
1-162-917-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
47PF
0.1uF
15PF
10%
10%
5%
10%
5%
16V
16V
50V
16V
50V
C804
C805
C807
C808
C809
1-162-916-11
1-164-392-11
1-126-205-11
1-117-863-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
12PF
390PF
47uF
0.47uF
0.1uF
5%
5%
20%
10%
10%
50V
50V
6.3V
6.3V
16V
FB702
FB703
FB704
FB705
FB706
1-216-295-00
1-469-324-21
1-216-295-00
1-469-324-21
1-216-295-00
SHORT CHIP
0
FERRITE, EMI (SMD) (2012)
SHORT CHIP
0
SHORT CHIP
0
C810
C811
C812
C813
C814
1-165-176-11
1-165-176-11
1-107-826-11
1-125-837-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.047uF
0.047uF
0.1uF
1uF
0.1uF
10%
10%
10%
10%
10%
16V
16V
16V
6.3V
16V
FB707
FB708
FB709
FB710
FB711
FB712
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
C815
C816
C817
C818
C819
1-107-826-11
1-107-826-11
1-165-176-11
1-107-826-11
1-164-160-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.047uF
0.1uF
20PF
10%
10%
10%
10%
5%
16V
16V
16V
16V
50V
C820
C821
C822
C823
C824
1-162-964-11
1-107-826-11
1-164-677-11
1-107-826-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
0.1uF
0.033uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
50V
16V
16V
16V
16V
C825
C826
C827
C829
C830
1-107-826-11
1-107-826-11
1-107-826-11
1-162-970-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.01uF
0.01uF
10%
10%
10%
10%
10%
16V
16V
16V
25V
25V
C831
C832
C833
C834
C835
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
16V
16V
16V
16V
16V
C837
C838
C839
C840
C841
1-124-779-00
1-107-826-11
1-107-826-11
1-107-826-11
1-162-964-11
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10uF
0.1uF
0.1uF
0.1uF
0.001uF
20%
10%
10%
10%
10%
16V
16V
16V
16V
50V
C843
C847
C849
C852
1-162-927-11
1-162-927-11
1-162-927-11
1-162-915-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
100PF
100PF
10PF
5%
5%
5%
0.5PF
50V
50V
50V
50V
C855
0.001uF
10%
50V
C856
C857
C858
C859
C860
1-162-964-11
1-162-964-11
1-162-964-11
1-162-964-11
1-162-964-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
0.001uF
0.001uF
0.001uF
0.001uF
10%
10%
10%
10%
10%
50V
50V
50V
50V
50V
C861
C869
C870
C871
1-162-964-11
1-162-964-11
1-162-964-11
1-125-837-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
0.001uF
0.001uF
1uF
10%
10%
10%
10%
50V
50V
50V
6.3V
< CONNECTOR >
CN701
CN702
* CN703
CN704
CN705
1-784-381-21
1-750-357-11
1-580-789-22
1-784-860-21
1-580-056-21
CONNECTOR, FFC/FPC 24P
CONNECTOR, FFC/FPC (ZIF) 24P
PIN, CONNECTOR (SMD) 6P
CONNECTOR, FFC (LIF (NON-ZIF)) 8P
PIN, CONNECTOR (SMD) 3P
< FERRITE BEAD/JUMPER RESISTOR >
0
0
0
0
0
0
< FERRITE BEAD/JUMPER RESISTOR >
FL701
FL702
FL703
FL705
FL706
1-469-324-21
1-216-296-11
1-216-295-00
1-216-295-00
1-216-295-00
SHORT CHIP
0
SHORT CHIP
0
SHORT CHIP
0
SHORT CHIP
0
FL707
FL708
FL709
FL710
FL711
1-216-296-11
1-216-295-00
1-216-295-00
1-216-295-00
1-216-295-00
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
FL712
FL713
1-216-295-00 SHORT CHIP
1-216-295-00 SHORT CHIP
0
0
< IC >
IC701
IC702
IC703
IC704
IC705
6-707-119-01
6-704-470-01
6-702-302-01
6-705-515-01
6-703-242-01
IC
IC
IC
IC
IC
TK11218CMCL-G
TK11233CMCL-G
TK11133CSCL-G
AK4385VT-E2
BA5954FP-E2
IC706
IC707
IC708
IC709
6-707-535-01
6-805-453-02
6-706-420-01
6-703-998-01
IC
IC
IC
IC
CXD9849R
MBM29LV160BE70TN-KE1-SR7596
MT48LC4M16A2P-7E-Y14W
BR24L16FV-WE2
< COIL/ JUMPER RESISTOR >
L701
1-412-982-21 INDUCTOR
1.8uH
77
ICF-DVD57TV
DVD
Ref. No.
Part No.
Description
L702
L703
L704
L705
1-412-982-21
1-412-982-21
1-469-527-11
1-412-951-11
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
L706
L707
1-412-951-11 INDUCTOR
1-216-864-11 SHORT CHIP
Remark
1.8uH
1.8uH
47uH
10uH
10uH
0
< TRANSISTOR >
Q701
Q702
Q703
6-550-653-01 TRANSISTOR
6-550-008-01 FET
QST8TR
UM6K1N-TN
UN2212
< RESISTOR/FERRITE BEAD >
Ref. No.
Part No.
Description
Remark
R758
R759
R760
R761
R762
1-216-837-11
1-216-833-11
1-216-833-11
1-216-864-11
1-216-817-11
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
22K
10K
10K
0
470
5%
5%
5%
1/10W
1/10W
1/10W
5%
1/10W
R763
R764
R765
R766
R767
1-216-809-11
1-216-821-11
1-216-833-11
1-216-809-11
1-218-684-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
1K
10K
100
470
5%
5%
5%
5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/10W
R768
R769
R770
R771
R772
1-218-724-11
1-218-668-11
1-216-833-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
100
10K
10K
10K
0.5%
0.5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R773
R774
R777
R778
R779
1-216-833-11
1-216-833-11
1-216-809-11
1-469-324-21
1-500-284-11
METAL CHIP
10K
5%
METAL CHIP
10K
5%
METAL CHIP
100
5%
INDUCTOR, FERRITE BEAD
R780
R781
R782
R784
R785
1-469-324-21
1-500-284-11
1-216-809-11
1-216-857-11
1-220-397-11
METAL CHIP
100
5%
METAL CHIP
1M
5%
METAL CHIP
4.7M
5%
R786
R787
R788
R790
R791
1-216-845-11
1-216-837-11
1-216-864-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
100K
22K
0
10K
10K
5%
5%
1/10W
1/10W
5%
5%
1/10W
1/10W
R792
R793
R794
R796
R797
1-216-821-11
1-216-821-11
1-216-295-00
1-216-864-11
1-216-864-11
METAL CHIP
METAL CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
1K
1K
0
0
0
5%
5%
1/10W
1/10W
R798
R799
R800
R801
R802
1-216-817-11
1-216-817-11
1-216-817-11
1-216-864-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
SHORT CHIP
470
470
470
0
0
5%
5%
5%
1/10W
1/10W
1/10W
R803
R804
R805
R806
R807
1-216-821-11
1-216-821-11
1-216-817-11
1-216-821-11
1-216-817-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
470
1K
470
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R808
R809
R810
R811
R812
1-216-817-11
1-216-817-11
1-216-817-11
1-216-817-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
470
470
470
470
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R701
R703
R706
R709
R710
1-216-295-00
1-216-295-00
1-216-295-00
1-216-821-11
1-216-821-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
0
0
0
1K
1K
R711
R712
R713
R714
R717
1-216-821-11
1-216-821-11
1-216-809-11
1-216-833-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
1K
1K
100
10K
0
R718
R720
R721
R722
R723
1-216-864-11
1-216-864-11
1-216-809-11
1-216-809-11
1-216-809-11
SHORT CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
0
100
100
100
5%
5%
5%
1/10W
1/10W
1/10W
R724
R725
R726
R727
R728
1-217-671-11
1-217-671-11
1-217-671-11
1-217-671-11
1-216-833-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
METAL CHIP
1
1
1
1
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R729
R731
R732
R733
R734
1-217-671-11
1-216-841-11
1-216-833-11
1-216-833-11
1-216-833-11
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1
47K
10K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R735
R736
R737
R738
R739
1-216-845-11
1-216-809-11
1-216-833-11
1-216-809-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100
10K
100
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R740
R741
R742
R743
R744
1-216-793-11
1-216-793-11
1-216-841-11
1-216-853-11
1-216-849-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7
4.7
47K
470K
220K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R745
R746
R747
R748
R750
1-216-853-11
1-216-849-11
1-216-864-11
1-216-833-11
1-216-864-11
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
SHORT CHIP
470K
220K
0
10K
0
5%
5%
1/10W
1/10W
5%
1/10W
R751
R752
R753
R754
R755
1-216-864-11
1-216-864-11
1-216-864-11
1-216-833-11
1-216-837-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
0
0
0
10K
22K
R813
R814
R815
R816
R817
1-216-817-11
1-216-817-11
1-216-821-11
1-216-817-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
470
470
1K
470
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
5%
5%
1/10W
1/10W
R818
R819
1-216-817-11 METAL CHIP
1-216-821-11 METAL CHIP
470
1K
5%
5%
1/10W
1/10W
78
5%
5%
1/10W
1/10W
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
1/10W
1/10W
1/10W
1/10W
1/10W
ICF-DVD57TV
DVD
Ref. No.
Part No.
Description
Remark
Ref. No.
Part No.
