JM Aerofoil - Cased Axial Fans 63JM/20/4/6/36

JM Aerofoil - Cased Axial Fans 63JM/20/4/6/36

Axial Fans Catalogue (50Hz)
JM Aerofoil - Cased Axial Fans
Features
•
•
•
•
•
•
•
•
315 - 1000 mm diameter
Volumes up to 72,000 m3/h (20 m3/s)
Static pressures up to 800 Pa
Fans tested to ISO5801 and BS848
High energy efficiency
Low installed noise levels
Motor protection IP55
Larger sizes available please enquire
for more information
Electrical Supply
• 220-240V/50Hz/1 f
• 380-420V/50Hz/3 f
Temperature Range
• 200ºC for 2 hours with 3 ph motors on
one off emergency operation only
• -40ºC to 50ºC as standard
• 50ºC to 70ºC must be run at full
speed only
Sizes
Product Code
315, 355, 400, 450, 500, 560, 630, 710, 800, 900 and 1000 mm
63JM/20/4/6/36
Impellers
A unique high efficiency aerofoil section blade with a purposely
smoothed hub and clamp plate for adjustable pitch angle availability.
•
•
•
•
•
•
The Fläkt Woods impellers are all high pressure die cast to offer thin
aerofoil sections for low generation of noise. Every cast aluminium
component is X-ray examined using Real Time Radiography inspection
prior to assembly. The maximum pitch angles shown allow for speed
control by frequency inverter (3ph only).
Motors
63 - denotes the fan impeller diameter in centimetres
JM - denotes fan type
20 - denotes impeller hub diameter in centimetres
4 - denotes a nominal 4 pole speed
6 - denotes the number of blades
36 - denotes the pitch angle for the required duty
Accessories
All motors are totally enclosed air stream rated class F insulation.
Constructed from aluminium or cast iron as standard with special ‘T’
slot, pad mounted and foot mounted fixings. Single speed motors are
suitable for speed control by voltage regulation where indicated. Three
phase motors are suitable for use with frequency inverters, suitable for
turn down to 20% of maximum speed. Two speed motors are available
on request. Suitable for horizontal or vertical shaft operation. Supplied
IP55, with removable drain plugs.
Damper
Guard
Bellmouth
Flange
Mounting Feet
Rubber AV’s
Spring AV’s
Flexible
Connector
Silencer
Controls
Transformer
Controls
Inverter
Controls
Electronic
Sealed for life bearings lubricated with wide temperature range grease.
The BT and CT frames are fitted with overheat protection thermostat as
standard. 80-160 frame motors are fitted with Thermistor OHP. These
motors are suitable for inverter\speed control down to 20% of full speed
and where within scope incorporate IE2 compliant motors.
Casings
JM Aerofoil fans are available in either a long cased form, complete with
an externally mounted pre-wired electrical terminal box, or short cased
for duct or plate installation. Casings are spun from sheet steel with
integral pre-drilled and radiused inlet flanges. The galvanised finish
gives a high resistance to corrosion and is ideal for external as well as
internal use.
Fläkt Woods Limited (UK)
TC-AF-EN-2013.12.0001
5
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
JM Aerofoil Performance and Electrical Data
Performance Chart - 315-355 mm, 2 Pole
JM Aerofoil
380-420v/50Hz/3f
315- 355 mm 2 Pole
600
500
2 3
5JM
/
/40
1
31
JM
/1
300
30
5/
2/
6/
Static Pressure (Pa)
400
16/
2/5
200
100
0
0
1000
2000
0
3000
4000
0.5
5000
6000
1
1.5
m 3/h
7000
2
m 3/s
Volume Flow
Performance Table - 315-355 mm, 2 Pole
380-420v/50Hz/3f
Ref
m3/s @ Pa (Static)
Product
Code
0
50
100
150
200
250
300
400
1
31JM/16/2/5/30
1.07
1.03
0.98
0.92
0.87
0.81
0.74
0.55
2
35JM/16/2/5/40
2.03
1.96
1.89
1.81
1.73
1.64
1.54
1.28
Product, Electrical and ErP Table - 315-355 mm, 2 Pole
380-420v/50Hz/3f
Ref
Product
Code
Pitch Angle (°)
Product
Number
Min
Max
Speed
rev/min
Motor
Rating
(kW)
Full Load
Current
(A)
Starting
Current
(A)
Wiring
Diagram
(CD)
Speed Controller
Electronic
Transformer
Inverter
1
31JM/16/2/5/30
EJ341202
22
30
2840
BT9 (IE1)
0.58
1.45
5.7
CD2416
N/A
N/A
N/A
2
35JM/16/2/5/40
EJ381274
14
40
2840
80 (IE2)
1.32
2.79
14.5
CD2416
N/A
N/A
IDDXF54-3.7
Ref
Product
Code
Product
Number
Inlet
Sound
Levels
Efficiency
Rating
Target
Grade
1
31JM/16/2/5/30
EJ341202
59
42.4
42.3
50
2
35JM/16/2/5/40
EJ381274
67
47.6
44.7
53
Sound pressure levels quoted are at the inlet, and are average dBA at 3m distance over a sphere at the mid point at the highest angle given,
under free field conditions. These are presented for comparative purposes only.
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
6
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
JM Aerofoil Performance and Electrical Data
Performance Chart - 315-355 mm, 4 Pole
JM Aerofoil
380-420v/50Hz/3f
315- 355 mm 4 Pole
150
2
100
Static Pressure (Pa)
1
31
JM
/1
6/
4/
35
5/
JM
/1
6/
4/
5/
26
32
50
0
0
500
0
1000
0.1
0.2
1500
0.3
2000
0.4
0.5
0.6
2500
m 3/h
0.7
m 3/s
Volume Flow
Performance Table - 315-355 mm, 4 Pole
380-420v/50Hz/3f
Ref
m3/h @ Pa (Static)
Product
Code
0
50
100
1
31JM/16/4/5/32
0.56
0.46
0.29
2
35JM/16/4/5/26
0.71
0.61
0.44
Product, Electrical and ErP Table - 315-355 mm, 4 Pole
380-420v/50Hz/3f
Pitch Angle (°)
Speed Controller
Speed
rev/min
Motor
Rating
(kW)
Full Load
Current
(A)
Starting
Current
(A)
Wiring
Diagram
(CD)
Electronic
Transformer
Inverter
32
1420
BT4 (IE1)
0.087
0.35
1.12
CD2420
N/A
TDID 2.5A
IDDXF54-2.2
8
26
1420
BT4 (IE1)
0.1
0.36
1
CD2416
N/A
N/A
IDDXF54-2.2
Product
Number
Inlet
Sound
Levels
Efficiency
Rating
Target
Grade
31JM/16/4/5/32
EJ341460
42
-
-
-
35JM/16/4/5/26
EJ381460
43
37.8
38.1
50
Ref
Product
Code
Product
Number
Min
Max
1
31JM/16/4/5/32
EJ341460
8
2
35JM/16/4/5/26
EJ381460
Ref
Product
Code
1
2
Sound pressure levels quoted are at the inlet, and are average dBA at 3m distance over a sphere at the mid point at the highest angle given,
under free field conditions. These are presented for comparative purposes only.
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
7
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
Drawing - 315-355 mm
315 mm
Size
Motor
Frame
C
K
Weight kg
Fan
315
BT4
330
245
21
355 mm
Size
Motor
Frame
C
K
Weight kg
Fan
355
BT4
330
245
22
All dimensions in mm
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
8
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
JM Aerofoil Performance and Electrical Data
Performance Chart - 400-450 mm, 2 Pole
JM Aerofoil
380-420v/50Hz/3f
400- 450 mm 2 Pole
1000
900
800
3
45
600
1
40
/2
/
/2
/5
/3
2
16
16
/
400
0/
2/
6/
34
JM
JM
45
500
JM
2
20
5/
2/
/
Static Pressure (Pa)
700
300
200
100
0
0
5000
0
0.5
1
10000
1.5
2
2.5
m 3/h
3
3.5
4 m 3/s
Volume Flow
Performance Table - 400-450 mm, 2 Pole
380-420v/50Hz/3f
Ref
m3/s @ Pa (Static)
Product
Code
0
50
100
150
200
250
300
400
500
1
40JM/16/2/5/32
2.58
2.51
2.43
2.35
2.26
2.17
2.07
1.85
1.6
3
45JM/16/2/5/20
2.7
2.63
2.56
2.48
2.4
2.32
2.23
2.04
1.81
5
45JM/20/2/6/34
3.87
3.79
3.72
3.63
3.55
3.46
3.37
3.18
2.96
600
700
2.71
2.41
Product, Electrical and ErP Table - 400-450 mm, 2 Pole
380-420v/50Hz/3f
Ref
Product
Code
Product
Number
Pitch Angle (°)
Min
Max
Speed
rev/min
Motor
Rating
(kW)
Full Load
Current
(A)
Starting
Current
(A)
Wiring
Diagram
(CD)
Speed Controller
Electronic Transformer
Inverter
1
40JM/16/2/5/32
EJ431273
10
32
2840
80 (IE2)
1.73
3.59
18.3
CD2416
N/A
N/A
IDDXF54-3.7
2
45JM/16/2/5/20
EE481272
8
20
2840
80 (IE2)
1.73
3.59
18.3
CD2416
N/A
N/A
IDDXF54-3.7
3
45JM/20/2/6/34
EJ481275
10
34
2910
100L (IE2)
3.6
7.1
45.44
CD2416
N/A
N/A
IDDXF54-7.2
Ref
Product
Code
Product
Number
Inlet
Sound
Levels
Efficiency
Rating
Target
Grade
1
31JM/16/4/5/32
EJ341460
66
52.0
45.3
57
2
35JM/16/4/5/26
EJ381460
67
58.3
53.1
63
3
45JM/20/2/6/34
EJ481275
72
52.3
47.5
55
Sound pressure levels quoted are at the inlet, and are average dBA at 3m distance over a sphere at the mid point at the highest angle given,
under free field conditions. These are presented for comparative purposes only.
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
9
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
JM Aerofoil Performance and Electrical Data
Performance Chart - 400-450 mm, 4 Pole
JM Aerofoil
380-420v/50Hz/3f
400- 450 mm 4 Pole
200
2
1
40
JM
/
16
JM
/1
16
5/
4/
6/
Static Pressure (Pa)
45
100
0
0
1000
2000
0
3000
0.5
4000
/
4/
5/
34
5000
1
6000
1.5
7000
2
m 3/h
m 3/s
Volume Flow
Performance Table - 400-450 mm, 4 Pole
380-420v/50Hz/3f
m3/s @ Pa (Static)
Ref
Product
Code
0
50
100
150
1
40JM/16/4/5/16
0.77
0.66
0.5
0.18
2
45JM/16/4/5/34
1.98
1.76
1.51
1.22
Product, Electrical and ErP Table - 400-450 mm, 4 Pole
380-420v/50Hz/3f
Pitch Angle (°)
Speed Controller
Speed
rev/min
Motor
Rating
(kW)
Full Load
Current
(A)
Starting
Current
(A)
Wiring
Diagram
(CD)
16
1420
BT4 (IE1)
0.1
0.36
1
CD2416
N/A
N/A
IDDXF54-2.2
34
1420
BT9 (IE1)
0.39
1.26
3.9
CD2417
N/A
N/A
IDDXF54-2.2
Ref
Product
Code
Product
Number
Min
Max
1
40JM/16/4/5/16
EJ431452
8
2
45JM/16/4/5/34
EJ481460
20
Ref
Product
Code
Product
Number
Inlet
Sound
Levels
Efficiency
Rating
Target
Grade
1
40JM/16/4/5/16
EJ431452
47
39.7
38.2
51
2
45JM/16/4/5/34
EJ481460
53
41.7
42.0
50
Electronic Transformer
Inverter
Sound pressure levels quoted are at the inlet, and are average dBA at 3m distance over a sphere at the mid point at the highest angle given,
under free field conditions. These are presented for comparative purposes only.
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
10
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
Drawings - 400-450 mm
400 mm
Size
Motor
Frame
400
BT4/5
330
245
24
400
80
375
290
35
C
Weight kg
Fan
K
450 mm
Size
Motor
Frame
C
K
Weight kg
Fan
450
BT9
375
289
28
450
80
375
290
37
450
100L
520
434
60
All dimensions in mm
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
11
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
JM Aerofoil Performance and Electrical Data
Performance Chart - 500 mm, 2 Pole
380-420v/50Hz/3f
JM Aerofoil
500 mm 2 Pole
1000
900
2
1
800
50
JM
JM
/
/
700
20
20
28
6/
2/
/
Static Pressure (Pa)
50
600
/
2/
6/
34
500
400
300
200
100
0
0
5000
0
10000
1
2
15000
3
20000 m 3/h
4
5
m 3/s
Volume Flow
Performance Table - 500 mm, 2 Pole
380-420v/50Hz/3f
Ref
m3/s @ Pa (Static)
Product
Code
0
50
100
150
200
250
300
400
500
600
700
800
1
50JM/20/2/6/28
4.85
4.77
4.68
4.59
4.5
4.41
4.31
4.11
3.9
3.66
3.39
3.05
2
50JM/20/2/6/34
5.56
5.46
5.36
5.27
5.16
5.06
4.95
4.73
4.49
4.23
3.93
3.58
Product, Electrical and ErP Table - 500 mm, 2 Pole
380-420v/50Hz/3f
Pitch Angle (°)
Speed Controller
Speed
rev/min
Motor
Rating
(kW)
Full Load
Current
(A)
Starting
Current
(A)
Wiring
Diagram
(CD)
28
2910
100L (IE2)
4.6
8.88
61.27
CD2416
N/A
N/A
IDDXF54-9
34
2910
112M (IE2)
6.05
11.6
76.56
CD2417
N/A
N/A
IDDXF54-12
Ref
Product
Code
Product
Number
Min
Max
1
50JM/20/2/6/28
EE531273
8
2
50JM/20/2/6/34
EJ531274
10
Ref
Product
Code
Product
Number
Inlet
Sound
Levels
Efficiency
Rating
Target
Grade
1
50JM/20/2/6/28
EE531273
72
59.7
56.0
61.0
2
50JM/20/2/6/34
EJ531274
75
57.5
56.8
58
Electronic Transformer
Inverter
Sound pressure levels quoted are at the inlet, and are average dBA at 3m distance over a sphere at the mid point at the highest angle given,
under free field conditions. These are presented for comparative purposes only.
