Belinea 101536(111514) Service Manual

Service Manual
Model: Belinea 101536
Art. No. 111514
MAXDATA Systeme GmbH
Elbestr. 12-16
45768 Marl / Germany
Belinea 101536(111514) Service Manual
TABLE OF CONTENTS
PAGE
1.
PRECAUTION AND NOTICES ------------------------------------------------------------------------------------- 1~2
1.1. SAFETY PRECAUTIONS ---------------------------------------------------------------------------------------- 1
1.2. PRODUCT SAFETY NOTICE ----------------------------------------------------------------------------------- 1
1.3. SERVICE NOTES-------------------------------------------------------------------------------------------------- 1
2.
SERVICE TOOL & EQUIPMENT REQUIRED ---------------------------------------------------------- 2
3.
SPECIFICATIONS ----------------------------------------------------------------------------------------------------- 2~4
3.1. PRODUCT SPECIFICATIONS------------------------------------------------------------------------------ 2
3.2. SUPPORTING TIMING CHART---------------------------------------------------------------------------- 3~4
3.3. D-SUB CONNECTOR -------------------------------------------------------------------------------------------- 4
4.
EXPLODED VIEW AND PARTS LIST --------------------------------------------------------------------------- 5~6
4.1. EXPLODED VIEW ------------------------------------------------------------------------------------------------ 5
4.2. EXPLODED VIEW PARTS LIST -------------------------------------------------------------------------------- 6
5.
BLOCK DIAGRAM ---------------------------------------------------------------------------------------------------- 7
6.
SCHEMATIC DIAGRAM -------------------------------------------------------------------------------------------- 8~15
6.1. Power---------------------------------------------------------------------------------------------------------------- 8
6.2. Input ----------------------------------------------------------------------------------------------------------------- 9
6.3. Scaler---------------------------------------------------------------------------------------------------------------- 10
6.4. Panel Interface----------------------------------------------------------------------------------------------------- 11
6.5. MCU----------------------------------------------------------------------------------------------------------------- 12
6.6. A-D Power---------------------------------------------------------------------------------------------------------- 13
6.7. Inverter-------------------------------------------------------------------------------------------------------------- 14
6.8. Audio ---------------------------------------------------------------------------------------------------------------- 15
7.
WORKING THEOREM----------------------------------------------------------------------------------------------- 16~19
8.
WIRING DIAGRAM --------------------------------------------------------------------------------------------------- 20
9.
PCB LAYOUT ----------------------------------------------------------------------------------------------------------- 21~26
9.1. MAIN PCB TOP VIEW ------------------------------------------------------------------------------------------- 21
9.2. MAIN PCB BOTTOM VIEW ------------------------------------------------------------------------------------- 22
9.3. CON PCB TOP VIEW -------------------------------------------------------------------------------------------- 23
9.4. CON PCB BOTTOM VIEW -------------------------------------------------------------------------------------- 24
9.5. POWER PCB TOP VIEW ---------------------------------------------------------------------------------------- 25
9.6. POWER PCB BOTTOM VIEW ---------------------------------------------------------------------------------- 26
10.
TROUBLE SHOOTING FLOW CHART ------------------------------------------------------------------------- 27~29
10.1. NO POWER or BACKLIGHT---------------------------------------------------------------------------------- 27
10.2. NO DISPLAY------------------------------------------------------------------------------------------------------- 28
10.3. NO SOUND -------------------------------------------------------------------------------------------------------- 29
11.
ADJUSTMENT---------------------------------------------------------------------------------------------------------- 30~31
11.1. ADJUSTMENT CONDITIONS AND PRECAUTIONS ------------------------------------------------------- 30
11.2. MAIN ADJUSTMENTS ------------------------------------------------------------------------------------------- 30
11.3. ALIGNMENT PROCEDURES----------------------------------------------------------------------------------- 30~31
12.
ELECTRICAL PARTS LIST ---------------------------------------------------------------------------------------- 32~39
04/25/2005
Belinea 101536(111514) Service Manual
1. PRECAUTION AND NOTICES
1.1. SAFETY PRECAUTIONS
This monitor is manufactured and tested on a ground principle that a user's safety comes first.
However, improper use or installation may cause damage to the monitor as well as to the user.
Carefully go over the following WARNINGS before installing and keep this guide handy.
WARNINGS:
!
!
!
!
!
!
!
!
!
This monitor should be operated only at the correct power sources indicated on the label on
the rear end of the monitor. If you're unsure of the power supply in your residence, consult
your local dealer or power company.
Use only the special power adapter that comes with this monitor for power input.
Do not try to repair the monitor your self as it contains no user-serviceable parts. This
monitor should only be repaired by a qualified technician.
Do not remove the monitor cabinet. There is high-voltage parts inside that may cause
electric shock to human bodies, even when the power cord is unplugged.
Stop using the monitor if the cabinet is damaged. Have it checked by a service technacian.
Put your monitor only in a clean, dry environment. If it gets wet, unplug the power cable
immediately and consult your service technician.
Always unplug the monitor before cleaning it. Clean the cabinet with a clean, dry cloth.
Apply non-ammonia based cleaner onto the cloth, not directly onto the glass screen.
Keep the monitor away from magnetic objects, motors, TV sets, and transformer.
Do not place heavy objects on the monitor or power cord.
1.2. PRODUCT SAFETY NOTICE
Many electrical and mechanical parts in this chassis have special safety visual inspections and the
protection afforded by them cannot necessarily be obtained by using replacement components
rated for higher voltages, wattage, etc. Before replacing any of these components read the parts
list in this manual carefully. The use of substitute replacement parts which do not have the same
safety characteristics as specified in the parts list may create shock, fire, or other hazards.
1.3. SERVICE NOTES
1. When replacing parts or circuit boards, clamp the lead wires around terminals before
soldering.
2. When replacing a high wattage resistor (more than 1W of metal oxide film resistor) in circuit
board, keep the resistor about 5mm away from circuit board.
3. Keep wires away from high voltage, high temperature components and sharp edges.
4. Keep wires in their original position so as to reduce interference.
5. Usage of this product please refer to also user's manual.
-1-
04/25/2005
Belinea 101536(111514) Service Manual
2. SERVICE TOOL & EQUIPMENT REQUIRED
1.
2.
3.
4.
5.
6.
7.
8.
SIGNAL GEN.
MULTIMETER
OSCILLOSCOPE
SCREW DRIVER
IRON
ABSORBER
SOLDER
DUMMY LOAD (5ohm/200W)
3. SPECIFICATIONS
3.1. PRODUCT SPECIFICATIONS
LCD Panel
15.0" TFT
Power Management
Energy Star compliant VESA
DPMS compatible
< 2W
Displayable Resolution
XGA 1024× 768 (max.)
Pixel Dimension
0.297× 0.297mm
LCD Display Color
16.2M Color Max.
Viewing Angle
CR≧10
Horizontal: -70°~+70°
Vertical: -65°~+60°
Tilt
+20°~-1°
Contrast Ratio
300 : 1 (min.)
400 : 1 (typ.)
Brightness
200 cd/m2 (min.)
250 cd/m2 (typ.)
Response Time
Tr: 7 ms Tf: 9ms (typ.)
Active Display Area
304.1mm× 228.1mm
Temperature
Operating: 0°C ~ +35°C
Storage: -20°C ~ +60°C
Power
Input Voltage: 100~240 Vac
Consumption: 35 Watts (Max.)
Audio
1Watt(L) + 1Watt(R)
-2-
04/25/2005
Belinea 101536(111514) Service Manual
3.2. SUPPORTING TIMING CHART
ITEM
TIMING
1
2
3
4
5
720×400@70Hz 640×480@60Hz 640×480@67Hz 640×480@75Hz 800×600@56Hz
Pixel Rate
28.322MHz
25.175MHz
30.240MHz
31.500MHz
36.000MHz
H TOTAL
31.778us
31.778us
28.571us
26.667us
28.444us
H DISPLAY
25.422us
25.422us
21.164us
20.317us
22.222us
H B-Porch
1.907us
1.907us
3.175us
3.810us
3.556us
H Width
3.813us
3.813us
2.116us
2.032us
2.000us
H Border
0.318us
0.318us
0.000us
0.000us
0.000us
V TOTAL
14.268ms
16.683ms
15.000ms
13.334ms
17.778ms
V DISPLAY
12.711ms
15.253ms
13.714ms
12.800ms
17.066ms
V B-Porch
1.112ms
1.049ms
1.114ms
0.427ms
0.626ms
Vs Width
0.064ms
0.064ms
0.086ms
0.080ms
0.057ms
V Border
0.222ms
0.254ms
0.000ms
0.000ms
0.000ms
H/V Sync
-/+
-/-
-/-
-/-
+/+
Interlace
No.
No.
No.
No.
No.
6
7
8
9
10
ITEM
TIMING
800×600@60Hz 800×600@72Hz 800×600@75Hz 832×624@74.5Hz 1024×768@60Hz
Pixel Rate
40.000MHz
50.000MHz
48.500MHz
57.280MHz
65.000MHz
H TOTAL
26.400us
20.800us
21.333us
20.112us
20.677us
H DISPLAY
20.000us
16.000us
16.162us
14.525us
15.754us
H B-Porch
2.200us
1.280us
3.232us
3.771us
2.462us
H Width
3.200us
2.400us
1.616us
1.118us
2.092us
H Border
0.000us
0.000us
0.000us
0.000us
0.000us
V TOTAL
16.579ms
13.853ms
13.333ms
13.417ms
16.666ms
V DISPLAY
15.840ms
12.480ms
12.800ms
12.552ms
15.880ms
V B-Porch
0.607ms
0.478ms
0.448ms
0.784ms
0.600ms
Vs Width
0.106ms
0.125ms
0.064ms
0.060ms
0.124ms
V Border
0.000ms
0.000ms
0.000ms
0.00ms
0.000ms
H/V Sync
+/+
+/+
+/+
-/-
-/-
Interlace
No.
No.
No.
No.
No.
-3-
04/25/2005
Belinea 101536(111514) Service Manual
ITEM
11
12
13
TIMING
1024×768@70Hz
1024×768@75Hz
Pixel Rate
75.000MHz
78.750MHz
H TOTAL
17.707us
16.660us
H DISPLAY
13.653us
13.003us
H B-Porch
1.920us
2.235us
H Width
1.813us
1.219us
H Border
0.000us
0.000us
V TOTAL
14.272ms
13.328ms
V DISPLAY
13.599ms
12.795ms
V B-Porch
0.513ms
0.466ms
Vs Width
0.106ms
0.050ms
V Border
0.000ms
0.000ms
H/V Sync
-/-
+/+
Interlace
No.
No.
14
15
3.3. D-SUB CONNECTOR
D-SUB 15 PIN CONNECTOR
1
2
6
11
3
7
12
4
8
13
5
9
14
10
15
1.Red Video
2.Green Video
3.Blue Video
4.GND
5.Self Test
6.Red GND
7.Green GND
8.Blue GND
9. +5V for DDC
10.GND
11.NC
12.SDA
13.H-sync
14.V-sync
15.SCL
SIGNAL LEVEL
CONNECTOR
R
G
B
H
V
SDA
SCL
SIGNAL
RED
GREEN
BLUE
H/SYNC
V/SYNC
DDC1/2B
DDC1/2B
DESCRIPTION
0.7vp-p(VIDEO)
0.7vp-p(VIDEO)
0.7vp-p(VIDEO)
TTL positive or negative
TTL positive or negative
TTL
TTL
-4-
04/25/2005
Belinea 101536(111514) Service Manual
4.1 Exploded View
FIG.1
2C08 X4
2C06
5B01
NOTE.1
K901
2C04X2
5B06
5B05
1F01
2C04X2
5B03
2C09
V901
5B02
MAIN PCB ASS'Y
1F05 X2
1F03
1F02
1F04
5B07 X4
1F10 X4
5B04 X4
FIG.1
2C07X4
1F05 X2
FIG.2
1F11
NOTE.1
1F12 X2
2C01
FIG.2
1F15
W902
2C02
POWER PCB ASS'Y
1F09 X4
2C03
1F06 X2
1F13 X2
KEYPAD PCB ASS'Y
2C02
-5-
4/25/2005
W901
Belinea 101536(111514) Service Manual
4.2. EXPLODED VIEW PARTS LIST
Ref. No. Source
Part No.