KEY
Description
LCD
Remark
R820
R821
R822
1-216-833-11 METAL CHIP
1-216-833-11 METAL CHIP
1-216-833-11 METAL CHIP
10K
10K
10K
5%
5%
5%
1/10W
1/10W
1/10W
R669
R670
R671
1-216-837-11 METAL CHIP
1-216-845-11 METAL CHIP
1-216-841-11 METAL CHIP
22K
100K
47K
5%
5%
5%
1/10W
1/10W
1/10W
R823
R824
R825
R826
R827
1-216-849-11
1-220-397-11
1-216-853-11
1-216-849-11
1-220-397-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220K
4.7M
470K
220K
4.7M
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R672
R673
R674
R675
R676
1-216-841-11
1-216-841-11
1-216-853-11
1-216-845-11
1-216-849-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
47K
470K
100K
220K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R828
R829
R830
R831
R832
1-216-853-11
1-216-841-11
1-216-845-11
1-216-833-11
1-216-805-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
470K
47K
100K
10K
47
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R677
R678
R679
R680
R681
1-216-849-11
1-216-853-11
1-216-837-11
1-216-841-11
1-216-837-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220K
470K
22K
47K
22K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R833
R834
R835
R836
R837
1-216-857-11
1-219-570-11
1-216-841-11
1-216-864-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
SHORT CHIP
1M
10M
47K
0
0
5%
5%
5%
1/10W
1/10W
1/10W
R682
R683
R684
R685
R686
1-216-845-11
1-216-841-11
1-216-841-11
1-216-841-11
1-216-853-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
47K
47K
47K
470K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R838
R839
1-216-864-11 SHORT CHIP
1-216-809-11 METAL CHIP
0
100
5%
1/10W
R687
R688
R689
R690
1-216-845-11
1-216-849-11
1-216-849-11
1-216-853-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
220K
220K
470K
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
< VIBRATOR >
X701
1-795-361-21 VIBRATOR, CRYSTAL (SMD) (27MHz)
************************************************************
A-1110-046-A KEY BOARD, COMPLETE
********************
< CONNECTOR >
CN408
1-779-546-11 CONNECTOR, FFC (LIF (NON-ZIF)) 9P
< LED >
D651
D652
D653
D654
D655
8-719-053-59
6-500-218-01
6-500-218-01
6-500-218-01
6-500-218-01
LED
LED
LED
LED
LED
SLR-342DU (OPEN/CLOSE Z)
TLFGE53T (MONITOR ON AUX)
TLFGE53T (MONITOR ON TV)
TLFGE53T (MONITOR ON DVD)
TLFGE53T (RADIO ON, BAND)
< SWITCH >
S659
S660
S661
S662
S663
1-762-196-21
1-762-196-21
1-762-196-21
1-762-196-21
1-762-196-21
SWITCH, TACT (RADIO TUNE/TIME SET –, m)
SWITCH, TACT (TV CH/PRESET +, >)
SWITCH, TACT (u)
SWITCH, TACT (x)
SWITCH, TACT (OFF)
S664
S665
S666
S667
S668
1-762-196-21
1-762-196-21
1-762-196-21
1-762-196-21
1-762-196-21
SWITCH, TACT (RADIO ON, BAND)
SWITCH, TACT (RADIO TUNE/TIME SET +, M)
SWITCH, TACT (TV CH/PRESET –, .)
SWITCH, TACT (OPEN/CLOSE Z)
SWITCH, TACT (MONITOR ON AUX)
S669
1-762-196-21 SWITCH, TACT (MONITOR ON TV)
S670
1-762-196-21 SWITCH, TACT (MONITOR ON DVD)
************************************************************
< TRANSISTOR >
Q651
Q652
Q653
Q654
Q655
8-729-029-14
8-729-029-14
8-729-029-14
8-729-029-14
8-729-029-14
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
A-1110-042-A LCD BOARD, COMPLETE
********************
DTC144EUA-T106
DTC144EUA-T106
DTC144EUA-T106
DTC144EUA-T106
DTC144EUA-T106
2-586-596-01 HOLDER (LCD)
2-586-601-01 SLIDER (TIMER)
2-586-620-01 CASE (LCD), SHIELD
< CAPACITOR >
< RESISTOR >
R610
R611
R612
R613
R614
1-216-813-11
1-216-809-11
1-216-813-11
1-216-809-11
1-216-813-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220
100
220
100
220
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R615
R616
R617
R618
R619
1-216-809-11
1-216-813-11
1-216-809-11
1-216-813-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
220
100
220
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R667
R668
1-216-837-11 METAL CHIP
1-216-841-11 METAL CHIP
22K
47K
5%
5%
1/10W
1/10W
C601
C602
C603
C604
C605
1-162-970-11
1-162-970-11
1-164-156-11
1-162-964-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
C606
0.01uF
0.01uF
0.1uF
0.001uF
0.1uF
10%
10%
10%
10%
25V
25V
25V
50V
16V
0.01uF
10%
25V
< CONNECTOR >
CN603
CN604
79
ICF-DVD57TV
LCD
Ref. No.
MAIN
Part No.
Description
Remark
Ref. No.
< LED >
D601
D602
D603
D604
6-500-218-01
6-500-218-01
6-500-218-01
8-719-053-59
LED
LED
LED
LED
Part No.
Description
Remark
A-1110-033-A MAIN BOARD, COMPLETE
*********************
TLFGE53T (LCD BACK LIGHT)
SLR-342DU (TIMER)
3-252-827-01 SCREW (B2.6), (+) BV TAPPING
3-253-143-01 SCREW (B2.6), (+) P TAPPING
< CAPACITOR >
< IC >
IC601
6-600-309-01 IC RPM7240-H9
< LIQUID CRYSTAL DISPLAY >
C101
C102
C103
C104
C105
1-127-692-11
1-127-692-11
1-164-315-11
1-162-927-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10uF
10uF
470PF
100PF
100PF
10%
10%
5%
5%
5%
16V
16V
50V
50V
50V
C107
C108
C109
C110
C111
1-162-927-11
1-162-927-11
1-126-963-11
1-125-838-11
1-126-959-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
100PF
100PF
4.7uF
2.2uF
0.47uF
5%
5%
20%
10%
20%
50V
50V
50V
6.3V
50V
C112
C114
C115
C116
C117
1-126-959-11
1-125-838-11
1-125-838-11
1-125-838-11
1-125-838-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.47uF
2.2uF
2.2uF
2.2uF
2.2uF
20%
10%
10%
10%
10%
50V
6.3V
6.3V
6.3V
6.3V
C118
C120
C121
C125
C126
1-162-966-11
1-107-826-11
1-115-467-11
1-126-963-11
1-162-964-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.0022uF
0.1uF
0.22uF
4.7uF
0.001uF
10%
10%
10%
20%
10%
50V
16V
10V
50V
50V
C127
C128
C129
C130
C131
1-126-959-11
1-162-966-11
1-162-970-11
1-126-947-11
1-126-933-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
0.47uF
0.0022uF
0.01uF
47uF
100uF
20%
10%
10%
20%
20%
50V
50V
25V
35V
16V
C132
C133
C134
C135
C136
1-126-767-11
1-162-970-11
1-126-964-11
1-107-826-11
1-126-964-11
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
1000uF
0.01uF
10uF
0.1uF
10uF
20%
10%
20%
10%
20%
16V
25V
50V
16V
50V
C137
C138
C139
C140
C141
1-126-959-11
1-162-927-11
1-162-964-11
1-162-964-11
1-107-826-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.47uF
100PF
0.001uF
0.001uF
0.1uF
20%
5%
10%
10%
10%
50V
50V
50V
50V
16V
C201
C202
C203
C204
C205
1-127-692-11
1-127-692-11
1-164-315-11
1-162-927-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10uF
10uF
470PF
100PF
100PF
10%
10%
5%
5%
5%
16V
16V
50V
50V
50V
C207
C208
C209
C210
C211
1-162-927-11
1-162-927-11
1-126-963-11
1-125-838-11
1-126-959-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
100PF
100PF
4.7uF
2.2uF
0.47uF
5%
5%
20%
10%
20%
50V
50V
50V
6.3V
50V
C212
C214
C215
C216
C217
1-126-959-11
1-125-838-11
1-125-838-11
1-125-838-11
1-125-838-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.47uF
2.2uF
2.2uF
2.2uF
2.2uF
20%
10%
10%
10%
10%
50V
6.3V
6.3V
6.3V
6.3V
C218
0.0022uF 10%
50V
LCD601 1-805-844-11 DISPLAY PANEL, LIQUID CRYSTAL
< TRANSISTOR >
Q601
DTA124EUA-T106
< RESISTOR >
R601
R602
R603
R604
R605
1-216-813-11
1-216-817-11
1-216-813-11
1-216-817-11
1-216-813-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220
470
220
470
220
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R606
R607
R608
R609
R651
1-216-817-11
1-216-813-11
1-216-833-11
1-216-809-11
1-216-837-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
470
220
10K
100
22K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R652
R653
R654
R655
R656
1-216-841-11
1-216-837-11
1-216-845-11
1-216-837-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
22K
100K
22K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R657
R658
R659
R660
R661
1-216-837-11
1-216-845-11
1-216-841-11
1-216-841-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
100K
47K
47K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R662
R663
R664
R665
R666
1-216-853-11
1-216-845-11
1-216-849-11
1-216-849-11
1-216-853-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
470K
100K
220K
220K
470K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
< ROTARY ENCODER/SWITCH >
S651
S652
S653
S654
S655
1-418-651-11 ENCODER, ROTARY
(TIMER PUSH START/STOP)
1-762-196-21 SWITCH, TACT (VOLUME +)
1-762-196-21 SWITCH, TACT (VOLUME –)
1-762-196-21 SWITCH, TACT (SOUND)
1-762-196-21 SWITCH, TACT (ENTER)
S656
1-762-196-21 SWITCH, TACT (TV MENU)
S657
1-762-196-21 SWITCH, TACT (MODE/SCREEN SIZE)
S658
1-762-196-21 SWITCH, TACT (CLOCK)
************************************************************
80
ICF-DVD57TV
MAIN
Ref. No.
Part No.