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
12
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
JM Aerofoil Performance and Electrical Data
Performance Chart - 500 mm, 4 Pole (IE1 motors)
380-420v/50Hz/3f
JM Aerofoil
500 mm 4 Pole IE1
300
200
50
JM
1
Static Pressure (Pa)
2
/2
50
JM
/2
20
6/
4/
0/
100
0
0/
4/
6/
38
0
1000
2000
0
3000
4000
0.5
5000
1
6000
7000
1.5
8000
9000
2
2.5
10000
11000
m 3/h
3
m 3/s
Volume Flow
Performance Table - 500 mm, 4 Pole (IE1 motors)
380-420v/50Hz/3f
Ref
m3/s @ Pa (Static)
Product
Code
0
50
100
150
1
50JM/20/4/6/20
1.83
1.68
1.51
1.29
2
50JM/20/4/6/38
2.88
2.68
2.44
2.15
Product, Electrical and ErP Table - 500 mm, 4 Pole (IE1 motors)
380-420v/50Hz/3f
Pitch Angle (°)
Speed Controller
Speed
rev/min
Motor
Rating
(kW)
Full Load
Current
(A)
Starting
Current
(A)
Wiring
Diagram
(CD)
20
1420
BT9 (IE1)
0.39
1.26
3.9
CD2417
N/A
N/A
IDDXF54-2.2
38
1420
CT9 (IE1)
0.83
2.3
8.6
CD2417
N/A
TDID 2.5A
IDDXF54-3.7
Ref
Product
Code
Product
Number
Min
Max
1
50JM/20/4/6/20
EJ531456
14
2
50JM/20/4/6/38
EJ531462
18
Ref
Product
Code
Product
Number
Inlet
Sound
Levels
Efficiency
Rating
Target
Grade
1
50JM/20/4/6/20
EJ531456
52
45.9
41.7
54
2
50JM/20/4/6/38
EJ531462
58
44.6
43.9
51
Electronic Transformer
Inverter
Sound pressure levels quoted are at the inlet, and are average dBA at 3m distance over a sphere at the mid point at the highest angle given,
under free field conditions. These are presented for comparative purposes only.
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
13
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
JM Aerofoil Performance and Electrical Data
Performance Chart - 500 mm, 4 Pole (IE2 motors)
JM Aerofoil
380-420v/50Hz/3f
500 mm 4 Pole IE2
300
200
Static Pressure (Pa)
2 50
JM/
20/4
/6/3
8
1
50
100
0
0
1000
2000
0
3000
4000
0.5
5000
1
6000
7000
1.5
JM
/1
6/
4/
5/
40
8000
9000
2
2.5
10000
11000
m 3/h
3
m 3/s
Volume Flow
Performance Table - 500 mm, 4 Pole (IE2 motors)
380-420v/50Hz/3f
Ref
m3/s @ Pa (Static)
Product
Code
0
50
100
1
50JM/16/4/5/40
3.02
2.74
2.42
2
50JM/20/4/6/40
2.96
2.76
2.52
150
2.21
Product, Electrical and ErP Table - 500 mm, 4 Pole (IE2 motors)
380-420v/50Hz/3f
Ref
Product
Code
Product
Number
Pitch Angle (°)
Min
Max
Speed
rev/min
Motor
Rating
(kW)
Full Load
Current
(A)
Starting
Current
(A)
Wiring
Diagram
(CD)
Speed Controller
Electronic Transformer
Inverter
1
50JM/16/4/5/40
EJ531474
14
40
1420
80 (IE2)
0.9
1.92
9.79
CD2416
N/A
N/A
IDDXF54-2.2
2
50JM/20/4/6/40
EJ531478
12
40
1420
80 (IE2)
0.9
1.92
9.79
CD2416
N/A
N/A
IDDXF54-2.2
Ref
Product
Code
Product
Number
Inlet
Sound
Levels
Efficiency
Rating
Target
Grade
1
50JM/16/4/5/40
EJ531474
60
58.2
43.4
57
2
50JM/20/4/6/40
EJ531478
59
48.2
43.8
54
Sound pressure levels quoted are at the inlet, and are average dBA at 3m distance over a sphere at the mid point at the highest angle given,
under free field conditions. These are presented for comparative purposes only.
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
14
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
Drawing - 500 mm
500 mm
Size
Motor
Frame
C
K
Weight kg
Fan
500
BT9
375
289
28
500
CT9
375
289
34
500
80
375
290
39
500
100L
520
434
66
500
112M
520
434
76
All dimensions in mm
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
15
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
JM Aerofoil Performance and Electrical Data
Performance Chart - 560 mm, 2 Pole
380-420v/50Hz/3f
JM Aerofoil
560 mm 2 Pole
1200
1100
1000
1
56
900
JM
Static Pressure (Pa)
800
700
/2
0/
2/
6/
22
600
500
400
300
200
100
0
0
5000
0
10000
1
2
15000
3
25000 m 3/h
m 3/s
20000
4
5
6
Volume Flow
Performance Table - 560 mm, 2 Pole
380-420v/50Hz/3f
Ref
2
m3/s @ Pa (Static)
Product
Code
56JM/20/2/6/22
0
50
100
150
200
250
300
400
500
600
700
800
900
5.95
5.86
5.77
5.68
5.58
5.48
5.38
5.16
4.93
4.68
4.4
4.08
3.72
Product, Electrical and ErP Table - 560 mm, 2 Pole
380-420v/50Hz/3f
Pitch Angle (°)
Speed
rev/min
Motor
Rating
(kW)
Full Load
Current
(A)
Starting
Current
(A)
Wiring
Diagram
(CD)
2910
112M (IE2)
6.05
11.6
76.56
CD2417
Ref
Product
Code
Product
Number
1
56JM/20/2/6/22
EE591271
Ref
Product
Code
Product
Number
Inlet
Sound
Levels
Efficiency
Rating
Target
Grade
1
56JM/20/2/6/22
EE591271
72
66
56.4
67
Min
Max
8
22
Speed Controller
Electronic Transformer
N/A
N/A
Inverter
IDDXF54-12
Sound pressure levels quoted are at the inlet, and are average dBA at 3m distance over a sphere at the mid point at the highest angle given,
under free field conditions. These are presented for comparative purposes only.
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
16
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
JM Aerofoil Performance and Electrical Data
Performance Chart - 560 mm, 4 Pole
380-420v/50Hz/3f
JM Aerofoil
560 mm 4 Pole
300
4
3
56
56
200
JM
/2
Static Pressure (Pa)
JM
20
20
5/
4/
30
5/
6/
4/
6/
/1
/1
JM
JM
56
56
1
/4
/6
/3
6
32
6/
4/
0/
2
100
0
/
0
5000
0
0.5
1
10000
1.5
2
2.5
3
3.5
4
3
15000 m /h
3
m /s
Volume Flow
Performance Table - 560 mm, 4 Pole
380-420v/50Hz/3f
m3/s @ Pa (Static)
Ref
Product
Code
0
50
100
150
200
1
56JM/16/4/5/20
2.74
2.5
2.23
1.92
1.45
2
56JM/16/4/5/30
3.6
3.31
3.02
2.69
2.25
3
56JM/20/4/6/32
3.8
3.56
3.31
3.03
2.7
4
56JM/20/4/6/36
4.08
3.83
3.56
3.26
2.9
Product, Electrical and ErP Table - 560 mm, 4 Pole
380-420v/50Hz/3f
Pitch Angle (°)
Product
Code
Product
Number
1
56JM/16/4/5/20
EJ591452
18
2
56JM/16/4/5/30
EE591473
8
3
56JM/20/4/6/32
EJ591458
14
32
4
56JM/20/4/6/36
EJ591478
10
36
Ref
Product
Code
Product
Number
Inlet
Sound
Levels
Efficiency
Rating
Target
Grade
1
56JM/16/4/5/20
EJ591452
56
43.6
43.0
51
2
56JM/16/4/5/30
EE591473
59
55.0
51.8
61
3
56JM/20/4/6/32
EJ591458
60
50.4
44.7
56
4
56JM/20/4/6/36
EJ591478
62
56.0
52.8
61
Ref
Min
Rating
(kW)
Full Load
Current
(A)
Starting
Current
(A)
Wiring
Diagram
(CD)
Speed Controller
Speed
rev/min
Motor
20
1420
CT5 (IE1)
0.54
1.8
4.9
CD2417
N/A
TDID 2.5A
IDDXF54-2.2
30
1420
80 (IE2)
0.9
1.92
9.79
CD2416
N/A
N/A
IDDXF54-2.2
1420
CT9 (IE1)
1.15
3.2
11
CD2417
N/A
TDID 8A
IDDXF54-3.7
1420
90S (IE2)
1.32
2.84
15.6
CD2416
N/A
N/A
IDDXF54-3.7
Max
Electronic Transformer
Inverter
Sound pressure levels quoted are at the inlet, and are average dBA at 3m distance over a sphere at the mid point at the highest angle given,
under free field conditions. These are presented for comparative purposes only.
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
17
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
Drawing - 560 mm
560 mm
Size
Motor
Frame
C
K
Weight kg
Fan
560
CT5/9
375
280
38
560
80
375
280
41
560
90S
520
434
55
560
112M
520
434
78
All dimensions in mm
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
18
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
JM Aerofoil Performance and Electrical Data
Performance Chart - 630 mm, 4 and 6 Pole
JM Aerofoil
380-420v/50Hz/3f
630 mm All
400
300
63
JM
/2
/2
22
6/
4/
20
0/
6/
4/
0/
JM
36
6/
4/
0/
JM
63
/2
63
Static Pressure (Pa)
4
3
2
200
1
100
0
0
63
JM
/2
0/
6/
6/
30
5000
0
10000
1
2
15000
3
m 3/h
20000
4
5
6
m 3/s
Volume Flow
Performance Table - 630 mm, 4 and 6 Pole
380-420v/50Hz/3f
Ref
m3/s @ Pa (Static)
Product
Code
0
50
100
150
200
250
2
63JM/20/4/6/20
3.76
3.57
3.36
3.14
2.88
2.55
3
63JM/20/4/6/22
4.04
3.84
3.63
3.39
3.13
2.79
4.95
4.59
4.19
4
63JM/20/4/6/36
5.93
5.61
5.29
1
63JM/20/6/6/30
3.24
2.85
2.32
Product, Electrical and ErP Table - 630 mm, 4 and 6 Pole
380-420v/50Hz/3f
Pitch Angle (°)
Speed Controller
Speed
rev/min
Motor
Rating
(kW)
Full Load
Current
(A)
Starting
Current
(A)
Wiring
Diagram
(CD)
20
1420
CT9 (IE1)
1.15
3.2
11
CD2417
N/A
TDID 8A
IDDXF54-3.7
22
1420
90S (IE2)
1.32
2.84
15.6
CD2416
N/A
N/A
IDDXF54-3.7
Ref
Product
Code
Product
Number
Min
Max
2
63JM/20/4/6/20
EJ661453
16
3
63JM/20/4/6/22
EE661473
8
Electronic Transformer
Inverter
4
63JM/20/4/6/36
EJ661474
12
36
1420
100L (IE2)
2.64
5.49
30.74
CD2417
N/A
N/A
IDDXF54-7.2
1
63JM/20/6/6/30
EJ661652
20
30
900
CT9 (IE1)
0.5
1.5
4.5
CD2417
N/A
TDID 2.5A
IDDXF54-2.2
Ref
Product
Code
Product
Number
Inlet
Sound
Levels
Efficiency
Rating
Target
Grade
2
63JM/20/4/6/20
EJ661453
61
48.3
44.8
53
3
63JM/20/4/6/22
EE661473
60
56.4
52.7
61
4
63JM/20/4/6/36
EJ661474
64
55.6
54.0
59
1
63JM/20/6/6/30
EJ661652
50
42.6
42.7
50
Sound pressure levels quoted are at the inlet, and are average dBA at 3m distance over a sphere at the mid point at the highest angle given,
under free field conditions. These are presented for comparative purposes only.