DESCRIPTION
SPECIFICATION
Q‘TY
1F01
2024268502 FRONT BEZEL
BELINEA ABS94HB 7035 701922
1
1F02
2053754001 LED INDIC.-PWR
JT198DP PMMA POWER
1
1F03
2044266803 FUNCTION KEY
JT198DP ABS94HB PS-7604B
1
1F04
2071973300 METAL FITTG
JT166DP SECC 0.8t CPTXP02
1
1F05
2080002200 SCREW,SPE
L355 M3x6 DH NICKEL-PLATED
4
1F06
2082630062 SCREW
M3X6 P=0.5
2
1F09
2080003700 SCREW,SPE
1SZZTER001A M3*6LMSWR17/FZMY1
4
1F10
2080003700 SCREW,SPE
1SZZTER001A M3*6LMSWR17/FZMY1
4
1F11
2080040062 SCREW,SPE
M4*8 PMS-3/W
1
1F12
2071672400 SHIELD PLATE
JT166DP SPTE T=0.3mm
1
1F13
2082630062 SCREW
M3X6 P=0.5
2
1F15
2072459900 INSULATOR
PC FR700 94V0 156*103*0.5+
1
2C01
2022263202 CABI BACK
BELINEA ABS94HB 7035 701922
1
2C02
2071873100 BRACKET,FIX
JT166DP SECC 0.8t WALL MOUNT
2
2C03
2071869400 BRACKET,FIX
METAL PLATE 1.0MM KENSINGTON
1
2C04
2082630062 SCREW
M3X6 P=0.5
4
2C06
2106657100 HINGE
JT166DP -1~20' 20KG/CM
1
2C07
2087340086 SCREW,B SPW+
M4X8 B SPW+ φ3.96 NYLON
4
2C08
2084740122 SCREW,BND T+
M4X12(BND T+)
4
2C09
2027260202 DUST COVER
JT166DP ABS94HB 7035 701922
1
5B01
2028258902 STAND
UP ABS94HB RAL 7035 701922
1
5B02
2071974800 METAL FITTG
JT166DP SECC 0.8T STAND TCO
1
5B03
2028259002 STAND
DOWN ABS94HB RAL7035 701922
1
5B04
2039819901 FOOT PAD
RUBBERφ16*2.0+ SQUARE GRAIN
4
5B05
2105252300 SPRING PLATE
JT166DP18 P-CU T=0.2mm
1
5B06
2083730082 SCREW,BND T+
BND T+ M3*8 ZN
1
5B07
2083730082 SCREW,BND T+
BND T+ M3*8 ZN
4
-6-
REMARK
04/25/2005
Belinea 101536(111514) Service Manual
5. BLOCK DIAGRAM
INPUT
3V3
12V
I101/I104
DC / DC
3V3
12V
SWITCHING
POWER SUPPLY
AC 110~220V
3V3
I901 OZ9RR
INVERTER
ONBACKLITE
PANEL POWER
1V8/2V5
ADJBACKLITE
R
I108
TSU13AK(MST8016A)
SXGA LVDS SCALAR
G
B
12V
3V3
PA [0,19]
PB [0,19]
H-Sync
LCD PANEL
V-Sync
GBO [0,4] OSP,ESP,0INV
CSZ
I107
24LC16
EEPROM
INT
SCL
12V
SDA
HW RESET
R
DDC-SDA
DDC-SCL
SDA
ONBACKLITE
I106
MTV312M64
VOLUME CONTROL
I601 TDA7496L
AUDIO AMP
(OPTION)
MUTE
SCL
R
L
P603
AUDIO IN
KEY- PAD LED
-7-
4/25/2005
P601
L
SPEAKER
Belinea 101536(111514) Service Manual
6. SCHEMATIC DIAGRAM
6.1. Power
Q108
AP2305
Q110
2SA1020
3.3VPANEL
12V
VLCD
R104
VLCD_12V
C193
.1uF
10K
R194
4K7
R196
R192
220
1K 1/3W
Q109
MMBT3904
onPANEL_3.3V
6
C192
.1uF
Q111
MMBT3904
onPANEL_12V
6
R105
SOT-223
R186
VCC2V5
3V3
NC
C104
C184
.1uF
C185
.1uF
P101
I101
NC
+
47uF/16V
1
VIN
2
ADJ
C106
VOUT
C105
CM2860-2.5V
.1uF
3
+
47uF/16V
C107
C196
.1uF
.1uF
VCC2.5
4
VCC3V3
4
VAA1
4
VAA2
4
VAA3
4
VAA4
4
12V
1 L113
2
3
4 L114
5 L115
6
7
8
9
200R
R106 100
12V
onBACKLITE 6
200R
200R
C108
.1uF
3V3
3.3VPANEL
R102 1K8
R103 1K
MUTE
Volume
AdjBACKLITE 4
C102
+
C101
.1uF
22uF/16V
CON9
C188 C187
.1uF .1uF
C186
.1uF
VCC3V3
R193 0 Ω 1/8W
3V3
3V3
VAA1
Q103
I102
MMBT3906
3
VCPU
6
1
C109
+
C111
IN
GND
VO
4
VO
2
C110
+
C112
C194
C195
.1uF
.1uF
.1uF
VAA2
NC / RC1117/3.3
47uF/16V
R107
R108
C113
C114
10K
2K7
.1uF
22uF/16V
.1uF
47uF/16V
VAA3
VAA4
Q104
MMBT3906
R109
D129
D128
PC5V
PC5V
1K
1N4148
3
1N4148
-8-
4/25/2005
Belinea 101536(111514) Service Manual
6.2. Input
3.3V
R110
10K
R111 100
R112
100
C115 47nF/25V
R114
100
C117 47nF/25V
R115
100
C118 47nF/25V
R117
NC
C119 NC
R118
100
C121 47nF/25V
R119
100
C122 47nF/25V
R121
100
C124 47nF/25V
RIN
4
GNDR
4
GIN
4
SOG
4
GNDG
4
BIN
4
GNDB
4
HSYNC
4
VSYNC
4
ST_DET1 6
D101
5V6 for W18
0Ω 1/8W for VA521
R113
C116
75 1%
NC
P102
RED+
REDGREEN+
GREENBLUE+
BLUEPC5V
VGA_CON
H Sync
V Sync
SDA_VGA
SCL_VGA
L102
0Ω
L103
0Ω
L104
0Ω
R116
C120
75 1%
NC
3.3V
CON13
C197
47pF V-port
D102
IN4148
D103
IN4148
D104
IN4148
C189
.1uF
D105
IN4148
D106
IN4148
R120
C123
75 1%
NC
D107
IN4148
R199
14
L106
0Ω
I103A
I103F
14
120 R
R123
1
7
D109
R124
2
13
7
74LVC14
SO-14
5V6
100
12
74LVC14
C125
47PF
SO-14
0603
2K2
3.3V
R200 NC
C191
NC(0.1U)
14
L105
0603
I103C
14
I103D
120 R
R122
V Sync
5
7
D110
R125
5V6
2K2
6
9
8
7
74LVC14
74LVC14
SO-14
C126
47PF
100
SO-14
0603
0Ω
R198
R201
bead 30R
1
DDC_CLK 4,6
DDC_DAT 4,6
D111
D112
5V6
5V6
C128
1
13
12
11
10
9
8
7
6
5
4
3
2
1
-9-
47PF
2
2
47PF
C129
4/25/2005
R202
bead 30R
Belinea 101536(111514) Service Manual
6.3. Scaler
VCC3.3
VPO
VCC2.5
L107
VCC3.3
VAD
VPLLVDVI VDPLL
VPO
C134
.1uF
R139 NC
R140 390/1%
66
REFP
67
REFM
C149
.1uF
6
CSZ
6
SCL
6
SDA
6 HWRESET
6
INT
AdjBACKLITE
73
74
PWM0
PWM1
C155 22pF
33
XIN
2
VCC2.5
C141
10uF/50V
C137
.1uF
C139
.1uF
C142
.1uF
C144
.1uF
18
87
97
117
C135
.1uF
108
109
110
111
112
113
PA0
PA1
PA2
PA3
PA4
PA5
GA1P
GA1N
GA2P
GA2N
GA3P
GA3N
98
99
100
101
102
103
PA6
PA7
PA8
PA9
PA10
PA11
BA1P
BA1N
BA2P
BA2N
BA3P
BA3N
CLKAP
CLKAN
88
89
90
91
92
93
118
119
PA12
PA13
PA14
PA15
PA16
PA17
PA18
PA19
NC/RB1P
NC/RB1N
NC/RB2P
NC/RB2N
NC/RB3P
NC/RB3N
16
17
22
23
24
25
PB0
PB1
PB2
PB3
PB4
PB5
NC/GB1P
NC/GB1N
NC/GB2P
NC/GB2N
NC/GB3P
NC/GB3N
8
9
12
13
14
15
PB6
PB7
PB8
PB9
PB10
PB11
124
125
128
1
4
5
120
121
PB12
PB13
PB14
PB15
PB16
PB17
PB18
PB19
VAA1
VAD
L109
VAA1
200R
C146
10uF/50V
C147 C148
.1uF .1uF
PA[0..5]
PA[6..11]
PA[12..19]
PB[0..5]
PB[6..11]
PB[12..19]
PA[0..5]
5
PA[6..11]
5
VAA2
PA[12..19] 5
PB[0..5]
5
PB[6..11]
5
VPLL
L110
VAA2
200R
C150
10uF/50V
PB[12..19] 5
C151
.1uF
GPO[0..4]
OSP
ESP
OINV
GPO[0..4]
5
5
5
5
VAA3
VDVI
L111
VAA3
200R
C152
10uF/50V
C153 C154
.1uF .1uF
NC/ESP
OSP
NC/EINV
OINV
75
76
77
78
ESP
OSP
GPO0
GPO1
GPO2
GPO3
GPO4
83
82
81
80
79
GPO0
GPO1
GPO2
GPO3
GPO4
VDPLL
L112
VAA4
200R
OINV
C158
10uF/50V
GNDC
GNDC
GNDC
GNDC
C159
.1uF
19
86
96
116
GNDP
GNDP
GNDP
GNDP
GNDP
GNDP
GNDP
10
20
85
95
105
115
127
BYPASS
AVSS_LPLL
AVSS_DVI
AVSS_DVI
AVSS_DVI
3
2
39
42
48
C157 .1uF
XOUT
AVSS_PLL
1M
34
54
14.318MHZ
R141
C156 22pF
C145
.1uF
200R
VAA4
X101
C143
.1uF
VDDC
VDDC
VDDC
VDDC
11
21
84
94
104
114
126
VDDP
VDDP
VDDP
VDDP
VDDP
VDDP
VDDP
53
AVDD_PLL
45
51
35
AVDD_DVI
AVDD_DVI
RA1P
RA1N
RA2P
RA2N
RA3P
RA3N
NC/BB1P
NC/BB1N
NC/BB2P
NC/BB2N
NC/BB3P
NC/BB3N
NC/CLKBP
NC/CLKBN
CSZ
SCL
SDA
HWRESETZ
INT
DDCROM_CLK/GPO6
DDCROM_DAT/GPO5
AVSS_MPLL
2
69
71
70
32
72
30
31
VDD
L108
C132
10uF/50V
VDD
R+
RG+
GB+
BCK+
CKREXT
36
VDVI
40
41
43
44
46
47
49
50
52
AVDD_MPLL
55
65
AVDD
AVDD
R138 NC
RIN0
RIN0M
GIN0
GIN0M
SOGIN0
BIN0
BIN0M
HSYNC0
VSYNC0
DDC1_CLK/GPO8
DDC1_DAT/GPO7
AVSS
AVSS
AVSS
DDC_CLK
DDC_DAT
63
62
60
59
61
58
57
37
38
29
28
RIN
GNDR
GIN
GNDG
SOG
BIN
GNDB
HSYNC
VSYNC
68
56
64
3
3,6
3
3
3
3
3
3
3
3
3
C138
.1uF
200R
C133
.1uF
I105
MST8016
C136
.1uF
-10-
4/25/2005
Belinea 101536(111514) Service Manual
6.4. Panel Interface
PA[0..5]
4
PA6
PA7
PA8
PA9
PA10
PA11
GA1P
GA1N
GA2P
GA2N
GA3P
GA3N
PA12
PA13
PA14
PA15
PA16
PA17
PA18
PA19
BA1P
BA1N
BA2P
BA2N
BA3P
BA3N
CLKAP
CLKAN
4
PB[12..19]
PB[12..19]
GPO[0..4]
GPOO0
GPOO1
GPOO2
GPOO3
GPOO4
8
7
6
5
33Ω
PB6
PB7
PB8
PB9
PB10
PB11
GB1P
GB1N
GB2P
GB2N
GB3P
GB3N
PB12
PB13
PB14
PB15
PB16
PB17
PB18
PB19
BB1P
BB1N
BB2P
BB2N
BB3P
BB3N
CLKBP
CLKBN
4
OSP
4
ESP
4
OINV
OSP
ESP
R142
0Ω
R143
NC
OINV R145
NC
ESPO
C162
NC
NC
R146
VLCD
5
2 VLCD
CN101
NC
C163
NC
2 VLCD_12V
VLCD_12V
C166
+
.1uF
FB0N
FB0P
RA2N
RA2P
FB1N
FB1P
RA1N
RA1P
FB2N
FB2P
GA3N
GA3P
FG0N
FG0P
GA2N
GA2P
FG1N
FG1P
GA1N
GA1P
FG2N
FG2P
CLKAN
CLKAP
FCLKN
FCLKP
BA3N
BA3P
FR0N
FR0P
BA2N
BA2P
