HYDRAULIC FLUID MATERIAL SAFETY DATA SHEET

S.A.M.
LOW TEMPERATURE
HYDRAULIC FLUID
MATERIAL SAFETY DATA SHEET
SL;FS Lubricants
Material Safefv Data Sheet
Trade Name:
1-
SECTION
POLAR ICE H}'BRAIfLIC OIL
CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
Manufacturer
SLiPS
Address
146 Erie Industrial Park
Port Clinton, OH 43452
tr
MSDS
ubricants
CAS
#
Number MIXTURE
DatePrepared
PhoneNumber 419-635-2100
Emergency
Number N/A
419-543-1356
Pro<iuctChemicalName PETROLEUM OIL
10/01/2005
Prepared
By
STANLEY SENSMEIER
Intended
Use
Eydraulic Oil
DATA CONTAII{ED HEREIN IS PURSTJANT TO TI{E AI{SI Z4OO.I STANDARD
SECTION
II.
COMPOSITION AND INFOR.MATION ON INGREDIENTS
COMPONENENTS CHEMICAL NAME
o/oY
OSTLA PEL
ACGTH TLV
LIMITS
Naphthenic Petroleum Oil
80-950%
N/A
N/A
N/A
Acr-vlic Polymer
3-l0o/o
N/A
N/A
N/A
Proprie tar-v Additives
1-3o/o
N/A
N/A
N/A
SECTION
Boiling
Vapor
IlI
- PHYSICAL /
CHEMICAL CHARACTERISTICS
Point 500*
Specific Gravity
Pressure 0.0 mm Hg at
Vapor Density
Solubility in
(air:l)
Water
70*F
Melting
Point
N/A
Evaporation Rate (Butyl Acetate=l) 0.001
INSOLUBLE
Water
Reactive
N/A
Appearance
VOC
Content NiA
DensitY
of3
0.88
>10
PH
Page 1
(FLO=I)
&
Odor
N/A
AMBER or BLLIE, PETR0LEUM oDoR
7'3 lb'
SECTION IV.I{AZARDOUS IDENTIFICATION. FIRST AID MEASURES
&
EXPOSURE CONTROL
FIRST AID
EFFECT OF EXPOSURE
SPECIAL
PROTECTION
MEASUR.ES
EYE
Direct Contnct with materiEl or
CONTACT
exposure to vapors mav tause
INILALATION
High concentrations ofvapor or mist
irritatiou.
may
irritate thc respiratory trecl
F
or direct contact, flush eyes
with water, holding eyelids
apart for tr5 minutes. Get
medical attention if irritrtion
or pain persists.
Wear eye protection.
Remove to fresh air, if not
breathing, give artificial
Use
respiration. If breathing ir
di{ficult, give oxygen. Seek
medieal aftention if breething
difliculties pcrsists.
INGESTION
May cause throfit irritalion, nauser,
vomiting and diarrher. Breathing
material into the Iutrgs dmring ingestion
or vomiting may csuse luing injury.
Immediately g€t medical
attcntion. DO NOT iuduce
vomiting. Ifspontaneous
vomiting occurs. keep head
below hips to avoid breathing
material into lungs.
Direct contact with material or
Remove contaminated
clothing end shoes. Wash skin
thoroughl.v with soap nnd
water. Get medical sttetrtion
ifirrigation or pain persists.
SKIN
exposure to vapors is not expecied to
cause irritstion. A single, prolonged
exposure is not likely to result in the
material being ebsorbed through the
skin io harmful amounts"
ABSORPTION
NOISII/MSILA approved
respimtory protective
equipment when
concentrafion of vapor or
mist exceeds applicable limits.
Use good persond hygiene,
Wash thoroughly with soap
and water after handling and
before eaiing. drinking, or
smoking.
SECTION V - STABILITY AND REACTION
X Stable
Stability:
Incompatibility (material to
Hazardous Decornposition
Hazardous
avoid):
Products:
Unstable
Avoid oxidizing agents.
None under nonnal temperatures and pressures,
Polymerization: X Will not occur_ May occur
SECTION IV - ACCIDENTAL RELEASE AND DISPOSAL MEASURES
Steps to be taken in case material is releasod or spilled:
Contain spill ad r€cover free liquid by absorbing with a suitable material. Rinse spill site with clean n'ater.
Waste disposal method:
Disposal of absorbent material in accordance with federal, state, and local regulations.
SECTION
Paee
VII,
2 of3
HANDLING AND STORAGE
Precautions to be taken in handling and storing:
Store away from strong oxidizers, strong acids and alkalis. Keep container closed when not dispensing, Keep
from freeing. Always wear protective squipment.
Other Precautions:
Good personal hygiene is important. Keep area clean and wash hands before eating.
SECTION
Flash
VIII. FIRE FIGIITING MEASURES
Point
Method
330*F
Flammabilitylimits
Used COC
Extinguisher
in
LEL:
UEL:
Air % by Vol.
lVo
l0o/"
Carbon Dioxide, dry chemical' regular foam or water spray
Media
HMIS
Rating
Special fire
Fighting
Procedures
Health
0
Fire
1
Reactivity
0
Specific Hazard 0
Keep storage containers cool with water spray. Positive-pressure
self contained breathing aFlparatus (SCBA) and structural firefighters
protective clothing may pr,ovide limited protection.
SECTION IX - TOXICOLOGICAL INFOR.MATION
data:
N/A
Carcinogens:
N/A
Clinical test
SECTION X - ECOLOGICAL INFORMATION
Ecological Impact
Ecotoxicology
data:
data:
N/A
N/A
SECTION XI - TRANSPORTATION
DOT Labeling
N/A
Information
Proper Shipping Name:
N/A
Hazard Class:
Classification:
Hazard
ldentification
Packing
Group:
Number: N/A
SECTION XII - REGULATION
Categories or Components under SARA Title ltr:
Components Listed in the TSCA Inventory:
RCRA Hazardous Waste Codes:
CERCLA Reportable Quantity:
Page 3
of3
WHMIS
1\/A