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
19
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
Drawing - 630 mm, 4 and 6 Pole
630 mm
Size
Motor
Frame
C
D
K
Weight kg
Fan
630
CT9
375
403
289
52
630
90S
520
403
434
61
630
100L
520
403
434
80
630
112M
520
403
434
92
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
20
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
JM Aerofoil Performance and Electrical Data
Performance Chart - 710 mm, 4 and 6 Pole
380-420v/50Hz/3f
JM Aerofoil
710 mm
600
500
4
3
71
300
JM
71
/2
200
1
100
0
JM
/2
30
6/
4/
0/
Static Pressure (Pa)
400
0
71
JM
2
/2
0/
6/
6/
18
5000
0
71
JM
/2
0/
6/
6/
36
10000
1
2
0/
4/
6/
36
15000
3
20000
4
5
25000
6
7
Electronic Transformer
30000
8
9
3
35000 m /h
3
m /s
Volume Flow
Performance Table - 710 mm, 4 and 6 Pole
380-420v/50Hz/3f
m3/s @ Pa (Static)
Ref
Product
Code
1
71JM/20/4/6/30
0
50
100
150
200
250
250
7.64
7.36
7.07
6.77
6.45
6.11
5.73
7.65
7.25
6.81
6.33
2
71JM/20/4/6/36
8.74
8.4
8.03
3
71JM/20/6/6/18
3.28
2.96
2.53
4
71JM/20/6/6/36
5.46
4.89
4.22
Product, Electrical and ErP Table - 710, 4 and 6 Pole
380-420v/50Hz/3f
Product
Code
Product
Number
3
71JM/20/4/6/30
4
1
Ref
Pitch Angle (°)
Speed Controller
Rating
(kW)
Full Load
Current
(A)
Starting
Current
(A)
Wiring
Diagram
(CD)
100L (IE2)
3.6
7.29
40.09
CD2416
N/A
1440
112M (IE2)
4.4
8.7
57.3
CD2417
N/A
N/A
IDDXF54-9
900
CT9 (IE1)
0.5
1.5
4.5
CD2417
N/A
TDID 2.5A
IDDXF54-2.2
900
90L (IE2)
1.32
3.13
13.15
CD2416
N/A
N/A
IDDXF54-3.7
Speed
rev/min
Motor
30
1440
10
36
14
18
14
36
Min
Max
EE741471
8
71JM/20/4/6/36
EJ741474
71JM/20/6/6/18
EJ741652
2
71JM/20/6/6/36
EJ741673
Ref
Product
Code
Product
Number
Inlet
Sound
Levels
Efficiency
Rating
Target
Grade
3
71JM/20/4/6/30
EE741471
67
62.5
55.4
65
4
71JM/20/4/6/36
EJ741474
69
59.9
56.0
61
1
71JM/20/6/6/18
EJ741652
53
46.4
42.6
54
2
71JM/20/6/6/36
EJ741673
58
54.5
52.4
60
N/A
Inverter
IDDXF54-9
Sound pressure levels quoted are at the inlet, and are average dBA at 3m distance over a sphere at the mid point at the highest angle given,
under free field conditions. These are presented for comparative purposes only.
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
21
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
Drawing - 710 mm, 4 and 6 Pole
710 mm
Size
Motor
Frame
C
D
J
K
Weight kg
Fan
710
CT5
375
10
259
54
710
CT9
375
10
259
54
710
90L
520
10
434
65
710
100L
520
10
434
84
710
112M
520
10
434
95
All dimensions in mm
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
22
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
JM Aerofoil Performance and Electrical Data
Performance Chart - 800 mm, 4 Pole
380-420v/50Hz/3f
JM Aerofoil
800 mm 4 Pole
700
600
1
Static Pressure (Pa)
500
80
JM
/
25
/4
/9
/2
2
2
80
400
JM
/
25
300
/
4/
9/
28
200
100
0
0
5000
0
10000
15000
2
20000
4
25000
30000
6
35000
8
40000
10
m 3/h
m 3/s
Volume Flow
Performance Table - 800 mm, 4 Pole
380-420v/50Hz/3f
Ref
m3/s @ Pa (Static)
Product
Code
0
50
100
150
200
250
300
400
1
80JM/25/4/9/22
8.4
8.15
7.89
7.62
7.34
7.04
6.72
5.95
2
80JM/25/4/9/28
10.06
9.8
9.53
9.24
8.92
8.58
8.2
7.34
Product, Electrical and ErP Table - 800 mm, 4 Pole
380-420v/50Hz/3f
Ref
Product
Code
Product
Number
Pitch Angle (°)
Min
Max
Speed
rev/min
Motor
Rating
(kW)
Full Load
Current
(A)
Starting
Current
(A)
Wiring
Diagram
(CD)
Speed Controller
Electronic Transformer
Inverter
1
80JM/25/4/9/22
EE831475
8
22
1440
112M (IE2)
4.8
9.69
49.53
CD2417
N/A
N/A
IDDXF54-12
2
80JM/25/4/9/28
EE831478
8
28
1455
132S (IE2)
6.6
12.6
76.25
CD2417
N/A
N/A
IDDXF54-15.5
Ref
Product
Code
Product
Number
Inlet
Sound
Levels
Efficiency
Rating
Target
Grade
1
80JM/25/4/9/22
EE831475
71
60.0
55.9
62
2
80JM/25/4/9/28
EE831478
71
60.2
56.7
61
Sound pressure levels quoted are at the inlet, and are average dBA at 3m distance over a sphere at the mid point at the highest angle given,
under free field conditions. These are presented for comparative purposes only.
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
23
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
JM Aerofoil Performance and Electrical Data
Performance Chart - 800 mm, 6 Pole
380-420v/50Hz/3f
JM Aerofoil
800 mm 6 Pole
200
80
/
JM
JM
80
20
24
6/
6/
0/
0
36
6/
6/
/
/2
Static Pressure (Pa)
2
1
100
0
5000
0
10000
1
2
15000
3
20000
4
5
25000
6
7
8
3
30000 m /h
m 3/s
Volume Flow
Performance Table - 800 mm, 6 Pole
380-420v/50Hz/3f
Ref
m3/s @ Pa (Static)
Product
Code
0
50
100
150
1
80JM/20/6/6/24
6.12
5.53
4.9
4.15
2
80JM/20/6/6/36
7.92
7.3
6.54
5.61
Product, Electrical and ErP Table - 800 mm, 6 Pole
380-420v/50Hz/3f
Ref
Product
Code
Product
Number
Pitch Angle (°)
Min
Max
Speed
rev/min
Motor
Rating
(kW)
Full Load
Current
(A)
Starting
Current
(A)
Wiring
Diagram
(CD)
Speed Controller
Electronic Transformer
1
80JM/20/6/6/24
EE831671
8
24
935
90L (IE2)
1.32
3.13
13.15
CD2416
N/A
2
80JM/20/6/6/36
EJ831672
14
36
935
112M (IE2)
2.64
6.18
26.5
CD2417
N/A
Ref
Product
Code
Product
Number
Inlet
Sound
Levels
Efficiency
Rating
Target
Grade
1
80JM/20/6/6/24
EE831671
58
55.3
52.5
60
2
80JM/20/6/6/36
EJ831672
63
54.7
54.1
58
Inverter
N/A
IDDXF54-3.7
N/A
IDDXF54-7.2
Sound pressure levels quoted are at the inlet, and are average dBA at 3m distance over a sphere at the mid point at the highest angle given,
under free field conditions. These are presented for comparative purposes only.
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
24
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
Drawing - 800 mm
800 mm
Motor
Frame
C
D
J
K
800
90L
520
443
10
404
71
800
112M
520
443
10
434
100
800
132S
520
480
12
434
166
Size
Weight kg
Fan
All dimensions in mm
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
25
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
JM Aerofoil Performance and Electrical Data
Performance Chart - 900 mm, 4 Pole
380-420v/50Hz/3f
JM Aerofoil
900 mm 4 Pole
800
700
600
1
2
/2
4
/2
/9
/4
34
9/
4/
5/
25
Static Pressure (Pa)
JM
/
JM
90
90
500
400
300
200
100
0
0
10000
0
20000
2
4
30000
6
40000
8
50000
10
12
14
m 3/h
60000
16
18
m 3/s
Volume Flow
Performance Table - 900 mm, 4 Pole
380-420v/50Hz/3f
Ref
m3/s @ Pa (Static)
Product
Code
0
50
100
150
200
250
300
400
500
600
8.79
1
90JM/25/4/9/24
13.21
12.9
12.6
12.29
11.97
11.65
11.33
10.64
9.85
2
90JM/25/4/9/34
17.07
16.67
16.26
15.84
15.4
14.94
14.46
13.44
12.29
Product, Electrical and ErP Table - 900 mm, 4 Pole
380-420v/50Hz/3f
Ref
Product
Code
Product
Number
Pitch Angle (°)
Min
Max
Speed
rev/min
Motor
Rating
(kW)
Full Load
Current
(A)
Starting
Current
(A)
Wiring
Diagram
(CD)
Speed Controller
Electronic Transformer
Inverter
1
90JM/25/4/9/24
EE931473
8
24
1440
132M (IE2)
9
17.1
100.89
CD2417
N/A
N/A
IDDXF54-23
2
90JM/25/4/9/34
EJ931476
10
34
1440
160M (IE2)
13.2
20.1
102.51
CD2417
N/A
N/A
IDDXF54-31
Ref
Product
Code
1
2
Product
Number
Inlet
Sound
Levels
Efficiency
Rating
Target
Grade
90JM/25/4/9/24
EE931473
75
68.0
57.8
68
90JM/25/4/9/34
EJ931476
77
63.6
58.2
63
Sound pressure levels quoted are at the inlet, and are average dBA at 3m distance over a sphere at the mid point at the highest angle given,
under free field conditions. These are presented for comparative purposes only.
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
26
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
JM Aerofoil Performance and Electrical Data
Performance Chart - 900 mm, 6 and 8 Pole
380-420v/50Hz/3f
JM Aerofoil
900 mm 6 & 8 Pole
300
Static Pressure (Pa)
2
90
JM
/
25
/6
/9
/2
4
200
0
32
6/
6/
5/
10000
/2
/2
0
JM
JM
0
90
90
3
1
100
5/
8/
9/
36
20000
2
4
30000
6
40000
8
10
m 3/h
m 3/s
Volume Flow
Performance Table - 900 mm, 6 and 8 Pole
380-420v/50Hz/3f
Ref
m3/s @ Pa (Static)
Product
Code
0
50
100
150
1
90JM/25/6/6/32
9.81
9.05
8.21
7.2
2
90JM/25/6/9/24
8.58
8.1
7.62
7.11
3
90JM/25/8/9/36
8.59
7.65
6.54
200
250
6.54
5.77
Product, Electrical and ErP Table - 900 mm, 6 and 8 Pole
380-420v/50Hz/3f
Ref
Product
Code
Product
Number
Pitch Angle (°)
Min
Max
Speed
rev/min
Motor
Rating
(kW)
Full Load
Current
(A)
Starting
Current
(A)
Wiring
Diagram
(CD)
Speed Controller
Electronic Transformer
Inverter
1
90JM/25/6/6/32
EJ933672
10
32
935
112M (IE2)
2.64
6.18
26.5
CD2417
N/A
N/A
IDDXF54-7.2
2
90JM/25/6/9/24
EE931672
8
24
935
112M (IE2)
2.64
6.18
26.5
CD2417
N/A
N/A
IDDXF54-7.2
3
90JM/25/8/9/36
EJ931872
12
36
695
112M (IE2)
1.8
4.51
19.39
CD2417
N/A
N/A
IDDXF54-5.3
Ref
Product
Code
Product
Number
Inlet
Sound
Levels
Efficiency
Rating
Target
Grade
1
90JM/25/6/6/32
EJ933672
65
58.2
54.5
61
2
90JM/25/6/9/24
EE931672
63
62.8
54.4
66
3
90JM/25/8/9/36
EJ931872
31
54.8
53.5
59
Sound pressure levels quoted are at the inlet, and are average dBA at 3m distance over a sphere at the mid point at the highest angle given,
under free field conditions. These are presented for comparative purposes only.
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
27
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
Drawing - 900 mm
900 mm
Size
Motor
Frame
C
D
J
K
Weight kg
Fan
900
112M
520
538
10
444
107
900
132M
520
575
12
440
179
900
160M
625
575
12
545
248
All dimensions in mm
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
28
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
JM Aerofoil Performance and Electrical Data
Performance Chart - 1000 mm, 4 Pole
380-420v/50Hz/3f
JM Aerofoil
1000 mm 4 Pole
1000
900
800
3 1
00J
M/
Static Pressure (Pa)
700
25/
600
4/9
/22
2
500
1
10
400
0J
M
300
/2
10
0J
M
/2
5/
4/
9/
28
5/
4/
6/
22
200
100
0
0
10000
20000
0
30000
5
40000
50000
10
60000
70000
15
80000
20
m 3/h
m 3/s
Volume Flow
Performance Table - 1000 mm, 4 Pole
380-420v/50Hz/3f
Ref
m3/s @ Pa (Static)
Product
Code
0
50
100
150
200
250
300
400
500
600
1
100JM/25/4/6/22
16.46
15.91
15.35
14.78
14.21
13.62
13.01
11.68
10.04
2
100JM/25/4/9/28
20.96
20.52
20.07
19.61
19.12
18.63
18.11
16.99
15.75
14.33
3
100JM/25/4/9/22
17.68
17.24
16.79
16.33
15.88
15.41
14.93
13.91
12.75
11.36
Product, Electrical and ErP Table - 1000 mm, 4 Pole
380-420v/50Hz/3f
Pitch Angle (°)
Speed Controller
Speed
rev/min
Motor
Rating
(kW)
Full Load
Current
(A)
Starting
Current
(A)
Wiring
Diagram
(CD)
22
1440
132M (IE2)
9
17.1
100.89
CD2417
8
28
1470
160L (IE2)
18
34.2
177.81
CD2417
N/A
N/A
IDDXF54-37
8
22
1470
160M (IE2)
13.2
25.3
136.62
CD2417
N/A
N/A
IDDXF54-31
Ref
Product
Code
Product
Number
Min
Max
1
100JM/25/4/6/22
EE133472
8
2
100JM/25/4/9/28
EE131475
3
100JM/25/4/9/22
EE131479
Ref
Product
Code
Product
Number
Inlet
Sound
Levels
Efficiency
Rating
Target
Grade
1
100JM/25/4/6/22
EE133472
79
68.6
57.6
69
2
100JM/25/4/9/28
EE131475
81
66.6
58.3
66
3
100JM/25/4/9/22
EE131479
80
63.5
58.1
63
Electronic Transformer
N/A
N/A
Inverter
IDDXF54-23
Sound pressure levels quoted are at the inlet, and are average dBA at 3m distance over a sphere at the mid point at the highest angle given,
under free field conditions. These are presented for comparative purposes only.