FR1N
FR1P
BA1N
BA1P
FR2N
FR2P
OSPO
GPOO1
GPOO0
FXDIO
XSTB
POL
C167
GPOO3
YCLK
GPOO2
YDIO
GPOO4
YOE
0Ω 1/8W
R148
0Ω 1/8W
R147
NC
R149
NC
R150
0Ω 1/8W
R151
NC
R152
NC
R153
0Ω 1/8W
+
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
C165
100uF/16V
** R153 NC for
CLAA150XG08 panel
4/25/2005
P104
RB3N
RB3P
B0N
B0P
RB2N
RB2P
B1N
B1P
RB1N
RB1P
B2N
B2P
GB3N
GB3P
BG0N
BG0P
GB2N
GB2P
BG1N
BG1P
GB1N
GB1P
BG2N
BG2P
CLKBN
CLKBP
BCLKN
BCLKP
BB3N
BB3P
BR0N
BR0P
BB2N
BB2P
BR1N
BR1P
BB1N
BB1P
BR2N
BR2P
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
NC CON30p
.1uF
C164
47uF/16V
-11-
RA3N
RA3P
OINVO
C160
6
R144
P105
4
GPO0
GPO1
GPO2
GPO3
GPO4
RN5
33Ω X 4
1
2
3
4
RB1P
RB1N
RB2P
RB2N
RB3P
RB3N
PB[6..11]
PB[6..11]
7
GPO[0..4]
PA[12..19]
4
3
4
PA[12..19]
PA[6..11]
2
4
PA[6..11]
PB0
PB1
PB2
PB3
PB4
PB5
RA1P
RA1N
RA2P
RA2N
RA3P
RA3N
PA0
PA1
PA2
PA3
PA4
PA5
4
PB[0..5]
PB[0..5]
8
PA[0..5]
1
4
CON50p
Belinea 101536(111514) Service Manual
6.5. MCU
3V3
VCPU
2
Q112
NC(MMBT3906)
NC(10K)
R187
0Ω
C170
8
7
6
5
D130
NC(1N4148)
VCPU
8
7
6
5
R204
VCPU
RN1
RN2
10K X4
10K X4
.1uF
C200
2.2uF/50V
R159
11
R160
22pF
.1uF
4K7
D125
I107
A0
A1
A2
GND
R161
22K
1N4148
VCC
WP
SCL
SDA
19
INT
4
8
7
6
5
R163
R164
100
100
14
13
27
26
16
9
30
31
32
33
24C16
2
MUTE
3 ST_DET1
VCPU
12V
VCPU
VCPU
R191
R168
R169
4K7
10K
10K
MTV312M64
R165
NC
8
7
6
5
10K X4
R190
R162
1K
100
R189
1K
R166
C176
R167
NC
NC(47nF)
NC
VCPU
WP
R188
NC(10K)
28
29
R170
R171
2K2
2K2
R174
R175
NC(100)
100
100
DDC_CLK 3
DDC_DAT 3,4
R172
R173
NC
3K3
VCPU
2
onPANEL_12V 2
HWRESET 4
onPANEL_3.3V
onBACKLITE 2
CSZ
4
SCL
4
SDA
4
VCPU
LED_G
LED_O
R195
R203
RN4
10K X4
NC
P106
1
2
3
4
Volume
NC(HEADER 4)
P701
Control_key_pad
VCPU
8 HEADER 2mm
8
7
6
5
4
3
2
1
P107
CON8
R177 3K3
LED_O
R184
8
7
6
5
4
3
2
1
PWR/SW
PSM/LED
PWR/LED
2
DOWN
UP
1
1
2
3
4
7
4K7
RN3
1
2
3
4
C174
C175
1
UP
DOWN
2
POWER
3
2
1
42
41
40
34
39
38
17
18
20
21
22
23
24
25
35
36
37
15
1
2
3
4
X102
12MHz
VSS
12
C173
P5.0
P5.1
P5.2
X1
P5.3
P5.4
P5.5
X2
P5.6
RESET
DA8/HLFHO
DA9/HALFV
P1.0
P1.1
P1.2
INT0/P3.2
P1.3
P1.4
P1.5
ISCL/P3.5/T1
P1.6
ISDA/P3.4/T0
P1.7
P6.0/AD0
P6.1/AD1
DA7
P6.2
P4.0
P6.3
P4.1
P6.4
P4.2
P6.5
P6.6
P3.1/TXD
P6.7
P3.0/RXD
10
R158
1M
NC
NC
VDD3
VCC
HSYNC
VSYNC
I106
VCPU
6
5
4
8
43
44
NC
VCPU
8
7
6
5
1
2
3
4
C172
22pF
NC(10uF/50V)
1
2
3
4
C171
R180
R181
R182
R183
100 POWER
R178
100
R179
100
ORG
MMBT3904
Q106
100 1
100 UP
100 DOWN
100 2
C199
NC(4.7uF)
VCPU
R176 3K3
LED_G
GREEN
GREEN
ORANGE
MMBT3904
Q107
S701
C177 C178 C179 C180 C181 C182 C183
NC
NC
NC
NC
NC
NC
NC
S705
S704
S703
S702
D701
-12-
4/25/2005
C198
NC(4.7uF)
2
Belinea 101536(111514) Service Manual
6.6. A-D Power
(4)C805 68uF 400V for W18. This model without audio amplifier
R832 22R 1/4WS
VCC12V
C815
1000pF/1KV
2A7
R803
R805
560K 1206
R837
536K F1206
R830
+
560K 1206
560K 1206
C805
82UF 400V
3
L802
D806
UF4007
R838
536K F1206
7
11
10,11
31DF2FC
D810
NC
D809
31DQ06
+
C819
1000UF/16V
5
D807
6
L804
JUMPER
R831 10R 1/4WS
7,8
+
C823
103PF Y2
R818
10R 1/4WS
C816
1000UF/16V
C814
1000PF/1KV
100K F1206
103pF CC
R808
N
C809
6
NC
Sense
R809
47R 1/4WS
C824
NC
+
C808
180P CC
Q804
PMBS3906
R829
3.3K 1206
R840
R819
2 12K 1/4WS
I803
TL431D
0.01UF/50V
C825
0.1u CC
R839
1K 1206
(1) SMD resistor - power rating is 1/6W,if not indicated
(2) SMD capacitpr - temperature is 85'C & voltage is 50V,if not indicated.
(3) D810 NC for model without audio, 31DF2 for model with audio.
-13-
D812
HZ12A2
R827
100R 1/4WS
Q803
2SC2100
C821
270 1206
D814
HZ18-2
R823
20.0K
1/4WS
R821
100R
1/4WS
1
R841
3.3K 1206
3
Q802
PMBS3904
AC IN 100~240V
R820
2.20K
1/4WS
I802
TLP621
4
C822
4.7uF 50V
R824
1K2 1/4W
R826
47R 3WS
5
1
3300pF Y1
RI
GND
4
C807
100P 1KV
R816
4R02 F1206
R833
8
R815
4R02 F1206
3
Driver
R814
4R02 F1206
1K 1206
LD7552
C803
SSS4N60B
I801
VIN
VDD
FB
Brightness
Q801
R807
22R 1/4WS
R813
4R02 F1206
F801
T2.5A/250V
FG
CON9_1
D813
NC
7
+
2
L
+
BLT_ON
C811
22uF/35V
3300pF Y1
1
2
3
4
5
6
7
8
9
R810
10R 1206
D808
1N4148
R802
10 3A
S801
P801
C810
47uF/35V
C801
0.47uF X2
C802
volume
+
L805
ET-20
MUTE
R842
NC
1/4WS
C817
C804
NC
R843
NC
+
3.3V 1A
5
R835
560K 1206
C820
470uF/16V
2A7
UF4004
2A7
D802
L807
5.2uH
22R 1/4WS
D811
12
T801
C806
1
2700pF/250V PPN
2
JUMPER
2A7
D803
R836
536K F1206
D805
R804
560K 1206
1000UF/16V
D801
NC
D804
R806 56K 1/2W
R817
4/25/2005
R822
2.74K
1/4WS
R828
10K 1/4WS
Belinea 101536(111514) Service Manual
6.7. Inverter
P901
1
VCC12V
2
T901
2
R912
2K2 1/4WS
R913
100K 1/4WS
R910
10R 1/4WS
8
7
C903
9
C915
20P,3KV,5% CC
EEL19
Q905
2SC945
88225-0211
R917
3M,1/2W 3KV
5,4
R901
R915
1.2K 1/4WS
C914
20P,3KV,5% CC
16:16: 2000
P902
Q903
2SC945
BLT_ON
I902
AP9960M
4R7 1/4WS
3300P CC
1
C911
5P,3KV,5% CC
88225-0211
D903
5
R911
10R
8
D906
5.6V/DIP
ON
3300P CC
C904
2
6
R916
NC
7
OFF
4R7 1/4WS
R902
1N4148/DIP
D904
Q901
2N7002
1N4148/DIP
SST
8
2
CT
VSEN
7
R903
C905
3
GNDA VCCA
6
5.1M
0.027uF MC
4
DRV2
5
DRV1
4
3
1
ISEN
C901
0.1uF CC
470uF 16V
R918
4.99K F
+
C912
3.3N MC
R919
NC
D901
BAV99
C913
2.2N MC
3
R905
10R
R904
10R
C917
0.022u MC
R923
R924
NC
402,F
R922
NC
C907
27P CC
C906
C923
C919
47uF/35V
330P CC
R907
90.9K 1/4WS
C908
0.1uF CC
R908
100K
C916
100pF CC
R909
1M
C910
0.01uF MC
R920
1M
0.1uF CC
C909
0.1uF CC
R906
Brightness
82.5K 1/4WS
D905
1N4148 DIP
(1) SMD resistor - power rating is 1/8W,if not indicated
(2) SMD capacitpr - temperature is 85'C & voltage is 50V,if not indicated.
(3)R913 100K, R915 1.2K,R916 NC for CPT XP02 which
Pannel power
did't had load on 12V.
(4)R915 100ohm, R916 10K for CPT XG08
(5)R924 357ohm
1
2
1
2
C902
I901
OZ9932D
OZ9RRA
Q902
2N7002
for DP18(2)
-14-
4/25/2005
D902
1N4148/DIP
R921
412,F
Belinea 101536(111514) Service Manual
6.8. Audio
DC12_AUDIO
R620
4K7
+
C610
220uF/16V
C601
470U/16V
R602
3K9 1/4WS
R601
100K 1/4WS
C602
22uF/50V
12
+
11
Volume
6
3
pitch=2mm
R621
2K2
C615
10uF/50V
8
4
+
L601
Bead 0805
MUTE
GND1
GND2
GND3
GND4
GND5
GND6
GND7
STBY
1
2
3
13
18
19
20
VAROUT_L
5
VAROUT_R
7
VOLUME
1
5
3
SOLDER SIDE
NC
C605
470U/16V
INL
OUTL
L604
Bead DIP
4
3
2
1
R622
100 1/4WS
C606
470U/16V
9
OUTR
L605
Bead DIP
R_OUT
14
LL+
RR+
SOCKET
TO SPEAKER
R613
10K 1/4WS
C617
NC 0805
R612
10K 1/4WS
+
R623
100 1/4WS
INR
P601
L_OUT
17
C603
1uF/50V
L602
Bead 0805
4
+
C604
1uF/50V
C616
NC 0805
SVR
AUDIO IN PCB
2
+
R619
0R
1
2
+
R611
NC
5
4
L-in
1
16
15
I601
TDA7496L
10
TO92
AUDIO INPUT (GREEN)
P603 (NC)
5 L
4 LS
3 RS
2 R
1 S
4
2
VP2
VP1
D601
1N4148 dip
R610
Q601
10K
2SC945
Volume
R-in
P604
P_JACK
MUTE
MUTE
P605
1
3
5
L606
Bead DIP
3
2
** The Audio circuitry is for JT166WP(/MP)18(48) series only.
SOLDER SIDE
(1) SMD resistor - power rating is 1/4W , if not indicated.
(2) AL-EL capacitor - temperture is 105 degree C , if not indicated.
P602
3
2
1
3
2
1
L603
Bead 0805
-15-
4/25/2005
Belinea 101536(111514) Service Manual
7. WORKING THEOREM
A. DC-DC CONVERTER
The power supply with a high-integrated green-mode PWM controller provides several features to
enhance the performance of power flyback converters.
I801 is a PWM controller and provides many protection functions.
