Pure Lead AGM Batteries

Pure Lead AGM Batteries
Engineered for the most demanding applications
Ultra High Performance
Date: 09-21-11
ECO: 1666-S11
DCN: SES-541-12-01
Proudly Manufactured in the USA
Pure Lead AGM Batteries
Approved as a non-hazardous cargo for
ground, sea, and air transport.
DOT 49CFR173.159(d). (i)and (ii)
No water levels to check, no terminals to clean
Can deliver up to 2150 pulse amps ensuring
the quickest starts every time
Can be cycled over 400 times to 80% depth of
discharge making it the best deep cycle
battery available
Recharges more quickly than conventional
batteries allowing constant engine Stop/Starts
to help with no idle law challenges
No surprises, unlike conventional batteries
Pure Lead technologies almost never
experience catastrophic failure
Batteries are built to exact BCI standards
ensuring an OEM fit every time
Robotic assembly and state of the art plate
forming process ensures the most consistent,
high quality built battery every time
NorthStar is registered to ISO 9001 & ISO
14001 standards
Automotive and Commercial
PL-AGM 24
Battery
PL-AGM 27
PL-AGM 31
PL-AGM 34 PL-AGM 34/78
PL-AGM 35
PL-AGM 65
PL-AGM 78
BCI Group Number
24
27
31
34
34/78
35
65
78
Height w/ Terminal
8.75 in
8.75 in
9.25 in
7.77 in
7.77 in
8.54 in
7.42 in
7.12 in
Width
6.77 in
6.77 in
6.77 in
6.75 in
6.99 in
6.76 in
7.32 in
6.99 in
Length w/ Rib
10.87 in
12.44 in
12.91 in
10.87 in
10.87 in
9.45 in
11.76 in
10.87 in
Weight
59.5 lbs
70.3 lbs
76.2 lbs
51.1 lbs
51.1 lbs
48.9lbs
55.8 lbs
51.1 lbs
Terminal Configuration
SAE
SAE
SAE
SAE
SAE
SAE
SAE
SAE
Pulse Cranking Amps
1500A
1750A
2150A
1500A
1500A
1400A
1750A
1500A
Cold Cranking Amps at 0˚ F
840A
930A
1150A
880A
880A
740A
930A
880A
Marine Cranking Amps
1010A
1080A
1370A
1050A
1050A
850A
1070A
1050A
Reserve Capacity
160 min
190 min
205 min
134 min
134 min
115 min
135 min
134 min
Capacity - 20 Hour Rate
76.6Ah
89.9Ah
102.7Ah
70.3Ah
70.3Ah
67.4Ah
73.0Ah
70.3Ah
Capacity - 10 Hour Rate
73.6Ah
88.0Ah
92.6Ah
61.4Ah
61.4Ah
59.0Ah
65.2Ah
61.4Ah
Internal Resistance
3.0 mΩ
2.6 mΩ
2.2 mΩ
3.6mΩ
3.6mΩ
3.8 mΩ
3.3 mΩ
3.6mΩ
Short Circuit Current
3100A
5000A
5000A
3100A
3100A
3100A
5000A
3100A
4 years full
4 years full
4 years full
4 years full
4 years full
4 years full
4 years full
4 years full
Warranty
Date: 09-21-11
ECO: 1666-S11
DCN: SES-541-12-01
Proudly manufactured in the USA.
In the industry’s newest and
most advanced lead acid
manufacturing facility.