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
29
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
JM Aerofoil Performance and Electrical Data
Performance Chart - 1000 mm, 6 and 8 Pole
380-420v/50Hz/3f
JM Aerofoil
1000 mm 6 & 8 Pole
400
Static Pressure (Pa)
300
2
200
1
100
0
0
10000
0
2
10
10
0J
M
0J
M
/
/2
25
/
6/
5/
8/
9/
26
20000
4
6/
22
30000
6
40000
8
10
12
50000
m 3/h
14
m 3/s
Volume Flow
Performance Table - 1000 mm, 6 and 8 Pole
380-420v/50Hz/3f
Ref
m3/h @ Pa (Static)
Product
Code
0
50
100
150
200
8.11
6.98
2
100JM/25/6/6/22
10.78
9.93
9.05
1
100JM/25/8/9/26
9.4
8.41
7.28
Product, Electrical and ErP Table - 1000 mm, 6 and 8 Pole
380-420v/50Hz/3f
Ref
Product
Code
Product
Number
Pitch Angle (°)
Min
Max
Speed
rev/min
Motor
Rating
(kW)
Full Load
Current
(A)
Starting
Current
(A)
Wiring
Diagram
(CD)
Speed Controller
Electronic Transformer
Inverter
2
100JM/25/6/6/22
EE133672
8
22
950
112M (IE2)
2.64
6.18
26.5
CD2417
N/A
N/A
IDDXF54-7.2
1
100JM/25/8/9/26
EE131872
8
26
695
112M (IE2)
1.8
4.51
19.39
CD2417
N/A
N/A
IDDXF54-5.3
Ref
Product
Code
Product
Number
Inlet
Sound
Levels
Efficiency
Rating
Target
Grade
2
100JM/25/6/6/22
EE133672
69
63.4
54.3
67
1
100JM/25/8/9/26
EE131872
56.9
56.9
53.4
61
Sound pressure levels quoted are at the inlet, and are average dBA at 3m distance over a sphere at the mid point at the highest angle given,
under free field conditions. These are presented for comparative purposes only.
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
30
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
Drawing - 1000 mm
1000 mm
Size
Motor
Frame
C
D
J
K
Weight kg
Fan
1000
112M
520
588
10
444
109
1000
132M
520
625
14
tbc
218
1000
160M
711
625
14
629
260
1000
160L
711
625
14
629
295
All dimensions in mm
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
31
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
JM XM Aerofoil Performance and Electrical Data
Performance Chart - 500 mm, 2 Pole
380-420v/50Hz/3f
JMXM Aerofoil
500 mm 2 Pole
1000
900
800
2
20
28
6/
2/
0/
600
34
6/
2/
/
/2
Static Pressure (Pa)
/
JM
JM
50
50
1
700
500
400
300
200
100
0
0
5000
0
10000
1
2
15000
3
4
5
3
20000 m /h
3
m /s
Volume Flow
Performance Table - 500 mm, 2 Pole
380-420v/50Hz/3f
Ref
m3/s @ Pa (Static)
Product
Code
0
50
100
150
200
250
300
400
500
600
700
800
1
50JM/20/2/6/28
4.85
4.77
4.68
4.59
4.5
4.41
4.31
4.11
3.9
3.66
3.39
3.05
2
50JM/20/2/6/34
5.56
5.46
5.36
5.27
5.16
5.06
4.95
4.73
4.49
4.23
3.93
3.58
Product, Electrical and ErP Table - 500 mm, 2 Pole
380-420v/50Hz/3f
Pitch Angle (°)
Speed Controller
Speed
rev/min
Motor
Rating
(kW)
Full Load
Current
(A)
Starting
Current
(A)
Wiring
Diagram
(CD)
28
2910
100L (IE2)
4.6
8.88
61.27
CD2416
N/A
N/A
IDDXF54-9
34
2910
112M (IE2)
6.05
11.7
77.2
CD2417
N/A
N/A
IDDXF54-12
Ref
Product
Code
Product
Number
Min
Max
1
50JM/20/2/6/28
XM531273
8
2
50JM/20/2/6/34
XM531274
10
Ref
Product
Code
Product
Number
Inlet
Sound
Levels
Efficiency
Rating
Target
Grade
1
50JM/20/2/6/28
XM531273
72
59.7
56.0
61
2
50JM/20/2/6/34
XM531274
75
57.5
56.8
58
Electronic Transformer
Inverter
Sound pressure levels quoted are at the inlet, and are average dBA at 3m distance over a sphere at the mid point at the highest angle given,
under free field conditions. These are presented for comparative purposes only.
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
32
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
JM XM Aerofoil Performance and Electrical Data
Performance Chart - 500 mm, 4 Pole
380-420v/50Hz/3f
JMXM Aerofoil
500 mm 4 Pole
300
200
Static Pressure (Pa)
2
50
JM
/
20
/4
/6
/4
0
1
50
JM
/1
100
0
0
1000
0
2000
3000
4000
0.5
5000
1
6000
7000
1.5
6/
4/
5/
40
8000
9000
2
2.5
10000
3
11000 m /h
3
m /s
3
Volume Flow
Performance Table - 500 mm, 4 Pole
380-420v/50Hz/3f
Ref
m3/s @ Pa (Static)
Product
Code
0
50
100
2
50JM/16/4/5/40
3.02
2.74
2.42
1
50JM/20/4/6/40
2.96
2.76
2.52
150
2.21
Product, Electrical and ErP Table- 500 mm, 4 Pole
380-420v/50Hz/3f
Ref
Product
Code
Product
Number
Pitch Angle (°)
Min
Max
Speed
rev/min
Motor
Rating
(kW)
Full Load
Current
(A)
Starting
Current
(A)
Wiring
Diagram
(CD)
Speed Controller
Electronic Transformer
Inverter
2
50JM/16/4/5/40
XM531474
14
40
1420
80 (IE2)
0.9
1.92
9.79
CD2416
N/A
N/A
IDDXF54-2.2
1
50JM/20/4/6/40
XM531478
12
40
1420
80 (IE2)
0.9
1.92
9.79
CD2416
N/A
N/A
IDDXF54-2.2
Ref
Product
Code
Product
Number
Inlet
Sound
Levels
Efficiency
Rating
Target
Grade
2
50JM/16/4/5/40
XM531474
60
50.2
43.4
57
1
50JM/20/4/6/40
XM531478
59
48.2
43.8
54
Sound pressure levels quoted are at the inlet, and are average dBA at 3m distance over a sphere at the mid point at the highest angle given,
under free field conditions. These are presented for comparative purposes only.
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
33
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
JM XM Aerofoil Performance and Electrical Data
Performance Chart - 560 mm, 2 Pole
380-420v/50Hz/3f
JMXM Aerofoil
560 mm 2 Pole
1200
1100
1000
900
1
JM
700
/2
22
6/
2/
0/
Static Pressure (Pa)
56
800
600
500
400
300
200
100
0
0
5000
0
10000
1
2
15000
3
3
25000 m /h
3
m /s
20000
4
5
6
Volume Flow
Performance Table - 560 mm, 2 Pole
380-420v/50Hz/3f
Ref
1
m3/h @ Pa (Static)
Product
Code
56JM/20/2/6/22
0
50
100
150
200
250
300
400
500
600
700
800
900
5.95
5.86
5.77
5.68
5.58
5.48
5.38
5.16
4.93
4.68
4.4
4.08
3.72
Product, Electrical and ErP Table - 560 mm, 2 Pole
380-420v/50Hz/3f
Pitch Angle (°)
Speed
rev/min
Motor
Rating
(kW)
Full Load
Current
(A)
Starting
Current
(A)
Wiring
Diagram
(CD)
2910
112M (IE2)
6.05
11.7
77.2
CD2417
Ref
Product
Code
Product
Number
1
56JM/20/2/6/22
XM591271
Ref
Product
Code
Product
Number
Inlet
Sound
Levels
Efficiency
Rating
Target
Grade
1
56JM/20/2/6/22
XM591271
73
66.0
56.4
67
Min
Max
8
22
Speed Controller
Electronic Transformer
N/A
N/A
Inverter
IDDXF54-12
Sound pressure levels quoted are at the inlet, and are average dBA at 3m distance over a sphere at the mid point at the highest angle given,
under free field conditions. These are presented for comparative purposes only.
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
34
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
JM XM Aerofoil Performance and Electrical Data
Performance Chart - 560 mm, 4 Pole
380-420v/50Hz/3f
JMXM Aerofoil
560 mm 4 Pole
300
56
Static Pressure (Pa)
2
200
JM
/2
56
36
6/
4/
0/
1
JM
/1
30
5/
4/
6/
100
0
0
5000
0
0.5
1
10000
1.5
2
2.5
15000
3
3.5
4
m 3/h
m 3/s
Volume Flow
Performance Table - 560 mm, 4 Pole
380-420v/50Hz/3f
Ref
m3/s @ Pa (Static)
Product
Code
0
50
100
150
200
2
56JM/16/4/5/30
3.6
3.31
3.02
2.69
2.25
1
56JM/20/4/6/36
4.08
3.83
3.56
3.26
2.9
Product, Electrical and ErP Table - 560 mm, 4 Pole
380-420v/50Hz/3f
Ref
Product
Code
Product
Number
Pitch Angle (°)
Min
Max
Speed
rev/min
Motor
Rating
(kW)
Full Load
Current
(A)
Starting
Current
(A)
Wiring
Diagram
(CD)
Speed Controller
Electronic Transformer
Inverter
1
56JM/16/4/5/30
XM591473
8
30
1420
80 (IE2)
0.9
1.92
9.79
CD2416
N/A
N/A
IDDXF54-2.2
2
56JM/20/4/6/36
XM591478
10
36
1420
90S (IE2)
1.32
2.84
15.6
CD2416
N/A
N/A
IDDXF54-3.7
Ref
Product
Code
Product
Number
Inlet
Sound
Levels
Efficiency
Rating
Target
Grade
1
56JM/16/4/5/30
XM591473
59
55.0
51.8
61
2
56JM/20/4/6/36
XM591478
61
56.0
52.8
61
Sound pressure levels quoted are at the inlet, and are average dBA at 3m distance over a sphere at the mid point at the highest angle given,
under free field conditions. These are presented for comparative purposes only.
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
35
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
JM XM Aerofoil Performance and Electrical Data
Performance Chart - 630 mm
380-420v/50Hz/3f
JMXM Aerofoil
630 mm All
400
300
63
JM
/2
JM
36
6/
4/
0/
63
/2
22
6/
4/
0/
Static Pressure (Pa)
3
2
200
100
0
1
0
5000
0
63
JM
/2
0/
6/
6/
36
10000
1
2
15000
3
m 3/h
20000
4
5
6
m 3/s
Volume Flow
Performance Table - 630 mm
380-420v/50Hz/3f
Ref
m3/h @ Pa (Static)
Product
Code
0
50
100
150
200
250
300
400
500
600
700
800
1
63JM/20/4/6/22
4.04
3.84
3.63
3.39
3.13
2.79
15,516
14,796
14,040
13,176
12,204
10,980
2
63JM/20/4/6/36
5.93
5.61
5.29
4.95
4.59
4.19
17,820
17,028
16,164
15,228
14,148
12,888
3
63JM/20/6/6/36
3.76
3.25
2.66
Product, Electrical and ErP Table - 630 mm
380-420v/50Hz/3f
Ref
Product
Code
Product
Number
Pitch Angle (°)
Min
Max
Speed
rev/min
Motor
Rating
(kW)
Full Load
Current
(A)
Starting
Current
(A)
Wiring
Diagram
(CD)
Speed Controller
Electronic Transformer
Inverter
2
63JM/20/4/6/22
XM661473
8
22
1420
90S (IE2)
1.32
2.84
15.6
CD2416
N/A
N/A
IDDXF54-3.7
3
63JM/20/4/6/36
XM661474
12
36
1420
100L (IE2)
2.64
5.49
30.74
CD2416
N/A
N/A
IDDXF54-7.2
1
63JM/20/6/6/36
XM661652
18
36
900
80 (IE2)
0.66
1.64
6.07
CD2416
N/A
N/A
IDDXF54-2.2
Ref
Product
Code
Product
Number
Inlet
Sound
Levels
Efficiency
Rating
Target
Grade
2
63JM/20/4/6/22
XM661473
60
56.4
52.7
61
3
63JM/20/4/6/36
XM661474
64
55.6
54.0
59
1
63JM/20/6/6/36
XM661652
53
46.7
42.7
54
Sound pressure levels quoted are at the inlet, and are average dBA at 3m distance over a sphere at the mid point at the highest angle given,
under free field conditions. These are presented for comparative purposes only.
