Biomethane production and its use in captive fleets Lille

Transcription

Biomethane production and its use in captive
fleets
Lille Metropole Experience
1
Lille Urban Community :
• Local authority reuniting 85 communes and 1.1 million inhabitants.
• 4th urban area of France after Paris, Marseille and Lyon
• 17 communes are situated at the Belgian border. The co-operation with the
Belgian part of the urban area is a major issue to develop a European District
reuniting 2 million inhabitants.
• Lille is situated at the crossing between major European routes and is well
connected by High Speed Train (TGV and Eurostar) with Paris (1 hour), Brussels
(35 minutes) and London (1hour 30 min)
• Pierre Mauroy, previous Prime Minister is the President of the Council of the
urban Community .
2
Lille Urban Community : responsibilities :
• public transport
• households waste collection and treatment
• households waste water collection and treatment
• water supply
• roads, traffic regulation
• urban planning plan, green belt
• housing
• economic development
• cultural and sport facilities
• in France, local authorities are not responsible for energy policy. The
responsibilities in waste management and sewage are limited to the
households (no industry or agriculture waste treated in public facilities)
3
4
The biomethane project in Lille
2 responsibilities of the urban community are reunited in an
energy saving project to fight the increase of the Green House
Effect :
• Waste water treatment policy, with energy recovered from
waste water treatment
•sustainable waste management policy which promotes the
optimisation of the recovery of all kind of waste fractions,
especially the organic part,
• mobility policy which consists of an increase in the use of
clean transport system : metro and gas-powered buses anfd
since recently, the waste trucks.
5
Potential of biogas fuel in Europe
6
What is biogas ?

The biological fermentation of any organic matter in an anaerobic reactor
produces a gas called biogas
Biogas content :
– Methane CH4 : 50 to 65 % (depending on the feedstock used)
– Carbon dioxide CO2 : 30 to 45 %
– Water H2O
– Several pollutants like NH3, siloxanes, H2S
7
8
9
Biogas in Europe (data : 2002)

Potential of biogas production in the EU15 is estimated between 70 to 136
billions m3

20 to 40 % of the energy for road transport could be replaced by upgraded
biogas

biogas powered vehicles respect the highest EU emission standards
(EURO 5)