Specialty • Marine • Stereo
RV and Marine
Battery
PL-AGM 24M
PL-AGM 27M
PL-AGM 31M
PL-AGM 34M
PL-AGM 65M
SMS-AGM 220
BCI Group Number
24
27
31
34
65
Specialty
Specialty
Height w/ Terminal
8.75 in
8.75 in
9.78 in
7.80 in
7.42 in
11.30 in
12.60 in
Width
6.77 in
6.77 in
6.77 in
6.75 in
7.32 in
4.24 in
4.92 in
Length w/ Rib
10.87 in
12.44 in
12.91 in
10.87 in
11.76 in
15.59 in
22.05 in
Weight
59.5 lbs
70.3 lbs
76.2 lbs
51.1 lbs
55.8 lbs
78.5 lbs
131.2 lbs
Terminal Configuration
Marine
Marine
Marine
Marine
Marine
Bolt in
Bolt in
Pulse Cranking Amps
1500A
1750A
2150A
1500A
1750A
1750A
2150A
Cold Cranking Amps at 0˚ F
840A
930A
1150A
880A
930A
950A
1400A
Marine Cranking Amps
1010A
1070A
1370A
1050A
1070A
1260A
1700A
Reserve Capacity
160 min
190 min
205 min
134 min
135 min
220 min
400 min
Capacity - 20 Hour Rate
76.6Ah
89.9Ah
102.7Ah
70.3Ah
73.0Ah
107.5Ah
185.8Ah
Capacity - 10 Hour Rate
73.6Ah
88.0Ah
92.6Ah
61.4Ah
65.2Ah
103.0Ah
176.5 Ah
Internal Resistance
3.0 mΩ
2.6 mΩ
2.2 mΩ
3.6mΩ
3.3 mΩ
3.4 mΩ
2.7 mΩ
Short Circuit Current
3100A
5000A
5000A
3100A
5000A
3500A
5000A
3 years full
3 years full
3 years full
3 years full
3 years full
2 years full
2 years full
Warranty
Date: 09-21-11
SMS -AGM 400
ECO: 1666-S11
DCN: SES-541-12-01
SLI PRODUCT LIMITED WARRANTY
WARRANTY
NorthStar Battery Company (NSB) warrants its batteries (hereafter referred to as “Battery”) to be free of defects in material and workmanship for the earlier of (a) the
Applicable Warranty Period or (b) within 400 cycles to 80% depth of discharge, whichever occurs first. The Applicable Warranty Period is (4) years in automotive and
commercial applications, (3) years in marine applications. The Applicable Warranty Period begins from the date of purchase with original receipt. Within the
Applicable Warranty Period, the battery will be replaced free of charge if, at the discretion of NSB, adjustment is necessary due to defect in material or workmanship
(not merely discharged). Batteries for warranty replacement consideration are to be returned to the original supplying distributor/dealer with original receipt. The
original battery sale receipt must be maintained for any claims.
GENERAL PROVISIONS
A. NSB has no obligation under the limited warranty and set forth above in the event the Battery is
damaged or destroyed as a result of one or more of the following:
• Willful abuse or neglect or if the top decorative cover has been removed.
• Natural forces such as wind, lightning, hail; damage due to fire, collision, explosion, vandalism,
theft, penetration or opening of the Battery case in any manner.
• Overcharging, undercharging, leaving in a discharged state, charging or installing in reverse
polarity, improper maintenance, allowing the Battery to be deeply discharged via parasitic load or
mishandling of the Battery such as but not limited to using the terminals for lifting or carrying the
Battery. Trickle chargers that do not have a regulated trickle charge voltage between 13.5V and
13.8V (no lower than 13.5V and no higher than 13.8V) will cause early failure of the Battery. Use of
such chargers with the Battery will also void the Battery’s warranty.
• Normal deterioration in the electrical qualities or the acceleration of such deterioration due to
conditions that accelerate such deterioration.
• If the Battery is used in an application that requires higher cranking power or a greater reserve
rating than the Battery is designed to deliver, or the Battery capacity is less than the Battery capacity
specified by the vehicle manufacturer, or the Battery is otherwise used in an application for which it
was not designed.
• Prolonged storage of vehicles with fuel injection computers, alarms, GPS and other electrical
devices that require continuous battery power to support active memories; this power drain must
be offset with a maintenance-float charger, periodic charging or disconnecting the battery to
prevent the establishment of irreversible crystallization sulphation in the battery plate oxide. Failure
to address this destroys battery capacity and voids the warranty, as this is not a warranted defect in
materials or workmanship. A battery with an open circuit voltage (OCV) of equal to or less then 10.0V
will be deemed as over discharged and void from warranty due to misuse and/or neglect.