Description
C220
C221
C225
C226
1-107-826-11
1-115-467-11
1-126-963-11
1-162-964-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.1uF
0.22uF
4.7uF
0.001uF
10%
10%
20%
10%
16V
10V
50V
50V
Remark
C227
C228
C229
C230
C231
1-126-959-11
1-162-966-11
1-162-970-11
1-126-947-11
1-126-933-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
0.47uF
0.0022uF
0.01uF
47uF
100uF
20%
10%
10%
20%
20%
50V
50V
25V
35V
16V
C232
C233
C234
C235
C236
1-126-767-11
1-162-970-11
1-126-964-11
1-107-826-11
1-126-964-11
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
1000uF
0.01uF
10uF
0.1uF
10uF
20%
10%
20%
10%
20%
16V
25V
50V
16V
50V
C237
C238
C239
C240
C241
1-126-959-11
1-162-927-11
1-162-964-11
1-162-964-11
1-107-826-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.47uF
100PF
0.001uF
0.001uF
0.1uF
20%
5%
10%
10%
10%
50V
50V
50V
50V
16V
C301
C302
C303
C304
C305
1-126-947-11
1-162-970-11
1-126-964-11
1-126-947-11
1-162-970-11
ELECT
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
47uF
0.01uF
10uF
47uF
0.01uF
20%
10%
20%
20%
10%
35V
25V
50V
35V
25V
C306
C307
C308
C309
C310
1-126-947-11
1-162-927-11
1-115-467-11
1-107-826-11
1-162-927-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
47uF
100PF
0.22uF
0.1uF
100PF
20%
5%
10%
10%
5%
35V
50V
10V
16V
50V
C311
C314
C315
C316
C317
1-126-961-11
1-104-662-11
1-164-227-11
1-162-966-11
1-162-966-11
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
2.2uF
22uF
0.022uF
0.0022uF
0.0022uF
20%
20%
10%
10%
10%
50V
25V
25V
50V
50V
C318
C321
C322
C351
C353
1-126-947-11
1-126-964-11
1-162-964-11
1-164-156-11
1-126-947-11
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
47uF
10uF
0.001uF
0.1uF
47uF
20%
20%
10%
20%
35V
50V
50V
25V
35V
C354
C355
C356
C357
C362
1-107-826-11
1-107-826-11
1-162-964-11
1-126-964-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.1uF
0.1uF
0.001uF
10uF
100PF
10%
10%
10%
20%
5%
16V
16V
50V
50V
50V
C363
C364
C401
C402
C403
1-162-964-11
1-162-970-11
1-162-927-11
1-162-970-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
0.01uF
100PF
0.01uF
100PF
10%
10%
5%
10%
5%
50V
25V
50V
25V
50V
C404
C405
C406
C407
C408
1-162-927-11
1-162-927-11
1-162-927-11
1-162-927-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
100PF
100PF
100PF
100PF
5%
5%
5%
5%
5%
50V
50V
50V
50V
50V
C409
C410
C411
C412
1-162-927-11
1-162-927-11
1-162-927-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
100PF
100PF
100PF
5%
5%
5%
5%
50V
50V
50V
50V
Ref. No.
Part No.
Description
Remark
C413
100PF
5%
50V
C414
C415
C416
C417
C418
1-162-927-11
1-162-927-11
1-162-927-11
1-162-927-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
100PF
100PF
100PF
100PF
5%
5%
5%
5%
5%
50V
50V
50V
50V
50V
C419
C420
C421
C422
C423
1-162-927-11
1-162-927-11
1-162-927-11
1-162-927-11
1-135-834-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
100PF
100PF
100PF
2.2uF
5%
5%
5%
5%
50V
50V
50V
50V
6.3V
C424
C425
C426
C427
C428
1-135-834-11
1-135-834-11
1-162-970-11
1-162-970-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
2.2uF
2.2uF
0.01uF
0.01uF
0.01uF
10%
10%
10%
6.3V
6.3V
25V
25V
25V
C429
C430
C431
C432
C433
1-162-927-11
1-162-927-11
1-162-927-11
1-162-927-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
100PF
100PF
100PF
100PF
5%
5%
5%
5%
5%
50V
50V
50V
50V
50V
C435
C436
C437
C438
C439
1-162-927-11
1-162-927-11
1-162-927-11
1-126-933-11
1-135-834-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
100PF
100PF
100PF
100uF
2.2uF
5%
5%
5%
20%
50V
50V
50V
16V
6.3V
C440
C441
C442
C443
C444
1-162-970-11
1-162-927-11
1-162-927-11
1-162-970-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
100PF
100PF
0.01uF
0.01uF
10%
5%
5%
10%
10%
25V
50V
50V
25V
25V
C445
C446
C447
C448
C449
1-162-970-11
1-162-970-11
1-162-927-11
1-162-970-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
100PF
0.01uF
100PF
10%
10%
5%
10%
5%
25V
25V
50V
25V
50V
C450
C451
C452
C453
C455
1-162-927-11
1-162-927-11
1-162-927-11
1-162-970-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
100PF
100PF
0.01uF
100PF
5%
5%
5%
10%
5%
50V
50V
50V
25V
50V
C456
C457
C458
C459
C460
1-162-970-11
1-162-970-11
1-162-927-11
1-162-927-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
100PF
100PF
100PF
10%
10%
5%
5%
5%
25V
25V
50V
50V
50V
C461
C462
C463
C464
C465
1-162-927-11
1-162-927-11
1-162-919-11
1-162-919-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
100PF
22PF
22PF
0.01uF
5%
5%
5%
5%
10%
50V
50V
50V
50V
25V
C466
C467
C470
C474
C475
1-135-834-11
1-126-933-11
1-162-970-11
1-162-970-11
1-126-964-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
2.2uF
100uF
0.01uF
0.01uF
10uF
20%
10%
10%
20%
6.3V
16V
25V
25V
50V
C476
1-126-935-11 ELECT
470uF
20%
16V
81
ICF-DVD57TV
MAIN
Ref. No.
Part No.
Description
C477
C478
C479
C480
1-107-826-11
1-107-826-11
1-107-826-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.01uF
10%
10%
10%
10%
16V
16V
16V
25V
C481
C482
C485
C501
C502
1-162-964-11
1-126-947-11
1-162-970-11
1-126-935-11
1-125-837-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.001uF
47uF
0.01uF
470uF
1uF
10%
20%
10%
20%
10%
50V
35V
25V
16V
6.3V
C503
C504
C505
C506
C507
1-162-970-11
1-162-919-11
1-162-919-11
1-104-662-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.01uF
22PF
22PF
22uF
0.01uF
10%
5%
5%
20%
10%
25V
50V
50V
25V
25V
C508
C509
C510
C511
C512
1-125-837-11
1-162-968-11
1-162-927-11
1-162-927-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
0.0047uF
100PF
100PF
100PF
10%
10%
5%
5%
5%
6.3V
50V
50V
50V
50V
C513
C514
C515
C516
C517
1-115-156-11
1-162-970-11
1-126-935-11
1-125-837-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
1uF
0.01uF
470uF
1uF
0.01uF
10%
20%
10%
10%
10V
25V
16V
6.3V
25V
C518
C519
C520
C521
C522
1-126-935-11
1-126-947-11
1-126-933-11
1-126-935-11
1-162-970-11
ELECT
ELECT
ELECT
ELECT
CERAMIC CHIP
470uF
47uF
100uF
470uF
0.01uF
20%
20%
20%
20%
10%
16V
35V
16V
16V
25V
C523
C524
C525
C527
C528
1-126-964-11
1-126-933-11
1-162-970-11
1-126-964-11
1-126-934-11
ELECT
ELECT
CERAMIC CHIP
ELECT
ELECT
10uF
100uF
0.01uF
10uF
220uF
20%
20%
10%
20%
20%
50V
16V
25V
50V
16V
C529
C913
C914
C915
C916
1-162-970-11
1-128-548-11
1-162-970-11
1-126-937-11
1-162-970-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.01uF
4700uF
0.01uF
4700uF
0.01uF
10%
20%
10%
20%
10%
25V
25V
25V
16V
25V
C917
C918
C919
C920
C921
1-164-156-11
1-107-826-11
1-115-156-11
1-104-662-11
1-126-935-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
0.1uF
0.1uF
1uF
22uF
470uF
C922
C923
C924
C925
C927
1-162-927-11
1-164-156-11
1-107-826-11
1-162-970-11
1-128-953-31
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
100PF
0.1uF
0.1uF
0.01uF
470uF
10%
10%
20%
50V
25V
16V
25V
25V
C928
C929
C930
C931
C932
1-162-927-11
1-164-315-11
1-162-970-11
1-162-970-11
1-128-953-31
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
100PF
470PF
0.01uF
0.01uF
470uF
5%
5%
10%
10%
20%
50V
50V
25V
25V
25V
C933
C935
C937
C938
1-126-943-11
1-162-970-11
1-162-970-11
1-162-927-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
2200uF
0.01uF
0.01uF
100PF
20%
10%
10%
5%
25V
25V
25V
50V
82
Remark
10%
20%
20%
5%
25V
16V
10V
25V
16V
Ref. No.
Part No.
Description
Remark
C939
0.0022uF 10%
50V
C940
C941
C942
C943
C945
1-117-863-11
1-165-884-11
1-126-964-11
1-163-059-00
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
0.47uF
2.2uF
10uF
0.01uF
100PF
10%
10%
20%
10%
5%
6.3V
6.3V
50V
50V
50V
C946
C947
C948
C949
C950
1-128-953-11
1-107-826-11
1-162-966-11
1-162-970-11
1-128-953-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
470uF
0.1uF
0.0022uF
0.01uF
470uF
20%
10%
10%
10%
20%
25V
16V
50V
25V
25V
C951
C952
C953
C954
C955
1-126-943-11
1-126-934-11
1-126-933-11
1-126-935-11
1-126-934-11
ELECT
ELECT
ELECT
ELECT
ELECT
2200uF
220uF
100uF
470uF
220uF
20%
20%
20%
20%
20%
25V
16V
16V
16V
16V
C956
C957
C959
C960
C961
1-126-935-11
1-162-970-11
1-162-970-11
1-162-970-11
1-162-970-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
470uF
0.01uF
0.01uF
0.01uF
0.01uF
20%
10%
10%
10%
10%
16V
25V
25V
25V
25V
C962
C963
C964
C965
C966
1-162-970-11
1-107-826-11
1-162-970-11
1-162-970-11
1-165-884-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.1uF
0.01uF
0.01uF
2.2uF
10%
10%
10%
10%
10%
25V
16V
25V
25V
6.3V
C967
C968
C970
C971
C972
1-164-315-11
1-164-230-11
1-117-863-11
1-162-927-11
1-126-935-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
470PF
220PF
0.47uF
100PF
470uF
5%
5%
10%
5%
20%
50V
50V
6.3V
50V
16V
C973
C974
C975
C976
C977
1-126-935-11
1-162-970-11
1-162-970-11
1-162-970-11
1-162-970-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
470uF
0.01uF
0.01uF
0.01uF
0.01uF
20%
10%
10%
10%
10%
16V
25V
25V
25V
25V
C978
C979
C980
C981
C982
1-126-933-11
1-104-662-11
1-109-982-11
1-104-662-11
1-109-982-11
ELECT
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
100uF
22uF
1uF
22uF
1uF
20%
20%
10%
20%
10%
16V
25V
10V
25V
10V
C983
C984
C985
0.1uF
0.001uF
100PF
10%
10%
5%
16V
50V
50V
< CONNECTOR >
CN10
CN302
CN351
CN354
CN355
1-568-830-11
1-815-445-11
1-779-273-11
1-784-381-21
1-691-550-11
CONNECTOR, FFC 11P
PIN, CONNECTOR (PWB) 4P
PIN, CONNECTOR (1.5mm) (SMD) 3P
CN401
* CN403
* CN404
CN405
* CN406
1-815-443-11
1-565-139-11
1-565-144-11
1-565-140-11
1-565-143-11
PIN, CONNECTOR (STRAIGHT) 6P
CN407
ICF-DVD57TV
MAIN
Ref. No.