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
36
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
JM XM Aerofoil Performance and Electrical Data
Performance Chart - 710 mm
380-420v/50Hz/3f
JMXM Aerofoil
710 mm
500
3
/2
36
6/
4/
0/
/2
30
6/
4/
0/
JM
JM
71
71
300
2
Static Pressure (Pa)
400
200
1
100
0
0
5000
0
1
71
10000
2
JM
/2
0/
6/
6/
36
15000
3
20000
4
5
25000
6
30000
7
8
9
3
35000 m /h
3
m /s
Volume Flow
Performance Table - 710 mm
380-420v/50Hz/3f
Ref
m3/h @ Pa (Static)
Product
Code
0
50
100
150
200
250
300
2
71JM/20/4/6/30
7.64
7.36
7.07
6.77
6.45
6.11
5.73
3
71JM/20/4/6/36
8.74
8.4
8.03
7.65
7.25
6.81
6.33
1
71JM/20/6/6/36
5.46
4.89
4.22
Product, Electrical and ErP Table - 710 mm
380-420v/50Hz/3f
Ref
Product
Code
Product
Number
Pitch Angle (°)
Min
Max
Speed
rev/min
Motor
Rating
(kW)
Full Load
Current
(A)
Starting
Current
(A)
Wiring
Diagram
(CD)
Speed Controller
Electronic Transformer
Inverter
2
71JM/20/4/6/30
XM741471
8
30
1440
100L (IE2)
3.6
7.29
40.1
CD2416
N/A
N/A
IDDXF54-9
3
71JM/20/4/6/36
XM741474
10
36
1440
112M (IE2)
4.4
9.2
56.9
CD2417
N/A
N/A
IDDXF54-12
1
71JM/20/6/6/36
XM741673
14
36
900
90L (IE2)
1.32
3.13
13.15
CD2416
N/A
N/A
IDDXF54-3.7
Ref
Product
Code
Product
Number
Inlet
Sound
Levels
Efficiency
Rating
Target
Grade
2
71JM/20/4/6/30
XM741471
66
62.5
55.4
65
3
71JM/20/4/6/36
XM741474
69
59.9
56.0
61
1
71JM/20/6/6/36
XM741673
58
54.5
52.4
60
Sound pressure levels quoted are at the inlet, and are average dBA at 3m distance over a sphere at the mid point at the highest angle given,
under free field conditions. These are presented for comparative purposes only.
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
37
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
JM XM Aerofoil Performance and Electrical Data
Performance Chart - 800 mm, 4 Pole
380-420v/50Hz/3f
JMXM Aerofoil
800 mm 4 Pole
700
600
2
400
80
JM
/2
80
300
JM
/2
22
9/
4/
5/
200
28
9/
4/
5/
1
Static Pressure (Pa)
500
100
0
0
5000
0
10000
15000
2
20000
4
25000
30000
6
35000
8
40000
10
m 3/h
m 3/s
Volume Flow
Performance Table - 800 mm, 4 Pole
380-420v/50Hz/3f
Ref
m3/h @ Pa (Static)
Product
Code
0
50
100
150
200
250
300
400
1
80JM/25/4/9/22
8.4
8.15
7.89
7.62
7.34
7.04
6.72
5.95
2
80JM/25/4/9/28
10.06
9.8
9.53
9.24
8.92
8.58
8.2
7.34
Product, Electrical and ErP Table - 800 mm, 4 Pole
380-420v/50Hz/3f
Pitch Angle (°)
Speed Controller
Speed
rev/min
Motor
Rating
(kW)
Full Load
Current
(A)
Starting
Current
(A)
Wiring
Diagram
(CD)
22
1440
112M (IE2)
4.8
8.56
56.49
CD2417
N/A
N/A
IDDXF54-9
28
1455
132S (IE2)
6.6
12.6
84.4
CD2417
N/A
N/A
IDDXF54-15.5
Ref
Product
Code
Product
Number
Min
Max
1
80JM/25/4/9/22
XM831475
8
2
80JM/25/4/9/28
XM831478
8
Ref
Product
Code
Product
Number
Inlet
Sound
Levels
Efficiency
Rating
Target
Grade
1
80JM/25/4/9/22
XM831475
71
66.0
55.9
62
2
80JM/25/4/9/28
XM831478
71
60.2
56.7
61
Electronic Transformer
Inverter
Sound pressure levels quoted are at the inlet, and are average dBA at 3m distance over a sphere at the mid point at the highest angle given,
under free field conditions. These are presented for comparative purposes only.
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
38
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
JM XM Aerofoil Performance and Electrical Data
Performance Chart - 800 mm, 6 Pole
380-420v/50Hz/3f
JMXM Aerofoil
800 mm 6 Pole
2
80
JM
1
/2
JM
36
6/
6/
0/
80
100
/2
24
6/
6/
0/
Static Pressure (Pa)
200
0
0
5000
0
10000
1
2
15000
3
20000
4
5
25000
6
7
30000
8
m 3/h
m 3/s
Volume Flow
Performance Table - 800 mm, 6 Pole
380-420v/50Hz/3f
Ref
m3/h @ Pa (Static)
Product
Code
0
50
100
150
1
80JM/20/6/6/24
6.12
5.53
4.9
4.15
2
80JM/20/6/6/36
7.92
7.3
6.54
5.61
Product, Electrical and ErP Table - 800 mm, 6 Pole
380-420v/50Hz/3f
Ref
Product
Code
Product
Number
Pitch Angle (°)
Min
Max
Speed
rev/min
Motor
Rating
(kW)
Full Load
Current
(A)
Starting
Current
(A)
Wiring
Diagram
(CD)
Speed Controller
Electronic Transformer
Inverter
1
80JM/20/6/6/24
XM831671
8
24
935
90L (IE2)
1.32
3.13
13.15
CD2416
N/A
N/A
IDDXF54-3.7
2
80JM/20/6/6/36
XM831672
14
36
935
112M (IE2)
2.64
6.18
26.5
CD2417
N/A
N/A
IDDXF54-7.2
Ref
Product
Code
Product
Number
Inlet
Sound
Levels
Efficiency
Rating
Target
Grade
1
80JM/20/6/6/24
XM831671
58
55.3
52.5
60
2
80JM/20/6/6/36
XM831672
63
54.7
54.1
58
Sound pressure levels quoted are at the inlet, and are average dBA at 3m distance over a sphere at the mid point at the highest angle given,
under free field conditions. These are presented for comparative purposes only.
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
39
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
JM XM Aerofoil Performance and Electrical Data
Performance Chart - 900 mm, 4 Pole
380-420v/50Hz/3f
JMXM Aerofoil
900 mm 4 Pole
800
700
1
2
500
JM
/
JM
90
90
/2
4
/2
/9
/4
400
34
9/
4/
5/
25
Static Pressure (Pa)
600
300
200
100
0
0
10000
0
20000
2
4
30000
6
40000
8
50000
10
12
14
m 3/h
60000
16
3
18 m /s
Volume Flow
Performance Table - 900 mm, 4 Pole
380-420v/50Hz/3f
Ref
m3/s @ Pa (Static)
Product
Code
0
50
100
150
200
250
300
400
500
600
8.79
1
90JM/25/4/9/24
13.21
12.9
12.6
12.29
11.97
11.65
11.33
10.64
9.85
2
90JM/25/4/9/34
17.07
16.67
16.26
15.84
15.4
14.94
14.46
13.44
12.29
Product, Electrical and ErP Table - 900 mm, 4 Pole
380-420v/50Hz/3f
Ref
Pitch Angle (°)
Speed Controller
Speed
rev/min
Motor
Rating
(kW)
Full Load
Current
(A)
Starting
Current
(A)
Wiring
Diagram
(CD)
24
1440
132M (IE2)
9
17
114
CD2417
N/A
N/A
IDDXF54-23
32
1440
160M (IE2)
13.2
25.4
127
CD2417
N/A
N/A
IDDXF54-31
Product
Code
Product
Number
Min
Max
8
10
1
90JM/25/4/9/24
XM931473
2
90JM/25/4/9/34
XM931476
Ref
Product
Code
Product
Number
Inlet
Sound
Levels
Efficiency
Rating
Target
Grade
1
90JM/25/4/9/24
XM931473
74
68.0
57.8
68
2
90JM/25/4/9/34
XM931476
77
63.6
58.2
63
Electronic Transformer
Inverter
Sound pressure levels quoted are at the inlet, and are average dBA at 3m distance over a sphere at the mid point at the highest angle given,
under free field conditions. These are presented for comparative purposes only.
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
40
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
JM XM Aerofoil Performance and Electrical Data
Performance Chart - 900 mm, 6 and 8 Pole
380-420v/50Hz/3f
JMXM Aerofoil
900 mm 6 & 8 Pole
300
90
JM
/2
200
5/
6/
9/
24
2
90
Static Pressure (Pa)
3
0
10000
0
90
JM
/2
5/
8/
9/
36
32
6/
6/
5/
0
1
/2
JM
100
20000
2
4
30000
6
40000
8
10
m 3/h
m 3/s
Volume Flow
Performance Table - 900 mm, 6 and 8 Pole
380-420v/50Hz/3f
Ref
m3/s @ Pa (Static)
Product
Code
0
50
100
150
2
90JM/25/6/6/32
9.81
9.05
8.21
7.2
3
90JM/25/6/9/24
8.58
8.1
7.62
7.11
1
90JM/25/8/9/36
8.59
7.65
6.54
200
250
6.54
5.77
Product, Electrical and ErP Table - 900 mm, 6 and 8 Pole
380-420v/50Hz/3f
Ref
Product
Code
Product
Number
Pitch Angle (°)
Min
Max
Speed
rev/min
Motor
Rating
(kW)
Full Load
Current
(A)
Starting
Current
(A)
Wiring
Diagram
(CD)
Speed Controller
Electronic Transformer
Inverter
2
90JM/25/6/6/32
XM933672
10
32
935
112M (IE2)
2.64
6.18
26.5
CD2417
N/A
N/A
IDDXF54-7.2
3
90JM/25/6/9/24
XM931672
8
24
935
112M (IE2)
2.64
6.18
26.5
CD2417
N/A
N/A
IDDXF54-7.2
1
90JM/25/8/9/36
XM931872
12
36
695
112M (IE2)
1.8
4.51
19.39
CD2417
N/A
N/A
IDDXF54-5.3
Ref
Product
Code
Product
Number
Inlet
Sound
Levels
Efficiency
Rating
Target
Grade
2
90JM/25/6/6/32
XM933672
65
58.2
54.5
61
3
90JM/25/6/9/24
XM931672
63
62.8
54.4
66
1
90JM/25/8/9/36
XM931872
61
54.8
53.5
59
Sound pressure levels quoted are at the inlet, and are average dBA at 3m distance over a sphere at the mid point at the highest angle given,
under free field conditions. These are presented for comparative purposes only.
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
41
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
JM XM Aerofoil Performance and Electrical Data
Performance Chart - 1000 mm, 4 Pole
380-420v/50Hz/3f
JMXM Aerofoil
1000 mm 4 Pole
1000
900
800
600
3
10
M
0J
2
500
/
/
25
4/
/
300
25
/
4/
28
9/
M
22
9/
4/
5/
0J
/2
10
M
0J
1
400
10
Static Pressure (Pa)
700
6/
200
22
100
0
0
10000
20000
0
30000
40000
5
50000
10
60000
70000
15
80000
20
m 3/h
m 3/s
Volume Flow
Performance Table - 1000 mm, 4 Pole
380-420v/50Hz/3f
Ref
m3/s @ Pa (Static)
Product
Code
0
50
100
150
200
250
300
400
500
600
1
100JM/25/4/6/22
16.46
15.91
15.35
14.78
14.21
13.62
13.01
11.68
10.04
3
100JM/25/4/9/28
20.96
20.52
20.07
19.61
19.12
18.63
18.11
16.99
15.75
14.33
2
100JM/25/4/9/22
17.68
17.24
16.79
16.33
15.88
15.41
14.93
13.91
12.75
11.36
Product, Electrical and ErP Table - 1000 mm, 4 Pole
380-420v/50Hz/3f
Pitch Angle (°)
Motor
Rating
(kW)
Full Load
Current
(A)
Starting
Current
(A)
Wiring
Diagram
(CD)
22
1440
132M (IE2)
9
17
114
CD2417
N/A
N/A
IDDXF54-23
8
28
1470
160L (IE2)
18
34.8
171
CD2417
N/A
N/A
IDDXF54-37
8
22
1470
160M (IE2)
13.2
25.4
127
CD2417
N/A
N/A
IDDXF54-31
Product
Code
Product
Number
Min
Max
1
100JM/25/4/6/22
XM133472
8
3
100JM/25/4/9/28
XM131475
2
100JM/25/4/9/22
XM131479
Ref
Product
Code
Product
Number
Speed Controller
Speed
rev/min
Ref
Inlet
Sound
Levels
Efficiency
Rating
Target
Grade
1
100JM/25/4/6/22 XM133472
79
68.6
57.6
69
3
100JM/25/4/9/28 XM131475
81
66.6
58.3
66
2
100JM/25/4/9/22 XM131479
80
63.5
58.1
63
Electronic Transformer
Inverter
Sound pressure levels quoted are at the inlet, and are average dBA at 3m distance over a sphere at the mid point at the highest angle given,
under free field conditions. These are presented for comparative purposes only.