• WARNING – Do NOT use any type of oil, organic solvent, alcohol, detergent, strong acids, strong
alkalis, petroleum-based solvent or ammonia solution to clean the jars or covers. These materials
may cause permanent damage to the battery casing and cover and will void the warranty.
B. To obtain warranty service:
• Return the Battery to the original NorthStar Battery wholesaler or dealer.
• If the Battery is determined by NSB, in its sole discretion, to be defective for material or workmanship under terms of this limited warranty, it will be replaced.
• NSB’s acceptance of any items shipped to NSB shall not be deemed an admission that the items so
shipped are defective. Any items shipped back to NSB, shall in NSB’s sole discretion, become NSB’s
sole property.
ALL BATTERIES ARE DESIGNED TO MEET CERTAIN PERFORMANCE SPECIFICATIONS, SUCH AS COLD
CRANKING AMPS AND RESERVE CAPACITY, BUT DUE TO VARYING USES AND OPERATING
CONDITIONS, IT IS IMPOSSIBLE TO ANTICIPATE THE USEFUL LIFE OF THISBATTERY, OR ANY OTHER
BATTERY. IF THIS BATTERY SHOULD MATERIALLY FAIL DURING THE WARRANTY PERIOD, THIS
LIMITED WARRANTY SHALL CONTROL THE TERMS FOR ADJUSTMENT. NORTHSTAR BATTERY’S
LIABILITY IS LIMITED TO REPLACEMENT OF THE BATTERY ACCORDING TO THE TERMS STATED
ABOVE. NORTHSTAR BATTERY WILL NOT BE RESPONSIBLE FOR ANY EXPENSES FOR INSTALLATION,
TOWING, ELECTRICAL SYSTEM TESTS, CHARGING A BATTERY, LOSS OF TIME, OR OTHER EXPENSES
WHICH WOULD BE CONSIDERED AS INCIDENTAL OR CONSEQUENTIAL DAMAGES.
All NorthStar Battery products are
proudly manufactured in the
industry’s most advanced manufacturing facility located in the United
States in Springfield, Missouri. Built
in 2009, utilizing the latest robotic
and processing technology, and
employing state-of-the-art environmental control systems, NorthStar
delivers the best consistency and
reliability in the battery industry.
Contact your Certified NorthStar
Distributor today to see how these
products can work for you.
THE ABOVE STATED WARRANTY IS IN LIEU OF ALL OTHER WARRANTIES, EXPRESSED OR IMPLIED,
INCLUDING, WITHOUT LIMITATION, ANY IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS. IN
NO EVENT SHALL NORTHSTAR BATTERY COMPANY BE RESPONSIBLE FOR ANY INCIDENTAL OR
CONSEQUENTIAL DAMAGES OR LOSS, AND EXCEPT AS STATED HERIN, NORTHSTAR BATTERY
COMPANY SHALL NOT BE LIABLE FOR ANY DEFECTS IN, OR ANY BREACH OF CONTRACTS RELATING
TO THE QUALITY OR PERFORMANCE OF THE ABOVE EQUIPMENT UNDER ANY THEORY OF LAW. THIS
LIMITED WARRANTY APPLIES TO THE ORIGINAL PURCHASER (USER) AND IS NONTRANSFERRABLE.
ALL REPLACEMENT BATTERIES WILL BE WARRANTIED FOR THE BALANCE OF THE ORIGINAL PERIOD.
RETURNED MATERIALS- In no event shall the User return material to NorthStar Battery Company
without prior written authorization. The User shall be responsible for all costs incurred in returning
material and for secure packaging of returned materials to provide the best possible assurance
against damage in the shipment. Batteries shall not be returned to NorthStar Battery Company
without special instructions for handling and shipping. The customer is responsible for paying all of
the following costs associated with the replacement: labor for removal or installation; applicable
taxes; and any shipping or transportation costs incurred in returning the battery to the
distributor/dealer for evaluation.
NorthStar Battery Company LLC
4000 Continental Way
Springfield, MO 65803
USA
Tel: (+1) 417 575 8200
Fax: (+1) 417 575 8250
info@northstarbattery.com
www.northstarbattery.com
Distributed by:
Date: 09-21-11
ECO: 1666-S11
DCN: SES-541-12-01