CN454
CN601
CN602
CN901
* CN902
Part No.
Description
1-784-367-11
1-779-280-11
1-770-168-11
1-815-447-11
FFC/CONNECTOR, FPC (LIF (NON-ZIF)) 16P
Remark
Ref. No.
Part No.
Description
IC402
IC501
IC502
IC901
IC902
8-759-682-21
6-702-654-01
8-759-530-28
6-701-109-01
6-705-994-01
IC
IC
IC
IC
IC
XC61CN2002MR
NJM2234V (TE2)
TC4066BFT (EL, N)
XC6202P502PR
XC6202P902FR
Remark
IC903
IC904
IC905
IC951
IC952
6-705-468-01
6-706-245-01
8-759-485-77
8-759-669-59
8-759-669-59
IC
IC
IC
IC
IC
BA33BC0FP-E2
XC6201P392PR
BA9743AFV-E2
XC61CN3502NR
XC61CN3502NR
1-564-187-00 PIN, CONNECTOR
< DIODE >
D101
D102
D103
D104
D105
8-719-988-61
8-719-988-61
8-719-988-61
8-719-988-61
8-719-988-61
DIODE
DIODE
DIODE
DIODE
DIODE
1SS355TE-17
1SS355TE-17
1SS355TE-17
1SS355TE-17
1SS355TE-17
D201
D202
D203
D204
D205
8-719-988-61
8-719-988-61
8-719-988-61
8-719-988-61
8-719-988-61
DIODE
DIODE
DIODE
DIODE
DIODE
1SS355TE-17
1SS355TE-17
1SS355TE-17
1SS355TE-17
1SS355TE-17
D303
D304
D351
D401
D402
8-719-988-61
8-719-988-61
8-719-063-79
8-719-911-19
8-719-911-19
DIODE
DIODE
DIODE
DIODE
DIODE
1SS355TE-17
1SS355TE-17
1N4002B
1SS119-25
1SS119-25
D403
D903
D904
D907
D908
8-719-911-19
8-719-988-61
8-719-988-61
8-719-058-24
8-719-058-24
DIODE
DIODE
DIODE
DIODE
DIODE
1SS119-25
1SS355TE-17
1SS355TE-17
RB501V-40TE-17
RB501V-40TE-17
D911
D912
D913
D914
D915
8-719-988-61
8-719-072-43
8-719-988-61
8-719-988-61
8-719-988-61
DIODE
DIODE
DIODE
DIODE
DIODE
1SS355TE-17
RB050L-40TE25
1SS355TE-17
1SS355TE-17
1SS355TE-17
D916
D917
D918
D919
D920
8-719-941-23
8-719-941-23
8-719-072-43
8-719-988-61
8-719-988-61
DIODE
DIODE
DIODE
DIODE
DIODE
DA204U
DA204U
RB050L-40TE25
1SS355TE-17
1SS355TE-17
Q101
Q103
Q104
Q201
Q203
8-729-905-35
6-550-364-01
8-729-905-35
8-729-905-35
6-550-364-01
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC4081-R
2SD2652T106
2SC4081-R
2SC4081-R
2SD2652T106
D921
D922
D923
D924
D925
8-719-988-61
8-719-109-89
8-719-109-97
8-719-988-61
8-719-988-61
DIODE
DIODE
DIODE
DIODE
DIODE
1SS355TE-17
RD5.6ESB2
RD6.8ESB2
1SS355TE-17
1SS355TE-17
Q204
Q301
Q302
Q401
Q402
8-729-905-35
8-729-028-91
8-729-028-83
8-729-905-35
8-729-028-81
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC4081-R
DTA144EUA-T106
DTA124EUA-T106
2SC4081-R
DTA123JUA-T106
Q501
Q502
Q503
Q504
Q505
8-729-422-27
8-729-028-83
8-729-028-83
8-729-029-14
8-729-905-35
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SD601A-Q
DTA124EUA-T106
DTA124EUA-T106
DTC144EUA-T106
2SC4081-R
< IC >
Q901
Q902
Q903
Q904
Q905
6-550-610-01
8-729-905-35
8-729-026-52
8-729-905-35
8-729-028-91
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SB1694
2SC4081-R
2SA1576A-T106-R
2SC4081-R
DTA144EUA-T106
IC
IC
IC
IC
IC
Q906
Q907
Q908
Q909
Q910
8-729-029-14
8-729-905-35
8-729-056-58
8-729-026-52
8-729-026-52
TRANSISTOR
TRANSISTOR
FET
TRANSISTOR
TRANSISTOR
DTC144EUA-T106
2SC4081-R
TPC6102 (TE85R)
2SA1576A-T106-R
2SA1576A-T106-R
< FUSE >
0 F903
0 F904
1-576-488-21 FUSE (3.15A/72V)
1-576-488-21 FUSE (3.15A/72V)
< JACK/IC >
JK501
JK502
1-580-443-21 JACK, PIN 3P (INPUT AUDIO/VIDEO)
8-749-016-00 IC HVE0024 (OPTICAL OUTPUT)
< JUMPER RESISTOR/COIL >
L301
L302
L401
L402
L501
1-216-295-00
1-412-963-11
1-412-963-11
1-412-963-11
1-412-955-11
SHORT CHIP
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
0
100uH
100uH
100uH
22uH
L502
L503
L504
L505
L903
1-412-951-11
1-412-951-11
1-412-955-11
1-412-963-11
1-400-707-21
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
COIL, CHOKE
10uH
10uH
22uH
100uH
22uH
L904
L905
L906
L907
L908
1-400-707-21
1-400-707-21
1-400-707-21
1-400-707-21
1-400-707-21
COIL, CHOKE
COIL, CHOKE
COIL, CHOKE
COIL, CHOKE
COIL, CHOKE
22uH
22uH
22uH
22uH
22uH
< TRANSISTOR >
< JUMPER RESISTOR >
FB351
FB352
IC301
IC302
IC303
IC351
IC401
1-216-295-00 SHORT CHIP
1-216-295-00 SHORT CHIP
8-759-426-51
6-701-824-11
6-706-118-01
8-759-962-08
6-805-450-01
0
0
BA5417
BD3870FS-E2
RC4580IPWR
BA6208
uPD789478GC-SR7596A
83
ICF-DVD57TV
MAIN
Ref. No.
Part No.
Description
Q911
Q912
Q913
Q914
Q915
8-729-021-82
8-729-021-82
8-729-905-35
8-729-026-52
8-729-026-52
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SD2396K
2SD2396K
2SC4081-R
2SA1576A-T106-R
2SA1576A-T106-R
Remark
Q916
Q917
Q918
Q919
Q920
8-729-056-58
8-729-026-52
8-729-026-52
8-729-905-35
8-729-905-35
FET
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TPC6102 (TE85R)
2SA1576A-T106-R
2SA1576A-T106-R
2SC4081-R
2SC4081-R
Q921
Q922
Q923
Q924
8-729-029-14
8-729-026-52
8-729-029-14
8-729-026-52
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC144EUA-T106
2SA1576A-T106-R
DTC144EUA-T106
2SA1576A-T106-R
< RESISTOR >
R101
R102
R103
R104
R105
1-216-841-11
1-216-841-11
1-216-829-11
1-216-829-11
1-216-837-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
47K
4.7K
4.7K
22K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R107
R108
R109
R111
R113
1-216-829-11
1-216-829-11
1-216-837-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
4.7K
22K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R116
R118
R119
R120
R122
1-216-829-11
1-216-825-11
1-216-829-11
1-216-837-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
4.7K
2.2K
4.7K
22K
0
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
R123
R124
R125
R126
R127
1-216-845-11
1-216-845-11
1-216-837-11
1-216-821-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100K
22K
1K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R128
R130
R131
R132
R133
1-216-853-11
1-216-825-11
1-216-849-11
1-216-864-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
SHORT CHIP
470K
2.2K
220K
0
0
5%
5%
5%
1/10W
1/10W
1/10W
R136
R137
R138
R139
R140
1-216-833-11
1-216-837-11
1-216-821-11
1-216-845-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
22K
1K
100K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R141
R142
R143
R144
R145
1-216-829-11
1-216-837-11
1-216-817-11
1-216-813-11
1-216-789-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
22K
470
220
2.2
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R146
R147
R149
R150
R151
1-216-833-11
1-216-837-11
1-216-833-11
1-216-841-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
22K
10K
47K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R152
R153
1-216-821-11 METAL CHIP
1-216-845-11 METAL CHIP
1K
100K
5%
5%
1/10W
1/10W
84
Ref. No.
Part No.
Description
Remark
R157
R158
R159
1-216-841-11 METAL CHIP
1-216-841-11 METAL CHIP
1-216-837-11 METAL CHIP
47K
47K
22K
5%
5%
5%
1/10W
1/10W
1/10W
R161
R162
R163
R201
R202
1-216-841-11
1-216-841-11
1-216-837-11
1-216-841-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
47K
22K
47K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R203
R204
R205
R207
R208
1-216-829-11
1-216-829-11
1-216-837-11
1-216-829-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
4.7K
22K
4.7K
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R209
R211
R213
R216
R218
1-216-837-11
1-216-833-11
1-216-833-11
1-216-829-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
10K
10K
4.7K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R219
R220
R222
R223
R224
1-216-829-11
1-216-837-11
1-216-864-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
4.7K
22K
0
100K
100K
5%
5%
1/10W
1/10W
5%
5%
1/10W
1/10W
R225
R226
R227
R228
R230
1-216-837-11
1-216-821-11
1-216-841-11
1-216-853-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
1K
47K
470K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R231
R232
R233
R236
R237
1-216-849-11
1-216-864-11
1-216-864-11
1-216-833-11
1-216-837-11
METAL CHIP
SHORT CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
220K
0
0
10K
22K
5%
1/10W
5%
5%
1/10W
1/10W
R238
R239
R240
R241
R242
1-216-821-11
1-216-845-11
1-216-825-11
1-216-829-11
1-216-837-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
100K
2.2K
4.7K
22K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R243
R244
R245
R246
R247
1-216-817-11
1-216-813-11
1-216-789-11
1-216-833-11
1-216-837-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
470
220
2.2
10K
22K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R249
R250
R251
R252
R253
1-216-833-11
1-216-841-11
1-216-845-11
1-216-821-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
47K
100K
1K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R257
R258
R259
R261
R262
1-216-841-11
1-216-841-11
1-216-837-11
1-216-841-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
47K
22K
47K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R263
R301
R302
R303
R304
1-216-837-11
1-216-821-11
1-216-821-11
1-216-849-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
1K
1K
220K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
ICF-DVD57TV
MAIN
Ref. No.