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
42
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
JM XM Aerofoil Performance and Electrical Data
Performance Chart - 1000 mm, 6 and 8 Pole
380-420v/50Hz/3f
JMXM Aerofoil
1000 mm 6 & 8 Pole
300
2
Static Pressure (Pa)
200
1
100
10
10
0J
M
0J
/2
5/
6/
6/
22
M
/2
5/
8/
9/
26
0
0
10000
0
20000
2
4
30000
6
40000
8
10
m 3/h
m 3/s
Volume Flow
Performance Table - 1000 mm, 6 and 8 Pole
380-420v/50Hz/3f
Ref
m3/h @ Pa (Static)
Product
Code
0
50
100
150
200
8.11
6.98
2
100JM/25/6/6/22
10.78
9.93
9.05
1
100JM/25/8/9/26
9.4
8.41
7.28
Product, Electrical and ErP Table - 1000 mm, 6 and 8 Pole
380-420v/50Hz/3f
Ref
Product
Code
Product
Number
Pitch Angle (°)
Min
Max
Speed
rev/min
Rating
(kW)
Motor
Full Load
Current
(A)
Starting
Current
(A)
Wiring
Diagram
(CD)
Speed Controller
Electronic Transformer
Inverter
2
100JM/25/8/9/26
XM131872
8
26
695
112M (IE2)
1.8
4.51
19.39
CD2417
N/A
N/A
IDDXF54-5.3
1
100JM/25/6/6/22
XM133672
8
22
950
112M (IE2)
2.64
6.18
26.5
CD2417
N/A
N/A
IDDXF54-7.2
Ref
Product
Code
Product
Number
Inlet
Sound
Levels
Efficiency
Rating
Target
Grade
2
100JM/25/8/9/26
XM131872
62
56.9
53.4
61
1
100JM/25/6/6/22
XM133672
69
63.4
54.3
67
Sound pressure levels quoted are at the inlet, and are average dBA at 3m distance over a sphere at the mid point at the highest angle given,
under free field conditions. These are presented for comparative purposes only.
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
43
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
Drawing - X Mount Fans, 500-1000 mm
500-1000 mm
C
F
2 X ØR
E
X
P
B
A
D
"S" NUMBER OF HOLES
"T" ON "H" PCD
Q
X
"K" CRS
"L" CRS
M
Product
Code
Motor
Size
ØA
ØB
C
D
E
F
H
K
L
M
P
Q
ØR
S
T
Weight(s) (kg)
500
D80
500
594
375
328.5
2.5
405
560
274
450
500
315
3
20
12
12
46
500
D90
500
594
520
328.5
3
405
560
419
450
500
315
3
20
12
12
51 (D90S)
500
D100
500
594
520
328.5
3
405
560
419
450
500
315
3
20
12
12
65
500
D112
500
594
520
328.5
3
405
560
419
450
500
315
3
20
12
12
97
580
D80
560
654
375
358.5
2.5
405
620
274
510
560
355
3
20
12
12
49
580
D90
560
654
520
358.5
3
405
620
419
510
560
355
3
20
12
12
55 (D90S)
580
D100
560
654
520
358.5
3
405
620
419
510
560
355
3
20
12
12
68
100
580
D112
560
654
520
358.5
3
405
620
419
510
560
355
3
20
12
12
630
D80
630
724
375
393.5
3
405
690
259
580
630
400
3
20
12
12
55
630
D90
630
724
520
393.5
3
405
690
404
580
630
400
3
20
12
12
61 (D90S)
630
D100
630
724
520
393.5
3
405
690
404
580
630
400
3
20
12
12
75
56 (D90L)
60 (D90L)
66 (D90L)
630
D112
630
724
520
393.5
3
405
690
404
580
630
400
3
20
12
12
113
630
D132
630
724
620
393.5
4
509
690
607
580
630
400
3
32.5
12
12
140 (D132S)
143 (D132L)
630
D160
630
724
725
393.5
4
509
690
607
580
630
400
3
32.5
12
12
197 (D160M)
217 (160L)
710
D80
710
804
520
433.5
3
405
770
404
660
710
440
5
20
16
12
60
710
D90
710
804
520
433.5
3
405
770
404
660
710
440
5
20
16
12
66 (D90S)
710
D100
710
804
520
433.5
3
405
770
404
660
710
440
5
20
16
12
79
710
D112
710
804
520
433.5
3
405
770
404
660
710
440
5
20
16
12
118
710
D132
710
804
620
433.5
4
509
770
607
660
710
440
5
32.5
16
12
148 (D132S)
800
D80
800
894
520
478.5
3
405
860
404
750
800
500
6
20
16
12
65
800
D90
800
894
520
478.5
3
405
860
404
750
800
500
6
20
16
12
72 (D90S)
800
D100
800
894
520
478.5
3
405
860
404
750
800
500
6
20
16
12
85
71 (D90L)
151 (D132M)
77 (D90L)
800
D112
800
894
520
478.5
3
405
860
404
750
800
500
6
20
16
12
123
800
D132
800
894
620
478.5
5
509
860
607
750
800
500
6
32.5
16
12
161 (D132S)
164 (D132M)
800
D160
800
894
725
478.5
5
509
860
607
750
800
500
6
32.5
16
12
221 (D160M)
241 (D160L)
900
D112
900
1006
520
528.5
3
405
970
404
850
900
560
6
20
16
15
130
900
D132
900
1006
620
528.5
5
509
970
607
850
900
560
6
32.5
16
15
187(D132S)
190 (D132M)
900
D160
900
1006
725
528.5
5
509
970
607
850
900
560
6
32.5
16
15
225 (D160S)
272 (D160L)
1000
D112
1000
1106
520
578.5
3
405
1070
384
950
1000
630
6
20
16
15
137
1000
D132
1000
1106
620
578.5
5
509
1070
585
950
1000
630
6
32.5
16
15
199 (D132S)
202 (D132M)
1000
D160
1000
1106
725
578.5
5
509
1070
585
950
1000
630
6
32.5
16
15
265 (D160M)
285 (D160L)
All dimensions in mm
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
44
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
JM ‘S’ Aerofoil Performance and Electrical Data
380-420v/50Hz/3f - S Type
Performance Chart - 315-355 mm, 2 Pole
380-420v/50Hz/3f
JM Aerofoil S Type
315- 355 mm 2 Pole
600
500
2
300
35
1
31
JM
Static Pressure (Pa)
400
/1
200
/1
6/
2/
5/
40
40
5/
2/
6/
100
0
JM
0
m 3/h
5000
0
0.5
1
1.5
2
m 3/s
Volume Flow
Performance Table - 315-355 mm, 2 Pole
380-420v/50Hz/3f
Ref
m3/s @ Pa (Static)
Product
Code
0
50
100
150
200
250
300
1
31JM/16/2/5/40
1.34
1.29
1.23
1.17
1.1
1.01
0.91
2
35JM/16/2/5/40
2.03
1.96
1.89
1.81
1.73
1.64
1.54
400
1.28
Product, Electrical and ErP Table - 315-355 mm, 2 Pole
380-420v/50Hz/3f
Pitch Angle (°)
Speed Controller
Speed
rev/min
Motor
Rating
(kW)
Full Load
Current
(A)
Starting
Current
(A)
Wiring
Diagram
(CD)
40
2840
80 (IE2)
0.90
1.95
9.75
CD2416
n/a
n/a
IDDXF54-2.2
40
2840
80 (IE2)
1.32
2.79
14.5
CD2416
n/a
n/a
IDDXF54-3.7
Ref
Product
Code
Product
Number
Min
Max
1
31JM/16/2/5/40
JS341202
18
2
35JM/16/2/5/40
JS381274
14
Ref
Product
Code
Product
Number
Inlet
Sound
Levels
Efficiency
Rating
Target
Grade
1
31JM/16/2/5/40
JS341202
61
43.3
43.1
50
2
35JM/16/2/5/40
JS381274
67
47.6
44.7
53
Electronic Transformer
Inverter
Sound pressure levels quoted are at the inlet, and are average dBA at 3m distance over a sphere at the mid point at the highest angle given,
under free field conditions. These are presented for comparative purposes only.
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
45
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
JM ‘S’ Aerofoil Performance and Electrical Data
Performance Chart - 315-355 mm, 4 Pole
380-420v/50Hz/3f
JM Aerofoil S Type
315- 355 mm 4 Pole
150
100
35
JM
/1
1
Static Pressure (Pa)
2
31
JM
/1
32
5/
4/
6/
50
0
6/
4/
5/
26
0
1000
0
0.1
0.2
2000
0.3
0.4
0.5
0.6
0.7
0.8
3
3000 m /h
3
m /s
Volume Flow
Performance Table - 315-355 mm, 4 Pole
380-420v/50Hz/3f
Ref
m3/s @ Pa (Static)
Product
Code
0
50
100
1
31JM/16/4/5/32
0.56
0.46
0.29
2
35JM/16/4/5/26
0.71
0.61
0.44
Product, Electrical and ErP Table - 315-355 mm, 4 Pole
380-420v/50Hz/3f
Pitch Angle (°)
Speed Controller
Speed
rev/min
Motor
Rating
(kW)
Full Load
Current
(A)
Starting
Current
(A)
Wiring
Diagram
(CD)
32
1420
BT4 (IE1)
0.087
0.35
1.12
CD2420
n/a
TDID 2.5A
IDDXF54-2.2
26
1420
BT4 (IE1)
0.10
0.36
1.00
CD2416
n/a
TDID 2.5A
IDDXF54-2.2
Ref
Product
Code
Product
Number
Min
Max
1
31JM/16/4/5/32
JS341460
8
2
35JM/16/4/5/26
JS381452
8
Ref
Product
Code
Product
Number
Inlet
Sound
Levels
Efficiency
Rating
Target
Grade
1
31JM/16/4/5/32
JS341460
42
-
-
-
2
35JM/16/4/5/26
JS381452
43
37.8
38.1
50
Electronic Transformer
Inverter
Sound pressure levels quoted are at the inlet, and are average dBA at 3m distance over a sphere at the mid point at the highest angle given,
under free field conditions. These are presented for comparative purposes only.
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
46
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
JM ‘S’ Aerofoil Performance and Electrical Data
Performance Chart - 400-450 mm, 2 Pole
380-420v/50Hz/3f
JM Aerofoil S Type
400- 450 mm 2 Pole
1000
900
800
600
3
45
JM
500
/
20
2
45
20
5/
2/
32
6/
5/
2/
6/
/1
/1
JM
JM
40
300
4
/3
/6
/2
400
1
Static Pressure (Pa)
700
200
100
0
0
5000
0
0.5
1
10000
1.5
2
2.5
15000
3
3.5
4
m 3/h
m 3/s
Volume Flow
Performance Table - 400-450 mm, 2 Pole
380-420v/50Hz/3f
Ref
m3/h @ Pa (Static)
Product
Code
0
50
100
150
200
250
300
400
500
1
40JM/16/2/5/32
2.58
2.51
2.43
2.35
2.26
2.17
2.07
1.85
1.6
2
45JM/16/2/5/20
2.7
2.63
2.56
2.48
2.4
2.32
2.23
2.04
1.81
3
45JM/20/2/6/34
3.87
3.79
3.72
3.63
3.55
3.46
3.37
3.18
2.96
600
700
2.71
2.41
Product, Electrical and ErP Table - 400-450 mm, 2 Pole
380-420v/50Hz/3f
Ref
Product
Code
Product
Number
Pitch Angle (°)
Min
Max
Speed
rev/min
Motor
Rating
(kW)
Full Load
Current
(A)
Starting
Current
(A)
Wiring
Diagram
(CD)
ErP
Compliant
Speed Controller
Electronic Transformer
Inverter
FMEG
(50=Pass)
Inlet
Sound
Levels
1
40JM/16/2/5/32
JS431273
10
32
2840
80 (IE2)
1.73
3.59
18.3
CD2416
n/a
n/a
IDDXF54-3.7
53-57
66
2
45JM/16/2/5/20
ES481272
8
20
2840
80 (IE2)
1.73
3.59
18.3
CD2416
n/a
n/a
IDDXF54-3.7
63
66
3
45JM/20/2/6/34
ES481275
10
34
2910
100 (IE2)
3.60
7.1
45.44
CD2416
n/a
n/a
IDDXF54-7.2
51-62
72
Ref
Product
Code
Product
Number
Inlet
Sound
Levels
Efficiency
Rating
Target
Grade
1
40JM/16/2/5/32
JS431273
66
52.0
45.3
57
2
45JM/16/2/5/20
ES481272
66
58.3
53.1
63
3
45JM/20/2/6/34
ES481275
72
52.3
47.5
55
Sound pressure levels quoted are at the inlet, and are average dBA at 3m distance over a sphere at the mid point at the highest angle given,
under free field conditions. These are presented for comparative purposes only.