I802 is a photo couple to transfer the feedback signal from the second side which I803 detected
both of the output DC voltage on 3.3V and 12V.
D813 detected the working voltage on I801 and Q805 would pull down the voltage on I801 pin5 to
shut down I801 if feedback loop was failed.
R826 would be a dynamic load which was active while backlight was turned off and system still
working on, this kept 12V output voltage under 13V to protect the panel.
After system went to
power saving mode, the R826 would no loaded. This was detected by I804 and Q803 active the
R826 to load or not.
B. Scaling controller
The ADC is to convert RGB analog signal to digital signal that scaling chip can acknowledge.
The HSYNC input receives a logic signal and provides the frequency reference for pixel clock
generation.
The scaling IC is to converts the input signal ranging from VGA to XGA into XGA resolution that
panel can acknowledge.
GENERAL DESCRIPTION
The MST8016A is a high performance, and fully integrated graphics processing IC solution for
LCD monitors with resolutions up to XGA. It is configured with an integrated triple-ADC/PLL, a
high quality scaling engine, an on-screen display controller, a built-in output clock generator, a
panel timing controller (TCON), and RSDS display interface. To further reduce system costs, the
MST8016A also integrates intelligent power management control capability for green-mode
requirements and spread-spectrum support for EMI management.
PIN DESCRIPTION
CPU Interface
Pin Name Pin Type Function Pin
HWRESET Schmitt Trigger Input
w/ 5V-tolerant Hardware reset; active high 32
CS Input w/ 5V-tolerant 3 Wire Serial Bus Chip Select; active high 69
SDA I/O w/ 5V-tolerant 3 Wire Serial Bus Data; 4mA driving strength 70
SCL Input w/ 5V-tolerant 3 Wire Serial Bus Clock 71
INT Output CPU interrupt; 4mA driving strength 72
Analog Interface
Pin Name Pin Type Function Pin
HSYNC0 Schmitt Trigger Input
w/ 5V-tolerant Analog HSYNC input 37
VSYNC0 Schmitt Trigger Input
w/ 5V-tolerant Analog VSYNC input 38
REFP Internal ADC top de-coupling pin 66
REFM Internal ADC bottom de-coupling pin 67
RIN0 Analog Input Analog red input 63
RIN0M Analog Input Reference ground for analog red input 62
SOGIN0 Analog Input Sync-on-green input 61
GIN0 Analog Input Analog green input 60
GIN0M Analog Input Reference ground for analog green input 59
BIN0 Analog Input Analog blue input 58
BIN0M Analog Input Reference ground for analog blue input 57
REXT External resistor 390 ohm to AVDD 52
RSDS Interface
Pin Name Pin Type Function Pin
CLKAP Output A-Link Positive RSDS Differential Clock Output from“Odd” Channel 118
CLKAN Output A-Link Negative RSDS Differential Clock Output from“Odd” Channel 119
CLKBP Output B-Link Positive RSDS Differential Clock Output from“Even” Channel 120
CLKBN Output B-Link Negative RSDS Differential Clock Output from“Even” Channel 121
BA[3:1]P Output A-Link Positive RSDS Differential Data Output from“Odd” Channel 92, 90, 88
-16-
04/25/2005
Belinea 101536(111514) Service Manual
BA[3:1]N Output A-Link Negative RSDS Differential Data Output from“Odd” Channel 93, 91, 89
GA[3:1]P Output A-Link Positive RSDS Differential Data Output from“Odd” Channel 102, 100, 98
GA[3:1]N Output A-Link Negative RSDS Differential Data Output from“Odd” Channel103, 101,99
RA[3:1]P Output A-Link Positive RSDS Differential Data Output from“Odd” Channel 112, 110, 108
RA[3:1]N Output A-Link Negative RSDS Differential Data Output from“Odd” Channel 113, 111, 109
BB[3:1]P Output B-Link Positive RSDS Differential Data Output from“Even” Channel 4, 128, 124
BB[3:1]N Output B-Link Negative RSDS Differential Data Output from“Even” Channel 5, 1, 125
GB[3:1]P Output B-Link Positive RSDS Differential Data Output from“Even” Channel 14, 12, 8
GB[3:1]N Output B-Link Negative RSDS Differential Data Output from“Even” Channel 15, 13, 9
RB[3:1]P Output B-Link Positive RSDS Differential Data Output from“Even” Channel 24, 22, 16
RB[3:1]N Output B-Link Negative RSDS Differential Data Output from“Even” Channel 25, 23, 17
GPO[8:5] Output TCON GPO[8:5]; 4mA driving strength 29, 28, 30,31
GPO[4:0] Output w/ Pull-down TCON GPO[4:0]; 4~12mA driving strength programmable 79-83
OINV Output w/ Pull-down Resistor TCON “Odd” Channel Inversion; 4~12mA driving strength
programmable 78
EINV Output w/ Pull-down Resistor TCON “Even” Channel Inversion; 4~12mA driving strength
programmable 77
OSP Output w/ Pull-down Resistor TCON “Odd” Channel Start Pulse; 4~12mA driving strength
programmable 76
ESP Output w/ Pull-down Resistor TCON “Even” Channel Start Pulse; 4~12mA driving strength
programmable 75
GPIO Interface
Pin Name Pin Type Function Pin
GOUT1/PWM1 Output GOUT1/PWM1; 4mA driving strength 74
GOUT0/PWM0 Output GOUT0/PWM0; 4mA driving strength 73
Misc. Interface
Pin Name Pin Type Function Pin
BYPASS For External Bypass Capacitor 3
XIN Crystal Oscillator Input Xin 33
XOUT Crystal Oscillator Output Xout 34
Power Pins
Pin Name Pin Type Function Pin
AVDD 3.3V Power ADC Power 45, 51, 55, 65
AVSS Ground ADC Ground 39, 42, 48, 56,
64, 68
AVDD_PLL 3.3V Power PLL Power 53
AVSS_PLL Ground PLL Ground 54
AVDD_MPLL 3.3V Power MPLL Power 35
AVSS_MPLL Ground MPLL Ground 2, 36
VDDP 3.3V Power Digital Output Power 11, 21, 84, 94,
104, 114, 126
GNDP Ground Digital Output Ground 10, 20, 85, 95,
105, 115, 127
VDDC 2.5V Power Digital Core Power 18, 87, 97, 117
GNDC Ground Digital Core Ground 19, 86, 96, 116
No Connects
Pin Name Pin Type Function Pin
NC No Connect. Leave These Pins Floating.
6, 7, 26, 27, 40,
41, 43, 44, 46,
47, 49, 50, 106,
107, 122, 123
Resolution 8 Bits
DC ACCURACY
Differential Nonlinearity ± 0.5 +1.50/-1.0 LSB
Integral Nonlinearity ± 1 LSB
No Missing Codes Guaranteed
ANALOG INPUT
Input Voltage Range
Minimum 0.5 V p-p
Maximum 1.0 V p-p
Input Bias Current 1 uA
Input Full-Scale Matching 1.5 %FS
Brightness Level Adjustment 62 %FS
-17-
04/25/2005
Belinea 101536(111514) Service Manual
SWITCHING PERFORMANCE
Maximum Conversion Rate 165 MSPS
Minimum Conversion Rate 20 MSPS
HSYNC Input Frequency 15 200 kHz
PLL Clock Rate 20 162.5 MHz
PLL Jitter 500 ps p-p
Sampling Phase Tempco TBD ps/°C
DIGITAL INPUTS
Input Voltage, High (VIH) 2.5 V
Input Voltage, Low (VIL) 0.8 V
Input Current, High (IIH) -1.0 uA
Input Current, Low (IIL) 1.0 uA
Input Capacitance 5 pF
DIGITAL OUTPUTS
Output Voltage, High (VOH) VDDP-0.1 V
Output Voltage, Low (VOL) 0.1 V
DYNAMIC PERFORMANCE
Analog Bandwidth, Full Power 250 MHz
Channel to Channel Matching 0.5% Full-Scale
3.3V Supply Voltages VVDD_33 -0.3 3.6 V
2.5V Supply Voltages VVDD_25 -0.3 2.75 V
Input Voltage (5V tolerant inputs) VIN5Vtol -0.3 5.0 V
Input Voltage (non 5V tolerant inputs) VIN -0.3 VVDD_33 V
C. MTV312M64
The MTV312M micro-controller is an 8051 CPU core embedded device especially tailored for CRT/LCD
Monitor applications. It includes an 8051 CPU core, 1024-byte SRAM, 14 built-in PWM DACs, VESA DDC interface,
4-channel A/D converter, and a 64K-byte internal program Flash-ROM.
A “CMOS output pin” means it can sink and drive at least 4mA current. It is not recommended to use such
pin as input function.
A “open drain pin” means it can sink at least 4mA current but only drive 10~20uA to VDD. It can be used as input or
output function and needs an external pull up resistor.
A “8051 standard pin” is a pseudo open drain pin. It can sink at least 4mA current when output is at low level, and drives
at least 4mA current for 160nS when output transits from low to high, then keeps driving at 100uA to maintain the pin at
high level. It can be used as input or output function. It needs an external pull up resistor when driving heavy load device.
POWER CONFIGURATION
The MTV312M can work on 5V or 3.3V power supply system.
In 5V power system, the VDD pin is connected to 5V power and the VDD3 needs an external capacitor, all
output pins can swing from 0~5V, input pins can accept 0~5V input range.
And ADC conversion range is 5V. However, X1 and X2 pins must be kept below 3.3V.
In 3.3V power system, the VDD and VDD3 are connected to 3.3V power, all output pins swing from 0~3.3V, HSYNC,
VSYNC and open drain pin can accept 0~5V input range, other pins must be kept below 3.3V. And the ADC conversion
range is 3.3V.
D. INVERTER
In order to drive the CCFLs embedded in the panel module, there is a push-pull inverter to convert by the controller.
from input 12V up to hundreds of AC voltage output peak to peak.
The inverter is formed by symmetric in order to drive the separate lamp modules.
The input stage consists of a PWM controller, push-pull inverter, and switching MOSFET to convert DC input into AC
output.
The output stage consists of a tuning capacitor, transformer, and push-pull MOSFET pair to boost AC output up to
hundreds of voltage peak to peak.
And one resister is serial to lamp for output voltage feedback.
There are two signals which control the inverter come from system to turn on the inverter and control brightness.
Logic “low” level which send to I901 is turn on the inverter.
BRI signal control brightness by DC level which was integral from PWM signal.
E. AUDIO
(This function is operated on the models which with audio function)
The TDA7496L is a stereo 2W+2W class AB
power amplifier assembled in the @ Powerdip
-18-
04/25/2005
Belinea 101536(111514) Service Manual
14+3+3 package, specially designed for high
quality sound, TV and Monitor applications.
And the real application on this model is 1W+1W.
Features of the TDA7496L include linear volume
control, Stand-by and mute functions
Ipeak Output Peak Current (internally limited) 0.7 0.9 A
Vin Input Signal 2.8 Vrms
GV Closed Loop Gain Vol Ctrl > 4.5V 28.5 30 31.5 dB
GvLine Monitor Out Gain Vol Ctrl > 4.5V; Zload > 30KΩ -1.5 0 1.5 dB
AMin VOL Attenuation at Minimum Volume Vol Ctrl < 0.5V 80 dB
BW 0.6 MHz
ABSOLUTE MAXIMUM RATINGS
Symbol Parameter Value Unit
VS DC Supply Voltage 26 V
VIN Maximum Input Voltage 8 Vpp
Ptot Total Power Dissipation (Tcase = 60°C) 6 W
Tamb Ambient Operating Temperature 0 to 70 °C
Tstg, Tj Storage and Junction Temperature -40 to 150 °C
V6 Volume CTRL DC voltage 7 V
0 4 8 12 Area(cm2)
-19-
04/25/2005
Belinea 101536(111514) Service Manual
8. WIRING DIAGRAM
LCD PANEL
P981
P801
P802
P901
P105
P801
P101
MAIN PCB
POWER PCB
P902
P107
P601
P102
P701
P701
KEYPAD PCB
P985
W902
SPK(L)
-20-
W901
SPK(R)
4/25/2005
P961
I/O CABLE
Belinea 101536(111514) Service Manual
9. PCB LAYOUT
9.1. MAIN PCB TOP VIEW
-21-
4/25/2005
Belinea 101536(111514) Service Manual
9.2. MAIN PCB BOTTOM VIEW
-22-
4/25/2005
Belinea 101536(111514) Service Manual
9.3. CON PCB TOP VIEW
-23-
4/25/2005
Belinea 101536(111514) Service Manual
9.4. CON PCB BOTTOM VIEW
-24-
4/25/2005
Belinea 101536(111514) Service Manual
9.5. POWER PCB TOP VIEW
-25-
4/25/2005
Belinea 101536(111514) Service Manual
9.6. POWER PCB BOTTOM VIEW
-26-
4/25/2005
Belinea 101536(111514) Service Manual
10. TROUBLE SHOOTING FLOW CHART
10.1. NO POWER or BACKLIGHT
NO POWER
With power
but power saving mode more
than 1 Watts
Yes
CHECK C805
with voltage more than
150volts or not
No
Check Q903,
without connecting main board,
with main board more than
1Watts
check main board.