Part No.
Description
Remark
R305
R306
R309
R311
R312
1-216-821-11
1-216-821-11
1-216-825-11
1-216-864-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
1K
1K
2.2K
0
10K
5%
5%
5%
1/10W
1/10W
1/10W
5%
1/10W
R314
R315
R316
R317
R354
1-216-833-11
1-216-825-11
1-216-833-11
1-216-821-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
10K
2.2K
10K
1K
0
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
R402
R403
R406
R408
R409
1-216-845-11
1-216-845-11
1-216-845-11
1-216-837-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100K
100K
22K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R410
R411
R412
R413
R414
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
10K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R415
R416
R417
R418
R419
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
10K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R420
R421
R422
R423
R424
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
10K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R425
R426
R427
R428
R429
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
10K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R430
R431
R434
R435
R436
1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
1K
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R437
R438
R439
R440
R441
1-216-821-11
1-216-809-11
1-216-821-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
100
1K
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R442
R443
R444
R445
R446
1-216-821-11
1-216-821-11
1-216-821-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
1K
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R447
R448
R449
R450
R451
1-216-821-11
1-216-821-11
1-216-821-11
1-216-833-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
1K
10K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R452
R453
1-216-805-11 METAL CHIP
1-216-809-11 METAL CHIP
47
100
5%
5%
1/10W
1/10W
Ref. No.
Part No.
Description
Remark
R454
R455
R456
1-216-809-11 METAL CHIP
1-216-809-11 METAL CHIP
1-216-833-11 METAL CHIP
100
100
10K
5%
5%
5%
1/10W
1/10W
1/10W
R457
R458
R459
R460
R461
1-216-821-11
1-216-821-11
1-216-833-11
1-216-821-11
1-216-849-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
10K
1K
220K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R462
R463
R464
R465
R466
1-216-809-11
1-216-809-11
1-216-845-11
1-216-845-11
1-216-849-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100K
100K
220K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R467
R468
R469
R470
R471
1-216-845-11
1-216-845-11
1-216-845-11
1-216-845-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100K
100K
100K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R472
R473
R474
R475
R476
1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
1K
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R477
R478
R479
R480
R481
1-216-821-11
1-216-829-11
1-216-849-11
1-216-833-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
4.7K
220K
10K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R482
R483
R484
R485
R486
1-216-821-11
1-216-821-11
1-216-821-11
1-216-864-11
1-216-853-11
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
1K
1K
1K
0
470K
5%
5%
5%
1/10W
1/10W
1/10W
5%
1/10W
R487
R488
R489
R501
R502
1-216-821-11
1-216-845-11
1-216-841-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
100K
47K
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R503
R504
R505
R506
R507
1-216-833-11
1-218-740-11
1-218-748-11
1-218-732-11
1-218-748-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
100K
220K
47K
220K
5%
0.5%
0.5%
0.5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/10W
R508
R509
R510
R511
R512
1-218-748-11
1-216-829-11
1-216-829-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220K
4.7K
4.7K
1K
1K
0.5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R513
R514
R515
R516
R517
1-216-821-11
1-216-817-11
1-216-809-11
1-216-821-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
470
100
1K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R518
R519
R520
R521
R522
1-216-864-11
1-216-864-11
1-216-821-11
1-216-864-11
1-216-821-11
SHORT CHIP
SHORT CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
0
0
1K
0
1K
5%
1/10W
5%
1/10W
85
ICF-DVD57TV
MAIN
Ref. No.
MONITOR
Part No.
Description
Remark
R523
R524
R525
R526
R527
1-216-841-11
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
10K
10K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R528
R529
R530
R531
R532
1-216-821-11
1-216-821-11
1-216-825-11
1-216-825-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
2.2K
2.2K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R533
R534
R535
R536
R537
1-216-864-11
1-216-821-11
1-216-825-11
1-216-817-11
1-216-833-11
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
1K
2.2K
470
10K
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
R538
R539
R540
R541
R542
1-216-833-11
1-216-809-11
1-216-825-11
1-216-825-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
100
2.2K
2.2K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R543
R544
R545
R906
R907
1-216-833-11
1-216-797-11
1-216-845-11
1-216-845-11
1-216-033-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10
100K
100K
220
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R908
R909
R910
R911
R912
1-216-837-11
1-216-837-11
1-216-821-11
1-216-821-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
22K
1K
1K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R913
R914
R915
R916
R917
1-216-841-11
1-216-841-11
1-220-277-11
1-218-732-11
1-218-716-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
47K
2.2K
47K
10K
5%
5%
5%
0.5%
0.5%
1/10W
1/10W
1/4W
1/10W
1/10W
R918
R920
R921
R922
R923
1-216-813-11
1-216-845-11
1-216-849-11
1-216-841-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220
100K
220K
47K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R924
R925
R926
R927
R928
1-216-849-11
1-216-833-11
1-216-833-11
1-218-708-11
1-218-700-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220K
10K
10K
4.7K
2.2K
5%
5%
5%
0.5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/10W
R929
R930
R931
R932
R933
1-216-805-11
1-216-813-11
1-216-841-11
1-216-849-11
1-216-837-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47
220
47K
220K
22K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R934
R935
R936
R937
R938
1-216-845-11
1-216-841-11
1-216-821-11
1-220-277-11
1-216-813-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
47K
1K
2.2K
220
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/4W
1/10W
R939
R940
1-216-837-11 METAL CHIP
1-218-748-11 METAL CHIP
22K
220K
5%
0.5%
1/10W
1/10W
Ref. No.
Part No.
Description
Remark
R941
R942
R943
1-218-740-11 METAL CHIP
1-249-401-11 CARBON
1-249-401-11 CARBON
100K
47
47
0.5%
5%
5%
1/10W
1/4W
1/4W
R945
R946
R947
R948
R949
1-216-841-11
1-216-813-11
1-216-813-11
1-216-849-11
1-216-805-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
220
220
220K
47
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R950
R951
R952
R953
R954
1-218-724-11
1-216-833-11
1-216-833-11
1-216-837-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
10K
10K
22K
10K
0.5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R955
R956
R957
R958
R959
1-216-833-11
1-216-841-11
1-216-813-11
1-216-845-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
47K
220
100K
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R960
R961
R962
R963
R964
1-216-837-11
1-216-841-11
1-216-849-11
1-216-837-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
47K
220K
22K
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R965
R966
R967
R968
R969
1-216-829-11
1-216-825-11
1-216-825-11
1-216-833-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
2.2K
2.2K
10K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R971
R972
R974
R975
R976
1-216-833-11
1-216-845-11
1-216-821-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
100K
1K
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R977
R978
1-216-821-11 METAL CHIP
1-216-841-11 METAL CHIP
1K
47K
5%
5%
1/10W
1/10W
< THERMISTOR >
TH901
TH902
1-804-471-21 THERMISTOR, POSITIVE
1-804-471-21 THERMISTOR, POSITIVE
< TV TUNER UNIT >
86
TU501
8-597-913-00 TUNER, FSS (BTF-PA402Z)
< VIBRATOR >
X401
1-795-054-21 VIBRATOR, CERAMIC (4.19MHz)
X402
1-760-252-12 VIBRATOR, CRYSTAL (32.768kHz)
************************************************************
A-1110-017-A MONITOR BOARD, COMPLETE
*************************
< CAPACITOR >
C1401
C1402
C1405
C1406
C1407
1-162-970-11
1-162-970-11
1-162-970-11
1-162-970-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
0.01uF
0.01uF
100PF
10%
10%
10%
10%
5%
25V
25V
25V
25V
50V
ICF-DVD57TV
MONITOR
Ref. No.
Part No.
Description
C1408
C1409
C1410
C1411
C1412
1-162-927-11
1-162-927-11
1-162-927-11
1-125-837-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
100PF
100PF
1uF
0.01uF
5%
5%
5%
10%
10%
Remark
50V
50V
50V
6.3V
25V
C1413
C1417
C1418
C1419
C1420
1-162-927-11
1-107-826-11
1-162-927-11
1-162-927-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
0.1uF
100PF
100PF
100PF
5%
10%
5%
5%
5%
50V
16V
50V
50V
50V
C1421
C1424
C1425
C1426
C1427
1-107-826-11
1-162-970-11
1-162-970-11
1-162-970-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.01uF
0.01uF
0.01uF
0.01uF
10%
10%
10%
10%
10%
16V
25V
25V
25V
25V
C1429
C1430
C1431
C1432
C1451
1-126-176-11
1-125-837-11
1-162-970-11
1-162-927-11
1-107-826-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
220uF
1uF
0.01uF
100PF
0.1uF
20%
10%
10%
5%
10%
10V
6.3V
25V
50V
16V
C1501
C1502
C1503
C1504
C1505
1-119-772-11
1-107-826-11
1-107-826-11
1-124-257-00
1-124-257-00
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
47uF
0.1uF
0.1uF
2.2uF
2.2uF
20%
10%
10%
20%
20%
35V
16V
16V
50V
50V
C1506
C1507
C1508
C1509
C1510
1-107-826-11
1-124-257-00
1-107-826-11
1-107-826-11
1-107-826-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
2.2uF
0.1uF
0.1uF
0.1uF
10%
20%
10%
10%
10%
16V
50V
16V
16V
16V
C1511
C1512
C1513
C1514
C1515
1-125-837-11
1-125-837-11
1-125-837-11
1-107-826-11
1-119-772-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
1uF
1uF
1uF
0.1uF
47uF
10%
10%
10%
10%
20%
6.3V
6.3V
6.3V
16V
35V
C1516
C1517
C1518
C1519
C1520
1-124-257-00
1-124-257-00
1-162-970-11
1-107-826-11
1-124-257-00
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
2.2uF
2.2uF
0.01uF
0.1uF
2.2uF
20%
20%
10%
10%
20%
50V
50V
25V
16V
50V
C1521
C1522
C1523
C1524
C1525
1-125-837-11
1-125-837-11
1-119-772-11
1-162-966-11
1-125-837-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
1uF
1uF
47uF
0.0022uF
1uF
10%
10%
20%
10%
10%
6.3V
6.3V
35V
50V
6.3V
C1526
C1527
C1528
C1529
C1530
1-164-227-11
1-124-234-00
1-164-227-11
1-124-465-00
1-125-837-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.022uF
22uF
0.022uF
0.47uF
1uF
10%
20%
10%
20%
10%
25V
16V
25V
50V
6.3V
C1531
C1532
C1533
C1534
C1535
1-162-962-11
1-124-234-00
1-162-964-11
1-162-927-11
1-162-927-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
470PF
22uF
0.001uF
100PF
100PF
10%
20%
10%
5%
5%
50V
16V
50V
50V
50V
C1536
C1537
C1538
1-126-163-11 ELECT
1-126-163-11 ELECT
4.7uF
2.2uF
4.7uF
20%
50V
6.3V
50V
20%
Ref. No.