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
47
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
JM ‘S’ Aerofoil Performance and Electrical Data
Performance Chart - 400-450 mm, 4 Pole
380-420v/50Hz/3f
JM Aerofoil S Type
400- 450 mm 4 Pole
2
1
45
100
/1
/
JM
JM
40
34
5/
4/
6/
16
6
/1
/5
/4
Static Pressure (Pa)
200
0
0
m 3/h
5000
0
0.5
1
1.5
2
m 3/s
Volume Flow
Performance Table - 400-450 mm, 4 Pole
380-420v/50Hz/3f
Ref
m3/s @ Pa (Static)
Product
Code
0
50
100
150
1
40JM/16/4/5/16
0.77
0.66
0.5
0.18
2
45JM/16/4/5/34
1.98
1.76
1.51
1.22
Product, Electrical and ErP Table - 400-450 mm, 4 Pole
380-420v/50Hz/3f
Ref
Product
Code
Product
Number
Pitch Angle (°)
Min
Max
Speed
rev/min
Motor
Rating
(kW)
Full Load
Current
(A)
Starting
Current
(A)
Wiring
Diagram
(CD)
Speed Controller
Electronic Transformer
Inverter
1
40JM/16/4/5/16
JS431452
8
16
1420
BT4 (IE1)
0.10
0.36
1.00
CD2416
n/a
TDID 2.5A
IDDXF54-2.2
2
45JM/16/4/5/34
JS481453
20
34
1420
BT9 (IE1)
0.39
1.26
3.9
CD2417
n/a
n/a
IDDXF54-2.2
Ref
Product
Code
Product
Number
Inlet
Sound
Levels
Efficiency
Rating
Target
Grade
1
40JM/16/4/5/16
JS431452
47
39.7
38.2
51
2
45JM/16/4/5/34
JS481453
53
41.7
42.0
50
Sound pressure levels quoted are at the inlet, and are average dBA at 3m distance over a sphere at the mid point at the highest angle given,
under free field conditions. These are presented for comparative purposes only.
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
48
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
JM ‘S’ Aerofoil Performance and Electrical Data
Performance Chart - 500 mm, 2 Pole
380-420v/50Hz/3f
JM Aerofoil S Type
500 mm 2 Pole
1000
900
800
700
50
JM
/2
2
JM
/2
0/
2/
300
6/
28
6/
2/
0/
JM
/2
50
400
34
6/
2/
0/
50
500
1
Static Pressure (Pa)
3
600
24
200
100
0
0
5000
0
10000
1
2
15000
3
4
5
3
20000 m /h
3
m /s
Volume Flow
Performance Table - 500 mm, 2 Pole
380-420v/50Hz/3f
Ref
m3/s @ Pa (Static)
Product
Code
0
50
100
150
200
250
300
400
500
600
700
800
1
50JM/20/2/6/28
4.85
4.77
4.68
4.59
4.5
4.41
4.31
4.11
3.9
3.66
3.39
3.05
2
50JM/20/2/6/34
5.56
5.46
5.36
5.27
5.16
5.06
4.95
4.73
4.49
4.23
3.93
3.58
Product, Electrical and ErP Table - 500 mm, 2 Pole
380-420v/50Hz/3f
Pitch Angle (°)
Speed Controller
Speed
rev/min
Motor
Rating
(kW)
Full Load
Current
(A)
Starting
Current
(A)
Wiring
Diagram
(CD)
28
2910
100 (IE2)
4.60
7.91
42.71
CD2416
n/a
n/a
IDDXF54-9
34
2910
112M (IE2)
6.05
10.3
58.71
CD2417
n/a
n/a
IDDXF54-12
Ref
Product
Code
Product
Number
Min
Max
1
50JM/20/2/6/28
JS531273
8
2
50JM/20/2/6/34
JS532660
10
Ref
Product
Code
Product
Number
Inlet
Sound
Levels
Efficiency
Rating
Target
Grade
1
50JM/20/2/6/28
JS531273
72
55.3
50.1
63
2
50JM/20/2/6/34
JS532660
75
52.3
50.8
59
Electronic Transformer
Inverter
Sound pressure levels quoted are at the inlet, and are average dBA at 3m distance over a sphere at the mid point at the highest angle given,
under free field conditions. These are presented for comparative purposes only.
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
49
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
JM ‘S’ Aerofoil Performance and Electrical Data
Performance Chart - 560 mm, 2 Pole
380-420v/50Hz/3f
JM Aerofoil S Type
560 mm 2 Pole
800
700
1
500
56
JM
/
20
400
24
3/
2/
/
Static Pressure (Pa)
600
300
200
100
0
0
10000
0
1
2
m 3/h
20000
3
4
5
6
m 3/s
Volume Flow
Performance Table - 560 mm, 2 Pole
380-420v/50Hz/3f
Ref
1
m3/s @ Pa (Static)
Product
Code
56JM/20/2/3/24
0
50
100
150
200
250
300
400
500
600
700
5.77
5.62
5.45
5.29
5.12
4.95
4.77
4.39
3.98
3.52
2.97
Product, Electrical and ErP Table - 560 mm, 2 Pole
380-420v/50Hz/3f
Pitch Angle (°)
Speed
rev/min
Motor
Rating
(kW)
Full Load
Current
(A)
Starting
Current
(A)
Wiring
Diagram
(CD)
2910
100 (IE2)
3.60
7.1
45.44
CD2416
Ref
Product
Code
Product
Number
1
56JM/20/2/3/24
ES592272
Ref
Product
Code
Product
Number
Inlet
Sound
Levels
Efficiency
Rating
Target
Grade
1
56JM/20/2/3/24
ES592272
68
65.2
55.5
67
Min
Max
8
24
Speed Controller
Electronic Transformer
n/a
n/a
Inverter
IDDXF54-7.2
Sound pressure levels quoted are at the inlet, and are average dBA at 3m distance over a sphere at the mid point at the highest angle given,
under free field conditions. These are presented for comparative purposes only.
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
50
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
JM ‘S’ Aerofoil Performance and Electrical Data
Performance Chart - 560 mm, 4 Pole
380-420v/50Hz/3f
JM Aerofoil S Type
560 mm 4 Pole
300
200
56
Static Pressure (Pa)
2
JM
/2
36
6/
4/
0/
1
56
JM
/1
0
30
5/
4/
6/
100
0
m 3/h
10000
0
0.5
1
1.5
2
2.5
3
3.5
4
m 3/s
Volume Flow
Performance Table - 560 mm, 4 Pole
380-420v/50Hz/3f
Ref
m3/s @ Pa (Static)
Product
Code
0
50
100
150
200
2
56JM/20/4/6/36
4.08
3.83
3.56
3.26
2.9
1
56JM/16/4/5/30
3.6
3.31
3.02
2.69
2.25
Product, Electrical and ErP Table - 560 mm, 4 Pole
380-420v/50Hz/3f
Pitch Angle (°)
Speed Controller
Speed
rev/min
Motor
Rating
(kW)
Full Load
Current
(A)
Starting
Current
(A)
Wiring
Diagram
(CD)
30
1420
80 (IE2)
0.90
1.92
9.8
CD2416
n/a
n/a
IDDXF54-2.2
36
1420
90 (IE2)
1.32
2.84
15.6
CD2416
n/a
n/a
IDDXF54-3.7
Ref
Product
Code
Product
Number
Min
Max
2
56JM/20/4/6/36
JS594583
8
1
56JM/16/4/5/30
JS591478
10
Ref
Product
Code
Product
Number
Inlet
Sound
Levels
Efficiency
Rating
Target
Grade
1
56JM/20/4/6/36
JS594583
61
56.0
52.8
61
2
56JM/16/4/5/30
JS591478
51
55.0
51.8
61
Electronic Transformer
Inverter
Sound pressure levels quoted are at the inlet, and are average dBA at 3m distance over a sphere at the mid point at the highest angle given,
under free field conditions. These are presented for comparative purposes only.
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
51
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
JM ‘S’ Aerofoil Performance and Electrical Data
Performance Chart - 630 mm
380-420v/50Hz/3f
JM Aerofoil S Type
630 mm
350
300
2
200
63
1
JM
150
20
36
6/
4/
0/
/
JM
/2
63
Static Pressure (Pa)
250
2
/2
/6
/4
100
50
0
0
10000
0
1
2
m 3/h
20000
3
4
5
6
m 3/s
Volume Flow
Performance Table - 630 mm
380-420v/50Hz/3f
Ref
m3/s @ Pa (Static)
Product
Code
0
50
100
150
200
250
1
63JM/20/4/6/22
4.04
3.84
3.63
3.39
3.13
2.79
2
63JM/20/4/6/36
5.93
5.61
5.29
4.95
4.59
4.19
Product, Electrical and ErP Table - 630 mm
380-420v/50Hz/3f
Pitch Angle (°)
Speed Controller
Speed
rev/min
Motor
Rating
(kW)
Full Load
Current
(A)
Starting
Current
(A)
Wiring
Diagram
(CD)
22
1420
90 (IE2)
1.32
2.84
15.6
CD2416
n/a
n/a
IDDXF54-3.7
36
1420
100 (IE2)
2.64
5.49
30.74
CD2416
n/a
n/a
IDDXF54-7.2
Ref
Product
Code
Product
Number
Min
Max
1
63JM/20/4/6/22
ES661473
8
2
63JM/20/4/6/36
JS661474
12
Ref
Product
Code
1
2
Product
Number
Inlet
Sound
Levels
Efficiency
Rating
Target
Grade
63JM/20/4/6/22
ES661473
60
56.4
52.7
61
63JM/20/4/6/36
JS661474
64
55.6
54.0
59
Electronic Transformer
Inverter
Sound pressure levels quoted are at the inlet, and are average dBA at 3m distance over a sphere at the mid point at the highest angle given,
under free field conditions. These are presented for comparative purposes only.
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
52
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
JM ‘S’ Aerofoil Performance and Electrical Data
Performance Chart - 710 mm
380-420v/50Hz/3f
JM Aerofoil S Type
710 mm
600
2
500
71
JM
/2
Static Pressure (Pa)
400
5/
4/
9/
34
300
3
1
2
36
0
6/
10000
4/
0/
6/
6/
36
0/
/2
/2
0
JM
30
6/
4/
0/
71
JM
/2
1
100
0
71
JM
4
71
200
20000
3
4
5
m 3/h
30000
6
7
8
9
m 3/s
Volume Flow
Performance Table - 710 mm
380-420v/50Hz/3f
m3/s @ Pa (Static)
Ref
Product
Code
3
71JM/20/4/6/30
0
50
100
150
200
250
300
7.64
7.36
7.07
6.77
6.45
6.11
5.73
7.07
6.77
6.45
6.11
7.65
7.25
6.81
6.33
2
71JM/25/4/9/34
7.89
7.63
7.36
1
71JM/20/6/6/36
5.46
4.89
4.22
4
71JM/20/4/6/36
8.74
8.4
8.03
Product, Electrical and ErP Table - 710 mm
380-420v/50Hz/3f
Ref
Product
Code
Product
Number
Pitch Angle (°)
Min
Max
Speed
rev/min
Motor
Rating
(kW)
Full Load
Current
(A)
Starting
Current
(A)
Wiring
Diagram
(CD)
ErP
Compliant
Speed Controller
Electronic Transformer
Inverter
FMEG
(50=Pass)
Inlet
Sound
Levels
3
71JM/20/4/6/30
JS741471
8
30
1440
100 (IE2)
3.60
7.29
40.09
CD2416
n/a
n/a
IDDXF54-9
52-70
67
2
71JM/25/4/9/34
JS741473
10
34
1440
112M (IE2)
4.80
9.20
56.90
CD2417
n/a
n/a
IDDXF54-12
54-61
68
1
71JM/20/6/6/36
JS741673
14
36
900
90L (IE2)
1.32
3.13
13.15
CD2416
n/a
n/a
IDDXF54-3.7
55-65
58
4
71JM/20/4/6/36
JS744644
10
36
1440
112M (IE2)
4.40
8.70
57.3
CD2417
n/a
n/a
IDDXF54-9
54-70
70
Ref
Product
Code
Product
Number
Inlet
Sound
Levels
Efficiency
Rating
Target
Grade
3
71JM/20/4/6/30
JS741471
67
62.5
55.4
65
2
71JM/25/4/9/34
JS741473
68
54.5
48
56
1
71JM/20/6/6/36
JS741673
58
54.5
52.4
60
4
71JM/20/4/6/36
JS744644
70
59.9
56.0
61
Sound pressure levels quoted are at the inlet, and are average dBA at 3m distance over a sphere at the mid point at the highest angle given,
under free field conditions. These are presented for comparative purposes only.