Yes
3.3V on P801
pin5,6 to GND
12V on P802
pin3 to GND
No
Yes
Check main board
backlight_on signal
No
Yes
NO BACKLIGHT.
Check P802 pin2 with
3.3V or not
Check R813~R816 broken or
not
Yes
Check Q903,D906
No
No
Yes
Check Q801 D & S short
not,I801 failed,
R807 broken or not
or
No
Check D814,Q802,Q804 failed
or not
If there had Sawtooth
waveform on DC output
Check 5V on I901 pin6
Yes
Check Q905.
Check I901,I902,
R904,R905
CHECK
D801~D804 failed or not,
F801 broken or not,
R802 failed or not
No
Check I901 pin1 voltage
>1.0volts,<3.0volts
while inverter turn on
Check I802,I803
If there had Sawtooth
waveform on DC output
Yes
No
Check D809,D810,D811.
If there had Sawtooth
waveform on DC outputr
Check
Q901,Q902,D903,D904
-27-
04/25/2005
Belinea 101536(111514) Service Manual
10.2. NO DISPLAY
No
Display
Check Power
region
Dark
Amber
Check LED Color
Check IO cable is
connect OK ?
Yes
Amber & Green
No
Check X102 Crystal
12MHz is working?
Green
Check I/P signal is in
pwr saving state?
Check I106 is OK ?
Yes
Refer to NO POWER
trouble shoot flow char
Press Power key
ON/OFF is OK ?
(See LED is green or
dark.)
No
Yes
Check uP I106
Reset is Ok ?
No
Yes
Press "1" key if OSD
menu is on display ?
No
Change
I106
Check Reset circuit
C173,D125
Check Keypad
pcb is OK ?
Yes
Check if
Inverter is Ok ?
Yes
Check I105
MST8016 if HWRST
Pin#32 have
reset pulse ?
No
Check Power
region with no
backlight
Check uP I106
pin#17 send reset
pulse ?
No
Yes
Yes
Check X101 Crystal
14.318MHz is
working ?
No
Change X101
Yes
Check I105
Pin#70,71 data bus
have signal
No
Change I105 LCD
controller IC
Yes
Check panel Powers
VLCD_3V3
VLCD_12V
correct
Yes
Change LCD panel
-28-
04/25/2005
Belinea 101536(111514) Service Manual
10.3. NO SOUND
Speaker
No
Sound
Check volume
control voltage on
I601 Pin6
No
Adjust OSD
Volume control
to Max. and
Check Pin 6
Voltage >0.02V
No
Check R619 has
PWM
output ?
Yes
Yes
Yes
Yes
Check OSD MUTE
function
was disable,
If yes,Check
Q601,D601,C602
fail or not
Check P601
connected or not.
Check if Speaker is
OK?
Yes
Change I601
TDA7496L
Yes
-29-
04/25/2005
Belinea 101536(111514) Service Manual
11. ADJUSTMENT
11.1. ADJUSTMENT CONDITIONS AND PRECAUTIONS
1. Approximately 30 minutes should be allowed for warm up before proceeding.
2. Adjustments should be undertaken only on those necessary elements since most of them
have been carefully preset at the factory.
3. ESD protection is needed before adjustment.
11.2. MAIN ADJUSTMENTS
NO.
1.
2.
3.
FUNCTION
V-com Voltage
Eeprom Initial
White Balance
DESIGNATION
on the back of the Panel
Function Key
Function Key
11.3. ALIGNMENT PROCEDURES
Adjustment Conditions and Precautions:
(A). Power supply voltage:
AC 110/120V± 10% 60 Hz± 5%, AC 220/240V± 10% 50 Hz ± 5%.
(B). Warm up time:
The display must be power ON for at least 30 minutes at full white pattern before
starting alignments.
This is especially critical in color temperature and white balance adjustments.
(C). Signals: reference the front detail specifications and timing table.
Video : reference the front detail specifications.
1. Adjustment of V-com Voltage:
A. Timing : 1024x768@60Hz. 48KHz
B. Pattern : The picture of “ Shut down windows” or Full screen pixel ON/OFF pattern.
C. Adjust V-com to let the center of the screen no flash.
2. Eeprom Initial:
A. Timing : 1024x768@60Hz.
B. Pattern : Cross hatch.
C. Switch off the power and press the “▲” and “ 2 “ key simultaneously, then switch
on the power. At this time we can enter into the factory mode when press the “ 1 “key.
D. Select the “EEPROM INIT” item and press “ 2 “key to reset the Eeprom.
3. White Balance Adjustment :
A. Timing : 1024x768@60Hz.
B. Pattern : 16Gray Level. or 5-MOSAIC (Pattern 42)
C. Set CA110 color analizer at the center of screen and along a perpendicular to the
screen at 20cm from the display.
D. Move “▼” key to select the “ WHITE BALANCE” item in the factory mode and
press “ 2 “key, then the white balance will be auto dadjusted.
E. Color temperature verification: (Set Brightness and Contrast to Maximum)
-30-
04/25/2005
Belinea 101536(111514) Service Manual
6500K verify : press “▼” ,“▲” key to move cursor to 6500K at factory mode
and press “ 2 “ key, and then check the color temperature is
x=0.312 ± 0.03
y=0.318 ± 0.03
Y≧200 cd/m2
-31-
04/25/2005
Belinea 101536(111514) Service Manual
12. ELECTRICAL PARTS LIST
When you place a parts order, be sure to indicate the following data on the order:
!
Location No.
!
Parts No.
!
Description
LOC NO. SOURCE PART NO.
DESCRIPTION
SPECIFICATION
REMARK
MAIN P.C.BOARD
C101
C102
C104
C105
C106
C107
C108
C109
C110
C111
C112
C113
C114
C115
C115
C117
C117
C118
C118
C121
C121
C122
C122
C124
C124
C125
C126
C128
C128
C129
C129
C132
C133
C134
C135
C136
C137
C138
C139
C141
C142
C143
C144
C145
C146
C147
C148
C149
C150
C151
C152
C153
C154
C155
C156
RA
RB
RA
RB
RA
RB
RA
RB
RA
RB
RA
RB
2346410496
2336322613
2336347613
2336347613
2346410496
2346410496
2346410496
2336347613
2336347613
2346410496
2346410496
2346410496
2336322613
2346147396
2346247396
2346147396
2346247396
2346147396
2346247396
2346147396
2346247396
2346147396
2346247396
2346147396
2346247396
2341147096
2341147096
2341147096
2349901096
2341147096
2349901096
2336610613
2346410496
2346410496
2346410496
2346410496
2346410496
2346410496
2346410496
2336610613
2346410496
2346410496
2346410496
2346410496
2336610613
2346410496
2346410496
2346410496
2336610613
2346410496
2336610613
2346410496
2346410496
2341122096
2341122096
CAP,CHIP 85'C
CAP,MINI ELE 105'C
CAP,MINI ELE 105'C
CAP,MINI ELE 105'C
CAP,CHIP 85'C
CAP,CHIP 85'C
CAP,CHIP 85'C
CAP,MINI ELE 105'C
CAP,MINI ELE 105'C
CAP,CHIP 85'C
CAP,CHIP 85'C
CAP,CHIP 85'C
CAP,MINI ELE 105'C
CAP,CHIP 125'C
CAP,CHIP 125'C
CAP,CHIP 125'C
CAP,CHIP 125'C
CAP,CHIP 125'C
CAP,CHIP 125'C
CAP,CHIP 125'C
CAP,CHIP 125'C
CAP,CHIP 125'C
CAP,CHIP 125'C
CAP,CHIP 125'C
CAP,CHIP 125'C
CAP,CHIP 125'C
CAP,CHIP 125'C
CAP,CHIP 125'C
CAP,CHIP SPEC
CAP,CHIP 125'C
CAP,CHIP SPEC
CAP,MINI ELE 105'C
CAP,CHIP 85'C
CAP,CHIP 85'C
CAP,CHIP 85'C
CAP,CHIP 85'C
CAP,CHIP 85'C
CAP,CHIP 85'C
CAP,CHIP 85'C
CAP,MINI ELE 105'C
CAP,CHIP 85'C
CAP,CHIP 85'C
CAP,CHIP 85'C
CAP,CHIP 85'C
CAP,MINI ELE 105'C
CAP,CHIP 85'C
CAP,CHIP 85'C
CAP,CHIP 85'C
CAP,MINI ELE 105'C
CAP,CHIP 85'C
CAP,MINI ELE 105'C
CAP,CHIP 85'C
CAP,CHIP 85'C
CAP,CHIP 125'C
CAP,CHIP 125'C
-32-
CS 0603/Y5V/50V
0.1u
Z
EC 22u/ 16V
4*7
P=2.5
EC 47u/ 16V
5*7
P=2.5
EC 47u/ 16V
5*7
P=2.5
CS 0603/Y5V/50V
0.1u
Z
CS 0603/Y5V/50V
0.1u
Z
CS 0603/Y5V/50V
0.1u
Z
EC 47u/ 16V
5*7
P=2.5
EC 47u/ 16V
5*7
P=2.5
CS 0603/Y5V/50V
0.1u
Z
CS 0603/Y5V/50V
0.1u
Z
CS 0603/Y5V/50V
0.1u
Z
EC 22u/ 16V
4*7
P=2.5
CS 0603/X7R/50V
0.047u
K
CS 0603/X7R/25V
0.047u
K
CS 0603/X7R/50V
0.047u
K
CS 0603/X7R/25V
0.047u
K
CS 0603/X7R/50V
0.047u
K
CS 0603/X7R/25V
0.047u
K
CS 0603/X7R/50V
0.047u
K
CS 0603/X7R/25V
0.047u
K
CS 0603/X7R/50V
0.047u
K
CS 0603/X7R/25V
0.047u
K
CS 0603/X7R/50V
0.047u
K
CS 0603/X7R/25V
0.047u
K
CS 0603/COG/50V
47p
J
CS 0603/COG/50V
47p
J
CS 0603/COG/50V
47p
J
AC0603470A 47P ± 10% INPAQ
CS 0603/COG/50V
47p
J
AC0603470A 47P ± 10% INPAQ
EC 10u/ 50V
5*7
P=2.5
CS 0603/Y5V/50V
0.1u
Z
CS 0603/Y5V/50V
0.1u
Z
CS 0603/Y5V/50V
0.1u
Z
CS 0603/Y5V/50V
0.1u
Z
CS 0603/Y5V/50V
0.1u
Z
CS 0603/Y5V/50V
0.1u
Z
CS 0603/Y5V/50V
0.1u
Z
EC 10u/ 50V
5*7
P=2.5
CS 0603/Y5V/50V
0.1u
Z
CS 0603/Y5V/50V
0.1u
Z
CS 0603/Y5V/50V
0.1u
Z
CS 0603/Y5V/50V
0.1u
Z
EC 10u/ 50V
5*7
P=2.5
CS 0603/Y5V/50V
0.1u
Z
CS 0603/Y5V/50V
0.1u
Z
CS 0603/Y5V/50V
0.1u
Z
EC 10u/ 50V
5*7
P=2.5
CS 0603/Y5V/50V
0.1u
Z
EC 10u/ 50V
5*7
P=2.5
CS 0603/Y5V/50V
0.1u
Z
CS 0603/Y5V/50V
0.1u
Z
CS 0603/COG/50V
22p
J
CS 0603/COG/50V
22p
J
04/25/2005
Belinea 101536(111514) Service Manual
LOC NO.
C157
C158
C159
C164
C165
C166
C167
C170
C172
C173
C174
C175
C184
C185
C186
C187
C188
C189
C192
C193
C194
C195
C196
C197
D101
D102
D102
D103
D103
D104
D104
D105
D105
D106
D106
D107
D107
D109
D110
D111
D112
D125
D125
D128
D128
D129
D129
E801
E802
E803
I101
I105
I106
I106
I107
I107
L102
L103
L104
L105
L106
L107
L108
L109
L110
SOURCE
RA
RB
RA
RB
RA
RB
RA
RB
RA
RB
RA
RB
RA
RB
RA
RB
RA
RB
RA
RB
RA
RB
PART NO.