Part No.
Description
Remark
C1539
C1540
0.1uF
0.1uF
10%
10%
16V
16V
C1541
C1542
C1543
C1544
C1545
1-107-826-11
1-107-826-11
1-107-826-11
1-164-227-11
1-162-919-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.022uF
22PF
10%
10%
10%
10%
5%
16V
16V
16V
25V
50V
C1546
C1547
C1548
C1549
C1550
1-162-915-11
1-162-912-11
1-125-837-11
1-162-914-11
1-127-715-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10PF
7PF
1uF
9PF
0.22uF
0.5PF
0.5PF
10%
0.5PF
10%
50V
50V
6.3V
50V
16V
C1551
C1552
C1553
C1554
C1555
1-125-837-11
1-162-970-11
1-162-927-11
1-126-157-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
1uF
0.01uF
100PF
10uF
0.1uF
10%
10%
5%
20%
10%
6.3V
25V
50V
16V
16V
C1556
C1557
C1558
C1559
C1560
1-119-772-11
1-162-910-11
1-162-919-11
1-162-915-11
1-162-915-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
47uF
5PF
22PF
10PF
10PF
20%
0.25PF
5%
0.5PF
0.5PF
35V
50V
50V
50V
50V
C1561
C1562
C1563
C1564
C1565
1-162-919-11
1-126-157-11
1-119-772-11
1-119-772-11
1-107-826-11
CERAMIC CHIP
ELECT
ELECT
ELECT
CERAMIC CHIP
22PF
10uF
47uF
47uF
0.1uF
5%
20%
20%
20%
10%
50V
16V
35V
35V
16V
C1566
C1567
C1568
C1569
C1570
1-107-826-11
1-107-826-11
1-115-566-11
1-162-964-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
4.7uF
0.001uF
100PF
10%
10%
10%
10%
5%
16V
16V
10V
50V
50V
C1571
C1601
C1602
C1603
C1604
1-162-927-11
1-162-927-11
1-162-964-11
1-162-970-11
1-119-774-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
100PF
100PF
0.001uF
0.01uF
100uF
5%
5%
10%
10%
20%
50V
50V
50V
25V
16V
C1605
C1606
C1607
C1608
C1609
1-107-826-11
1-107-826-11
1-162-923-11
1-162-914-11
1-162-964-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
47PF
9PF
0.001uF
10%
10%
5%
0.5PF
10%
16V
16V
50V
50V
50V
C1610
C1611
C1651
C1652
C1653
1-119-774-11
1-162-964-11
1-107-826-11
1-162-970-11
1-162-964-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100uF
0.001uF
0.1uF
0.01uF
0.001uF
20%
10%
10%
10%
10%
16V
50V
16V
25V
50V
C1654
C1655
C1656
C1657
C1658
1-119-772-11
1-162-970-11
1-107-826-11
1-124-234-00
1-107-826-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
47uF
0.01uF
0.1uF
22uF
0.1uF
20%
10%
10%
20%
10%
35V
25V
16V
16V
16V
C1659
C1660
C1661
C1662
C1801
1-107-826-11
1-164-315-11
1-162-960-11
1-107-826-11
1-119-772-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
0.1uF
470PF
220PF
0.1uF
47uF
10%
5%
10%
10%
20%
16V
50V
50V
16V
35V
87
ICF-DVD57TV
MONITOR
Ref. No.
Part No.
Description
C1803
C1804
C1805
C1806
C1807
1-164-227-11
1-125-837-11
1-162-970-11
1-125-837-11
1-162-964-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.022uF
1uF
0.01uF
1uF
0.001uF
10%
10%
10%
10%
10%
25V
6.3V
25V
6.3V
50V
Remark
C1808
C1809
C1810
C1811
C1812
1-162-970-11
1-117-863-11
1-107-826-11
1-109-982-11
1-109-982-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.47uF
0.1uF
1uF
1uF
10%
10%
10%
10%
10%
25V
6.3V
16V
10V
10V
C1813
C1814
C1815
C1816
C1817
1-162-970-11
1-162-970-11
1-137-980-11
1-137-980-11
1-165-176-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
0.47uF
0.47uF
0.047uF
10%
10%
10%
10%
10%
25V
25V
50V
50V
16V
C1818
C1819
C1820
C1823
C1824
1-164-315-11
1-100-372-21
1-162-968-11
1-162-962-11
1-164-227-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
470PF
15PF
0.0047uF
470PF
0.022uF
5%
5%
10%
10%
10%
50V
3.15KV
50V
50V
25V
C1901
C1902
C1903
C1904
C1905
1-162-970-11
1-162-960-11
1-107-826-11
1-164-315-11
1-119-772-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
0.01uF
220PF
0.1uF
470PF
47uF
10%
10%
10%
5%
20%
25V
50V
16V
50V
35V
C1906
C1907
C1908
C1909
C1910
1-117-863-11
1-117-863-11
1-117-863-11
1-164-315-11
1-164-315-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.47uF
0.47uF
0.47uF
470PF
470PF
10%
10%
10%
5%
5%
6.3V
6.3V
6.3V
50V
50V
C1911
C1912
C1913
C1915
C1916
1-100-155-11
1-164-315-11
1-109-982-11
1-126-163-11
1-126-157-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
470PF
470PF
1uF
4.7uF
10uF
5%
5%
10%
20%
20%
100V
50V
10V
50V
16V
C1917
C1918
C1919
C1920
C1921
1-124-234-00
1-126-157-11
1-126-163-11
1-119-772-11
1-124-234-00
ELECT
ELECT
ELECT
ELECT
ELECT
22uF
10uF
4.7uF
47uF
22uF
20%
20%
20%
20%
20%
16V
16V
50V
35V
16V
C1922
C1923
C1924
C1925
C1951
1-119-774-11
1-124-234-00
1-124-234-00
1-162-970-11
1-126-157-11
ELECT
ELECT
ELECT
CERAMIC CHIP
ELECT
100uF
22uF
22uF
0.01uF
10uF
20%
20%
20%
10%
20%
16V
16V
16V
25V
16V
C1953
C1955
C1957
C1958
C1959
1-124-234-00
1-126-157-11
1-126-163-11
1-119-772-11
1-107-826-11
ELECT
ELECT
ELECT
ELECT
CERAMIC CHIP
22uF
10uF
4.7uF
47uF
0.1uF
20%
20%
20%
20%
10%
16V
16V
50V
35V
16V
C1960
0.1uF
10%
16V
< CONNECTOR >
* CN1403
CN1404
* CN1405
* CN1406
CN1801
88
1-565-153-11
1-565-158-11
1-565-154-11
1-565-157-11
1-815-494-21
PIN, CONNECTOR (ANGLE) 6P
PIN, CONNECTOR 2P
Ref. No.
Part No.
Description
Remark
CN1802 1-794-237-21 CONNECTOR, FFC/FPC 30P
< DIODE >
D1402
D1403
D1501
D1651
D1652
8-719-911-19
8-719-911-19
8-719-044-76
8-719-027-74
8-719-069-54
DIODE
DIODE
DIODE
DIODE
DIODE
1SS119-25
1SS119-25
1SS356-TW11
1SV231-TPH3
UDZSTE-175.1B
D1653
D1654
D1901
D1902
D1903
8-719-044-76
8-719-987-69
8-719-938-72
8-719-938-72
8-719-938-75
DIODE
DIODE
DIODE
DIODE
DIODE
1SS356-TW11
DAN217
SB01-05CP
SB01-05CP
SB05-05CP
D1904
D1905
D1951
D1952
8-719-938-75
8-719-938-72
8-719-044-76
8-719-044-76
DIODE
DIODE
DIODE
DIODE
SB05-05CP
SB01-05CP
1SS356-TW11
1SS356-TW11
< FUSE >
0 F1801
0 F1901
1-576-612-21 FUSE (1A/32V)
1-576-646-11 FUSE (0.5A/50V)
< FILTER/FERRITE BEAD >
FB1601
FB1602
FB1603
FB1604
FB1605
1-239-896-12
1-239-896-12
1-239-896-12
1-414-594-11
1-414-594-11
FILTER, EMI (SMD)
FILTER, EMI (SMD)
FILTER, EMI (SMD)
FB1606
FB1607
FB1608
FB1609
FB1610
1-414-594-11
1-414-594-11
1-414-594-11
1-414-594-11
1-414-594-11
FB1611 1-414-594-11 INDUCTOR, FERRITE BEAD
FB1612 1-414-594-11 INDUCTOR, FERRITE BEAD
< IC >
IC1401
IC1451
IC1501
IC1502
IC1503
6-805-451-01
8-759-640-40
6-704-269-01
6-803-083-01
8-759-331-71
IC
IC
IC
IC
IC
uPD789477GC-SR7596B
BR24C04F-WE2
AN2546FH-AV
uPD6467GR-546-E1
NJM4558E (TE2)
IC1601
IC1651
IC1801
IC1901
6-704-648-01
6-704-270-01
6-707-943-01
8-759-485-77
IC
IC
IC
IC
MN5814
NJU7071V
MP1015EF-LF-Z
BA9743AFV-E2
< COIL >
L1501
L1502
L1505
L1506
L1507
1-400-145-21
1-412-963-11
1-412-963-11
1-400-145-21
1-400-145-21
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
47uH
100uH
100uH
47uH
47uH
L1508
L1509
L1510
L1601
1-412-955-11
1-412-951-11
1-412-951-11
1-412-941-11
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
22uH
10uH
10uH
1.5uH
ICF-DVD57TV
MONITOR
Ref. No.