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
53
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
JM ‘S’ Aerofoil Performance and Electrical Data
Performance Chart - 800 mm
380-420v/50Hz/3f
JM Aerofoil S Type
800 mm
600
500
4
300
80
/2
20000
2
4
28
9/
4/
5/
0
22
9/
4/
0/
0/
6/
6/
24
10000
/2
/2
4
/2
/6
/4
JM
JM
0
80
20
100
/
JM
1
0
80
80
200
JM
3
2
Static Pressure (Pa)
400
3
40000 m /h
3
m /s
30000
6
8
10
Volume Flow
Performance Table - 800 mm
380-420v/50Hz/3f
Ref
m3/h @ Pa (Static)
Product
Code
0
50
100
150
200
250
300
400
3
80JM/25/4/9/22
8.4
8.15
7.89
7.62
7.34
7.04
6.72
5.95
4
80JM/25/4/9/28
10.06
9.8
9.53
9.24
8.92
8.58
8.2
7.34
7.86
7.43
6.97
2
80JM/20/4/6/24
9.43
9.05
8.67
8.27
1
80JM/20/6/6/24
6.12
5.53
4.9
4.15
Product, Electrical and ErP Table - 800 mm
380-420v/50Hz/3f
Product
Code
Product
Number
3
80JM/25/4/9/22
4
2
Ref
Pitch Angle (°)
Full Load
Current
(A)
Starting
Current
(A)
Wiring
Diagram
(CD)
112M (IE2)
4.40
8.70
57.3
CD2417
n/a
Motor
Min
Max
JS804944
8
22
1440
80JM/25/4/9/28
JS804966
8
28
1440
132S (IE2)
6.60
12.5
76.25
CD2417
80JM/20/4/6/24
JS834644
8
24
1440
112M (IE2)
4.40
8.70
57.3
CD2417
1
80JM/20/6/6/24
ES831671
8
24
935
90L (IE2)
1.32
3.13
13.15
CD2416
Ref
Product
Code
Product
Number
Inlet
Sound
Levels
Efficiency
Rating
Target
Grade
3
80JM/25/4/9/22
JS804944
71
60.0
55.9
62
4
80JM/25/4/9/28
JS804966
71
60.2
56.7
61
2
80JM/20/4/6/24
JS834644
70
61.1
55.8
63
1
80JM/20/6/6/24
ES831671
58
55.3
52.5
60
ErP
Compliant
Speed Controller
Rating
(kW)
Speed
rev/min
Inlet
Sound
Levels
Inverter
FMEG
(50=Pass)
n/a
IDDXF54-9
54-62
n/a
n/a
IDDXF54-15.5
50-62
71
n/a
n/a
IDDXF54-9
56-64
70
n/a
n/a
IDDXF54-3.7
50-61
58
Electronic Transformer
71
Sound pressure levels quoted are at the inlet, and are average dBA at 3m distance over a sphere at the mid point at the highest angle given,
under free field conditions. These are presented for comparative purposes only.
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
54
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
JM ‘S’ Aerofoil Performance and Electrical Data
Performance Chart - 900 mm
380-420v/50Hz/3f
JM Aerofoil S Type
900 mm
800
700
600
5
400
32
9/
4/
5/
24
9/
4/
5/
/2
/2
JM
JM
90
90
Static Pressure (Pa)
4
500
300
1 90
JM
200
/25/
6/9/
24
3
90
JM
2 9
/2
0JM
5/
/25
6/
/8/
6/
9/3
32
6
100
0
0
10000
0
2
20000
4
30000
6
40000
8
10
50000
12
14
16
3
60000 m /h
3
m /s
Volume Flow
Performance Table - 900 mm
380-420v/50Hz/3f
m3/s @ Pa (Static)
Ref
Product
Code
1
90JM/25/6/9/24
0
50
100
150
200
250
8.58
8.1
7.62
7.11
6.54
5.77
300
400
500
600
5
90JM/25/4/9/32
16.33
15.96
15.58
15.18
14.77
14.35
13.91
12.96
11.91
10.73
4
90JM/25/4/9/24
13.21
12.9
12.6
12.29
11.97
11.65
11.33
10.64
9.85
8.79
2
90JM/25/8/9/36
8.59
7.65
6.54
3
90JM/25/6/6/32
9.81
9.05
8.21
7.2
Sound pressure levels quoted are at the inlet, and are average dBA at 3m distance over a sphere at the mid point at the highest angle given,
under free field conditions. These are presented for comparative purposes only.
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
55
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
JM ‘S’ Aerofoil Performance and Electrical Data
Product, Electrical and ErP Table - 900 mm
380-420v/50Hz/3f
Ref
1
Product
Code
Product
Number
90JM/25/6/9/24
Pitch Angle (°)
Min
Max
ES931672
8
24
Rating
(kW)
Full Load
Current
(A)
Starting
Current
(A)
Wiring
Diagram
(CD)
112M (IE2)
2.64
6.18
26.5
CD2417
Speed
rev/min
Motor
935
Speed Controller
Electronic Transformer
n/a
n/a
Inverter
IDDXF54-7.2
5
90JM/25/4/9/34
JS904913
10
34
1440
160M (IE2)
13.2
25.4
136.62
CD2417
n/a
n/a
IDDXF54-31
4
90JM/25/4/9/24
JS904990
8
24
1440
132M (IE2)
9
17
100.89
CD2417
n/a
n/a
IDDXF54-23
2
90JM/25/8/9/36
JS931872
12
36
695
112M (IE2)
1.80
4.51
19.39
CD2417
n/a
n/a
IDDXF54-5.3
3
90JM/25/6/6/32
JS933672
10
32
935
112M (IE2)
2.64
6.18
26.5
CD2417
n/a
n/a
IDDXF54-7.2
Ref
Product
Code
Product
Number
Inlet
Sound
Levels
Efficiency
Rating
Target
Grade
1
90JM/25/6/9/24
ES931672
63
62.8
54.4
66
5
90JM/25/4/9/34
JS904913
67
63.6
58.2
63
4
90JM/25/4/9/24
JS904990
74
68.0
57.8
68
2
90JM/25/8/9/36
JS931872
61
54.8
53.5
59
3
90JM/25/6/6/32
JS933672
65
58.2
54.5
61
Sound pressure levels quoted are at the inlet, and are average dBA at 3m distance over a sphere at the mid point at the highest angle given, under
free field conditions. These are presented for comparative purposes only.
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
56
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
JM ‘S’ Aerofoil Performance and Electrical Data
Performance Chart - 1000 mm
380-420v/50Hz/3f
JM Aerofoil S Type
1000 mm
1000
900
800
600
500
400
4
0
30000
5
5/
6/
9/
34
40000
4/
20000
/2
10000
/2
/
25
0
25
/6
/6
/2
2
M
0J
0
0J
M
/
100
0J
M/
10
M
0J
10
10
2
3
1
200
10
300
30
28
6/
9/
4/
4/
/
5/
25
/
/2
M
M
0J
0J
22
10
10
9/
6
5
4/
5/
22
6/
Static Pressure (Pa)
700
50000
10
60000
15
70000
20
3
80000 m /h
3
m /s
Volume Flow
Performance Table - 1000 mm
380-420v/50Hz/3f
Ref
m3/s @ Pa (Static)
Product
Code
0
50
100
150
200
250
300
400
500
600
3
100JM/25/4/6/22
16.46
15.91
15.35
14.78
14.21
13.62
13.01
11.68
10.04
4
100JM/25/4/9/22
17.68
17.24
16.79
16.33
15.88
15.41
14.93
13.91
12.75
11.36
18.11
16.99
15.75
14.33
16.42
14.9
12.88
6
100JM/25/4/9/28
20.96
20.52
20.07
19.61
19.12
18.63
2
100JM/25/6/9/34
15.43
14.74
13.95
13.07
12.06
10.91
1
100JM/25/6/6/22
10.78
9.93
9.05
8.11
6.98
5
100JM/25/4/6/30
20.08
19.51
18.94
18.34
17.73
17.09
Sound pressure levels quoted are at the inlet, and are average dBA at 3m distance over a sphere at the mid point at the highest angle given,
under free field conditions. These are presented for comparative purposes only.
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
57
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
JM ‘S’ Aerofoil Performance and Electrical Data
Product, Electrical and ErP Table - 1000 mm
380-420v/50Hz/3f
Ref
Product
Code
Product
Number
Pitch Angle (°)
Min
Max
Speed
rev/min
Motor
Rating
(kW)
Full Load
Current
(A)
Starting
Current
(A)
Wiring
Diagram
(CD)
Speed Controller
Electronic Transformer
Inverter
3
100JM/25/4/6/22
JS104690
8
22
1450
132M (IE2)
9.00
17.0
100.89
CD2417
n/a
n/a
IDDXF54-23
4
100JM/25/4/9/22
JS104913
8
22
1470
160M (IE2)
13.20
25.4
136.62
CD2417
n/a
n/a
IDDXF54-31
6
100JM/25/4/9/28
JS104918
8
28
1470
160L (IE2)
18.00
34.2
177.84
CD2417
n/a
n/a
IDDXF54-37
2
100JM/25/6/9/34
JS136966
10
34
960
132M (IE2)
6.60
14.7
82.32
CD2417
n/a
n/a
IDDXF54-15.5
1
100JM/25/6/6/22
ES133672
8
22
950
112M (IE2)
2.64
6.18
26.5
CD2417
n/a
n/a
IDDXF54-7.2
5
100JM/25/4/6/30
JS133476
8
30
1450
160M (IE2)
13.20
25.4
136.62
CD2417
n/a
n/a
IDDXF54-31
Ref
Product
Code
Product
Number
Inlet
Sound
Levels
Efficiency
Rating
Target
Grade
3
100JM/25/4/6/22
JS104690
80
68.6
57.6
69
4
100JM/25/4/9/22
JS104913
80
63.5
58.1
63
6
100JM/25/4/9/28
JS104918
81
66.6
58.3
66
2
100JM/25/6/9/34
JS136966
73
59.7
56.9
60
1
100JM/25/6/6/22
ES133672
69
63.4
54.3
67
5
100JM/25/4/6/30
JS133476
81
67.0
58.2
66
Sound pressure levels quoted are at the inlet, and are average dBA at 3m distance over a sphere at the mid point at the highest angle given,
under free field conditions. These are presented for comparative purposes only.
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
58
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
Drawing - JM Aerofoil ‘S’ Fans, 315-1000 mm
C
137
D
*WHERE IMPELLER SIDE GUARD IS FITED ON THE MOTOR
SIDE THE GUARD ENCLOSES THE MOTOR. A HOLE 15 DIA
* HOLE
IS PROVIDED IN THE DUCT FOR CUSTOMERS SUPPLY LEADS.
W
E
S No. OF HOLES DIA T
EQUISPACED ON H PCD.
(EACH END0
*WHERE A MOTOR SIDE GUARD IS FITTED
WITH D132 & D160 FRAMES THE GUARD ALSO
ENCLOSES MOTOR. A HOLE 22 DIA. FOR LEADS
IS PROVIDED IN THE SAME POSITION ON DUCT.
AIRFLOW
FORM B
BT/CT FRAMES
1 COMPRESSION GLAND CM20/CM16
1 Phase AND 3 Phase SUPPLY.
SUITABLE FOR 7-10.5 CABLE.
ØA INSIDE
FORM A
ØB OVER FLANGES
AIRFLOW
F22 FRAMES
ENTRY FOR CM25 CONDUIT
SUITABLE FOR 8 - 13 mm DIA CABLE
GUARDS OPTIONAL
EITHER END
V
D132 FRAMES
CABLE ENTRY 2 - KNOCKOUTS 26 DIA FOR CM25
D160/20/23/26/28/32 FRAMES
2 - KNOCKOUTS FOR CM32
D132 & D160
TAPPED FOR CM40
D160/L/LM/LMA/LBK FRAMES
2 - HOLES TAPPED CM32
Product
Code
Motor
Frame
ØA
ØB
C
D
S
T
W
Weight
(kg)
301
225
8
10
137
13.5
180
8
10
137
25
225
8
10
137
14
180
8
10
137
31
31JM
BT4
315
395
31JM
80
315
395
35JM
BT4
355
435
35JM
80
355
435
40JM
BT4
400
480
348
225
8
12
137
40JM
80
400
480
302
180
8
12
137
29
45JM
BT9
450
530
444
225
8
12
137
40
45JM
80
450
530
331
225
8
12
137
30
45JM
100
450
530
377
225
8
12
137
50
50JM
80
500
594
331
225
12
12
137
35
50JM
100
500
594
377
225
12
12
137
53
50JM
112
500
594
394
225
12
12
200
64
56JM
80
560
654
331
225
12
12
137
37
56JM
90
560
654
370
225
12
12
137
43
56JM
100
560
654
377
225
12
12
137
55
56JM
112
560
654
394
225
12
12
200
66
63JM
90
630
724
370
225
12
12
137
46
63JM
100
630
724
377
225
12
12
137
66
71JM
90
710
804
358
225
16
12
137
49
71JM
100
710
804
377
225
16
12
137
68
71JM
112
710
804
394
225
16
12
200
79
80JM
90
800
894
333
225
16
12
137
55
80JM
112
800
894
394
225
16
12
137
84
80JM
132
800
894
438
260
16
12
372
137
90JM
112
900
1006
394
225
16
15
200
87
90JM
132
900
1006
475
225
16
15
348
153
207
301
90JM
160
900
1006
569
300
16
15
348
100JM
112
1000
1006
394
225
16
15
200
92
100JM
132
1000
1106
475
300
16
15
372
161
100JM
160
1000
1106
613
300
16
15
372
215
All dimensions in mm
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
59
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
Wiring Diagrams - JM Aerofoil
CD1705
EACH DIAGRAM
E
K
P
K
E
A
E
K
K
P
E
E
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
60
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
Wiring Diagrams - JM Aerofoil
CD2416
THREE PHASE
ADDITIONAL
CIRCUITS WHEN FITTED:
CD2417
THREE PHASE
ADDITIONAL
CIRCUITS WHEN FITTED:
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
61
Specifications are subject of alteration without further notice
Axial Fans Catalogue (50Hz)
Wiring Diagrams - JM Aerofoil
CD2420
THREE PHASE
CD2423
THREE PHASE
)
Fläkt Woods FWG-AXIALFAN-9534 GB 2014.09.09
62
Specifications are subject of alteration without further notice