The replacement of 5 % of the European vehicles would use 12 to 24 % of
the potential of biogas production and economise 10 Mt/year of diesel, 32
Mt/year of CO2 (4.8 % of total), 120,000 tonnes of nitrogen oxide (3.7 % of
total) and 9,500 tonnes of particles (5 % of total)
10
Lille Metropole and biogas fuel :
1994-1999 : the pilot experiment
11
Natural gas and biomethane powered buses
in Lille : the History
• 1990 : launch of an experiment to recover the surplus of biogas
produced by the digestion of sewage sludge (Marquette Plant).
The main usage of this biogas was CHP.
• Design of an upgrading pilot unit to increase the methane
content of the raw biogas from 60 to 97 % (water scrubbing to
eliminate CO2 and pollutants that could damage the engines).
Operational in 1995
• This project was supported by the European Commission
(THERMIE Programme), the State (ADEME) and the Region
• 1994 : the first gas-powered buses in operation (199 : 9
vehicles)
12
First gas-powered bus in 1994
13
14
Pilot upgrading Plant in Marquette (1)
15
Pilot upgrading Plant in Marquette (2)
16
Outcomes of the project
Î
Production of good quality biogas : Méthane : 97,5 % ; H2S : 2 ppm ; H2O : 3
ppm
ÎReliability
of gas buses : Comparable with diesel buses (rate of brakedown,
wear on the tyres, brakes, oil)
Î
Cost per kilometre equal to or less than that for diesel buses : Fuel
consumption - Gas : 65 Nm3/100 km (0,27 € =0,35 $ /m3) ; Diesel : 50 l /100
km (0,68 € = 0,89 $/l)
Î
Contribution to the environment
Buses Exhaust Emissions (g/kWh)
DIESEL
CO
HC
NOx
Particulates
CH4
AGORA Diesel 300ppm
AGORA Diesel 50ppm with filter
EURO 4 Standard
0,56
0,11
1,5
0,17
0,01
0,46
4,67
4,94
3,5
0,041
0,006
0,02
0
0
CNG
CO
NmHC
NOx
Particulates
CH4
AGORA CNG, 2002 model
AGORA CNG, 2004 model
0,024
0,52
0,003
0,003
2,432
1,21
0,004
0,004
0,531
0,049
EURO 4 Standard
EEV LABEL
4
3
0,55
0,4
3,5
2
0,03
0,02
1,1
0,65
2000-now : the decision to switch to (bio)gas fuel
19
1. The development of the bus fleet
20
Urban Mobility Plan in Lille and the development of the
gas-powered buses fleet
• 1999 : decision to replace progressively yet totally the diesel fleet with gas
powered buses
• 60 gas-powered Iris-bus buses in operation in 2001, 100 in 2002, 127 in 2004,
200 in the beginning of 2007. Cofinanced under TRENDSETTER project
• Increase of the bus fleet (331 in 2005) : + 100 in 2006, + 200 beyond
• one gas bud depot now ; 2 new bus depots (capacity of 150 buses each) with
biomethane supply :
• Sequedin (already in function) : 100 of the 150 buses will be fuelled with
biomethane (from 2008)
• Wattrelos : experiment to increase the biogas production with non-easy
biodegradable sewage sludge (sept 2007)
21
Environmental advantages of using (bio)gas buses
• Gas-powered buses are 50 % less noisy compared to diesel
• Exhaust gas emissions of a Euro 3 gas-powered bus vs. a Euro 3 diesel
bus are :
• reduction of 96 % on the carbon monoxide
• reduction of 99 % on the residual hydrocarbons
• reduction of 51 % on nitrogen oxides
• reduction of 100 % on particles
• GHG emissions close to zero !
22
Lille gas-powered bus in operation
23
Gas powered buses and compression unit
(first gas-powered bus depot)
24
Gas powered buses
25
Compressed
gas
Natural Gas
Biomethane
Compression
Unit
26
Lille : a Civitas City
Stockholm
Lille
Prag
Graz
Pécs
27
Development of a (bio)gas
waste truck fleet
• March 2005 : ESTERRA (Lille Metropole operator for waste treatment)
purchases the first (bio)gas waste trucks (Mercedes). Evaluation phase (fiability
and gas consumption, security)
• Jan. 2005-Nov 2006 : feasability study on the replacement of the diesel fleet
by a biogas powered one
• 2006 : purchase of 2 new vehicules and decision to set up gas compression
unit in different trucks depot
• The trucks based in sequedin (location of Waste recovery center) will run on
(bio)gas
• 2013 : 70 CBG/CNG vehicles (19 and 26 tons)
28
One third of the service
fleet = clean vehicles
(electricity and gas)
Twingo, C3 gas vehicles.
Expanding fleet but
difficulty to purchase
vehicles !
Gas powered service car
29
2. Dévelopment of the biogas production
30
Producing biogas fuel from organic waste
• 1992 : adoption of “the integrated Scheme for Urban Waste Collection
and Treatment” : otimisation of re-use of matter (packaging and organic
waste) & energy recovery
• 1995 : feasibility studies of the Organic Recovery Centre (cofinanced by
the EC, TRENDSETTER project)
• 1997 : choice of the digestion process
• 2004 : decision to generate biomethane with the raw biogas produced by
the O.R.C. (vs. electricity). 100 urban gas-powered buses will be fuelled
with biomethane.
• nov 2004 : Beginning of the construction of the O.R.C.
• nov 2005 : start of operation of the Sequedin new bus depot
• June 2007 : start of operation of the O.R.C.
• Sept. 2007 : start of the refuelling with biomethane
31
Organic Recovery Centre & bus
depot
January 2007
32
Organic Recovery Centre
33
New bus
depot in
Sequedin
34
Environmental advantages of the ORC project
• The digestion process enables an energetic recovery (vs. composting) and
therefore an income (8,5 € / ton ) based on the same price as the natural
gas (0,025 €/kWh currently)
• Biomethane does not contribute to green house effect
• 4 million liters of diesel saved per year
• no need of fuel transport because the bus depot is situated next to the
O.R.C. and connected with a dedicated pipeline.
• Feasibility study ongoing on the injection of biomethane into the natural
gas grid
• health impact assessment
• impact assessment on the reliability of the grid
35
Biogas Upgrading
¾
2 scrubbing towers
¾
capacity. 2 x 600 Nm3/ h
of raw biogas
¾1
compression unit (9 bar)
¾1
storage tank. Capacity 5000 Nm3
corresponding to ½ day of production
¾
Production : 4 millions Nm3/an
¾
Heat value eq. 10,5kWh/ Nm3
36
37
>95% CH 4
2% CO 2
Saturated in water vapor
process Air
To biofilter
<1% CH 4
traces of H S
2
56% N 2
29% CO 2
14% O 2
Dryers
>95% CH 4
2% CO 2
Dew point: -80°C
Scrubbing
Tower
Flashing
Tank
4 bar
CH4
Recovery
Stripping
Tower
CO2
at
atmospheric
pressure
Pressure
2 stages
Air
9 bar
compressor
Raw biogast
55-65% CH 4
35-45% CO 2
relative pressure 50 mbar
Cooled water pump
(<15°C)
Recovery of the methane
From the water process
38
Biomethane Quality
3
Heat Value (kWh/Nm )
Due Point
Sulphur and mercaptans
Carbon monoxide
Chlorine
Fluorine
Particles
Biomethane Quality
10,5 kWh/m3 at 0°C
T<-20°C at 250 bars
<5mg/Nm3
< 2%
< 0,1 mg/Nm3
< 0,1 mg/Nm3
Size of particle <1 µg
39
Biomethane financial issues
• The choice of biomethane production with the raw biogas generated by
the new O.R.C was based on the comparison : electricity generation vs.
fuel production. In France, renewable electricity generation was not well
supported by the State, but it’s changing. Gas is cheap
• Total cost of the investment : 90 Million € (70 + 20 for the depot)
• Biomethane will be sold on the natural gas price basis (0,025 €/kWh)
• This income can reduce the treatment cost by 8 to 9 €/ton (treatment
cost = 60 to 70 €/ton) --> not a profitable activity !
• Taxation of biomethane will be the same as natural gas
• Political actions to have a free taxation for biomethane like other liquid
biofuels
• Strong focus of central administration on liquid biofuels
40
Biogas production from wastewater treatment :
further development
• General objective : produce biogas fuel throughout the territory.
Develop systematically a feasability study for each wastewater
treatment to be built or refurbished
• renovation of the pilot upgrading unit at the waste water treatment
plant of Marquette (pilot plant)
• Feasibility study of biomethane production (new waste water
treatment plant to be in operation in 2013 ; production of biogas fuel
for 100 buses ?)
• study of the production of biomethane with the digestion of noneasy biodegradable sewage sludge generated by the Grimonpont
waste water treatment plant. A new gas-powered bus depot in
Wattrelos could be fed with this biomethane
41
Biogasmax project : an FP-6 cofunded project aiming at
developing the biogas fuel in Europe
(http://www.biogasmax.eu)
42
More information on Lille Metropole biogas experience ?
Pierre HIRTZBERGER (production aspects), phirtzberger@cudl-lille.fr
Yves BAESEN (fleet aspects), ybaesen@cudl-lille.fr
43