Part No.
Description
Remark
L1602
1-400-145-21 INDUCTOR
47uH
L1603
L1651
L1652
L1801
L1901
1-400-145-21
1-412-951-11
1-400-145-21
1-469-993-21
1-456-439-21
INDUCTOR
47uH
INDUCTOR
10uH
INDUCTOR
47uH
INDUCTOR (POWER)
COIL, CHOKE
150uH
L1902
L1903
L1904
L1905
L1906
1-412-951-11
1-469-527-11
1-469-527-11
1-456-160-11
1-456-160-11
INDUCTOR
INDUCTOR
INDUCTOR
COIL, CHOKE
COIL, CHOKE
10uH
47uH
47uH
47uH
47uH
L1907
L1950
L1951
L1952
L1953
1-469-527-11
1-412-951-11
1-412-951-11
1-410-381-11
1-410-381-11
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
47uH
10uH
10uH
10uH
10uH
L1954
1-412-951-11 INDUCTOR
10uH
100uH
< TRANSISTOR >
Q1501
Q1502
Q1503
Q1504
Q1505
8-729-905-35
8-729-905-35
8-729-905-35
8-729-905-35
8-729-905-35
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC4081-R
2SC4081-R
2SC4081-R
2SC4081-R
2SC4081-R
Q1506
Q1507
Q1508
Q1509
Q1510
8-729-905-35
8-729-026-52
6-550-139-01
8-729-905-35
8-729-026-52
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC4081-R
2SA1576A-T106-R
IMZ1A-T108
2SC4081-R
2SA1576A-T106-R
Q1901
Q1902
Q1903
Q1904
8-729-922-62
8-729-905-35
6-550-139-01
6-550-610-01
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SD1760F5-TLQ
2SC4081-R
IMZ1A-T108
2SB1694
< RESISTOR >
R1402
R1403
R1404
R1405
R1406
1-216-849-11
1-216-845-11
1-216-833-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220K
100K
10K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1407
R1408
R1409
R1410
R1411
1-216-821-11
1-216-833-11
1-216-809-11
1-216-809-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
10K
100
100
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1412
R1413
R1414
R1415
R1416
1-216-821-11
1-216-829-11
1-216-829-11
1-216-809-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
4.7K
4.7K
100
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1417
R1418
R1419
R1420
R1421
1-216-821-11
1-216-813-11
1-216-833-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
220
10K
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1422
R1423
1-216-821-11 METAL CHIP
1-216-809-11 METAL CHIP
1K
100
5%
5%
1/10W
1/10W
Ref. No.
Part No.
Description
Remark
R1424
R1425
R1426
1-216-809-11 METAL CHIP
1-216-809-11 METAL CHIP
1-216-809-11 METAL CHIP
100
100
100
5%
5%
5%
1/10W
1/10W
1/10W
R1427
R1428
R1429
R1430
R1431
1-216-821-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1432
R1433
R1434
R1435
R1436
1-216-809-11
1-216-821-11
1-216-821-11
1-216-821-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
1K
1K
1K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1437
R1438
R1439
R1440
R1441
1-216-829-11
1-216-864-11
1-216-809-11
1-216-864-11
1-216-821-11
METAL CHIP
SHORT CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
4.7K
0
100
0
1K
5%
1/10W
5%
1/10W
5%
1/10W
R1442
R1443
R1444
R1451
R1452
1-216-821-11
1-216-821-11
1-216-821-11
1-216-829-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
1K
4.7K
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1453
R1454
R1501
R1502
R1503
1-216-821-11
1-216-833-11
1-216-841-11
1-216-833-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
10K
47K
10K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1504
R1505
R1506
R1507
R1508
1-216-833-11
1-216-829-11
1-216-833-11
1-216-829-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
4.7K
10K
4.7K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1509
R1510
R1511
R1512
R1513
1-216-805-11
1-216-805-11
1-216-805-11
1-216-833-11
1-216-853-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47
47
47
10K
470K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1514
R1515
R1516
R1517
R1518
1-216-845-11
1-216-845-11
1-216-833-11
1-216-837-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100K
10K
22K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1519
R1520
R1521
R1522
R1523
1-216-841-11
1-216-833-11
1-216-857-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
10K
1M
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1524
R1525
R1526
R1527
R1528
1-216-833-11
1-216-829-11
1-216-821-11
1-216-829-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
4.7K
1K
4.7K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1529
R1530
R1531
R1532
R1533
1-216-849-11
1-216-817-11
1-216-821-11
1-216-825-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220K
470
1K
2.2K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
89
ICF-DVD57TV
MONITOR
Ref. No.
Part No.
Description
Remark
R1534
R1535
R1536
R1539
R1540
1-216-833-11
1-216-833-11
1-216-864-11
1-216-845-11
1-216-841-11
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
10K
10K
0
100K
47K
5%
5%
1/10W
1/10W
5%
5%
1/10W
1/10W
R1541
R1542
R1543
R1544
R1545
1-216-841-11
1-216-837-11
1-216-817-11
1-216-817-11
1-216-817-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
22K
470
470
470
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1546
R1547
R1548
R1549
R1550
1-216-809-11
1-216-845-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100K
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1551
R1552
R1553
R1554
R1555
1-216-821-11
1-216-833-11
1-216-809-11
1-216-809-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
10K
100
100
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1556
R1557
R1558
R1559
R1560
1-216-837-11
1-216-845-11
1-216-841-11
1-216-837-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
100K
47K
22K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1561
R1562
R1563
R1564
R1565
1-216-849-11
1-216-845-11
1-216-845-11
1-216-837-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220K
100K
100K
22K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1566
R1567
R1568
R1569
R1570
1-216-845-11
1-216-805-11
1-216-805-11
1-216-837-11
1-216-837-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
47
47
22K
22K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1571
R1572
R1573
R1574
R1575
1-216-837-11
1-216-841-11
1-216-793-11
1-216-841-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
47K
4.7
47K
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1576
R1577
R1578
R1579
R1601
1-216-829-11
1-216-829-11
1-216-837-11
1-216-833-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
4.7K
22K
10K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1602
R1603
R1604
R1605
R1607
1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
1K
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1609
R1611
R1612
R1614
R1615
1-216-821-11
1-216-821-11
1-216-821-11
1-216-864-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
1K
1K
1K
0
100
5%
5%
5%
1/10W
1/10W
1/10W
5%
1/10W
R1616
R1617
1-216-809-11 METAL CHIP
1-216-809-11 METAL CHIP
100
100
5%
5%
1/10W
1/10W
90
Ref. No.
Part No.
Description
Remark
R1618
R1619
R1620
1-216-809-11 METAL CHIP
1-216-809-11 METAL CHIP
1-216-809-11 METAL CHIP
100
100
100
5%
5%
5%
1/10W
1/10W
1/10W
R1621
R1622
R1623
R1624
R1625
1-216-809-11
1-216-809-11
1-216-864-11
1-216-864-11
1-216-809-11
METAL CHIP
METAL CHIP
SHORT CHIP
SHORT CHIP
METAL CHIP
100
100
0
0
100
5%
5%
1/10W
1/10W
5%
1/10W
R1626
R1628
R1629
R1630
R1631
1-216-864-11
1-216-864-11
1-216-821-11
1-216-809-11
1-216-853-11
SHORT CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
0
1K
100
470K
5%
5%
5%
1/10W
1/10W
1/10W
R1633
R1634
R1638
R1639
R1640
1-216-809-11
1-216-809-11
1-216-864-11
1-216-821-11
1-216-864-11
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
SHORT CHIP
100
100
0
1K
0
5%
5%
1/10W
1/10W
5%
1/10W
R1642
R1643
R1644
R1645
R1646
1-216-809-11
1-216-809-11
1-216-809-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1651
R1652
R1653
R1655
R1656
1-216-821-11
1-216-821-11
1-216-833-11
1-216-845-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
10K
100K
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1657
R1658
R1659
R1660
R1661
1-216-849-11
1-216-841-11
1-216-829-11
1-216-857-11
1-216-849-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220K
47K
4.7K
1M
220K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1662
R1663
R1665
R1666
R1667
1-216-837-11
1-216-845-11
1-216-841-11
1-216-841-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
100K
47K
47K
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1802
R1803
R1804
R1805
R1806
1-218-716-11
1-218-724-11
1-216-864-11
1-216-821-11
1-218-768-11
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
10K
22K
0
1K
470K
0.5%
0.5%
1/10W
1/10W
5%
0.5%
1/10W
1/10W
R1807
R1808
R1810
R1811
R1812
1-216-821-11
1-216-825-11
1-216-849-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
2.2K
220K
100K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1813
R1814
R1815
R1816
R1817
1-216-829-11
1-216-821-11
1-216-829-11
1-216-849-11
1-218-676-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
1K
4.7K
220K
220
5%
5%
5%
5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1818
R1819
R1820
R1821
R1822
1-218-684-11
1-218-716-11
1-216-845-11
1-216-845-11
1-218-692-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
470
10K
100K
100K
1K
0.5%
0.5%
5%
5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/10W
ICF-DVD57TV
MONITOR
Ref. No.
Part No.
Description
Remark
Ref. No.
Part No.