DESCRIPTION
SPECIFICATION
2346410496
2336610613
2346410496
2336347613
2336310713
2346410496
2346410496
2346410496
2341122096
2336622513
2341122096
2346410496
2346410496
2346410496
2346410496
2346410496
2346410496
2346410496
2346410496
2346410496
2346410496
2346410496
2346410496
2349901096
2364503996
2364200896
2364600196
2364200896
2364600196
2364200896
2364600196
2364200896
2364600196
2364200896
2364600196
2364200896
2364600196
2364503996
2364503996
2364503996
2364503996
2364200896
2364600196
2364200896
2364600196
2364200896
2364600196
2097400301
2097400301
2097400301
2365815096
2365932396
2365929996
2365101796
2365915896
2365100996
2253200096
2253200096
2253200096
2379312196
2379312196
2379820196
2379820196
2379820196
2379820196
CAP,CHIP 85'C
CAP,MINI ELE 105'C
CAP,CHIP 85'C
CAP,MINI ELE 105'C
CAP,MINI ELE 105'C
CAP,CHIP 85'C
CAP,CHIP 85'C
CAP,CHIP 85'C
CAP,CHIP 125'C
CAP,MINI ELE 105'C
CAP,CHIP 125'C
CAP,CHIP 85'C
CAP,CHIP 85'C
CAP,CHIP 85'C
CAP,CHIP 85'C
CAP,CHIP 85'C
CAP,CHIP 85'C
CAP,CHIP 85'C
CAP,CHIP 85'C
CAP,CHIP 85'C
CAP,CHIP 85'C
CAP,CHIP 85'C
CAP,CHIP 85'C
CAP,CHIP SPEC
DIODE,ZENER SMD
DIODE,RECT(SMD)
DIODE,SWITCH SMD
DIODE,RECT(SMD)
DIODE,SWITCH SMD
DIODE,RECT(SMD)
DIODE,SWITCH SMD
DIODE,RECT(SMD)
DIODE,SWITCH SMD
DIODE,RECT(SMD)
DIODE,SWITCH SMD
DIODE,RECT(SMD)
DIODE,SWITCH SMD
DIODE,ZENER SMD
DIODE,ZENER SMD
DIODE,ZENER SMD
DIODE,ZENER SMD
DIODE,RECT(SMD)
DIODE,SWITCH SMD
DIODE,RECT(SMD)
DIODE,SWITCH SMD
DIODE,RECT(SMD)
DIODE,SWITCH SMD
EYELET
EYELET
EYELET
IC,LINEAR(SMD)
IC,DIGITAL SMD
IC,DIGITAL SMD
IC,MEMORY
IC,DIGITAL SMD
IC,MEMORY
RES,CHIP 1/10W
RES,CHIP 1/10W
RES,CHIP 1/10W
BEAD,HI-IMPEDANCE
BEAD,HI-IMPEDANCE
BEAD,HI-IMPEDANCE
BEAD,HI-IMPEDANCE
BEAD,HI-IMPEDANCE
BEAD,HI-IMPEDANCE
CS 0603/Y5V/50V
0.1u
Z
EC 10u/ 50V
5*7
P=2.5
CS 0603/Y5V/50V
0.1u
Z
EC 47u/ 16V
5*7
P=2.5
EC 100u/ 16V
6.3*7
P=2.5
CS 0603/Y5V/50V
0.1u
Z
CS 0603/Y5V/50V
0.1u
Z
CS 0603/Y5V/50V
0.1u
Z
CS 0603/COG/50V
22p
J
EC 2.2u/ 50V
4*7
P=2.5
CS 0603/COG/50V
22p
J
CS 0603/Y5V/50V
0.1u
Z
CS 0603/Y5V/50V
0.1u
Z
CS 0603/Y5V/50V
0.1u
Z
CS 0603/Y5V/50V
0.1u
Z
CS 0603/Y5V/50V
0.1u
Z
CS 0603/Y5V/50V
0.1u
Z
CS 0603/Y5V/50V
0.1u
Z
CS 0603/Y5V/50V
0.1u
Z
CS 0603/Y5V/50V
0.1u
Z
CS 0603/Y5V/50V
0.1u
Z
CS 0603/Y5V/50V
0.1u
Z
CS 0603/Y5V/50V
0.1u
Z
AC0603470A 47P ± 10% INPAQ
BZV55-C5V6
PHILIPS
BAS32L SOD80C
PHILIPS
LL4148 3.5X1.5φ TEMIC GS08
BAS32L SOD80C
PHILIPS
LL4148 3.5X1.5φ TEMIC GS08
BAS32L SOD80C
PHILIPS
LL4148 3.5X1.5φ TEMIC GS08
BAS32L SOD80C
PHILIPS
LL4148 3.5X1.5φ TEMIC GS08
BAS32L SOD80C
PHILIPS
LL4148 3.5X1.5φ TEMIC GS08
BAS32L SOD80C
PHILIPS
LL4148 3.5X1.5φ TEMIC GS08
BZV55-C5V6
PHILIPS
BZV55-C5V6
PHILIPS
BZV55-C5V6
PHILIPS
BZV55-C5V6
PHILIPS
BAS32L SOD80C
PHILIPS
LL4148 3.5X1.5φ TEMIC GS08
BAS32L SOD80C
PHILIPS
LL4148 3.5X1.5φ TEMIC GS08
BAS32L SOD80C
PHILIPS
LL4148 3.5X1.5φ TEMIC GS08
BSS3-1/2H T=0.25 SN 3 μｍ
BSS3-1/2H T=0.25 SN 3 μｍ
BSS3-1/2H T=0.25 SN 3 μｍ
AME8805MEGT SOT-223
AME
TSU15AK PQFP-128
Mstar
MTV312M64-AJ PLCC44
MYSON
STK6006 PLCC44
Syntek
24LC16B/SN
MICROCHIP SO08
AT24C16AN-10SI-2.7 SOIC8 ATMEL
RC 0603 1/10W
0 ohm J
RC 0603 1/10W
0 ohm J
RC 0603 1/10W
0 ohm J
Z= 120ohm(100MHZ~) 0603 200mA
Z= 120ohm(100MHZ~) 0603 200mA
Z= 200ohm(100MHZ~) 0805 200mA
Z= 200ohm(100MHZ~) 0805 200mA
Z= 200ohm(100MHZ~) 0805 200mA
Z= 200ohm(100MHZ~) 0805 200mA
-33-
REMARK
04/25/2005
Belinea 101536(111514) Service Manual
LOC NO.
L111
L112
L113
L114
L115
P101
P102
P105
P107
Q103
Q103
Q104
Q104
Q106
Q106
Q107
Q107
Q108
Q108
Q109
Q109
Q110
Q111
Q111
R102
R103
R104
R106
R107
R108
R109
R110
R111
R112
R113
R114
R115
R116
R118
R119
R120
R121
R122
R123
R124
R125
R140
R141
R142
R144
R146
R148
R150
R153
R158
R159
R160
R161
R162
R163
R164
R168
R169
R170
R171
SOURCE
RA
RB
RA
RB
RA
RB
RA
RB
RA
RB
RA
RB
RA
RB
PART NO.
DESCRIPTION
SPECIFICATION
2379820196
2379820196
2379520196
2379520196
2379520196
2404371008
2404301112
2407630250
2404301107
2360100696
2360100796
2360100696
2360100796
2360301296
2360300896
2360301296
2360300896
2360501396
2360501296
2360301296
2360300896
2361111191
2360301296
2360300896
2253218296
2253210296
2253210396
2253210196
2253210396
2253227296
2253210296
2253210396
2253210196
2253210196
2251275096
2253210196
2253210196
2251275096
2253210196
2253210196
2251275096
2253210196
2253210196
2253210196
2253222296
2253222296
2251239006
2253210596
2253200096
2253233096
2253300096
2253300096
2253300096
2253300096
2253210596
2253247296
2253247296
2253222396
2253210196
2253210196
2253210196
2253247296
2253210396
2253222296
2253222296
BEAD,HI-IMPEDANCE
BEAD,HI-IMPEDANCE
BEAT,HI-CURRENT
BEAT,HI-CURRENT
BEAT,HI-CURRENT
CONNECTOR
CONNECTOR
SOCKET,SMD
CONNECTOR
XISTOR,PNP R SMD
XISTOR,PNP R SMD
XISTOR,PNP R SMD
XISTOR,PNP R SMD
XISTOR,NPN R SMD
XISTOR,NPN R SMD
XISTOR,NPN R SMD
XISTOR,NPN R SMD
FET,P-CH SMD
FET,P-CH SMD
XISTOR,NPN R SMD
XISTOR,NPN R SMD
XISTOR,PNP R
XISTOR,NPN R SMD
XISTOR,NPN R SMD
RES,CHIP 1/10W
RES,CHIP 1/10W
RES,CHIP 1/10W
RES,CHIP 1/10W
RES,CHIP 1/10W
RES,CHIP 1/10W
RES,CHIP 1/10W
RES,CHIP 1/10W
RES,CHIP 1/10W
RES,CHIP 1/10W
RES,CHIP 1/10
RES,CHIP 1/10W
RES,CHIP 1/10W
RES,CHIP 1/10
RES,CHIP 1/10W
RES,CHIP 1/10W
RES,CHIP 1/10
RES,CHIP 1/10W
RES,CHIP 1/10W
RES,CHIP 1/10W
RES,CHIP 1/10W
RES,CHIP 1/10W
RES,CHIP 1/10
RES,CHIP 1/10W
RES,CHIP 1/10W
RES,CHIP 1/10W
RES,CHIP 1/8
RES,CHIP 1/8
RES,CHIP 1/8
RES,CHIP 1/8
RES,CHIP 1/10W
RES,CHIP 1/10W
RES,CHIP 1/10W
RES,CHIP 1/10W
RES,CHIP 1/10W
RES,CHIP 1/10W
RES,CHIP 1/10W
RES,CHIP 1/10W
RES,CHIP 1/10W
RES,CHIP 1/10W
RES,CHIP 1/10W
Z= 200ohm(100MHZ~) 0805 200mA
Z= 200ohm(100MHZ~) 0805 200mA
Z= 200ohm 0805 I=2.0A
Z= 200ohm 0805 I=2.0A
Z= 200ohm 0805 I=2.0A
JST PH 9P TOP P=2.0 OR EQUAL
JST PH 13P SIDE P=2.0 OR EQUAL
6240-50-OR5P 0.5*50P KYOCERA
JST PH 8P SIDE P=2.0 OR EQUAL
PMBS3906
SOT-23
PHILIPS
MMBT3906
SOT-23
DIODES
PMBS3906
SOT-23
PHILIPS
MMBT3906
SOT-23
DIODES
MMBT3904
SOT-23
DIODES
MMBT3904
SOT-23 FAIRCHILD
MMBT3904
SOT-23
DIODES
MMBT3904
SOT-23 FAIRCHILD
AP2305N
SOT-23
APEC
AO3411
SOT-23
ALPHA
MMBT3904
SOT-23
DIODES
MMBT3904
SOT-23 FAIRCHILD
2SA1020(Y) TO-92
TOSHIBA
MMBT3904
SOT-23
DIODES
MMBT3904
SOT-23 FAIRCHILD
RC 0603 1/10W
1.8Kohm J
RC 0603 1/10W
1Kohm J
RC 0603 1/10W
10Kohm J
RC 0603 1/10W
100 ohm J
RC 0603 1/10W
10Kohm J
RC 0603 1/10W
2.7Kohm J
RC 0603 1/10W
1Kohm J
RC 0603 1/10W
10Kohm J
RC 0603 1/10W
100 ohm J
RC 0603 1/10W
100 ohm J
RC 0603 1/10W
75 ohm F
RC 0603 1/10W
100 ohm J
RC 0603 1/10W
100 ohm J
RC 0603 1/10W
75 ohm F
RC 0603 1/10W
100 ohm J
RC 0603 1/10W
100 ohm J
RC 0603 1/10W
75 ohm F
RC 0603 1/10W
100 ohm J
RC 0603 1/10W
100 ohm J
RC 0603 1/10W
100 ohm J
RC 0603 1/10W
2.2Kohm J
RC 0603 1/10W
2.2Kohm J
RC 0603 1/10W
390 ohm F
RC 0603 1/10W
1Mohm J
RC 0603 1/10W
0 ohm
J
RC 0603 1/10W
33 ohm J
RC 0805 1/8 W
0ohm
J
RC 0805 1/8 W
0ohm
J
RC 0805 1/8 W
0ohm
J
RC 0805 1/8 W
0ohm
J
RC 0603 1/10W
1Mohm J
RC 0603 1/10W
4.7Kohm J
RC 0603 1/10W
4.7Kohm J
RC 0603 1/10W
22Kohm J
RC 0603 1/10W
100 ohm J
RC 0603 1/10W
100 ohm J
RC 0603 1/10W
100 ohm J
RC 0603 1/10W
4.7Kohm J
RC 0603 1/10W
10Kohm J
RC 0603 1/10W
2.2Kohm J
RC 0603 1/10W
2.2Kohm J
-34-
REMARK
04/25/2005
Belinea 101536(111514) Service Manual
LOC NO.