MS-203
Description
TRANS
Remark
************************************************************
R1902
R1903
R1904
R1905
R1906
1-216-841-11
1-216-837-11
1-216-841-11
1-216-841-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
22K
47K
47K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1907
R1908
R1909
R1910
R1911
1-216-841-11
1-216-829-11
1-216-837-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
4.7K
22K
100K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1912
R1913
R1914
R1916
R1917
1-216-295-00
1-216-837-11
1-216-837-11
1-216-825-11
1-216-833-11
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
22K
22K
2.2K
10K
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
R1918
R1919
R1920
R1922
R1923
1-216-825-11
1-216-825-11
1-216-833-11
1-216-837-11
1-216-849-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
2.2K
10K
22K
220K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1924
R1925
R1926
R1927
R1928
1-216-849-11
1-216-849-11
1-216-849-11
1-216-833-11
1-216-837-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220K
220K
220K
10K
22K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1929
R1930
R1931
R1932
R1933
1-216-833-11
1-216-837-11
1-216-833-11
1-216-837-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
22K
10K
22K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1934
R1935
R1936
R1937
R1938
1-216-825-11
1-216-837-11
1-216-825-11
1-216-841-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
22K
2.2K
47K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1939
R1940
R1950
R1951
R1952
1-216-841-11
1-216-845-11
1-216-829-11
1-216-864-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
SHORT CHIP
47K
100K
4.7K
0
0
5%
5%
5%
1/10W
1/10W
1/10W
R1953
R1954
R1955
1-216-864-11 SHORT CHIP
1-216-829-11 METAL CHIP
1-216-864-11 SHORT CHIP
0
4.7K
0
MS-203 BOARD
*************
(included in LOADING ASSY (M))
< CONNECTOR >
CN001
1-815-412-11 CONNECTOR, FFC/FPC 5P
< SWITCH >
S001
1-225-905-21
1-225-905-21
1-225-901-21
1-225-901-21
5%
RES, ADJ, CERMET (3 TYPE) 47K
1-443-572-11 TRANSFORMER, INVERTER
1-443-571-11 TRANSFORMER, DC/DC CONVERTER
< VIBRATOR >
X1401
X1501
1-533-233-31 FUSE HOLDER
1-828-104-11 POWER SUPPLY CORD
0
< CAPACITOR >
C901
C902
C903
C904
C905
1-162-927-11
1-164-156-11
1-164-156-11
1-164-156-11
1-164-156-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
0.1uF
0.1uF
0.1uF
0.1uF
5%
50V
25V
25V
25V
25V
C906
C907
C908
C909
C910
1-107-826-11
1-107-826-11
1-164-156-11
1-164-156-11
1-164-156-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
10%
10%
16V
16V
25V
25V
25V
C911
C912
0.1uF
0.47uF
10%
25V
6.3V
< DIODE >
D901
D902
D905
D906
0 F901
0 F902
< TRANSFORMER >
T1801
T1901
A-1110-007-A TRANS BOARD, COMPLETE
**********************
8-719-052-84
8-719-052-84
8-719-988-61
8-719-988-61
DIODE
DIODE
DIODE
DIODE
LN4SB60
LN4SB60
1SS355TE-17
1SS355TE-17
< FUSE >
< VARIABLE RESISTOR >
RV1501
RV1651
RV1901
RV1902
1-786-693-11 SWITCH, DETECTION
(DISC TRAY OPEN/CLOSE DETECT)
************************************************************
1/10W
< COIL >
L901
L902
1-402-964-11 COIL, AIR-CORE
1-402-964-11 COIL, AIR-CORE
< RESISTOR >
0 R901
R902
R903
1-219-759-11 METAL
1-216-841-11 METAL CHIP
1-216-845-11 METAL CHIP
1M
47K
100K
5%
5%
5%
1/2W F
1/10W
1/10W
< TRANSFORMER >
0 T901
1-443-733-11 TRANSFORMER, POWER
************************************************************
1-795-054-21 VIBRATOR, CERAMIC (4.19MHz)
1-577-292-11 VIBRATOR, CRYSTAL (3.579545MHz)
91
ICF-DVD57TV
TU
Ref. No.
Part No.
Description
Remark
Ref. No.
Part No.
A-1070-124-A TU BOARD, COMPLETE
******************
Description
Remark
< CONNECTOR >
CNP1
< CAPACITOR >
1-568-854-11 CONNECTOR, FFC 11P
C1
C4
C7
C8
C9
1-162-923-11
1-162-964-11
1-162-910-11
1-162-964-11
1-162-915-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
47PF
0.001uF
5PF
0.001uF
10PF
5%
10%
0.25PF
10%
0.5PF
50V
50V
50V
50V
50V
< TRIMMER >
C10
C11
C12
C13
C14
1-126-960-11
1-107-826-11
1-126-963-11
1-162-970-11
1-164-227-11
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
1uF
0.1uF
4.7uF
0.01uF
0.022uF
20%
10%
20%
10%
10%
50V
16V
50V
25V
25V
C15
C18
C20
C21
C22
1-164-227-11
1-126-934-11
1-107-826-11
1-126-960-11
1-107-826-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.022uF
220uF
0.1uF
1uF
0.1uF
10%
20%
10%
20%
10%
25V
16V
16V
50V
16V
C23
C24
C26
C27
C29
1-126-960-11
1-162-960-11
1-162-927-11
1-162-927-11
1-104-665-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
1uF
220PF
100PF
100PF
100uF
20%
10%
5%
5%
20%
50V
50V
50V
50V
25V
C30
C31
C32
C33
C34
1-162-970-11
1-162-919-11
1-162-964-11
1-162-970-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
22PF
0.001uF
0.01uF
0.01uF
10%
5%
10%
10%
10%
25V
50V
50V
25V
25V
C35
C37
C39
C41
C42
1-162-970-11
1-162-970-11
1-107-826-11
1-164-230-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
0.1uF
220PF
100PF
10%
10%
10%
5%
5%
25V
25V
16V
50V
50V
C43
C47
C49
C51
C52
1-162-919-11
1-162-915-11
1-161-051-00
1-162-919-11
1-162-915-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC
CERAMIC CHIP
CERAMIC CHIP
22PF
10PF
0.01uF
22PF
10PF
5%
0.5PF
10%
5%
0.5PF
50V
50V
25V
50V
50V
L1
L2
L3
L3
L3
1-409-775-11
1-416-509-11
1-428-947-11
1-428-948-11
1-754-117-12
C53
C54
C55
C56
C57
1-136-169-00
1-126-934-11
1-162-927-11
1-162-964-11
1-162-964-11
FILM
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.22uF
220uF
100PF
0.001uF
0.001uF
5%
20%
5%
10%
10%
50V
16V
50V
50V
50V
L4
L11
L21
1-411-234-21 COIL, AM OSC
1-414-142-11 INDUCTOR
1-410-509-11 INDUCTOR
C59
C60
C61
C62
C63
1-162-927-11
1-162-964-11
1-162-927-11
1-162-927-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
0.001uF
100PF
100PF
100PF
5%
10%
5%
5%
5%
50V
50V
50V
50V
50V
R1
R2
R3
R4
R5
1-216-817-11
1-216-817-11
1-216-833-11
1-216-833-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
470
470
10K
10K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
C65
C66
C68
C80
C95
1-126-963-11
1-162-927-11
1-162-927-11
1-162-970-11
1-162-964-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
4.7uF
100PF
100PF
0.01uF
0.001uF
20%
5%
5%
10%
10%
50V
50V
50V
25V
50V
R10
R11
R13
R14
R24
1-216-805-11
1-216-825-11
1-216-821-11
1-216-821-11
1-216-813-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47
2.2K
1K
1K
220
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R30
R31
R32
R33
1-216-837-11
1-216-829-11
1-216-845-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
4.7K
100K
10K
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
CT1
CT3
1-141-442-91 CAP, CERAMIC TRIMMER
1-141-304-21 CAP, CERAMIC TRIMMER
< DIODE >
< FILTER >
CF2
CF4
92
1-760-235-81 FILTER, CERAMIC
1-781-962-21 FILTER, CERAMIC
D1
D2
D3
D10
D11
8-719-078-48
8-719-078-48
8-719-050-69
8-719-988-61
8-719-988-61
DIODE
DIODE
DIODE
DIODE
DIODE
KV1471ETR-G
KV1471ETR-G
KV1520N
1SS355TE-17
1SS355TE-17
< IC >
IC1
IC2
6-700-512-01 IC TA2149BN
8-759-483-40 IC LC72137M-TLM-E
< JUMPER RESISTOR >
JC1
JC2
JC3
JC4
JC5
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
JC6
JC11
JC12
JC13
JC33
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
JC34
1-216-864-11 SHORT CHIP
0
< COIL >
COIL, AIR-CORE
COIL, AIR-CORE
ANTENNA, FERRITE-ROD (MW)
1uH
10uH
< RESISTOR >
ICF-DVD57TV
TU
Ref. No.
Part No.
Description
Remark
R40
1-216-849-11 METAL CHIP
220K
5%
1/10W
R41
R50
R51
R52
R53
1-216-833-11
1-216-821-11
1-216-833-11
1-216-864-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
10K
1K
10K
0
4.7K
5%
5%
5%
1/10W
1/10W
1/10W
5%
1/10W
R54
R55
R56
R57
R58
1-216-817-11
1-216-833-11
1-216-813-11
1-216-809-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
470
10K
220
100
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R59
R60
R61
R63
R65
1-216-825-11
1-216-825-11
1-216-825-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
2.2K
2.2K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R91
R92
R94
1-216-813-11 METAL CHIP
1-216-813-11 METAL CHIP
1-216-821-11 METAL CHIP
220
220
1K
5%
5%
5%
1/10W
1/10W
1/10W
Ref. No.
Part No.
Description
Remark
< TRANSFORMER >
T1
T2
1-433-741-11 TRANSFORMER, IF
1-419-465-11 COIL (DET)
< VIBRATOR >
X1
1-795-449-11 VIBRATOR, CRYSTAL (75kHz)
************************************************************
MISCELLANEOUS
**************
60
61
62
108
109
1-830-500-11
1-830-499-11
1-830-498-11
1-830-501-11
1-830-497-11
113
401
A-6071-669-A LOADING ASSY (M) (Including disc tray open/
close motor (M301), MS-203 board)
8-820-264-03 OPTICAL PICK-UP KHM-310BAA/C2RP
(Including sled motor, spindle motor)
403
0 406
408
LCD1
1-805-652-12 DISPLAY PANEL, LIQUID CRYSTAL
SP101 1-826-139-11 SPEAKER (7.7cm)
SP201 1-826-139-11 SPEAKER (7.7cm)
************************************************************
ACCESSORIES
************
2-593-845-21
3-009-707-01
3-011-879-01
2-638-127-01
4-982-576-41
MANUAL, INSTRUCTION (ENGLISH)
SPACER
SCREW (M5X80), +B (MOUNTING SCREW)
CARD BOARD (TENPLATE)
LID, BATTERY (for RMT-CDVD57A)
A-1113-245-A REMOTE CONTROL UNIT (RMT-CDVD57A)
93
ICF-DVD57TV
REVISION HISTORY
Clicking the version allows you to jump to the revised page.
Also, clicking the version at the upper right on the revised page allows you to jump to the next revised
page.
2
Ver.
Date
1.0
2005.04
Description of Revision
New

service manual - Philips Parts and Accessories

Transcription

Similar documents

service manual - Philips Parts and Accessories

service manual - Philips Parts and Accessories

HCD-GTR33/GTR55/GTR77

ICF-CD873 - Electronica.ro

Service Manual for Portable DVD DPC-7909 Series