SOURCE
R173
R174
R175
R176
R177
R178
R179
R180
R181
R182
R183
R184
R187
R189
R190
R191
R192
R193
R194
R196
R198
R199
R201
R202
RN1
RN2
RN3
RN4
RN5
U101
X101
X102
PART NO.
DESCRIPTION
SPECIFICATION
2253233296
2253210196
2253210196
2253233296
2253233296
2253210196
2253210196
2253210196
2253210196
2253210196
2253210196
2253210196
2253200096
2253210296
2253210296
2253210396
2253427296
2253300096
2253247296
2253222196
2253200096
2253200096
2379330006
2379330006
2259210308
2259210308
2259210308
2259210308
2259233008
2202517900
2369102901
2369103601
RES,CHIP 1/10W
RES,CHIP 1/10W
RES,CHIP 1/10W
RES,CHIP 1/10W
RES,CHIP 1/10W
RES,CHIP 1/10W
RES,CHIP 1/10W
RES,CHIP 1/10W
RES,CHIP 1/10W
RES,CHIP 1/10W
RES,CHIP 1/10W
RES,CHIP 1/10W
RES,CHIP 1/10W
RES,CHIP 1/10W
RES,CHIP 1/10W
RES,CHIP 1/10W
RES,CHIP 1/4
RES,CHIP 1/8
RES,CHIP 1/10W
RES,CHIP 1/10W
RES,CHIP 1/10W
RES,CHIP 1/10W
BEAD,HI-IMPEDANCE
BEAD,HI-IMPEDANCE
RES,CHIP NETWORKS
RES,CHIP NETWORKS
RES,CHIP NETWORKS
RES,CHIP NETWORKS
RES,CHIP NETWORKS
PCB MULTILAYER
XTAL,OSC
XTAL,OSC
RC 0603 1/10W
3.3Kohm J
RC 0603 1/10W
100 ohm J
RC 0603 1/10W
100 ohm J
RC 0603 1/10W
3.3Kohm J
RC 0603 1/10W
3.3Kohm J
RC 0603 1/10W
100 ohm J
RC 0603 1/10W
100 ohm J
RC 0603 1/10W
100 ohm J
RC 0603 1/10W
100 ohm J
RC 0603 1/10W
100 ohm J
RC 0603 1/10W
100 ohm J
RC 0603 1/10W
100 ohm J
RC 0603 1/10W
0 ohm
J
RC 0603 1/10W
1Kohm J
RC 0603 1/10W
1Kohm J
RC 0603 1/10W
10Kohm J
RC 1206 1/4 W
2.7Kohm J
RC 0805 1/8 W
0ohm
J
RC 0603 1/10W
4.7Kohm J
RC 0603 1/10W
220 ohm J
RC 0603 1/10W
0 ohm
J
RC 0603 1/10W
0 ohm
J
Z= 30ohm(200MHz~) 0603 300mA
Z= 30ohm(200MHz~) 0603 300mA
8P4R 1/16W 10Kohm
J P=0.8
8P4R 1/16W 10Kohm
J P=0.8
8P4R 1/16W 10Kohm
J P=0.8
8P4R 1/16W 10Kohm
J P=0.8
8P4R 1/16W 33ohm
J P=0.8
JT166HA18 M/B FR4*2 100*82
14.31818MHZ/49US
12.000MHZ/49US
REMARK
2363703800
2427408181
2403702513
2403702513
2403702513
2403702513
2403702513
2202125802
LED
WIRE HARNESS
SWITCH,TACT
SWITCH,TACT
SWITCH,TACT
SWITCH,TACT
SWITCH,TACT
PC BOARD
LED 3φ GRN/YEL
8P H/B 1061#26 L=180mm P=2.0
TSTA-2 4.3mm 160g
HUA JIE
TSTA-2 4.3mm 160g
HUA JIE
TSTA-2 4.3mm 160g
HUA JIE
TSTA-2 4.3mm 160g
HUA JIE
TSTA-2 4.3mm 160g
HUA JIE
JT166WP17 K/B CEM1 140*16 2.02
CAP,ELE 105'C
CAP,ELE 105'C
CAP,ELE 105'C
CAP,ELE 105'C
CAP,ELE 105'C
CAP,ELE 105'C
CAP,ELE 105'C
CAP,ELE 105'C
CAP,CER
CAP,CER
CAP,MTL MINI
CAP,CER
CAP,CER
CAP,ELE 105'C
CAP,PPP
CAP CER
CAP,CER
CAP,CER
CAP,ELE 105'C
EC 470u/ 16V
10*12.5
EC 10u/ 50V
5*11
EC
1u/ 50V
5*11
EC
1u/ 50V
5*11
EC 470u/ 16V
10*12.5
EC 470u/ 16V
10*12.5
EC 220u/ 16V
8*11
EC 10u/ 50V
5*11
CK45F 1000.000PF 50V
CK45F 1000.000PF 50V
X2 0.47u/275V
Y1 CAP 3300P/250V
Y1 CAP 3300P/250V
EC 82u/400V 18*32
PPN 2700P/250V
CK45B
100.000PF 125'C
CC
180p/500V
CC 0.01u/50V
EC 47u/ 35V
6.3*11
CON P.C.BOARD
D701
P701
S701
S702
S703
S704
S705
U701
POWER P.C.BOARD
C601
C602
C603
C604
C605
C606
C610
C615
C616
C617
C801
C802
C803
C805
C806
C807
C808
C809
C810
2333347791
2333610691
2333610501
2333610501
2333347701
2333347701
2333322701
2333610691
2281410291
2281410291
2300947401
2287133212
2287133212
2334382608
2297427212
2284110191
2283118191
2281410391
2333547691
-35-
P=5.0
P=5.0
P=2.0
P=2.0
P=5.0
P=5.0
P=3.5
P=5.0
T
T
P=15.0
K
K
P=7.5
P=10.0
K
P=5.0
P=5.0
P=5.0
04/25/2005
Belinea 101536(111514) Service Manual
LOC NO.
C811
C814
C815
C816
C817
C819
C820
C821
C822
C823
C825
C901
C902
C903
C904
C905
C906
C907
C908
C909
C910
C911
C912
C913
C914
C915
C916
C917
C919
D601
D801
D801
D801
D802
D802
D802
D803
D803
D803
D804
D804
D804
D806
D806
D807
D807
D808
D809
D809
D809
D810
D810
D811
D811
D812
D814
D814
D814
D901
D901
D902
D903
D904
D905
D906
SOURCE
RA
RB
RC
RA
RB
RC
RA
RB
RC
RA
RB
RC
RA
RB
RA
RB
RA
RB
RC
RA
RB
RA
RB
RA
RB
RC
RA
RB
PART NO.
DESCRIPTION
SPECIFICATION
2333522691
2284110291
2284110291
2335310841
2335310841
2335310841
2333347701
2290410391
2333647591
2287210312
2281410491
2333347701
2281410491
2281433291
2281433291
2290427391
2272133191
2272127091
2281410491
2281410491
2290410391
2275450901
2290433291
2290422291
2275420001
2275420001
2281410491
2290422391
2336347691P
2363600195
2363221195
2363227295
2363233795
2363221195
2363227295
2363233795
2363221195
2363227295
2363233795
2363221195
2363227295
2363233795
2363231995
2363223195
2363220395
2363226995
2363600195
2363300282
2363231212
2363234012
2363231612
2363225012
2363231612
2363225012
2363505995
2363517695
2363518385
2363517995
2364600996
2364601096
2363600195
2363600195
2363600195
2363600195
2363516895
CAP ELE 105'C
CAP,CER
CAP,CER
CAP,ELE L ESR 105'C
CAP,ELE L ESR 105'C
CAP,ELE L ESR 105'C
CAP,ELE 105'C
CAP,MYL
CAP,ELE 105'C
CAP,CER
CAP,CER
CAP,ELE 105'C
CAP,CER
CAP,CER
CAP,CER
CAP,MYL
CAP,CER
CAP,CER
CAP,CER
CAP,CER
CAP,MYL
CAP,CER
CAP,MYL
CAP,MYL
CAP CER
CAP CER
CAP,CER
CAP,MYL
CAP,MINI ELE 105'C
DIODE,SWITCH
DIODE,RECT
DIODE,RECT
DIODE,RECT
DIODE,RECT
DIODE,RECT
DIODE,RECT
DIODE,RECT
DIODE,RECT
DIODE,RECT
DIODE,RECT
DIODE,RECT
DIODE,RECT
DIODE,RECT
DIODE,RECT
DIODE,RECT
DIODE,RECT
DIODE,SWITCH
DIODE,SCHOTTKY
DIODE,RECT
DIODE,RECT
DIODE,RECT
DIODE,RECT
DIODE,RECT
DIODE,RECT
DIODE,ZENER
DIODE,ZENER
DIODE,ZENER
DIODE,ZENER
DIODE,SWITCH SMD
DIODE,SWITCH SMD
DIODE,SWITCH
DIODE,SWITCH
DIODE,SWITCH
DIODE,SWITCH
DIODE,ZENER
EC 22u/ 35V 5*11
P=5.0
CC 1000P/1KV X7R
P=5.0
CC 1000P/1KV X7R P=5.0
K
EC 1000u/ 16V
10*16
P=5.0
EC 1000u/ 16V
10*16
P=5.0
EC 1000u/ 16V
10*16
P=5.0
EC 470u/ 16V
10*12.5 P=5.0
MEF COA MEF 0.01u/50V
P=5.0
EC 4.7u/ 50V 5*11
P=5.0
CK45F
0.010UF 250VA M KC
CC 0.1u/ 50V Y5V
P=5.0
EC 470u/ 16V
10*12.5 P=5.0
CC 0.1u/ 50V Y5V
P=5.0
CK45F 3300.000PF 50V
T
CK45F 3300.000PF 50V
T
MEF COA MEF 0.027u/50V
P=5.0
TC 330p/50V CH
P=5.0
TC 27p/50V CH
P=5.0
CC 0.1u/ 50V Y5V
P=5.0
CC 0.1u/ 50V Y5V
P=5.0
MEF COA MEF 0.01u/50V
P=5.0
TC
5P/3KV SL
P=7.5
MEF COA MEF 3300p/50V
P=5.0
MEF COA MEF 2200p/50V
P=5.0
TC 20P/3KV SL
P=7.5
TC 20P/3KV SL
P=7.5
CC 0.1u/ 50V Y5V
P=5.0
CQ93M
0.022UF 50V
J
EC 47u/ 16V 5*7
P=5.0
1N4148 DO-35
PG208
2A07 DO-15 1000V/2A
PS2010 2A/1000V DO-15
PG208
2A07 DO-15 1000V/2A
PS2010 2A/1000V DO-15
PG208
2A07 DO-15 1000V/2A
PS2010 2A/1000V DO-15
PG208
2A07 DO-15 1000V/2A
PS2010 2A/1000V DO-15
UF4007
PEC
UF4007
GS
UF4004G T/B
PEC
UF4004
CHENMKO
1N4148
31DQ06FC3 60V/1.6A H=9.8 IR
SB360(F9) 3A/60V DO-201AD PEC
SR306 DO-201AD
MOSPEC
31DF2
IR(NI)
ER302(F9) DO-201AD
PEC
31DF2
IR(NI)
ER302(F9) DO-201AD
PEC
HZ12A-2 11.9-12.4V 0.5W HITACH
HZ18-2 17.5-18.3V 0.5W HITACHI
BZX79B18 17.6~18.4V PHILIPS
TZX18B 17.5-18.3V TELEFUNKEN
BAV99 SOT-23
DIODES
BAV99 SOT-23
PHILIPS
1N4148
1N4148
1N4148
1N4148
HZ6B-2
HITACHI
-36-
REMARK
04/25/2005
Belinea 101536(111514) Service Manual
LOC NO.
SOURCE
PART NO.
DESCRIPTION
SPECIFICATION
F801
F801
I601
I801
I802
I802
I803
I803
I803
I803
I901
I902
I902
L601
L602
L603
L604
L605
L606
L805
L807
P601
P603
P801
P901
P902
Q601
Q601
Q601
Q801
Q801
Q801
Q801
Q802
Q802
Q802
Q802
Q802
Q803
Q803
Q804
Q804
Q804
Q901
Q901
Q901
Q902
Q902
Q902
Q903
Q903
Q903
Q905
Q905
Q905
R601
R602
R610
R612
R613
R619
R620
R621
R622
R623
RA
RB
2213125207
2213125211
2365329700
2365330900
2362401800
2362401600
2365328191
2365321991
2365327691
2365319391
2365331000
2360608596
2360609296
2379822106
2379822106
2379822106
2379101495
2379101495
2379101495
2371145301
2371150901
2404371003
2405106000
2427409001
2404380202
2404380202
2361316191
2361302591
2361313691
2361610600
2361610700
2361611700
2361611600
2360301696
2360301296
2360301896
2360300596
2360300296
2361315391
2361412691
2360100696
2360100796
2360100396
2360608496
2360609096
2360609196
2360608496
2360609096
2360609196
2361316191
2361302591
2361313691
2361316191
2361302591
2361313691
2233410495
2233439295
2253410396
2233410395
2233410395
2251400096
2253447296
2253422296
2233410195
2233410195
FUSE
FUSE
IC,LINEAR
IC,LINEAR
PHOTO COUPLR
PHOTO COUPLR
IC,LINEAR
IC,LINEAR
IC,LINEAR
IC,LINEAR
IC,LINEAR
FET,N-CH(SMD)
FET,N-CH(SMD)
BEAD,HI-IMPEDANCE
BEAD,HI-IMPEDANCE
BEAD,HI-IMPEDANCE
FERRITE CORE
FERRITE CORE
FERRITE CORE
COIL,CHOKE
COIL,CHOKE
CONNECTOR
EARPHONE JACK
WIRE HARNESS
CONNECTOR
CONNECTOR
XISTOR,NPN R
XISTOR,NPN R
XISTOR,NPN R
FET,N-CH
FET,N-CH
FET,N-CH
FET,N-CH
XISTOR,NPN R SMD
XISTOR,NPN R SMD
XISTOR,NPN R SMD
XISTOR,NPN R SMD
XISTOR,NPN R SMD
XISTOR,NPN R
XISTOR,NPN A
XISTOR,PNP R SMD
XISTOR,PNP R SMD
XISTOR,PNP R SMD
FET,N-CH(SMD)
FET,N-CH(SMD)
FET,N-CH(SMD)
FET,N-CH(SMD)
FET,N-CH(SMD)
FET,N-CH(SMD)
XISTOR,NPN R
XISTOR,NPN R
XISTOR,NPN R
XISTOR,NPN R
XISTOR,NPN R
XISTOR,NPN R
RES,CBN 1/4 S
RES,CBN 1/4 S
RES,CHIP 1/4
RES,CBN 1/4 S
RES,CBN 1/4 S
RES,CHIP 1/4
RES,CHIP 1/4
RES,CHIP 1/4
RES,CBN 1/4 S
RES,CBN 1/4 S
FUSE 2.5A/250V 21502.5 LITTEL
FUSE 2.5A/250V SG501302.5 PICO
TDA7496L DIP-20P
SGS
LD7552IN DIP-8
LEADTREND
TLP621(D4-GR-LF2) TOSHIBA
TLP721F(D4-GR)
TOSHIBA
AP431VA
TO-92
ATC
KA431AZTA
TO-92 FAIRCHILD
CM431BCN
CHAMPION
TL431CLP
TI
OZ9930D PDIP-8
O2-MICRO
AP9960M SO-8
APEC
FDS9945 SO-8
FAIRCHILD
Z= 220ohm(200MHZ~) 0805 200mA
Z= 220ohm(200MHZ~) 0805 200mA
Z= 220ohm(200MHZ~) 0805 200mA
3.5X9X0.8
3.5X9X0.8
3.5X9X0.8
45mH ET-20 2UEW 0.26mm/55+55Ts
5uH 0.5mm*19Ts R3*15 I=2.0A
JST PH 4P TOP P=2.0 OR EQUAL
2SJ-P520-A04 (577C) SINGATRON
9/9P H/B 1007#26 L=80mm P=2.0
WBT CONN. P=8.0mm 2P
WBT CONN. P=8.0mm 2P
2PC945P
PHILIPS
2SC945(P) TO-92
NEC
KSC945C-G
FAIRCHILD
PHX4NQ60E TO-220AB
PHILIPS
SSS4N60B TO-220F
FAIRCHILD
FQPF5N60C TO-220F FAIRCHILD
AP03N70F-A TO-220FM
APEC
PMBS3904
SOT-23
PHILIPS
MMBT3904
SOT-23
DIODES
MMBT3904LT1 SOT-23
LRC
MMBT3904-7 SOT-23
VISHAY
HMBT3904
SOT-23
HI-SIN
2SC2001(L)
NEC
KSD1616A-G TO-92
FAIRCHILD
PMBS3906
SOT-23
PHILIPS
MMBT3906
SOT-23
DIODES
MMBT3906-7 SOT-23
VISHAY
2N7002K SOT-23
VISHAY
2N7002K SOT-23
PHILIPS
2N7002L SOT-23
ON
2N7002K SOT-23
VISHAY
2N7002K SOT-23
PHILIPS
2N7002L SOT-23
ON
2PC945P
PHILIPS
2SC945(P) TO-92
NEC
KSC945C-G
FAIRCHILD
2PC945P
PHILIPS
2SC945(P) TO-92
NEC
KSC945C-G
FAIRCHILD
RD 1/4WS 100Kohm J T52
RD 1/4WS 3.90K J T52
MINI
RC 1206 1/4 W
10Kohm J
RD 1/4WS 10Kohm J T52
RD 1/4WS 10Kohm J T52
RC 1/4W
0.00
F
RC 1206 1/4 W
4.7Kohm J
RC 1206 1/4 W
2.2Kohm J
RD 1/4WS 100 ohm J T52
RD 1/4WS 100 ohm J T52
RA
RB
RA
RB
RC
RD
RA
RB
RA
RB
RC
RA
RB
RC
RD
RA
RB
RC
RD
RE
RA
RB
RA
RB
RC
RA
RB
RC
RA
RB
RC
RA
RB
RC
RA
RB
RC
-37-
REMARK
04/25/2005
Belinea 101536(111514) Service Manual
LOC NO.
R802
R803
R804
R805
R806
R807
R808
R809
R810
R813
R814
R815
R816
R817
R818
R819
R820
R821
R822
R823
R824
R826
R827
R828
R829
R830
R831
R832
R833
R835
R836
R837
R838
R839
R840
R841
R901
R902
R903
R904
R905
R906
R907
R908
R909
R910
R911
R912
R913
R915
R917
R918
R920
R921
R924
S801
S801
S802
S803
T801
T901
U801
SOURCE
RA
RB
PART NO.
DESCRIPTION
SPECIFICATION
2229201212
2253456496
2253456496
2253456496
2232656395
2233422095
2251410036
2233447095
2253410096
2251440286
2251440286
2251440286
2251440286
2233422095
2233410095
2233412395
2239222015
2239210005
2239227415
2239220025
2232412295
2235647013
2233410195
2233410395
2253433296
2253456496
2233410095
2233422095
2253410296
2253456496
2251453636
2251453636
2251453636
2253410296
2253427196
2253433296
2233447995
2233447995
2253351596
2253310096
2253310096
2239282525
2239290925
2251310036
2253310596
2233410095
2253310096
2233422295
2233410495
2233412295
2242330595
2251349916
2253310596
2251341206
2251335706
2407413100
2407413300
2407200991
2407200991
2374228004
2374300700
2202130500
THERMISTOR,PTH
RES,CHIP 1/4
RES,CHIP 1/4
RES,CHIP 1/4
RES,CBN 1/2
RES,CBN 1/4 S
RES,CHIP 1/4
RES,CBN 1/4 S
RES,CHIP 1/4
RES,CHIP 1/4
RES,CHIP 1/4
RES,CHIP 1/4
RES,CHIP 1/4
RES,CBN 1/4 S
RES,CBN 1/4 S
RES,CBN 1/4 S
RES,PRE 1/4 S
RES,PRE 1/4 S
RES,PRE 1/4 S
RES,PRE 1/4 S
RES,CBN 1/4
RES,MTL 3
RES,CBN 1/4 S
RES,CBN 1/4 S
RES,CHIP 1/4
RES,CHIP 1/4
RES,CBN 1/4 S
RES,CBN 1/4 S
RES,CHIP 1/4
RES,CHIP 1/4
RES,CHIP 1/4
RES,CHIP 1/4
RES,CHIP 1/4
RES,CHIP 1/4
RES,CHIP 1/4
RES,CHIP 1/4
RES,CBN 1/4 S
RES,CBN 1/4 S
RES,CHIP 1/8
RES,CHIP 1/8
RES,CHIP 1/8
RES,PRE 1/4 S
RES,PRE 1/4 S
RES,CHIP 1/8
RES,CHIP 1/8
RES,CBN 1/4 S
RES,CHIP 1/8
RES,CBN 1/4 S
RES,CBN 1/4 S
RES,CBN 1/4 S
H/V RESISTOR
RES,CHIP 1/8
RES,CHIP 1/8
RES,CHIP 1/8
RES,CHIP 1/8
SOCKET (AC INLET)
SOCKET (AC INLET)
HOLDER,FUSE
HOLDER,FUSE
XFORMER,POWR
XFORMER INVERTER
PC BOARD
SCK-103 10+-20% 3A THINKING
RC 1206 1/4 W
560Kohm J
RC 1206 1/4 W 560Kohm
J
RC 1206 1/4 W 560Kohm
J
RD 1/2W
56Kohm J
RD 1/4WS 22.00 J T52
MINI
RC 1206 1/4 W 100Kohm
F
RD 1/4WS 22.00 J T52
MINI
RC 1206 1/4 W
10ohm
J
RC 1206 1/4 W 4.02 ohm
F
RC 1206 1/4 W 4.02 ohm
F
RC 1206 1/4 W 4.02 ohm
F
RC 1206 1/4 W 4.02 ohm
F
RD 1/4WS 22.00 J T52
MINI
RD 1/4WS 10 ohm J T52
RD 1/4WS 12Kohm J T52
RN 1/4WS 2.20K F T52 MINI
RN 1/4WS 100.00 F
RN 1/4WS 2.74K F T52 MINI
RN 1/4WS 20.00K F T52 MINI
RD 1/4W 1.2Kohm P=10.0
J
RS 3WS 47ohm
P=20.0
J
RD 1/4WS 100 ohm J T52
RD 1/4WS 10Kohm J T52
RC 1206 1/4 W 3.3Kohm
J
RC 1206 1/4 W
560Kohm J
RD 1/4WS 10 ohm J T52
RD 1/4WS 22.00 J T52
MINI
RC 1206 1/4 W
1Kohm
J
RC 1206 1/4 W 560Kohm
J
RC 1206 1/4 W 536Kohm
F
RC 1206 1/4 W 536Kohm
F
RC 1206 1/4 W 536Kohm
F
RC 1206 1/4 W
1Kohm
J
RC 1206 1/4 W 270 ohm
J
RC 1206 1/4 W 3.3Kohm
J
RD 1/4WS 4.70
J
RD 1/4WS 4.70
J
RC 0805 1/8W
5.1Mohm J
RC 0805 1/8 W
10ohm
J
RC 0805 1/8 W
10ohm
J
RN 1/4WS 82.5Kohm
F
RN 1/4WS 90.9Kohm
F
RC 0805 1/8 W
100Kohm F
RC 0805 1/8 W
1Mohm J
RD 1/4WS 10 ohm J T52
RC 0805 1/8 W
10ohm
J
RD 1/4WS 2.2Kohm J T52
RD 1/4WS 100Kohm J T52
RD 1/4WS 1.20K J T52
MINI
RD 1/2W 3.00M
J
RC 0805 1/8W
4.99Kohm F
RC 0805 1/8 W
1Mohm J
RC 0805 1/8W
412 ohm F
RC 0805 1/8 W
357 ohm F
0711-2-P10-9
INALWAYS
SC-8R-F15A9
SUPERCOM
CQ-05T (5mm DIA FUSE)
CQ-05T (5mm DIA FUSE)
JT166W18 ER-28
EEL-19 16/2080Ts 0.4/0.045mm
JT166WP18-1 P/B FR1 160*125
REMARK
OTHERS
-38-
04/25/2005
Belinea 101536(111514) Service Manual
LOC NO.
K901
P951
P961
P962
P981
P985
V901
W901
W902
SOURCE
PART NO.
DESCRIPTION
SPECIFICATION
2427307102
2427130055
2427501173
2427700015
2420309501
2427404320
2212006000
2391301081
2391301082
LUG W/WIRE
POWER CORD
I/O CABLE
CABLE
FFC CABLE
WIRE HARNESS
LCD PANEL
SPEAKER ASS'Y
SPEAKER ASS'Y
φ4.3*2 1007#18+CORE BLK 100
GERMAN WALL
1.83M GE96750
D15/C13 20276(3+6) 1.83M 96750
EAR 3.5(577C) 1.83M GE96750
FFC 50P*0.5*L90mm
4/2+2P 1007#24 260/320 P=2/2.5
CLAA150XP02
CPT
1W 8ohm 52*19.5*14
(R)
1W 8ohm 52*19.5*14
(L)
-39-
REMARK
04/25/2005